2021 Kia Rio Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2021 Kia Rio, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Steering425.0%
- Brakes318.8%
- Engine212.5%
- Powertrain (other)212.5%
- Driver assistance212.5%
- Electrical16.3%
- Fuel system16.3%
- Seat belts16.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
Steering Gear Assembly completely broke at 81,000 miles. My daughter was backing up in a busy street at 5pm and lost 100 percent of steering control. Lucking cars dodged her and she didn’t get hurt or worse.
On 3/19/23, as I was driving on a dry, straight, two lane road at the posted speed of 40mph, the car began to try to steer into oncoming traffic. I had to exert moderate force to keep the car in my lane. This continued continuously for about 1/2 mile. No low tire pressure indicator lights were illuminated, however the lane assist icon was on and green, indicating normal operation. Just as I was going to turn down a side street to check the tires manually, the steering returned to normal. However, the lane assist icon was now white, and as I drove the remaining approximately 2 miles home, the icon would change from white to green every 20 seconds or so. The car now operates normally. We took the car to the dealer today to be checked and they reported they could not replicate the issue. Attached is their report.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
Having been complaining about a noise from under the front right tire, I was initially told it was a little piece of plastic and that got cut off. I was still hear the scraping and squealing and I kept check the from right tire because I thought that's where it was coming from. I mentioned this to every mechanic at kia and was told "that's just how 2021s sound". Finally after months of complaining the noise got louder and you could hear it was clearly something in steering. They schedules an appointment for Dec 7th on Mon Nov 28th. Said it was safe to drive when that night while working I was turning a corner, I heard a loud spring noise, the tire and wheel jerked. It was snowing, so the car slide, only sliding into the curb. The front right break seemed to be locked and when you turn the steering wheel makes even more noise. Haven't been told the issue, but I'm certain it is not safe and definitely shouldn't be on the streets until it's fixed.
Vehicle failed to reduce speed effectively while trying to avoid a collision with another vehicle during a left turn, which then caused the vehicle to turn widely and collide with the curb.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
I was driving 60-70 miles an hour for 45 minutes then car lost all acceleration and engine light came on. I pulled over immediately turned the car off. Turned it back on drove 1/4 of a mile and same thing happened. I pulled over turned car off and had it towed to the dealership.
Vehicle has less than 4000 miles and throttle body had to be replaced
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
Placed car in park got out to open a gate. Car took off forward even when shifter was in Park Position and almost ran a child over.
I had driven my wife to her school about 5 miles and headed back to my work another 5 miles when i tried to accelerate pass car I lost almost all power barely making it up a slight hill I kept going trying to make it to my house barely going 10 miles an hour. I thought the transmission had let go cause while I had the gas peddle floored i went at best 10-15 miles an hour I eventually parked the car I knew it would never make it up another slight hill. It was rowed to a nearby dealer where they could find no problem telling me it was just some bad gas. This sounds like what I read about today with a couple of other models of Kia.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
Center Console Display blank (screen black) upon startup unable to see cameras and backing up affected creating safety concern.
On 3/19/23, as I was driving on a dry, straight, two lane road at the posted speed of 40mph, the car began to try to steer into oncoming traffic. I had to exert moderate force to keep the car in my lane. This continued continuously for about 1/2 mile. No low tire pressure indicator lights were illuminated, however the lane assist icon was on and green, indicating normal operation. Just as I was going to turn down a side street to check the tires manually, the steering returned to normal. However, the lane assist icon was now white, and as I drove the remaining approximately 2 miles home, the icon would change from white to green every 20 seconds or so. The car now operates normally. We took the car to the dealer today to be checked and they reported they could not replicate the issue. Attached is their report.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
Center Console Display blank (screen black) upon startup unable to see cameras and backing up affected creating safety concern.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
Vehicle has less than 4000 miles and throttle body had to be replaced
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
seatbelts in rear are inoperable/anti theft not working. Kia dealership told me that its not their issue about the anti theft. I have been told on 3 separate occasions that my seatbelts have been ordered but they haven’t!!!! No one is following up with me, when I call I get told “until they can get in contact with the dealership Kia the corporate company cannot do anything” have 2 kids Kia the dealership as well as the corporate company knows about this and no one is doing anything!! NO ONE CARES
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .