2012 Kia Optima Problems

The dealer is refusing to replace the engine under the previously completed Safety Recall Campaign SC147 (NHTSA Campaign 17V224000). The engine is currently exhibiting clear signs of connecting rod bearing failure—the exact mechanical hazard SC147 was issued to address. The dealership inspected the vehicle, confirmed internal engine failure, and verified that SC147 was completed on this VIN. However, they denied coverage citing an incomplete software update (Product Improvement Campaign PI1803) associated with a separate class-action lawsuit. The dealer is incorrectly conflating the requirements of the class-action warranty with the vehicle's independent eligibility under the safety recall. Independent of the class-action parameters, I am requesting a repair under the standalone 15-year/unlimited-mileage extended warranty provided specifically for vehicles that completed SC147 (detailed in the SC147 Safety Recall Campaign Q&A dated May 22, 2017, and Kia Warranty Bulletin 2017-09, both uploaded with this submission). The vehicle is well within this 15-year extended warranty period. Additionally, the PI1803 Knock Sensor Detection System update is a diagnostic detection tool, not a physical remedy for the underlying crankshaft machining defects identified in 17V224000. A manufacturer and its dealer network should not be permitted to use an unrelated class-action software prerequisite to invalidate a pre-existing, federally mandated safety recall warranty.

Engine faílúre on June 26, 2026.Dies while moving. Engine died while turning from my side street onto busy street and traffic.I could've been struck in the rear had I not pulled out far enough in advance for the traffic to move around me. This is a second engine failure for my Kia. The engine was replaced in December 2023/ January 2024. Incident #11558201. It does not immediately restart. After some time (about an hour) it takes a long time for it to kick over then finally starts. When beginning to move forward it travels approximately 100-150 feet then dies again. A gentleman stopped to see if he could help. He thought the fuel gauge was broken and just needed gas. (Gas tank was full). Then he put the car in neutral and pushed me home with his truck. Then he helped me push it up into my driveway. I haven't gotten to the dealership (Ferguson Imports) Kia because of the cost of towing which I am responsible for if I wish to have it seen by a service specialist. It is available for inspection upon requést.

Steering flexible coupling was a recall over 10 years ago, it was replaced. The steering wheel “sticks” and it’s catching again and they will not do anything. I’m not happy that this is an ongoing problem and can be dangerous if it sticks at the wrong time!

I had a engine replaced 1600 miles ago delarsship advised it was ok to drive gave me a vechicle back with abs light tracation control light on along with a exuast leak

The horn stops working, steering heat stop working, control functions and air bag warning. I changed the clock spring and it fixed all those issues the first time but within 6 months all those issues happened again. Is there something more wrong?

A issue with the Valve cover gasket leaking into the engine causing a misfire. Making the car suddenly stop while driving which is very unsafe. I took the car to the dealership and they want to charge me for the repairs. I have 2 kia optima hybrid and both cars have the same issue around the same mileage. There were no warning lights during the time it was at the shop. However one day the check engine light did come on and the OBD code P1326 came up. When I took it to the shop the check engine light disappeared and the dealership said they will not check my engine unless they see the code on their end. I believe later down the line the engine will stall out and it should be fixed now while under warranty. However I received no help from the dealership unless I am willing to pay upfront. In addition to this there are electrical issues the front seats aren't moving immediately when the button is pressed. The steering wheel buttons barely work along with the radio. This is a huge problem that needs to be fixed.

I bought this car February 2026 when I drove it on the freeway they car felt wiggly not the axle is broke and the wheel bearings stop the car from going

When the brake pedal is pressed on the brakes will grab. It snatches the car kinda hard. Also when you give the car gas it will hesitate and will not accelerate. Another with the gas is that you can be driving at a higher speed such as 45 to 55 or so and you press down the gas pedal like your going into passing gear and it will not accelerate it’s like it’s trying to stop. Feels like the car is gonna fall on down onto itself and it loses power.

Car simply started for me after work this past Thursday @4 pm I dove down the street and for about 5 mins and had to turn around due to me leaving something at work. When I arrived back at work I parked and cut my car off as I normally do and when I returned to start it back up it never did. I have previously been having to add 5 quarts of oil frequently at least once or twice a month for the past 7 months since last year. Was told my car had an oil consumption problem by a previous mechanical shop last year. Noticed that these cars have recalls on them and that my car and year do fit the requirements. I do owned my car with the Title in hand. It’s NOT a salvaged title. I have a service appointment on the 24th of June next Tuesday at Kia of Gastonia located in Gastonia, NC. I have to get my car towed to this establishment on Monday or the morning of my appointment. I’m asking that this situation can be properly investigated and properly and honestly handled under KIA policy. My name is [XXX] my # is [XXX] thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving home at night around 8pm. I was merging into the slow lane and my car completely lost power. A semi truck was right behind me. Luckily I was able to get over to the emergency lane safely. My car had no acceleration at all or any control of the steering. Prior to this incident there was no problem or warnings of any lights on dash or car having problems. It’s a daily driver for me to work. It’s never gave me any problems prior to this. I’ve had the routine maintenance done on along with the recommended mileage maintenance done. It’s been over a month now and my car still won’t start I haven’t had time to get it towed to a dealer ship or repair shop because I work 17 hour days. Everything I’ve researched about my make and model is starting to indicate that the engine seized up. I really hope that’s now the case because my car will be paid off in 3months. It has 165k miles on it I need help on weather the engine is part of a recall.

Sudden engine failure while driving with no warning. Vehicle began jerking, shaking, and losing power. RPMs dropped unexpectedly and the engine stalled intermittently. Multiple misfire codes were present (cylinders 1, 3, and 4), and the engine was found to have low or no compression in cylinder 1. The condition rapidly worsened to near complete engine failure. The vehicle was operating normally prior to this incident. This failure is consistent with known Kia engine defects involving internal engine damage, including rod bearing failure. This is a safety concern due to sudden loss of power while driving.

The contact owns a 2012 Kia Optima. The contact stated that while parking the vehicle, the gear shifter was shifted into park; however, the message to shift to park was displayed. In addition, the contact stated that there was a delay while shifting gears. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the vehicle was taken to several dealers, and the failure was not duplicated. The contact was informed by one dealer that the transmission needed to be replaced. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact researched and determined that the failure was related to the TCM failure. The manufacturer was made aware of the failure. The failure mileage was approximately 78,000.

When the brake pedal is pressed on the brakes will grab. It snatches the car kinda hard. Also when you give the car gas it will hesitate and will not accelerate. Another with the gas is that you can be driving at a higher speed such as 45 to 55 or so and you press down the gas pedal like your going into passing gear and it will not accelerate it’s like it’s trying to stop. Feels like the car is gonna fall on down onto itself and it loses power.

While in park and driving the instrument panel will show, "Check Brake" and "Hybrid System Warning! Safely Stop and Do not Drive". This is accompanied by the engine not responding to the gas pedal. The brake pedal will also loose pressure and once pushed the brakes will lock up making a grinding noise. The problem has not been able to be duplicated by the dealer. However there are multiple forms and online communities dedicated to try to resolve this issue since it's so prevalent. This issue causes a major saftey hazard as the car comes to a grinding halt and does not respond to the driver. From online sources it seems the problem is prevalent across years and models and only tied to hybrid vehicles.

I had a engine replacement under Pi1803 they gave me the vechile back w active abs light exuast leak and damaged click spring refused ti look at till I paid dx fee this all appeared the day I went to pick uo vechicle

I had a engine replaced 1600 miles ago delarsship advised it was ok to drive gave me a vechicle back with abs light tracation control light on along with a exuast leak

On August 25th around 7:00 PM, the vehicle suddenly caught fire while parked after a short test drive. The car had just been purchased a few days prior and was taken to a mechanic for a precautionary inspection. During the test drive, the mechanic parked the vehicle in a residential driveway. After backing in, smoke was observed coming from the engine bay. When the hood was lifted, the engine area was already on fire. The fire department was called immediately and was able to extinguish the flames before the fire spread to surrounding property. The fire completely destroyed the vehicle. The vehicle had no warning lights, unusual performance issues, or prior signs of trouble, and it appeared to be in good condition prior to the incident. This fire posed a serious safety hazard and could have resulted in injury or property damage. Component or system that failed: The engine area, likely associated with the Hydraulic Electronic Control Unit (HECU) fuse/fire risk. The vehicle may or may not be available for inspection, as it is severely burned. Safety risk: The fire posed a serious hazard to the mechanic, surrounding property, and anyone nearby. Rapid ignition could have caused injury or significant property damage. Problem confirmation: The fire was observed firsthand by the mechanic. The open recall related to the HECU fuse/fire risk indicates a known defect consistent with the incident. Inspections: The fire department responded and documented the incident. The vehicle has not yet been inspected by the manufacturer or insurance representatives, but the recall status is verifiable through official records. Warning signs: There were no warning lamps, messages, or other symptoms prior to the failure. This incident appears consistent with the conditions described in the open recall for the HECU fuse/fire risk, suggesting a possible link between the recall defect and the fire.

Rapid Delamination and paint peeling in the color of snow pearl white. The entire car is affected by this defect. Somewhere on the paint assembly line a missing step in the paint procedure is causing detrimental corrosion and overall safety and protection of the elements from outside.

Subject: RECALL VIOLATION: Kia on the Boulevard (Philadelphia) - Refused Remedy, Charged $199, Returned Unsafe Vehicle Vehicle Information: [Year] Kia Optima Hybrid Dealership Name: Kia on the Boulevard Dealership Address: 11295 Roosevelt Blvd, Philadelphia, PA 19154 Complaint Description: 1. The Safety Incident: While operating the vehicle, I experienced a catastrophic engine failure. Thick smoke poured from the engine compartment, followed by immediate stalling. This presented a severe fire risk and safety hazard. 2. Dealer Misconduct & Illegal Charges: I towed the vehicle to Kia on the Boulevard (11295 Roosevelt Blvd, Philadelphia) for the active engine recall remedy. The dealership: * Refused to perform the recall repair free of charge. * Forced me to pay a $199 "diagnostic fee" just to look at the recall-related defect, which should be covered by the manufacturer. * Threatened me with $45/day storage fees if I did not pay the $199 and remove the vehicle immediately. 3. Current Status: Under the threat of accumulating storage fees, I was coerced into paying the $199 and towing the vehicle back to my residence. The dealership knowingly released a vehicle with a catastrophic engine failure (smoke/fire risk) back to the owner without performing the federally mandated remedy. The unsafe vehicle is now sitting at my home unrepaired. 4. Conclusion: I request an immediate investigation into Kia on the Boulevard's refusal to honor the recall and their practice of charging customers for recall-related inspections.

My 2012 Kia optima headlamps are extremely dim, even though I’ve replaced the lightbulbs with the highest possible lumens, multiple times, the headlamp assembly continues to dim. This requires that I ride with my high-beams on to drive at night. The lights have been dimming for more than 20,000 miles, but they are almost useless at this point.

The contact owns a 2012 Kia Optima. The contact stated that while driving at 30 MPH, the contact pressed on the horn, and the horn failed to function as intended. No warning lights were illuminated. The contact stated that on a separate occasion, upon starting the vehicle and attempting to adjust the driver’s side mirror, there was an abnormal clicking sound coming from the side-view mirror motor. The contact stated that several days later, the abnormal clicking sound ceased, and the driver’s side mirror failed to function as intended. On a separate occasion, the passenger’s side mirror motor was making an abnormal clicking sound. Several days later, the clicking sound ceased and the passenger’s side mirror failed to function as intended. No warning lights were illuminated. The contact stated that while attempting to close the sunroof, the motor failed to function as intended and the sunroof was half closed. The contact had to place a tarp over the sunroof to protect inside the vehicle from the elements. No warning lights were illuminated. Recently the vehicle received maintenance and there was an abnormal knocking sound coming from the engine. In addition, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that while driving at slow speeds, the vehicle stalled. The contact was able to coast to the side of the road. No warning lights were illuminated. The vehicle was towed to the dealer, where it was diagnosed and determined that an unknown part had failed in the engine. The contact was unsure what part of the engine had been replaced. The failure recurred, and the contact had safety concerns about the vehicle. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.

The contact owns a 2012 Kia Optima. The contact stated that the front passenger's side window failed to roll up or down as needed. The vehicle was taken to the dealer; however, the contact was unaware of the diagnostic result, nor the parts that needed to be replaced to repair the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

BRAKES SQUICK EVEN AFTER REPAIR AND REPLACEMENT AND HAS A SLOWER RESPONSE TIME THEN USUAL AND CAUSED A REAR END ACCIDENT, COOLING AND HEATED SEATS STOPPED WORKING ON THE DRIVER SIDE WHICH I MET OWNERS OF MY EXACT CAR SAID THE SAME THING HAS HAPPENED TO THEM, AND THE PASSENGER SEAT CONTROLLERS DOESN'T WORK TO OPERATE ADJUSTABLE SEATS! THE SUSPENSIONS HAS BEEN BAD EVERY SINCE THE RECALL ON THE ENGINE; FOR SOME REASON IT WAS GIVING BACK TO ME WITH THAT PROBLEM FROM KIA DEALERSHIP. BACK-UP CAMERA IS MALFUNCTIONING FOR YEARS NOW AND CAR DOESN'T EVEN BEEP WHEN GETTING TOO CLOSE TO OBJECTS/OTHER VEHICLES ANYMORE EITHER FOR YEARS! I'M JUST FINDING OUT ABOUT THE PROCESS, RECALL LAWS AND RIGHT TO AN INVESTIGATION.*DT*JB

THE VEHICLE REQUIRES THAT YOU HOLD THE STEERING WHEEL TIGHTLY AT ALL TIMES TO PREVENT THE VEHICLE FROM VEERING TO THE RIGHT OR LEFT. THIS IS NOT AN ALIGNMENT ISSUE, NO UNEVEN WEAR OF THE TIRES. IN ADDITION THE STEERING IS QUITE HARD REQUIRING UNUSUAL GRIP ON THE WHEEL. ALSO EVERY SLIGHT BUMP IS FELT THROUGHOUT THE CAR. THE FAILURE OF KIA TO ADDRESS THIS PROBLEM FOUND IN MANY OF THEIR PRODUCTS, MAKES THIS COMPANY/MNF OF QUESTIONABLE CHARACTER.

I bought this car February 2026 when I drove it on the freeway they car felt wiggly not the axle is broke and the wheel bearings stop the car from going

Dear NHTSA, I am submitting a formal complaint regarding my 2012 Kia Optima, which experienced an engine fire directly related to the defects identified in Kia Safety Recalls SC147, SC200, and SC201. On XXX, my vehicle’s engine failed and caught fire. This is the exact condition covered by the above recalls, which state that affected engines may seize, stall, or ignite. I have been in contact with both a Kia dealership and Kia Consumer Affairs for close to a month without any resolution. The dealership has confirmed that my car requires a complete engine replacement, but Kia has refused to address the recall issue, claiming that other unrelated recalls were not performed. When I previously contacted dealerships to schedule recall repairs, I was told that parts were not available, which prevented me from completing them. In addition to the engine failure, the fire also caused my starter to fail. I was forced to purchase a replacement starter out of pocket, which has added to my financial hardship. I believe I am owed compensation for this expense, as it was a direct result of the safety defect. This situation has caused me severe financial strain, as I relied on my vehicle for work and currently have no income due to its inoperability. Kia has not provided a timeline for repairs, towing coverage, or written confirmation that they remain obligated to remedy this federally mandated safety defect. I am requesting that NHTSA investigate Kia’s refusal to fulfill its recall obligations and intervene to ensure that my vehicle is repaired or replaced in compliance with federal recall requirements. My vehicle details are as follows: •Year/Make/Model: 2012 Kia Optima •VIN: XXXX •Recalls involved: SC147, SC200, SC201 •Incident: Engine fire, vehicle no longer drivable; starter also failed due to fire Please advise on next steps. Thank you for your time and attention to this matter. Sincerely, XXXX XXXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2012 Kia Optima EX with 67000 miles driver-side seatbelt dash warning goes off even it is buckled securely while driving.

The front driver's seat bolts loosened and came completely off the track. This could have caused me to crash as the seat was no longer stable and shifted about the car until I could get to a safe location. If I had gotten into a crash I would most likely not survived as there was nothing that held me in the car despite having my seat belt on. The vehicle is at the dealership now. There were no warnings that this seat was malfunctioning and the bolts were loosening.

TL* THE CONTACT OWNS A 2012 KIA OPTIMA EQUIPPED WITH HANKOOK OPTIMO H431 TIRES, SIZE 225/45R 18V. WHILE DRIVING 20 MPH, THE TIRE GAUGE INDICATOR ILLUMINATED. AN INDEPENDENT MECHANIC FOUND AN AIR BUBBLE IN THE REAR DRIVER SIDE TIRE. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN AND DOT NUMBER WERE UNAVAILABLE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 36,000 AND THE TIRE FAILURE MILEAGE WAS 7,000.

ALL 4 HANKOOK OPTIMO 225/45/18 TIRES THAT CAME WITH MY 2012 KIA OPTIMA SX VEHICLE DEVELOPED A BUBBLE IN THE SIDEWALL WITHIN 18 MONTHS. DUE TO SAFETY CONCERNS AND ADVICE FROM THE DEALERSHIP ALL 4 TIRES WERE REPLACED AROUND THE 2 YEAR POINT FROM PURCHASE OF THE VEHICLE. *TR

2012 Kia Optima EX with 67000 miles driver-side seatbelt dash warning goes off even it is buckled securely while driving.

TL* THE CONTACT OWNS A 2012 KIA OPTIMA. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED, AN OCCUPANT WAS WEARING THE DRIVER'S SIDE REAR SEAT BELT HOWEVER, THE BUCKLE CEASED AND FAILED TO RETRACT OR RELEASE. THE OCCUPANT HAD TO SLIDE OUT THE SEAT BELT. THE CONTACT CALLED GRAND KIA (1950 W 104TH AVE, DENVER, CO 80234, (720) 943-1144) TO NOTIFY THE DEALER OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSE NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 230,000.

The shifter cable came off during the car was on motion in my driveway..and unable to put it in PARK. My driveway has quite inclining uphill.. imagine if the car would roll back .. or simply the fact it worries me if that could happen somewhere away i would totally get stranded.. upon google i was able to confirm that KIA using the cheap parts and this happened to others also.. My boyfriend was able open gear console cover and snapped the cable ring back ...KIA should replace this part ASAP. BTW .. this was the second time it happened within a year