2006 Kia Optima Owner Complaints

The front subframe is dangerously rusted. The same way the other optima were recalled for.

NHTSA ID

11538403

Incident

Aug 11, 2023

I HAVE A 2006.5 KIA OPTIMA. I AM EXPERIENCING THE SAME PROBLEM WITH THE BRAKE LIGHT SWITCH STICKING AS OTHER KIAS CURRENTLY UNDER RECALL. MY BRAKE LIGHTS ARE ALWAYS ON. AM I OUT OF LUCK ON THIS ONE?

NHTSA ID

11374127

Incident

Oct 1, 2020

Mileage

105,000 mi

HOOD RELEASED WHILE IN MOTION, FOLDED BACK OVER WINDSHIELD AND ROOF TOP TOTALLY BLINDING DRIVER WHILE IN MOTION. VEHICLE WAS IN MOTION, TRAVELING SOUTH ON NC HWY 16 AT A RATE OF 50 MPH, TWO LANE ROAD. HOOD RELEASED AND FLEW UP, NO KNOWN CAUSE OR EFFECT. HOOD RELEASE AND/OR SAFETY LATCH OBVIOUSLY RELEASED WITHOUT CAUSE OR WARNING.

NHTSA ID

11257837

Incident

Sep 23, 2019

Mileage

130,000 mi

CAR WILL NOT ALWAYS START. SOMETIMES I HAVE TO WAIT 24 HOURS AND PICK UP THE CAR WHEREVER I HAD TO LEAVE IT CAUSE IT WOULDN'T START. WHEN TRYING TO START THERE'S A CLICKING SOUND AND ALL PANEL LIGHT START TO FLASH. REPLACED ALTERNATOR AND BATTERY, STILL NOT FIXED. SEEN A LOT OF REVIEWS COMPLAINING ABOUT THE EXACT SOME PROBLEM.

NHTSA ID

11254209

Incident

Aug 7, 2019

Mileage

153,000 mi

TL* THE CONTACT OWNS A 2006 KIA OPTIMA. WHILE REVERSING OUT OF THE DRIVEWAY, THE VEHICLE FAILED TO REVERSE AND THE INSTRUMENT PANEL INDICATED THAT THE SHIFTER WAS IN PARK. THE CONTACT STATED THAT THE GEAR SHIFTER WOULD SHIFT OUT OF PARK INTO REVERSE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED KIA OF LYNCHBURG (3400 OLD FOREST RD, LYNCHBURG, VA 24501, (434) 847-3292) AND WAS INFORMED THAT THE TRANSMISSION COULD BE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 171,000.

NHTSA ID

11235041

Incident

Jul 25, 2019

Mileage

171,000 mi

OH REAR LOWER SWING ARM SUPPORTING THE SPRING BROKE LETTING THE SPRING COME OUT OF POSITION AND LETTING THE WHEEL TILT AS IF FLAT. THE LOWER ARM HAD RUSTED IN TWO ALLOWING THIS TO HAPPEN.

NHTSA ID

11206558

Incident

Jan 3, 2019

Mileage

130,000 mi

I HAVE AN 06 OPTIMA (06.5/ MS) 2.4 ENGINE BUT THE PROBLEM IM HAVING JUGING FROM KIA INTERNET FORUMS IS SPREAD ACROS MENEY YEARS AND MODELS IT IS AN INTERMITANT ENGINE STALL IT CAN HAPPEN AT ANY TIME IVE HAD IT HAPPEN AT 65MPH ON INTERSTATE THIS IS FOLLOWED BY A SERIES OF START STALL THEN IT WILL RUN FINE FOR A WHILE IVE HAD A COMPLETE WIRE HARNESS CHECK REACED SEVERAL SENSORS AND OTHER PARTS NOTHING HAS CURED THE PROBLEM IT SHOULD BE RECALLED AND REPAIRED BY KIA BEFORE SOME ONE GETS HURT NOT AFTER.THIS IS A TOTALLY RANDOM HAPPENING

NHTSA ID

11139710

Incident

Oct 10, 2018

Mileage

240,000 mi

INSTRUMENT PANEL IS NOT WORKING NO SPEED NO TEMP NO RPM NO FUEL. CHECKED ALL FUSES.

NHTSA ID

11097561

Incident

May 23, 2018

Mileage

63,734 mi

FRONT PASSENGER SIDE DOOR WILL MOT OPEN FROM THE INSIDE OR OUTSIDE CAUSING YOU TO BE LOCKED IN THE VEHICLE. ALSO WHEN YOU TRY TO OPEN THE DOOR FROM INSIDE THE VEHICLE AUTOMATICALLY LOCKS THE CAR. THIS IS A SAFETY HAZARD THAT NEEDS TO BE ADDRESS.

NHTSA ID

11091106

Incident

Jan 2, 2018

Mileage

150,000 mi

DRIVER'S SIDE DOOR WILL NOT OPEN FROM EITHER THE INSIDE OR THE OUTSIDE. THIS IS THE SECOND TIME THAT THIS HAS OCCURRED BUT I WAS ABLE TO FINALLY GET THE DOOR OPEN BEFORE AND DISENGAGED THE ACTUATOR. AS LONG AS NO ONE LOCKED THE DOOR, IT WORKED FINE, HOWEVER; MOTHER RECENTLY HAD WORK DONE ON HER CAR AND WHEN THEY RETURNED IT, THEY LOCKED THE DOOR. I'VE SPENT NUMEROUS HOURS TRYING TO GET THE DOOR OPEN SO THAT I CAN REPLACE THE MECHANISM AND ACTUATOR BUT HAVE BEEN UNSUCCESSFUL. AFTER LOOKING ONLINE, THIS SEEM TO BE AN ONGOING ISSUE WITH KIA, THIS IS A DANGEROUS CONDITION AND NEEDS TO BE LOOKED INTO. NOT SURE HOW LITTLE ELDERLY PEOPLE ARE EXPECTED TO SAFELY GET OUT OF THEIR VEHICLES IN CASE OF AN EMERGENCY. (THIS HAPPENED WHILE STATIONARY ON A FLAT, PAVED ROAD).

NHTSA ID

11088437

Incident

Mar 22, 2018

Mileage

96,000 mi

AIR BAG LIGHTS WON'T TURN OFF CONSTANTLY ON ALL THE TIME

NHTSA ID

11076797

Incident

Jan 1, 2016

Mileage

96,000 mi

I PURCHASED MY CAR BRAND NEW FROM THE KIA DEALERSHIP AND IT HAS NEED THE SAME REPAIR ON THE SAME PART 3 TIMES (THE CLUTCH). THE TRANSMISSION IN THE 2006 KIA OPTIMA IS A VEHICLE DEFECT.

NHTSA ID

11073629

Incident

Jan 1, 2015

Mileage

100,000 mi

2006 KIA OPTIMA. CONSUMER WRITES IN REGARDS TO CLUTCH AND ENGINE LIGHT TURN ON AND OFF. *LD *JS

NHTSA ID

11056508

Incident

Nov 1, 2017

AUTO LOCK ISSUE. AT 118,000 MILES MY AUTO LOCKS STARTED TO AUTOMATICALLY LOCK WHEN I TRIED TO UNLOCKED THEM, ESSENTIALLY TRAPPING ME IN THE VEHICLE. AS SOON AS I CLICK UNLOCK THEY IMMEDIATELY RELOOK. IF THIS ISN'T A SAFETY ISSUE IN NEED OF A RECALL I DON'T KNOW WHAT IS. I'VE LOOKED INTO THE PROBLEM ON OTHER FORUMS AND IT SEEMS QUITE COMMON. YIKES! PLEASE GET THIS RECALL DONE!

NHTSA ID

11054469

Incident

Dec 13, 2017

Mileage

118,000 mi

"FIRST" TIME PROBLEM HAPPENED WAS JULY 3, 2016 WITH MY 2006 KIA OPTIMA. I WAS SB ON HWY I25 IN CS, CO. SPEEDOMETER READ 25MPH AS I WAS COMING OFF THE ON-RAMP. I ACCELERATED TO 40MPH INTO FLOW OF TRAFFIC. I FELT A LURCH & THE VEHICLE AUTOMATICALLY ACCELERATED. SPEED WENT FROM 40MPH TO ABOUT 60 MPH WITHOUT DEPRESSING ACCELERATOR. BREAKING DID NOT SLOW IT DOWN. I FELT CAR WAS GOING OUT OF CONTROL. MY PASSENGER REACHED OVER & TURNED IGNITION SWITCH OFF & ON QUICKLY, TO DECELERATE & ACCELERATE. THIS HELPED CAR SLOW DOWN WHEN KEY WAS TURNED OFF TO THE FIRST CLICK & HELPED MAINTAIN AN ADJUSTED SPEED AS TRAFFIC WAS IN-FRONT & IN-BACK. WE KEPT DOING THIS UNTIL CAR SLOWED DOWN ENOUGH TO PULL OVER TO RIGHT SHOULDER. KEY WAS COMPLETELY TURNED OFF & CAR WAS AT A COMPLETE STOP. CAR WAS TOWED TO MECHANICS. DIAGNOSTIC WAS PERFORMED USING ENGINE ANALYZER. IT WAS ROAD TESTED MULTIPLE TIMES & DIDN'T IT DUPLICATE MY EXPERIENCE. THIS HAPPENED AGAIN SEPT.10, 2016 AS I, AGAIN, ENTERED HWY I25 SO.I WAS DRIVING ALONE. MY SPEEDOMETER WAS 40 MPH, IN HEAVY HWY TRAFFIC. I ONCE AGAIN "FELT" LURCH OF CAR. THIS TIME IT "STUCK" AT 40 MPH. IT DIDN'T SLOW DOWN WHEN I BRAKED, IT CONTINUED AT 40 MPH. I CONTINUED TO BRAKE & SPEED DID SLOW A BIT. MY FOOT WAS TOTALLY DOWN ON BREAK WHEN IT WAS STILL AUTO ACCELERATING AT THE HWY EXIT RAMP; NOW SLOWED TO 26 MPH AS I CONTINUED HOLDING BRAKE DOWN. FINALLY SPEED WAS DOWN TO 23MPH AS I DROVE INTO A PARKING LOT (NO CARS WERE MOVING IN & OUT AT THE TIME). I TURNED THE KEY OFF COMPLETELY; MY FOOT WAS STILL ON THE BRAKE & THE CAR CAME TO A LURCHING HAUL AT THAT TIME IN THE MIDDLE OF THE PARKING LOT. I WAITED ABOUT A MINUTE & THEN STARTED THE ENGINE AGAIN WITH MY FOOT ON THE BRAKE. I WAS ABLE TO PULL INTO A PARKING SLOT. I STARTED IT & VERY SLOWLY DROVE HOME, BUT NOT ON THE HWY. I MAINTAINED SPEED OF 25-30MPH. IT WAS ONLY ABOUT 1K BETWEEN THE 2 INCIDENTS.

NHTSA ID

10905623

Incident

Sep 10, 2016

Mileage

103,083 mi

I ALSO HAVE THE DRIVER'S SIDE AIRBAG WARNING LIGHT CAME ON AND STAYS ON. I CHECKED AND FOUND OUT THERE IS A RECALL FOR DRIVER SIDE AIRBAG ON 2006 KIA OPTIMA, BUT THE DEALERSHIP SAID MY CAR IS NOT COVERED UNDER THIS RECALL. THIS RECALL NEED TO COVER ALL 2006 KIA OPTIMAS SINCE SO MANY HAVE THE SAME PROBLEM.

NHTSA ID

10885436

Incident

Jul 18, 2016

THE DRIVER'S SIDE AIRBAG WARNING LIGHT CAME ON AND STAYS ON. I CHECKED AND FOUND OUT THERE IS A RECALL FOR DRIVER SIDE AIRBAG ON 2006 KIA OPTIMA, BUT THE DEALERSHIP SAID MY CAR IS NOT COVERED UNDER THIS RECALL. THIS RECALL NEED TO COVER ALL 2006 KIA OPTIMAS SINCE SO MANY HAVE THE SAME PROBLEM.

NHTSA ID

10876967

Incident

Jun 1, 2016

PULLING OUT OF MY GARAGE MY CAR ACCELERATED OUT OF CONTROL AT HIGH SPEED BACKWARDS ACROSS THE STREET INTO THE SIDE OF MY NEIGHBOR'S HOUSE TAKING HER ELECTRICAL BOX, SPRINKLER MOTOR AND A/C UNIT DOWN. THE WIRE'S WERE HOT AND I WAS ADVISED TO STAY IN THE CAR UNTIL THE FIREFIGHTERS ARRIVED AND THE POWER SHUT DOWN BY THE POWER COMPANY - SCARED TO DEATH OF A FIRE OR ELECTROCUTION.

NHTSA ID

10875403

Incident

Jun 7, 2016

Mileage

44,700 mi

MY AIRBAG LIGHT CAME ON A FEW MONTHS AGO WHEN I WAS DRIVING TO WORK THE LIGHT CAME ON AND HAVE NOT GONE OFF YET. I TOOK IT TO GET A DIAGNOSE AND WAS TOLD IT WAS A SENSOR IN THE SEAT AND I SHOULD HAVE IT REPLACED. WELL I HAD SOMEONE PUT IN A DIFFERENT SEAT AND THE AIRBAG LIGHT DID NOT GO OFF. NOW IT'S TIME FOR MY INSPECTIONS AND I CAN'T EVEN GET IT DONE BECAUSE THE AIRBAG LIGHT IS STILL ON.

NHTSA ID

10871474

Incident

Nov 24, 2015

Mileage

115,075 mi

SC088:11V-153,I CAN'T PUT MY CAR IN PART NOR CAN I GO IN REVERSE. MY KEY IS STUCK IN THE IGNITION. I SEE IT WAS A RECALL ON THIS MATTER FOR THE KIA OPTIMA. TOOK MY CAR TO THE KIA DEALERSHIP,THE TOLD ME MY VIN# WASN'T ON THE LIST. IT'S A 2006 KIA OPTIMA. AM TRYING TO GET THIS REALIZE.ARE THERE CERTAIN VIN#UNDER THE RECALL FOR THIS IF NOT WHERE I NEED TO TAKE MY CAR TO HAVE IT FIX. I WAS STATIONARY WHEN THE PROBLEM OCCURRED I COULDN'T BACK UP NOR PUT IT IN PART AGAIN IT WANT ALLOW ME TOO DO SO.

NHTSA ID

10846045

Incident

Feb 25, 2016

I HAD A RECALL ON AIRBAGS TOOK IT TWICE TO DEALER AND THE LIGHT IS STILL ON WILL NOT GO OFF. ALSO WHEN I STOP AND GET GAS AND AFTER I FINISH PUMP ON THE INSIDE IT SMELL SO LOUD JUST LIKE I WASTE IT ON ME I HAVE TOOK IT TO LET THEM CHECK IT OUT CANNOT FIND OUT WHERE IT COME FROM

NHTSA ID

10820578

Incident

Jun 10, 2006

Mileage

96,000 mi

ON 1/11/16, I TOOK MY OPTIMA TO THE KIA DEALERSHIP (LOKEY IN CLEARWATER FLORIDA) BECAUSE THE AIR BAG LIGHT SUDDENLY CAME ON AND I WANTED AN UPDATE ON ALL APPLICABLE OPTIMA MODELS AND YEARS. I PAID $135.29 FOR THEM TO JUST LOOK AT THE PROBLEM. THEY INFORMED ME THAT MY OPTIMA HAS NO RECALLS AND THAT MY DRIVER`S SIDE SEAT BACK NEEDED TO BE REPLACED IN ORDER TO REPAIR THE AIRBAG PROBLEM. PARTS FOR THIS ALONE WERE QUOTED TO ME TO BE OVER $1248.71 THEIR REPAIR ORDER (#26083616/1) NOTED THAT THE AIRBAG PROBLEM WAS "A LOOSE CONNECTION."

NHTSA ID

10819931

Incident

Jan 12, 2016

Mileage

78,263 mi

"TAKATA RECALL" ON OR ABOUT OCTOBER 16, 2015 I COULD NOT GET OUT OF MY DRIVERS SIDE DOOR...I WAS LOCKED IN. I AM UNABLE TO UNLOCK THE DOOR FROM THE INSIDE, OR FROM THE OUTSIDE WITH MY KEY. THE DOOR WILL NOT OPEN AND I HAVE TO CLIMB ACROSS TO THE PASSENGER SIDE TO GET IN AND OUT. I DON'T KNOW IF IT HAPPENED WHILE I WAS DRIVING DOWN THE ROAD, OR WHEN I STOPPED.

NHTSA ID

10816767

Incident

Oct 16, 2015

Mileage

121,000 mi

AIRBAG- WE STARTED THE CAR UP AND THE AIRBAG LIGHT CAME ON AND HAS NOT WENT OFF (OTHER THAN WHEN THE CAR IS SHUT DOWN). AFTER RESEARCH DISCOVERED THAT AN AIRBAG FAILURE WAS PART OF A RECALL FOR THIS MODEL, BUT ONLY FOR OPTIMA'S MANUFACTURED FROM SEPT 2005 FORWARD. THIS ONE WAS MANUFACTURED A FEW WEEKS PRIOR, YET HAS THE SAME PROBLEM. AFTER A GOOGLE SEARCH, THE ISSUE CAN BE FOUND ON OPTIMA'S WITH A MANUFACTURE DATE AS FAR BACK AS APRIL OF 2005. THE RECALL NEEDS TO BE EXPANDED TO ALL 2006 MODELS. DRIVER DOOR LOCKS- WHEN THE DOOR IS LOCKED, IT WILL NOT UNLOCK WITHOUT A LOT OF PLAYING WITH THE FOB OR USING KEY AND 'GETTING LUCKY' TO GRAB THE HANDLE AT THE CORRECT TIME WHILE DOING SO, OTHERWISE IT LOCKS BACK IMMEDIATELY UPON PULLING THE HANDLE. THIS IS A SAFETY ISSUE ON 2 LEVELS. 1-IF FOR WHATEVER REASON YOUR TRAVELS TAKE YOU THROUGH ROUGH NEIGHBORHOODS, THE ABILITY TO LOCK THE DOORS COULD SAVE YOUR LIFE IF YOU COME ACROSS THE WRONG PEOPLE. HOWEVER, YOU CAN NOT LOCK THEM BECAUSE IF YOU HAVE AN ACCIDENT AND THE CAR CATCHES ON FIRE OR YOU NEED TO ESCAPE THE VEHICLE QUICKLY, THE DOOR WILL NOT UNLOCK SO YOU CAN OPEN IT LEAVING YOU TRAPPED IN THE VEHICLE. AFTER PERFORMING A SEARCH ON GOOGLE, THIS ISSUE SEEMS TO BE WITH THE LOCK ACTUATOR AND IS EFFECTING OPTIMA'S DATING BACK TO THE 2002-2003 MODELS. BOTH OF THESE ISSUES SERIOUSLY NEED TO BE DEALT WITH BY KIA. EITHER ISSUE IS SETTING UP A SCENARIO THAT WILL RESULT IN THE DEATH OF THE DRIVER, IF A SEVERE ACCIDENT OCCURS. *TR

NHTSA ID

10789786

Incident

May 30, 2015

Mileage

152,000 mi

TL* THE CONTACT OWNS A 2006 KIA OPTIMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT PULLED OVER AND DISCOVERED THAT THE REAR PASSENGER SIDE OF THE VEHICLE WAS DRAGGING ON THE GROUND. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER SIDE CONTROL ARM HAD FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 129,000.

NHTSA ID

10758898

Incident

Apr 15, 2015

Mileage

129,000 mi