2005 Kia Rio Problems

WHEN THE CAR IS EXPOSED TO MOISTURE, EITHER FROM UNDERNEATH BY DRIVING THROUGH A SMALL PUDDLE OR FROM ABOVE IN A RAINSTORM, THE ENGINE COMPARTMENT GETS WET AND CAUSES THE SERPENTINE BELT TO SLIP. THIS RESULTS IN SUDDEN LOSS OF POWER STEERING AND ALTERNATOR FAILURE, WHICH CAN LEAD TO THE CAR'S POWER CUTTING OUT IN THE MIDDLE OF THE ROAD. THIS IS AN OBVIOUS DRIVING HAZARD, BUT I AM TOLD THAT THIS IS A COMMON ISSUE DUE TO THE CONSTRUCTION OF THE ENGINE COMPARTMENT IN KIA VEHICLES RATHER THAN A PRECIPITATING MECHANICAL FAILURE CAUSING IT.

TL* THE CONTACT OWNS A 2005 KIA RIO. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD TO A COMPLETE STOP. THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT FRACTURED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT ALSO STATED THAT THE VEHICLE WAS INSPECTED AND TAGGED WITH LICENSE PLATES ONE HOUR BEFORE THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 65,125.

WHEN THE CAR IS EXPOSED TO MOISTURE, EITHER FROM UNDERNEATH BY DRIVING THROUGH A SMALL PUDDLE OR FROM ABOVE IN A RAINSTORM, THE ENGINE COMPARTMENT GETS WET AND CAUSES THE SERPENTINE BELT TO SLIP. THIS RESULTS IN SUDDEN LOSS OF POWER STEERING AND ALTERNATOR FAILURE, WHICH CAN LEAD TO THE CAR'S POWER CUTTING OUT IN THE MIDDLE OF THE ROAD. THIS IS AN OBVIOUS DRIVING HAZARD, BUT I AM TOLD THAT THIS IS A COMMON ISSUE DUE TO THE CONSTRUCTION OF THE ENGINE COMPARTMENT IN KIA VEHICLES RATHER THAN A PRECIPITATING MECHANICAL FAILURE CAUSING IT.

TL*THE CONTACT OWNS A 2005 KIA RIO. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE WOULD SUDDENLY STALL. IT WOULD RESUME NORMALLY AFTER SHE DEPRESSED THE ACCELERATOR PEDAL. THE FAILURE BECAME PROGRESSIVELY WORSE OVER TIME. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP THREE TIMES FOR AT LEAST A WEEK SO THAT THE DEALER COULD DUPLICATE THE FAILURE AND FIND A CAUSE FOR THE FAILURE. THE DEALER STATED THAT THE PROBLEM COULD HAVE BEEN THE FUEL FILTER OR SENSOR. THE FUEL FILTER AND SPARK PLUGS WERE REPLACED BUT THE FAILURE CONTINUED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE VEHICLE WAS CURRENTLY AT THE DEALERSHIP AND THE CONTACT DID NOT FEEL IT WAS SAFE TO DRIVE. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000. THE CURRENT MILEAGE WAS APPROXIMATELY 54,000. THE SENSORS AND FUEL PUMP WERE REPLACED, HOWEVER THE VEHICLE CONTINUED TO STALL. UPDATED 06/22/10.*JB UPDATED 08/11/10. *LJ UPDATED 10/05/10*JB

I WAS DRIVING ON PUBLIC STREET LOSS CONTROL DUE TO A POT HOLE IN THE STREET THE CAR LOST CONTROL FLIPPING SLIDING THEN FLIP UP RIGHT TILL IT CAME TO A STOP ON APT WALL THEN WHEN IT WAS ALL OVER AND DONE THE AIRBAG DEPLOYED GO OFF ON MY ARM RIGHT ARM GIVING ME SECOND TO THIRD DEGREE BURNS THE PURPOSE OF THE AIR BAG ? I HAVE BROKEN BACK CAR WAS TOTALED NOW I GOT CHRONIC PAIN EVERYDAY I LOST MY CAR AM LIMITED ON MOBILEBILITY WAS GOING GET SCREWS PLACED ON MY BACK AND UN ABLE TO SET WALK OR STAND DO TO CHRONIC PAIN

TL* THE CONTACT OWNS A 2005 KIA RIO. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING LIGHTS RANDOMLY FLASHED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V244000 (AIR BAGS); HOWEVER, THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION. THE VEHICLE WAS TO BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 KIA RIO. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING LIGHTS RANDOMLY FLASHED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V244000 (AIR BAGS); HOWEVER, THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION. THE VEHICLE WAS TO BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

THE DRIVER SEAT BELT LATCH ASSEMBLY IS SPLIT IN TWO. THERE WERE NO EVENTS LEADING UP TO THE EVENT, IT JUST HAPPENED ONE DAY. IT HAS NOT BEEN REPAIRED OR REPLACED, IT IS CURRENTLY BEING HELD TOGETHER WITH DUCT TAPE. *TR

NOT REALLY A SAFETY ISSUE BUT MAYBE YOU CAN HELP, PLEASE. I CHECK ENGINE LIGHT CAME ON TELLING ME I'M AT LESS THAN 90% EFFICIENCY RELATIVE TO POLLUTION. WHEN THE MECHANIC CHECKS THE CO2 AND OTHER POLLUTION REQUIREMENTS I'M OK. I STILL GET GREAT MILEAGE AND GOOD POWER. THE PROBLEM IS THE COMPUTER SAYS THE CONVERTER IS OFF AND HENCE CAN'T GET A STICKER BUT THE CAR IS NOT POLLUTING ?? IF I LIVED OUT SIDE A BIG CITY WHERE THEY DO NOT TRACK THIS STUFF THERE WOULD BE NO PROBLEM. PS THE COST TO REPLACE THE CAT CONVERTER IS OVER $1400.00. WHILE IT US STILL 90% EFFECTIVE??? WHAT GIVES PLEASE HELP. THANKS, *TR

KIA PLACED A BULLETIN WITH YOU ON 1/1/05,#TSB82,#10015272. APPARENTLY KIA THOUGHT THAT WAS ENOUGH. MY KIA WAS PURCHASED 7/21/05. I WAS TOLD I HAD "BUMPER TO BUMPER COVERAGE IF I PURCHASED THE ADDITIONAL 4,000. EXTENDED WARRANTY. THEY WERE REQUIRED TO FURNISH ME WITH A COMPLETE WARRANTY DISCLOSURE BEFORE PURCHASE. THEY DID FURNISH ME WITH A BOOKLET CALLED WARRANTY AND CONSUMER INFORMATION MANUAL AND A PAMPHLET CALLED START UP TIPS FOR YOUR KIA. I DID READ THESE. AND THE TIMING BELT ISN'T MENTIONED. LATER WHEN I READ MY OWNERS MANUAL I DID NOTICE THAT THE MAINTENANCE REQUIREMENTS DID MENTION THE TIMING BELT, IT SHOULD BE CHECKED AT 30,000 MI, 60,000MI AND POSSIBLY CHANGED AT 105,000. KIA DOES CLAIM 100,000 WARRANTY, AND I HAD THE BUMPER TO BUMPER COV, SO I STILL FELT PRETTY CONFIDENT IN MY CAR. IF KIA HAD COMPLETELY DISCLOSED ALL THE MAINTENANCE AT THE TIME OF PURCHASE I WOULD HAVE WALKED. AT 38,000 MI I WAS ON MY WAY TO WA. I WAS JUST ABOUT TO THE TOP OF RICE HILL WHEN SOMETHING HAPPENED. 6 LANES OF 70MPH TRAFFIC, CONCRETE ON ALL SIDES AND NOWHERE TO GO, WHEN THE CAR LOST POWER. IT WAS VERY DISORIENTING THE ENGINE REVVED BUT NO POWER, NO CHECK ENGINE LIGHT, NOTHING,I WAS DUMBFOUNDED. I PUT MY FLASHERS ON AND WAS ABLE TO COAST TO THE RT. LANE. WE PUSHED IT OVER THE TOP OF RICE HILL AND COASTED TO THE SHOULDER. I CALLED KIA, THEY TOLD ME I HAD NO COVERAGE, BECAUSE MY CAR WAS A WEEK PAST 5 YRS. WE TOWED IT TO KIA WHERE THEY TOLD ME I WASN'T COVERED. SO I CALLED KIA AND THEY TOLD ME IT WAS UP TO THE SERVICE MAN.. I WENT BACK TO KIA, AND THE MANAGER TOLD ME I NEEDED TO DO A DIAG TEST ($174.) WHICH I KNEW WAS IMPOS. BECAUSE THE CAR WON'T START. AFTERWARD THE SERVICE MAN TOLD ME HE HAD LOOKED AT MY CAR AND THE TB WAS GONE BUT THE PISTONS WERE FINE WHICH IS RARE. THEY WON'T FIX IT. I WENT ONLINE AND FOUND 100 CONSUMERS WITH BLOWN ENGINES AND DEFECT. TIMING BELTS. WHATS UP? THIS IS DANGEROUS! IT CAN CAUSE ACCIDENTS! I WAS LUCKY! DO SOMETHING. *TR

I HAVE A 2005 KIA RIO (VIN PROVIDED LATER) PURCHASED 2006, LOW MILES. SUMMER 2011 CAR STALLED, STOPPED & CHECK ENGINE LIGHT CAME ON & HAD IT TOWED TO THE NEAREST SHOP, NTB. REPLACED TIMING BELT & NO DAMAGE TO MY MOTOR. I FOUND OUT THE TIMING BELT NEEDED CHANGING AT 60K MILES (MINE WAS LOWER). THE MECHANIC WASN'T ABLE TO DETERMINE A REASON FOR THE CHECK ENGINE LIGHT. ANOTHER SUGGESTED A BAD SENSOR & WIPED SOMETHING OFF UNDER THE HOOD. THE LIGHT WENT OFF AFTER DRIVING LESS THAN 5 MILES. REPLACED THE ALTERNATOR APRIL 2013 (NEW ALTERNATOR, BELT & PARTS STILL UNDER WARRANTY). JUNE 2013 THE CHECK ENGINE LIGHT STARTED COMING ON WHEN PARKED UPWARD ON AN STEEP HILL, ESP WHEN OUTSIDE TEMP WAS VERY HOT (TX). THE LIGHT WOULD REMAIN ON UNTIL AFTER PARKING IT IN A COVERED GARAGE & DRIVING HRS LATER. JULY 2013 MANDATORY CAR INSPECTION. WEEK OR 2 LATER, PROBLEMS W/ RPM STARTED; DURING TAKE AFTER IDLE. ABOUT 2WKS LATER, AC SPEED SUDDENLY SLOWED & BECAME WARMER. 2DAYS LATER CHECK ENGINE LIGHT ON & A STRANGE NOISE NEAR THE DRIVER'S SIDE. AGAIN, TOWED TO THE NEAREST SHOP, THE SAME NTB. ALL ELECTRICAL COMPONENTS WAS STILL WORKING. AT THE SHOP THE CAR STARTED BUT NOT LONG. THEY WERE PUZZLED. AFTER 2DAYS I WAS TOLD MY MOTOR WAS BAD & NEEDED REPLACED. NO ONE HAD AN EXPLANATION.I HAD TO HAVE MY CAR, ONLY TRANSPORTATION FOR ME & MY KIDS TOWED HOME. I TALKED TO DIFFERENT MECHANICS THAT AGREE I HAVE A BAD SENSOR & CATALYST WHICH CAUSED MY MOTOR TO LOCK (PRE-IGNITION). THERE ARE SEVERAL BLOGS/ARTICLES W/THIS SAME PROBLEM. HOWEVER, KIA HAS NEVER SAID ANYTHING ABOUT THE 2005 RIO FUEL PROBLEMS, ONLY THE 2004 & SUPPOSEDLY CORRECTING IT. BUT IT WASN'T & MECHANICS CAN'T DIAGNOSE IT. SOMETHING IS WRONG & NEEDS INVESTIGATING. A FATAL ACCIDENT COULD HAVE OCCURRED IF I HAD BEEN DRIVING ON THE HWY. KIA SHOULD TAKE RESPONSIBILITY FOR LOST $ AND TIME BC THEY ONLY BANDAGED THE PROBLEM & NOT ACTUALLY FIXING IT.

DT: THE CONSUMER STATED SEVERAL TIMES WHILE AT A STOP LIGHT, THEN AGAIN AT A STOP SIGN WITH HER FOOT ON THE GAS PEDAL WITH THE VEHICLE IN DRIVE AND THE GEAR SHIFTED INT NEUTRAL. THE PROBLEM ALSO OCCURRED WHEN DRIVING AT VERY LOW SPEEDS IN THE PARKING LOT. THE GEAR SHIFTED INTO NEUTRAL AGAIN. WHILE DRIVING AT 65 MPH IN A RAIN STORM THE VEHICLE MADE A NOISE AND THE DASHBOARD LIGHTS CAME ON. THE CONSUMER PULLED OFF OF THE FREEWAY AND TURNED THE VEHICLE OFF. THE CONSUMER STARTED THE VEHICLE, BACKED UP AND IT WORKED FINE. THE VEHICLE HAD 3400 MILES ON IT. THE PROBLEM STARTED AT 2000 MILES. THE VEHICLE HAD BEEN CHECKED AT A LOCAL DEALERSHIP. THE MECHANIC STATED THAT THE TRANSMISSION SENSORS WERE FINE. *AK (11/29/05) THE OVERDRIVE WOULD SHUT OFF AT 65 MPH. *SC

I WAS DRIVING ON PUBLIC STREET LOSS CONTROL DUE TO A POT HOLE IN THE STREET THE CAR LOST CONTROL FLIPPING SLIDING THEN FLIP UP RIGHT TILL IT CAME TO A STOP ON APT WALL THEN WHEN IT WAS ALL OVER AND DONE THE AIRBAG DEPLOYED GO OFF ON MY ARM RIGHT ARM GIVING ME SECOND TO THIRD DEGREE BURNS THE PURPOSE OF THE AIR BAG ? I HAVE BROKEN BACK CAR WAS TOTALED NOW I GOT CHRONIC PAIN EVERYDAY I LOST MY CAR AM LIMITED ON MOBILEBILITY WAS GOING GET SCREWS PLACED ON MY BACK AND UN ABLE TO SET WALK OR STAND DO TO CHRONIC PAIN

WHEN THE CAR IS EXPOSED TO MOISTURE, EITHER FROM UNDERNEATH BY DRIVING THROUGH A SMALL PUDDLE OR FROM ABOVE IN A RAINSTORM, THE ENGINE COMPARTMENT GETS WET AND CAUSES THE SERPENTINE BELT TO SLIP. THIS RESULTS IN SUDDEN LOSS OF POWER STEERING AND ALTERNATOR FAILURE, WHICH CAN LEAD TO THE CAR'S POWER CUTTING OUT IN THE MIDDLE OF THE ROAD. THIS IS AN OBVIOUS DRIVING HAZARD, BUT I AM TOLD THAT THIS IS A COMMON ISSUE DUE TO THE CONSTRUCTION OF THE ENGINE COMPARTMENT IN KIA VEHICLES RATHER THAN A PRECIPITATING MECHANICAL FAILURE CAUSING IT.

I WAS DRIVING ON PUBLIC STREET LOSS CONTROL DUE TO A POT HOLE IN THE STREET THE CAR LOST CONTROL FLIPPING SLIDING THEN FLIP UP RIGHT TILL IT CAME TO A STOP ON APT WALL THEN WHEN IT WAS ALL OVER AND DONE THE AIRBAG DEPLOYED GO OFF ON MY ARM RIGHT ARM GIVING ME SECOND TO THIRD DEGREE BURNS THE PURPOSE OF THE AIR BAG ? I HAVE BROKEN BACK CAR WAS TOTALED NOW I GOT CHRONIC PAIN EVERYDAY I LOST MY CAR AM LIMITED ON MOBILEBILITY WAS GOING GET SCREWS PLACED ON MY BACK AND UN ABLE TO SET WALK OR STAND DO TO CHRONIC PAIN

TL*THE CONTACT OWNS A 2005 KIA RIO. WHILE DRIVING AT LOWS SPEEDS THE VEHICLE BEGAN TO RANDOMLY HESITATE. THE FAILURE USUALLY OCCURRED WHEN THE ENGINE WAS COLD OR IT HAS NOT RAINED WITHIN A FEW HOURS. THE VEHICLE BEGAN TO DRIVE NORMALLY WHEN THE ENGINE WAS SHUT OFF AND RESTARTED. THE DEALER HAS MADE SEVERAL ATTEMPTS TO DIAGNOSE THE FAILURE. TWO WEEKS LATER THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. AN AUTHORIZED MECHANIC DIAGNOSED THE FAILURE ON A THIRD VISIT TO THE DEALER AND STATED THAT THEY WERE ABLE TO REPAIR THE VEHICLE; HOWEVER, THEY WERE UNABLE TO SAY WHAT COMPONENT WAS REPAIRED. THE FAILURE CONTINUED TO OCCUR. THE FAILURE MILEAGE WAS ESTIMATED TO BE 9,000 AND THE CURRENT MILEAGE WAS 39,000.

KIA RIO 2005 IS A VERY POORLY BUILT CAR. THE PASSENGERS DOOR WILL NOT OPEN, A MECHANISM IN THE DOOR IS BROKEN. SINCE THE DOOR WON'T OPEN NO ONE SEEMS TO KNOW HOW TO REPAIR THIS PROBLEM. THE DOOR PANEL CAN NOT BE REMOVED FROM THE DOOR WITHOUT THE DOOR BEING OPEN. NEVER AGAIN WILL I BUY A KIA OF ANY KIND. *TR

THE PASSENGER DOOR WON'T OPEN. AND THIS IS A PROBLEM THAT MANY KIA RIO OWNERS HAVE WITH THEIR CAR. CAR IS A PIECE OF JUNK. IT IS BY FAR THE WORST CAR I HAVE EVER OWNED. *TR

BOUGHT NEW CAR CHILD SAFETY LOCKS FAILED. DRIVER DOOR JAMMED CLOSED COULD NOT OPEN FROM INSIDE OR OUTSIDE. THE DEALER MADE ME DRIVE WITH THE PROBLEM FOR THREE WEEKS BEFORE THEY WOULD EVEN LOOK AT IT. THAN TOOK A WEEK AND A HALF TO FIX IT. *NM

THE BLOWER STOPPED BLOWING AIR. FOR A SHORT WHILE IT WOULD COME ON, RARE OCCASIONS AND EVENTUALLY STOPPED WORKING. CHANGED THE BLOWER MOTOR AND RESISTOR, STILL DIDN'T WORK. PULLED THE DASH APART TO CHANGE THE BLOWER SWITCH AND FOUND THAT IT HAD MELTED THE PLASTIC CONNECTOR. NOT SURE WHAT CAUSED THE MALFUNCTION, HOWEVER ONCE THE NEW SWITCH WAS PUT IT THE BLOWER WORKED. *TR

AT ABOUT 5,000 MILES OR MAYBE EVEN SOONER I BEGAN TO DETECT AND HEAR SOMETHING THAT SOUNDED AND ACTED LIKE THE TRANSMISSION. EACH TIME TAKING VEHICLE FOR OIL CHANGE I TOLD THE SERVICE TECHNICIAN TO CHECK THE TRANSMISSION. IT JUMPED IN 2ND GEAR WHILE IN REVERSE. THEY FORGOT EACH TIME, AND DUE TO THE FACT THAT MY APPOINTMENT WAS EITHER CANCELLED OR NO OIL CHANGE PERSON WAS THERE WHEN I TOOK VEHICLE AT SCHEDULED TIME, IT WENT UNRESOLVED UNTIL THE OIL CHANGE ON JANUARY '6, 2006. DURING THE JANUARY 6, 2006 OIL CHANGE THE MECHANIC SAID THAT TRANSMISSION DIDN'T SOUND RIGHT. MADE ANOTHER APPOINTMENT TO BRING VEHICLE BACK FOR INSPECTION. IT TOOK 3 MORE WEEKS TO GET THE APPOINTMENT. I LEFT THE CAR AT 9 AM, WENT 5 MILES HOME, AND THEY ADVISED ME ON THE TELEPHONE THAT IT WAS THE CLUTCH NOT THE TRANSMISSION. THE WARRANTY ON THE CLUTCH EXPIRED AT 12,000 MILES. THE MILEAGE AT TIME OF THE FAILURE EXCEED THAT BY 2,000 MILES. THE CHARGE WOULD BE $668. 00. I THINK BILL BYRD KIA OF PANAMA CITY FLORIDA PURPOSELY LET THE WARRANTY EXPIRE BY PUTTING OFF APPOINTMENTS . I BOUGHT THE CAR FROM A DEALER IN ANOTHER STATE, AND THEY DIDN'T WANT TO DO THE WARRANTY WORK, AND THEY KNEW IT WAS THE CLUTCH. BY THE TIME FOR NEXT SCHEDULED APPOINTMENT 3 WEEKS LATER IT WOULD BE OVER THE 12,000 MILES. I WAS FURIOUS AND DID NOT INTEND TO TAKE THIS WITHOUT A FIGHT. THE MECHANIC SAID IT WAS A PROBLEM OF WEAR AND TEAR, AND IMPROPER DRIVING OF A STANDARD SHIFT. I THINK A CLUTCH SHOULD LAST LONGER THAN 12,000 MILES. AS FAR AS IMPROPER DRIVING OF A STANDARD SHIFT I HAVE BEEN DRIVING STANDARD SHIFTS FOR 48 YEARS, INCLUDING SCHOOL BUSES AND DUMP TRUCKS. *AK

DT*: THE CONTACT STATED THE BRAKES ON THE VEHICLE HAVE BEEN MAKING LOUD SCREECHING NOISES EVERY TIME THE BRAKE PEDAL IS DEPRESSED AT 10MPH. THE VEHICLE HAS BEEN TAKEN TO A SERVICE DEALER FOR REPAIR WHERE THEY DETERMINED THE DISCS WERE SLIGHTLY OFF CENTER. AFTER THE REPAIR, THE NOISE CONTINUED. THE DEALER WAS CONSULTED AGAIN, AND WAS UNABLE TO DETERMINE THE CAUSE OF THE NOISE.