2019 Kia Sedona Owner Complaints

The contact owns a 2019 Kia Sedona. The contact stated that while operating the vehicle, the check engine warning light illuminated, and the engine overheated. The vehicle was driven to the local dealer, who diagnosed that the engine head bolts had failed. The contact was informed that the engine needed to be replaced. The engine was replaced. The contact stated that later while driving at an undisclosed speed, the vehicle stalled. The vehicle was towed back to the dealer who diagnosed that the ignition coil had failed. The ignition coil and spark plug seals were replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 146,000.

NHTSA ID

11755275

Incident

Jun 18, 2026

Mileage

146,000 mi

The contact owns a 2019 Kia Sedona. The contact stated that the heat and A/C control knobs had melted twice, and the contact had purchased and personally replaced the entire control panel. Additionally, the contact stated that there was an abnormal strong fuel odor coming from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed, and the low-pressure fuel pump and fuel injectors were replaced on separate occasions. However, the failure recurred while leaving the dealer. The vehicle was taken back to the dealer, where it was determined that the high-pressure fuel pump needed to be replaced; however, after the repair, the vehicle started making abnormal sounds. Additionally, the contact stated that the abnormally strong fuel odor had worsened. The vehicle was taken back to the dealer, who informed the contact that no diagnostic trouble code was retrieved, and the contact was advised to pick up the vehicle. The contact expressed safety concerns that the vehicle was unsafe to drive due to the persistent failure. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.

NHTSA ID

11745095

Incident

Jun 18, 2024

Mileage

40,000 mi

Both sliding doors will not open using door buttons. Both doors stopped latching on their own before this occurred. Needed to push doors manually for the door to latch.

NHTSA ID

11734427

Incident

Apr 28, 2026

Driver's side power sliding door stopped latching and alarms, but doesn't hinder the vehicle from moving. This is an obvious safety risk, especially when our kids sit in the back next to that door. Evidence indicates that this was a known issue for the previous years of this vehicle, but the recall didn't include 2019 models, even though the issue looks to be the same.

NHTSA ID

11732039

Incident

Dec 1, 2025

The contact owns a 2019 Kia Sedona. The contact stated that while driving at 20 MPH, the vehicle was suddenly rear-ended when the other vehicle failed to stop. As a result, the vehicle was pushed into the vehicle in front. The driver-side and passenger-side air bags did not deploy. After the impact, the contact was unsure if any warning lights were illuminated. A police report was filed. The paramedics evaluated everyone at the scene of the accident. The contact and his family were not injured. The vehicle was towed to a towing yard. A lawyer was contacted, and the lawyer would inform the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.

NHTSA ID

11723849

Incident

Mar 9, 2026

Mileage

75,000 mi

Sliding doors have an issue where the car alarms like the doors aren’t shut. Took it in and paid a diagnostic for them to tell me a sensor was bad, it still beeps. Seems to beep more when turning away from that door (driver sliding door beeps more when turning right or when stopping, passenger beeps more when turning left or stopping). This was a problem with previous generation to where the warranty was extended and seems a decent amount of complaints for this model are related to the same.

NHTSA ID

11709206

Incident

Nov 5, 2025

My 2019 kia sedona showed the exact same symptoms for the oil pressure switch recall red oil light on the dash and a leaking oil pressure switch.2010 to 2018 sedona why was the 2019 model not added to the list

NHTSA ID

11706319

Incident

Dec 19, 2025

Oil consumption high and engine needs to be replaced after 75k miles.

NHTSA ID

11693240

Incident

Oct 10, 2025

Engine failed.hole in bottom engine housing approx. 2x2”

NHTSA ID

11680929

Incident

Jul 16, 2025

When using the power sliding doors, specifically the driver's side, it will not close and latch 100% of the time. It usually beeps and indicates it has not closed and has to be manually closed but on two occasions has opened on it's own. Fortunately it's been while parked, which poses a whole different issue, but I've read that others are having this happen while driving.

NHTSA ID

11672196

Incident

Jul 6, 2025

Sliding mini van doors fail to latch when closing. This is a well known and documented problem. The NHTSA has issued remedies for the previous year but not this one.

NHTSA ID

11655275

Incident

Apr 17, 2025

The engine seems to be burning oil. After my last oil change, I had to replace three quarts of oil after driving 2,500 miles. Once previously, the engine oil got dangerously low (no oil showing on dipstick) even without the vehicle giving any indication of low oil. This could lead to engine failure while operating the vehicle, which could have disastrous consequences.

NHTSA ID

11634804

Incident

Dec 2, 2024

Right power sliding door stopped closing all the way and would constantly beep. Now, power sliding door opens too far which has broken the motors causing the beeping to resume. This is an safety issue as anything hanging out the window would be crushed (such as a child's head or extremity). We have done a fuse reset as suggested by Kia, then also replaced the motor and the actuator, and it still opens too far which broke the motor again. We again brought it to Kia and they do not know what to do. Now, the left hand door is starting to have the same problem. Yesterday, the door stopped mid-way. When replacing the door actuator system, we learned that the left side door actuator was in the right side door. It was not made correctly.

NHTSA ID

11630722

Incident

Sep 15, 2024

On [XXX] at [XXX] the following incident happen with my 2019 KIA Sedona. The ABS and Traction Control Warning lights came ON when I applied the brakes when approaching a 4 way stop sign intersection, I heard a loud grinding sound from the back of the Sedona. The Sedona took longer to come to a stop, a full vehicle length past the stop bar. I was put at risk by the Sedona being in the intersection, instead of stopping at the stop bar. After clearing the intersection, I pulled over the Sedona, turned it off and then restarted it. Both the ABS and Traction Control Lights came back ON. I called the Jackson Kia Dealer in Cocoa Florida and got an answering machine for the service department. I left a message letting them know about the alarm lights and that I had already has at least 2 ABS modules replaced. I asked for an appointment as soon as possible to fix the problem. I had been told previously by KIA that it was safe to drive, but that I would have manual brakes in the rear and to apply breaks earlier, plus get the Sedona in for repair at the next opportunity for an appointment. As of yet the dealership has not seen the Sedona to diagnose the exact problem and cause. This is when these systems first appeared, and I had no other indications of a problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11619808

Incident

Oct 15, 2024

Side impact airbag didn't deploy causing head injury to driver. Van was hit at high speed by impaired driver who ran a red light. Van has hit from the driver's side in the engine compartment just in front of the driver. The engine was basically laying in the street after the impact.

NHTSA ID

11592169

Incident

Mar 15, 2024

Mileage

163,000 mi

The contact owns a 2019 Kia Sedona. The contact stated while driving, he became aware of a strong and unpleasant fuel odor that made him and his granddaughter sick. The contact stated that the check engine warning light flashed on and off several times. The vehicle was taken on several occasions to a local dealer where it was diagnosed with a fuel leak and several parts related to the fuel leak failure were replaced; however, the failure persisted. The contact stated the failure had been for a year and the dealer had not been able to repair the vehicle properly. The vehicle was also inspected by an independent mechanic who confirmed the failure and stated that the exhaust was very hot which could cause a fire. The vehicle remained at the dealer unrepaired. The vehicle was no longer under warranty. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 30,000.

NHTSA ID

11590999

Incident

Oct 1, 2023

Mileage

30,000 mi

My car made a rattling noise when hitting the accelerator. The mechanic said that I only had one quart of oil left in my engine. No sign of leaks and no error codes. The engine light never came on. The oil has been changed regularly. The mechanic said the pistons were not firing correctly.

NHTSA ID

11589189

Incident

May 1, 2024

The contact owns a 2019 Kia Sedona. The contact stated that while operating the vehicle, there was a strong fuel odor inside the cabin of the vehicle. The check engine warning light had remained illuminated. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the high-pressure fuel regulator was faulty and needed to be replaced. The high-pressure fuel regulator was replaced but the failure persisted. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 39,000.

NHTSA ID

11584547

Incident

Jul 1, 2023

Mileage

39,000 mi

Passenger side seat belt don’t want to click in contacted don franklin kia and they stated they couldn’t fix it until there was a recall

NHTSA ID

11582848

Incident

Apr 13, 2024

I have needed to replace the drivers side brake light almost every 3 months. I have seen many Kia Sedonas with that brake light out

NHTSA ID

11567730

Incident

Jan 23, 2024

I was shutting the door and my hand was still in the door way. Sensor failed and closed my hand into the door and latched. I had to press the open door button to get it to release my finer. I had to go to ER and orthopedic doctor, resulting in a break in two parts of my finger. If it would have been one of my small children instead of me, it would have been much worse. The only issue we have had was a failed motor in the door but it was fixed and inspected months ago by the Kia dealer.

NHTSA ID

11522286

Incident

May 15, 2023

I had to replace the left brake light 4 times already. I see other Kia Sedonas that have the same brake light out all the time.

NHTSA ID

11522140

Incident

May 15, 2023

TIRE SEZE 235/60 R 18 103H - Tires are original equipment on our 2019 KIA Sedona. Only 16000 miles on tires. Had vehicle to dealership a few weeks before incident and tires rotated and tires were OK. Did a family trip from New Jersey to Florida. On the way home vehicle started shaking really bad. Hard to control vehicle. This was during the night driving at high speed on interstate I-95. I got out and looked at vehicle at rest stops in the middle of the night and saw nothing wrong...so I slowed down to minimum speed all the way home from North Carolina to our home in Cherry Hill NJ. Took vehicle to dealer and was informed that there was a problem with tire. Uneven Cupping around the bead of the wheel. Tried to balance. Tire was not mounting properly on rim. Rim is not bent or uneven. Tried to contact Kumho and opened an incident but was told my KIA dealer had to provide information, which they did, however Kumho refused to help out with the cost of the new tire ($261.67). I could have had a serious accident on the way home with a tire that only had 16000 miles on it. I am still in possession of the tire if you need to see it

NHTSA ID

11515386

Incident

Mar 13, 2023

Drivers side power sliding door does not close. Grinds and beeps and door shows open on display. When you disengage the power feature the door does NOT open manually.

NHTSA ID

11481837

Incident

Aug 1, 2022

Door cable binds up and causes the door not to shut back leaving occupants either stranded or having to drive with the door open. This has happened 3 times even after being fixed

NHTSA ID

11473791

Incident

May 19, 2022