2024 Kia Seltos Problems

My 2024 Kia Seltos (leased, approximately 19,800 miles) received an over-the-air (OTA) software update on [07/03/2026]. The vehicle's screen prompted me to approve the update and stated it would complete with the ignition off. I approved it and exited the vehicle as instructed by Kia's on-screen directions and owner's manual. Immediately after this update, the vehicle developed an intermittent no-start condition, and the 12V battery went completely flat, accompanied by an ESC (Electronic Stability Control) warning. The vehicle had no electrical or starting problems of any kind before the update. The vehicle was disabled and could not be started without a jump start, which is a safety concern — this could strand a driver in an unsafe location or in extreme weather. The dealer (Car Pros Kia Glendale, RO #531279, dated 07/25/2026) performed a full system scan, found no DTCs, and confirmed the 12V battery failed testing. The dealer's repair order documents the customer complaint as "intermittent no start condition and battery went completely flat after the software update." The battery was replaced at my expense. The vehicle's software version after the update was NNK-02-0118 (previous resident version NNK-02-0108). Kia America has acknowledged partial responsibility by approving a 50% goodwill reimbursement. I am reporting this because a manufacturer-initiated OTA update that discharges the battery and disables the vehicle is a safety defect that may affect other vehicles.

Under extremely cold temperatures, approx 10° the main display does not work. The MPH & other vehicle information will not display. KIA service requires the vehicle to be brought to the facility while condition exists in order to troubleshoot, however once the vehicle warms up, the non functioning display begins to operate normally and the problem does not exist. Speaking with the service advisor and service manager in charge, they are aware of the problem and know of other vehicles with this display problem.

Since November 2025, this vehicle has experienced repeated loss of power, severe shaking during acceleration, jerking between gear shifts, abnormal humming/grinding noises, and multiple check engine light events. The condition is most noticeable between approximately 40-70 mph and has repeatedly occurred while driving on highways. On multiple occasions, the vehicle struggled to accelerate properly and would not respond normally to throttle input. During one occurrence, the vehicle had difficulty accelerating beyond approximately 55 mph while on the expressway. The shaking became severe enough that I feared mechanical failure could occur while driving. I was forced to pull off to the shoulder of the highway because I no longer felt it was safe. The inability to maintain speed and accelerate normally created a safety risk for both myself and surrounding traffic. The vehicle has been returned to the dealership six times for the same recurring issue. Repairs have included replacement of the ECU, catalytic converter, ignition components, fuel injectors, and other engine related components. Despite these repairs, the problem continues to return. The condition has been repoduced and documented by the dealership, and a manufacturer field technician was involved in the most recent diagnosis process. Most recently, after the vehicle was inspected and believed to be repaired, the check engine light illuminated again while the service manager was moving my vehicle to be washed inside of their garage, as I waited (today, June 11th 2026). The recurring loss of power, repeated check engine light events, and inability to permanently correct the defect raise significant safety concerns while operating the vehicle. I have all documentation in my notes, as well as the dealership repair documents.

See attached document for complaint.

During the incident in question, the vehicle’s lane‑assist system malfunctioned in a manner I have never previously experienced. As I approached an area with multiple lane markings, the system appeared to become confused—possibly due to low‑light conditions—and abruptly pulled the steering wheel with significant force. This deviation was severe enough that I temporarily lost control, causing the vehicle to drift toward the left-side ditch. When the steering suddenly released and became limp, I attempted to correct the trajectory, but the response window was too narrow to avoid impact. The vehicle struck a wooden signpost, resulting in damage to the right headlight assembly and the complete detachment of the right fog light. No lane‑departure warnings were issued at any point. Under normal circumstances, the vehicle provides audible alerts regardless of whether lane assist is active, and I am familiar with the areas where such alerts typically occur. Additionally, the forward‑collision warning system failed to activate, despite its usual tendency to trigger even in non‑hazard situations. This inconsistency has been present since I acquired the vehicle. Prior to this event, I had also been experiencing intermittent electrical issues. I attempted to seek service at the nearest Kia dealership; however, reaching it requires traveling through a national forest during winter conditions, which is unsafe unless absolutely necessary. I attempted to file an incident report with local law enforcement, but was informed that a report could only be taken if another motor vehicle was involved. I then attempted to file a report with the DMV, but the online system requires an Oregon‑issued driver’s license. I currently hold a valid Oklahoma license and have been unable to update it due to financial constraints and an anticipated move later this year. I have experienced neck pain between my shoulders since the incident.

Our vehicle was in an accident with extensive damage to the entire front end. The accident warning senors did not go off and the air bags did not deploy. The insurance adjuster said the entire engine was pushed back towards the driver area so it's surprising the air bags did not deploy. In our Kia Access app, only the "passenger turn signal" has a critical error detected. The car has been deemed totaled.

See attached document for complaint.

Rear view camera collects rain drops obstructing the rear view while backing up during rainy weather

Since November 2025, this vehicle has experienced repeated loss of power, severe shaking during acceleration, jerking between gear shifts, abnormal humming/grinding noises, and multiple check engine light events. The condition is most noticeable between approximately 40-70 mph and has repeatedly occurred while driving on highways. On multiple occasions, the vehicle struggled to accelerate properly and would not respond normally to throttle input. During one occurrence, the vehicle had difficulty accelerating beyond approximately 55 mph while on the expressway. The shaking became severe enough that I feared mechanical failure could occur while driving. I was forced to pull off to the shoulder of the highway because I no longer felt it was safe. The inability to maintain speed and accelerate normally created a safety risk for both myself and surrounding traffic. The vehicle has been returned to the dealership six times for the same recurring issue. Repairs have included replacement of the ECU, catalytic converter, ignition components, fuel injectors, and other engine related components. Despite these repairs, the problem continues to return. The condition has been repoduced and documented by the dealership, and a manufacturer field technician was involved in the most recent diagnosis process. Most recently, after the vehicle was inspected and believed to be repaired, the check engine light illuminated again while the service manager was moving my vehicle to be washed inside of their garage, as I waited (today, June 11th 2026). The recurring loss of power, repeated check engine light events, and inability to permanently correct the defect raise significant safety concerns while operating the vehicle. I have all documentation in my notes, as well as the dealership repair documents.

Electrical control unit car just shuts off in drive completely goes black no matter what within seconds even on freeway going 70 mph car tune off loss of control then starts back up very dangerous

The dashboard goes completely black and will not work when it is really cold outside. This is a dangerous problem because I cannot see my speedometer, how much gas I have in my car, or the engine temperature. I have been to the Kia dealership 3 or 4 times for this problem and have them report it to Kia. They always tell me that they cannot replicate the problem so they cannot fix it. I have video evidence of this happening and have showed it to the dealership. This has happened now for 2 winters. There have been no warning messages or anything before this happens.

On Wednesday [XXX], at [XXX]. I started to drive to work. I noticed the instrument cluster on my 2024 Kia Seltos SX was completely dark. I couldn't see the speedometer, fuel gauge, engine temperature, or any other function that should show on the instrument cluster. I turned around and returned home. I called the Kia dealer's service department and got an appointment for the car to be checked that afternoon. This service center is about 30 miles from my home. I drove there with a totally black screen for the instrument cluster--not able to see my speed or any other information about the car. I left the car running when I arrived at the service center. The service manager confirmed the issue. I also told her I'd been getting warnings that the key fob batteries were drained. She checked the key fobs and told me the batteries were sending strong signals. She also told me the odometer mileage had been deleted and that it was illegal to drive the car in that condition. She said that the instrument cluster unit had to be replaced but there wasn't a replacement unit anywhere in the U.S. She gave me a loaner vehicle but warned me she had no idea when she could get a new instrument cluster. I notice in online searches that instrument cluster failures for Kias are not unusual. I also notice that some Kia models have been recalled for this reason. Why isn't the Seltos on the list of recalled vehicles? It doesn't appear that Kia knows how to correct the problem. My instrument cluster screen has been repeatedly dimming and brightening for no obvious reason. That problem is longstanding and intermittent. When the car was restarted at the Kia dealership on Wednesday, the screen suddenly came back up with the service manager with me. I am unwilling to drive the car if it is not reliable or safe to drive. It has about 34,000 miles on the odometer and is less than two years old. Is this a design problem or the result of faulty components? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

During the incident in question, the vehicle’s lane‑assist system malfunctioned in a manner I have never previously experienced. As I approached an area with multiple lane markings, the system appeared to become confused—possibly due to low‑light conditions—and abruptly pulled the steering wheel with significant force. This deviation was severe enough that I temporarily lost control, causing the vehicle to drift toward the left-side ditch. When the steering suddenly released and became limp, I attempted to correct the trajectory, but the response window was too narrow to avoid impact. The vehicle struck a wooden signpost, resulting in damage to the right headlight assembly and the complete detachment of the right fog light. No lane‑departure warnings were issued at any point. Under normal circumstances, the vehicle provides audible alerts regardless of whether lane assist is active, and I am familiar with the areas where such alerts typically occur. Additionally, the forward‑collision warning system failed to activate, despite its usual tendency to trigger even in non‑hazard situations. This inconsistency has been present since I acquired the vehicle. Prior to this event, I had also been experiencing intermittent electrical issues. I attempted to seek service at the nearest Kia dealership; however, reaching it requires traveling through a national forest during winter conditions, which is unsafe unless absolutely necessary. I attempted to file an incident report with local law enforcement, but was informed that a report could only be taken if another motor vehicle was involved. I then attempted to file a report with the DMV, but the online system requires an Oregon‑issued driver’s license. I currently hold a valid Oklahoma license and have been unable to update it due to financial constraints and an anticipated move later this year. I have experienced neck pain between my shoulders since the incident.

On July 9 while waiting at a red light car randomly turned off, had to put car in park and restart On July 19 while driving about 55mph on an extremely busy interstate highway car shut down completely. I could not restart or shut the car off, car was in drive and we had full power, no issue with battery, no warning signs, we were nearly killed by an 18-wheel truck traveling at normal high speed on this highway. We were eventually pushed off to the side where we sat for 2 hours until family members came. In the car were 2 seniors, 1 battling dementia and another anxiety and a young man who suffers from paranoia schizophrenia. Both trying to recover. In addition, Kia roadside assist wanted to tow us 2 hours past our dealership and home and charge us $661 when we were fully covered. Kia dealership said if they could not repeat the stall they could not really determine what is wrong. This is the 3rd serious issue I have had with this vehicle and each occurrence I was made to feel like the issues did not exist. 1 week into ownership I complained about a knocking noise, was told that the struts came from the factory loose, a month ago the differential gear box needed to be changed. I am now told that it could take a very long time to repair, and I would need to rent a car at my expense and if approved will be reimbursed at some point. I am terrified to drive my new car.

While driving, the vehicle suddenly began handling abnormally. In response, we safely pulled over as quickly as possible. Before we could fully stop, the wheel catastrophically failed. The rim cracked around the entire circumference, the tire completely separated from the vehicle, and the vehicle lost stability and struck the guardrail. As a result of this incident, the vehicle sustained substantial damage, including but not limited to: •Complete destruction of the wheel/rim; •Tire separation; •Axle and suspension damage; •Body damage to the driver-side front and rear panels; and •Additional mechanical damage that is still being assessed. Photographs taken immediately after the incident clearly show that the wheel fractured around the rim itself. The damage pattern is consistent with a catastrophic wheel failure, not ordinary cosmetic damage or curb rash. When I initially contacted the Kia dealership, I was told that they had "never seen anything like it." However, after the vehicle was towed to the dealership, the explanation changed, and I was informed that Kia now believes the vehicle must have struck something and that the impact caused the wheel to fail. That explanation is inconsistent with what occurred. At no point prior to the failure did we strike debris, a pothole, a curb, or any other object that would reasonably explain a complete structural fracture of the wheel and the tire separating from the vehicle. The wheel failed first. The collision with the guardrail occurred only after the catastrophic wheel failure and loss of control while attempting to safely pull over.

The contact owns a 2024 Kia Seltos. The contact stated that while driving at an undisclosed speed, the strip of black plastic on the steering wheel and the dashboard above the glove compartment impaired her vision. The contact stated that the black plastic impaired the vision of her and the passenger. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 118.

While driving, the vehicle suddenly began handling abnormally. In response, we safely pulled over as quickly as possible. Before we could fully stop, the wheel catastrophically failed. The rim cracked around the entire circumference, the tire completely separated from the vehicle, and the vehicle lost stability and struck the guardrail. As a result of this incident, the vehicle sustained substantial damage, including but not limited to: •Complete destruction of the wheel/rim; •Tire separation; •Axle and suspension damage; •Body damage to the driver-side front and rear panels; and •Additional mechanical damage that is still being assessed. Photographs taken immediately after the incident clearly show that the wheel fractured around the rim itself. The damage pattern is consistent with a catastrophic wheel failure, not ordinary cosmetic damage or curb rash. When I initially contacted the Kia dealership, I was told that they had "never seen anything like it." However, after the vehicle was towed to the dealership, the explanation changed, and I was informed that Kia now believes the vehicle must have struck something and that the impact caused the wheel to fail. That explanation is inconsistent with what occurred. At no point prior to the failure did we strike debris, a pothole, a curb, or any other object that would reasonably explain a complete structural fracture of the wheel and the tire separating from the vehicle. The wheel failed first. The collision with the guardrail occurred only after the catastrophic wheel failure and loss of control while attempting to safely pull over.

While driving in traffic, my 2024 Kia Seltos suddenly shut down without warning again. I lost propulsion while the vehicle was in motion with passengers inside, creating an immediate safety hazard. The issue appears electrical or powertrain-related. This occurred during normal operation and could result in a serious crash. My vehicle shutting down in active traffic with passengers is unacceptable, and there is no recall remedy in place to correct this hazard. I am requesting a manufacturer-level resolution under Ohio Lemon Law and the Magnuson–Moss Warranty Act.

Driver side seat stays warm all the time I tried removing both seat heater fuses and in plugged the seat warmer plugs but the back seat rest still stay warm

The front brakes prematurely failed at 5,000 miles and this is a brand new vehicle. We had 3 miles or so at purchase (purchase date: August 7, 2024). By January 4, 2025 or so, the front brakes began making grinding noises. We had a licensed, independent shop inspect this and then replace the worn brakes on January 6, 2025. We have driven the vehicle as we have driven other vehicles and we have never seen brand new brakes wear out after 5,000 miles with standard driving. We believe it could be due to the driver assistance technology and would like this to be thoroughly reviewed. Hopefully, Kia can reimburse us with some discount on other routine maintenance as this is a cost we did not expect so soon with a brand new vehicle.

Since November 2025, this vehicle has experienced repeated loss of power, severe shaking during acceleration, jerking between gear shifts, abnormal humming/grinding noises, and multiple check engine light events. The condition is most noticeable between approximately 40-70 mph and has repeatedly occurred while driving on highways. On multiple occasions, the vehicle struggled to accelerate properly and would not respond normally to throttle input. During one occurrence, the vehicle had difficulty accelerating beyond approximately 55 mph while on the expressway. The shaking became severe enough that I feared mechanical failure could occur while driving. I was forced to pull off to the shoulder of the highway because I no longer felt it was safe. The inability to maintain speed and accelerate normally created a safety risk for both myself and surrounding traffic. The vehicle has been returned to the dealership six times for the same recurring issue. Repairs have included replacement of the ECU, catalytic converter, ignition components, fuel injectors, and other engine related components. Despite these repairs, the problem continues to return. The condition has been repoduced and documented by the dealership, and a manufacturer field technician was involved in the most recent diagnosis process. Most recently, after the vehicle was inspected and believed to be repaired, the check engine light illuminated again while the service manager was moving my vehicle to be washed inside of their garage, as I waited (today, June 11th 2026). The recurring loss of power, repeated check engine light events, and inability to permanently correct the defect raise significant safety concerns while operating the vehicle. I have all documentation in my notes, as well as the dealership repair documents.

Our vehicle was in an accident with extensive damage to the entire front end. The accident warning senors did not go off and the air bags did not deploy. The insurance adjuster said the entire engine was pushed back towards the driver area so it's surprising the air bags did not deploy. In our Kia Access app, only the "passenger turn signal" has a critical error detected. The car has been deemed totaled.

Issue: Defective Seatbelt Sensor - Refused Warranty Repair Vehicle: 2024 Kia Seltos EX Make/Model/Year: Kia Seltos, 2024 Mileage (approx.): 12,033 I am filing a formal safety complaint regarding a malfunctioning seatbelt sensor on my 2024 Kia Seltos EX. The front passenger seatbelt alarm goes off repeatedly even when there is no one sitting in the seat, and this behavior is unpredictable and distracting while driving. When I contacted the Kia dealership (Summit Place Kia, Auburn Hills, MI), they refused to inspect or repair the issue without charging me $180 upfront, even though my vehicle is fully under warranty and this clearly relates to a safety system. They claimed they would only waive the fee if they determine it’s covered, which gives them the option to deny responsibility arbitrarily. Kia Consumer Affairs was contacted and gave the same answer: pay up front or we won’t look at it. This raises major concerns about Kia’s warranty practices and possible violations of federal law requiring free repairs of safety-related defects under warranty. I am reporting this to request investigation and to hold the manufacturer accountable for failing to honor federally mandated coverage.

At slow speeds such as parking or backing up, when you turn the wheel, you hear a popping sound from the left front wheel area.