2001 Kia Sephia

BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.

IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.

HAVING TROUBLE WITH DRIVERS SIDE WINDOW. IT WILL WORK THEN THE MOTOR/REGULATOR GETS STUCK AND WON'T FUNCTION. THEN ALL OF A SUDDEN IT WILL WORK THEN NOT WORK. I JUST WANT TO FIND OUT WHAT'S CAUSING PROBLEM. ALL WIRES TO SWITCH TESTED POSITIVE POWER IS GOING TO AND FROM MOTOR/REGULATOR TO ALL SWITCHES. MY CELL IS [XXX] I JUST WANT A NAME AND PHONE NUMBER OF SOMEONE WHO CAN FIX THIS IN 07646 AREA CODE. I,E AN EXPERT ON POWER WINDOW PROBLEMS THANK YOU. MY NAME IS [XXX] THIS IS SORT OF A COMPLAINT BECAUSE IT'S BECOME A DIFFICULT DIAGNOSIS I NEED A KIA SPECIALISTS HELP. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10884375

Incident

Jul 10, 2016

I WAS ON MY WAY TO COLLEGE WHEN I HIT A PATCH OF WET ROAD, WHEN I TRIED TO CORRECT THE SLIDE, THE RIGHT SIDE GRABBED AND PUT ME INTO A SPIN OVER BOTH LANES AND I HIT THE LEFT SIDE GUARD RAIL HEAD ON AT APPROX. 45MPH. AIR BAGS DIDN'T DEPLOY FOR EITHER SIDE. CAR IS ALMOST WORTH FIXING BUT I WILL NEVER DRIVE THAT METAL DEATHTRAP AGAIN. THIS IS MY FIRST AND ABSOLUTELY THE LAST KIA I WILL EVER BUY. *TR

NHTSA ID

10457546

Incident

May 4, 2012

Mileage

136,000 mi

CAR GIVES OFF A VERY BAD GAS ODOR. EVERYTIME I PUT GAS IN THE CAR, THE GAS INDICATOR ON THE DASHBOARD GOES DOWN AND CAR CUTS OFF ON ME WHEN IM DOING 20 MPH. *TR

NHTSA ID

10415436

Incident

Jul 27, 2011

I AM COMPLAINING BECAUSE MY GEAR SHIFT WON'T SHIFT. IN THE OWNER'S MANUAL, IT SAYS IF THIS HAPPENS TO REMOVE THE SMALL CAP ON THE GEAR SHIFT BOX AND PUT A SCREW DRIVER IN THE HOLE TO MANUALLY SHIFT, WHICH I HAVE HAD TO DO FOR THE PAST FEW MONTHS. IF THEY KNEW IT WAS GOING TO HAPPEN AND PLACED A BACK-UP PLAN IN THE MANUAL, WHY DIDN'T THEY FIX IT TO BEGAN WITH? IT WOULD COST A FEW HUNDRED DOLLARS TO REPLACE THE GEAR SHIFT CABLE. WHY SHOULD I HAVE TO BE THE ONE TO DO THIS? I THINK IT IS KIA'S RESPONSIBILITY TO REPLACE MY GEAR SHIFT CABLE. LIKE I SAID, IT IS IN THE OWNER'S MANUAL TO USE A SCREW DRIVER IF THE GEAR SHIFT FAILS. UPDATED 04/21/11 *BF

NHTSA ID

10396329

Incident

Jan 4, 2011

TL* THE CONTACT OWNS A 2001 KIA SEPHIA. THE CONTACT STATED THAT THE VEHICLE EXHIBITED AN UNUSUALLY OVERPOWERING GASOLINE ODOR FROM THE BLOWER VENTS WHEN FIRST STARTING THE VEHICLE. THE FAILURE WOULD OCCUR INTERMITTENTLY AND BECAME PROGRESSIVELY WORSE OVER TIME. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED A LEAK IN THE FUEL DAMPENER AT THE CONNECTION WITH THE FUEL LINE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

NHTSA ID

10377912

Incident

Sep 15, 2008

Mileage

60,000 mi

I JUST TAKE OVER A 2001 KIA SEPHIA FROM MY BROTHER IN-LAW AND HE WARNED ME NOT TO LOCK THE CAR IF I LOCK THE CAR DOORS I MIGHT NOT GET IN OR OUT SOME TIMES, TO DAY WHEN I STARTED THE CAR BUT I COULD NOT CLOSE THE DOOR, THEN I TRIED TO PRESS THE LOCK SWITCH AND SLAMMED THE DOOR, THE DOOR WAS CLOSED, AND I DROVE THE CAR TO A COFFEE SHOP I PARKED MY CAR THERE BUT I COULD NOT OPEN THE DOOR, LUCKY ME I CAN OPENED FROM THE PASSENGER SIDE DOOR AND I GOT OUT FROM THERE. AFTER I LEFT THE COFFEE SHOP I HAD TO GET IN FROM THE SAME DOOR WHEN I GOT OUT, WHEN I GOT HOME I CAN OPEN THE DOOR AND THE DOOR LOCKS SEEMED TO BE WORKING PROPERLY, BUT AFTER I LEFT IT FOR ABOUT 2 HOURS AND IT HAPPENED AGAIN THE WEATHER OUTSIDE WAS ABOUT -6 DEGREE, I WENT ONLINE CHECKED THERE WERE MANY COMPLAINT WITH THE SAME PROBLEM AND SAME TYPE OF CAR THAT I HAD , I THINK THIS IS A SAFETY ISSUE THAT SHOULD BE PRESSURED TO KIA LET THEM RECALL ALL OF THE MODEL WHICH HAD THE SAME PROBLEM TO CORRECT IT! *TR

NHTSA ID

10373825

Incident

Jan 2, 2011

Mileage

90,650 mi

I WAS DRIVING MY 2001 KIA SEPHIA APPROXIMATELY 45 MPH IN DECATUR COUNTY, GEORGIA ON AUGUST 1, 2006 WHEN A PONTIAC BONNEVILLE PULLED INTO MY LANE OF TRAVEL. MY SEPHIA COLLIDED WITH THE BONNEVILLE AT A 20 DEGREE ANGLE. NEITHER OF THE FRONT AIRBAGS DEPLOYED AND MY SON (FRONT SEAT PASSENGER) WAS THROWN INTO THE FRONT WINDSHIELD WHERE HIS HEAD WAS LODGED IN THE GLASS. HE SUSTAINED A SEVERE AND PERMANENT CLOSED HEAD INJURY AND NOW REQUIRES 24/7 CARE. IN ADDITION TO SUFFERING A CLOSED HEAD INJURY, MY SON'S KNEE IMPACTED THE INSTRUMENT PANEL TO THE LEFT OF THE GLOVE BOX WHICH CAUSED SEVERE HIP AND LEG INJURIES. KIA DENIED RESPONSIBILITY AND LITIGATION IS ONGOING. EXPERTS IN THE LITIGATION ESTIMATE THE EBS OF THE CRASH TO BE BETWEEN 12 & 18 MPH. *TR

NHTSA ID

10352232

Incident

Aug 1, 2006

Mileage

119,583 mi

DRIVE AND PASSENGER AIRBAG DID NOT DEPLOY IN 2001 KIA SEPHIA LS. *TR

NHTSA ID

10328228

Incident

Apr 22, 2010

Mileage

135,000 mi

TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.

PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.

TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.? It is critical for technicians to be aware that ALL such locking fasteners, regardless of type, are for ?one time use? only.

TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?

TSB: AUTOMATIC TRANSMISSION FLUID APPLICATION GUIDE - THIS BULLETIN PROVIDES INFORMATION RELATING TO THE CORRECT AUTOMATIC TRANSMISSION FLUIDS THAT ARE REQUIRED FOR EACH KIA MODEL. REFER TO THE SHOP MANUAL ON KGIS FOR THE SPECIFIC KIA MODEL, THEN REFERENCE THE AUTOMATIC TRANSAXLE SYSTEM/ REPAIR PROCEDURES/ INSPECTION AND ADJUSTMENT SECTION FOR THE CORRECT ATF CHECK/FILL PROCEDURES.

KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB LIFE FOR REAR COMBINATION BULB; REAR STOP LAMP/TAIL LAMP BULB UTILIZED ON MULTIPLE KIA MODELS. *PE