Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 143 NHTSA owner-reported complaints for the 2001 Kia Optima. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 143 · page 1 of 6
My air bag light has been on and I've check everything and my seat belt don't lock when its on and the light to the seat belt goes off contented, I've tried to go to the dealer to have them fix my airbags and senses I don't have recall on it they won't fix it ,The air bag is very important and so is the seat belt
My airbag light on and I've check the fuses in it,Not it,,, My AC,. The drivers door lock , Oxagen senser Crank Shaft,
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR SCHEDULED MAINTENANCE, WHEN THE VEHICLE WAS PLACED ON THE LIFT, THE MECHANIC NOTICED THAT THE SUB FRAME WAS SEVERELY RUSTED AND THE DETERMINED THAT THE VEHICLE SHOULD NOT BE DRIVEN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. *TT *JB
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. WHILE DRIVING 15 MPH, THE FRONT PASSENGER SIDE WHEEL COMPLETELY DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 09V183000 (SUSPENSION). THE FAILURE MILEAGE WAS 100,000.
I TOOK MY CAR FOR A STATE SAFETY INSPECTION AND WAS TOLD THE ENGINE CRADLE WAS BEGINNING TO SHOW RUST. I TOOK IT TO A SECOND PROVIDER WHO CONFIRMED THAT THIS WAS THE CASE. AFTER DOING SOME RESEARCH I FOUND THAT RUSTING OF THE SUBFRAME HAD BEEN RECALLED BUT NOT FOR THE STATE I LIVE IN (VIRGINIA).
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. WHILE DRIVING APPROXIMATELY 30 MPH IN THE RAIN, THE VEHICLE SWERVED TO THE RIGHT. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT END NEEDED TO BE ALIGNED. THE VEHICLE WAS NOT REPAIRED BECAUSE THE FRONT SUBFRAME WAS CORRODED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 09V183000 (SUSPENSION); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED THAT WHILE THE VEHICLE BEING INSPECTED BY AN INDEPENDENT MECHANIC, THE MECHANIC STATED THAT THE AXLE HAD FRACTURED DUE TO SEVERE CORROSION ON THE MOTOR MOUNT BRACKETS. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 09V183000 (SUSPENSION). THE MANUFACTURER WAS CONTACT AND INFORMED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 236,000.
GOT IN CAR TO GO HOME NOTICED CAR STEERING WAS TERRIBLE AS IF I WAS ON ICE IN THE MIDDLE OF SEPT. GOT OUT TO SEE IF I WAS EXPERIENCING A FLAT TIRE NOTICED THE TWO FRONT TIRES WEREN'T LINED UP CORRECTLY. AFTER GETTING TO A GARAGE AND HAVING THE TWO FRONT TIRES REMOVED IT WAS FOUND THAT THE FRONT SUBFRAME ON PASSENGER SIDE OF CAR HAD RUSTED AND BROKEN!!!! IT NEEDED REPLACED. I HAVEN'T BEEN ABLE TO DO SO AS OF YET :( SOMETHING NEEDS TO BE DONE ABOUT ALL THESE 2001 OPTIMAS THAT ARE STILL ON THE STREET IN DESPERATE NEED OF RECALL. I COULD OF EASILY HAVE WRECKED AND INJURED MYSELF OR SOMEONE ELSE.
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. WHILE PERFORMING MAINTENANCE ON THE VEHICLE, THE VEHICLE WAS LIFTED AND THE CONTACT NOTICED THAT THE SUBFRAME OF THE VEHICLE WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE SUB FRAME OF THE VEHICLE WAS INDEED CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.
THE FRONT K FRAME OF THE VEHICLE IS RUSTED AND MAKES LOUD NOISE WHILE DRIVING. THIS HAS AFFECTED THE ALIGNMENT OF THE VEHICLE, AND CAN CAUSE A ROAD ACCIDENT OR FATALITY.
TL* THE CONTACT OWNS 2001 KIA OPTIMA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 01V156000 (AIR BAGS) BUT AS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE VEHICLE WAS PREVIOUSLY INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V183000 (SUSPENSION). THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL REPAIR. THE TECHNICIAN DID NOT FIND CORROSION OF THE FRAME AT THAT TIME AND DID NOT PERFORM ANY REPAIR. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE BEGAN TO PULL TO THE SIDES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THE SUB FRAME WAS FRACTURED ON THE FRONT PASSENGER SIDE DESTROYING THE AXEL AND TIE RODS. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.
2001 KIA OPTIMA. CONSUMER WRITES IN REGARDS TO SUB-FRAME RECALL. *SMD THE CONSUMER BELIEVED HE WAS TREATED UNFAIRLY AND CHARGED EXORBITANT REPAIR CHARGES THAT SHOULD HAVE BEEN INCLUDED IN THE RECALL. ON OCTOBER 25, 2012, AS THE CONSUMER'S GIRLFRIEND WAS DRIVING THE VEHICLE, THE SUB-FRAME COLLAPSED. THE VEHICLE WAS TOWED TO THE NEAREST REPAIR FACILITY, WHERE IT WAS DETERMINED THE VEHICLE WAS NOT REPAIRABLE. THE VEHICLE WAS THEN TOWED TO A KIA DEALERSHIP. THE DEALERSHIP AGREED TO REPLACE THE SUB-FRAME, BUT THEY STATED THEY WOULD NOT REPAIR ANY OTHER DAMAGE CAUSED AS A RESULT OF THE SEPARATION. THE CONSUMER WAS INFORMED HE WOULD BE RESPONSIBLE FOR THE TOW CHARGES, PLUS AN ADDITIONAL $1,100-$1,150 TO REPAIR OTHER RUSTY AREAS UNDER THE VEHICLE. THE CONSUMER BELIEVED THAT ANY SUBSEQUENT DAMAGES CAUSED BY THE SUB-FRAME CORROSION AND SEPARATION SHOULD BE INCLUDED IN THE RECALL REPAIRS THAT WERE NEEDED TO MAKE THE VEHICLE ROAD WORTHY. *JB
AS I WAS LEAVING MY NEIGHBORHOOD, MY CAR DRIFTED TO THE RIGHT AND FELL ON TOP OF THE RIGHT FRONT TIRE. AFTER INSPECTION OF THE CAR, WE NOTICED THAT THERE WAS A HOLE IN THE SUBFRAME WHERE THE SUSPENSION BROKE APART. INSURANCE INFORMED ME OF RECALL SC075 AND NOT KIA. INSURANCE WILL NOT COVER BECAUSE OF RECALL AND KIA WILL NOT COVER BECAUSE THEY DID NOT RECALL IT, THEY SAY. *TR
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE WOULD VEER TO THE RIGHT INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSE THAT DUE TO THE MOISTURE FROM THE AIR CONDITIONER THE CROSS BAR BECAME CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V183000 (SUSPENSION:FRONT). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 122,000.
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR A ROUTINE OIL CHANGE WHEN SHE WAS ADVISED THAT THERE WAS A HOLE IN THE ENGINE CRADLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THEY STATED THAT THE ENGINE CRADLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 105,000 AND THE CURRENT MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED THAT THE DRIVER WAS DRIVING 65 MPH WHEN THE FRONT PASSENGER SIDE OF THE VEHICLE COLLAPSED. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE CONTACT NOTICED THAT THE TIRE WAS STUCK TO THE SIDE OF THE VEHICLE AND THE FENDER WELL WAS DAMAGED. THE VEHICLE WAS NOT TAKEN TO A MECHANIC. THE DEALER WAS NOTIFIED AND THEY STATED THAT THERE WERE NO WARRANTIES COVERING THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 157,930.
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED THAT THE VEHICLE SURGED FORWARD WHILE IT WAS STOPPED. THE CONTACT APPLIED EXCESSIVE PRESSURE TO THE BRAKE PEDAL TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT THE REAR BRAKES INTERMITTENTLY SEIZED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 175,000. ...UPDATED 07/19/12 *BF THE CONSUMER STATED ONE OF THE REAR BRAKE HAD JAMMED AND ONLY APPLIED BRAKE PRESSURE FROM ONE SIDE, CAUSING THE BRAKE PAD ON ONE SIDE TO WEAR METAL TO METAL, WHILE THE BRAKE ON THE OTHER SIDE OF THE DISK HAD LITTLE WEAR. UPDATED 07/23/12
DEFECT #2032 ENGINE FAMILIES 1KMXV02.5D01 IMPROPERLY MADE CRANKSHAFT POSITION SENSORS DIDN'T MEET DIMENSIONAL SPECIFICATIONS. EPOXY FLOWED BETWEEN GAPS IN CASES AND CONTACTED THE PRINTED CIRCUIT BOARD RESULT CRACKED CIRCUIT BOARD CAPACITOR. *TR
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN UNRELATED REPAIR AND THEY DETECTED THE SUB FRAME COMPLETELY RUSTED. IN ADDITION, THE FRONT DRIVER'S SIDE WHEEL ASSEMBLY SEPARATED FROM THE SUB FRAME. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V183000 (SUSPENSION: FRONT). THE VEHICLE WAS INELIGIBLE UNDER THE RECALL DUE TO NOT BEING CURRENTLY REGISTERED OR ORIGINALLY SOLD IN THE STATES MENTIONED IN THE RECALL. THE CONTACT PLANNED TO NOTIFY THE MANUFACTURER OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 142,000.
WHILE DRIVING IN A NEIGHBORHOOD, MY DAUGHTER HEARD A LOUD "POP" AND THEN THE CAR CAME TO A STOP AND SHUDDERED. I GOT THERE AND DID A QUICK LOOK AND I NOTICED THE DRIVER SIDE INSIDE CV JOINT HAD FAILED AND WAS LEAKING THE GREASE OUT OF THE BOOT. WE TOWED IT HOME AND WAS ABLE TO JACK THE CAR UP AND GET A BETTER VIEW OF THE AREA AND NOTICED THE LOWER ARM OF SUSPENSION HAD PULLED FROM THE RUSTED FRAME. LOOKS LIKE THE SAME THING IS HAPPENING ON THE PASSENGER SIDE. I CAME IN TO LOOK UP PARTS NEEDED AND FOUND THE RECALL INFO #09V183000 THAT SHOWED THE SAME EXACT PROBLEM WE HAVE BUT DOESN'T INCLUDE KANSAS??? I ACTUALLY BOUGHT THIS IN MISSOURI, WHICH IS INCLUDED??? I BELIEVE THIS SHOULD BE COVERED. PLEASE REPLY ASAP. *TR
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN THE FRONT PASSENGER TIRE BENT INWARD ABNORMALLY. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE SUB-FRAME HAD CAVED IN. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT THE VEHICLE WOULD BE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 09V183000 (SUSPENSION:FRONT). THERE WAS ADDITIONAL DAMAGE TO THE STRUTS AS A RESULT OF THE FAILURE BUT THE DEALER REFUSED TO PERFORM ANY REPAIRS OUTSIDE OF WHAT WAS STATED WOULD BE REPAIRED IN THE RECALL. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE. UPDATED 02/09/12*LJ
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED AFTER HAVING HIS VEHICLE ALIGNED THE FRONT PASSENGER SIDE SUB FRAMED COLLAPSED. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE SUB FRAME AND THE CONTROL ARM WERE CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN ID NUMBER: 09V183000 (SUSPENSION:FRONT). THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 126,000.
TL* THE CONTACT OWNS A 2001 KIA OPTIMA. THE CONTACT STATED THAT WHEN DRIVING VARIOUS SPEEDS, THE STEERING WHEEL WOULD BECOME HARD TO CONTROL, WHICH CAUSED THE TIRES TO WEAR PREMATURELY.THE CONTACT CALLED THE MANUFACTURER AND WAS TOLD THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V183000 (SUSPENSION:FRONT). THE CONTACT STATED THAT THE REASON THE VEHICLE WAS NOT INCLUDED WAS THAT VIRGINA WAS NOT LISTED AS A SALT BELT STATE, WHICH THE RECALL ONLY PERTAININED TO THOSE VEHICLE THAT WERE LOCATED IN SALT BELT STATES. THE FAILURE MILEAGE WAS 210,000. UPDATED 06/01/11*LJ
TL*THE CONTACT OWNS 2001 KIA OPTIMA. THE CONTACT STATED THAT NHTSA CAMPAIGN ID NUMBER: 09V183000, SUSPENSION: FRONT WAS RELATED TO THE CORROSION ON THE FRONT SUB FRAME OF HIS VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO SPRAYED AN UNDER COATING ON THE BOTTOM TO COVER THE RUST, CORROSION AND REPLACED THE SUB FRAME. AFTER ROUTINE MAINTENANCE, HE FOUND THE ENTIRE BOTTOM OF THE VEHICLE INCLUDING THE FUEL WELL COVERED WITH RUST AGAIN. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 113,400.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .