2022 Kia Sorento PHEV Owner Complaints

Engine wiring is covered in soy based products which attract rodents as a source of food. Rodents then chew various wires and damage the electrical system. The check engine light has popped on twice in one year with both times requiring service repair for the chewed wires. There is a potential for electrical fires or other various failures due to rodents chewing through the wires. Kia has known about this problem for over a decade and continues to use soy based coverings in their engine without any mitigation for rodents.

NHTSA ID

11742016

Incident

May 30, 2026

The drive train and motor slow to a near stop in traffic when trying to clear a lane and makes it very dangerouos for other traffic to have to wait for me to clear a lane. There is something wrong and we complained about this before the warranty ran out, but they could not find anything. The car stops in traffic unexpectedly. I am not sure if sensors are causing this or what, but it has put me in danger of collision many times. We have to plan an exceedingly long time to pull into traffic so we don't get run over. Anti slip also doesn't turn off even though it says it is off. The car will slip a little bit and then shut the motor down to a crawl making it very dangerous in traffic. The 4x4 doesn't seem to work as we turn it on to try to eleminate slipping. The slipping mostly occurs because of the motor becoming doggedly slow and then decides to speed up. The 4x4 on and the turning of the anti-slip do not work because it still slips and shuts down. The other tires don't seem to slip or do anything. Please help!!!

NHTSA ID

11723548

Incident

Mar 11, 2026

My Sorento PHEV popped a P0c4e code and now the car is gutless on electric power. Kia cleared the code in an attempt to fix it but now the code is gone and it’s still weak. When I let off the brake it rolls when it used to have the power to hold it. I used to be able to get on the freeway and now I can’t get up to speed in town (35mph). It’s running in some sort of limp mode and Kia can’t see any codes. It’s loud, too. Each gear whines. It whines when I hit the brake and it regenerates electricity. It regens so little now that it doesn’t hardly slow me down anymore until I stand on them and use the brake pads. Kia said that it might be a sensor in the electric motor but it’s not replaceable and you have to replace the whole motor. Even though it’s under warranty, it’s 15 hours labor to replace it. I have family with the same car and theirs has done the same thing in the past and had to be replaced. My dealer said that they have seen a bunch of these throw that same code and have to have the motor replaced. She said she is expecting Kia to start replacing them for free or possibly recall them because of how many she has seen all doing the same thing.

NHTSA ID

11678045

Incident

Jul 29, 2025

I have gotten the notice Refill Inverter Coolant and Hybrid System Failure and lost acceleration and the all power. The first time this happened was in Dec 2024 with about 60,000 miles on the car. Dealer flushed system and it worked fine until April 2025 at about 71000 miles Hybrid system failure alert again, barely able to accelerate from stop light, made to a parking space just as I lost power steering. After about 2 hours to cool off car started and could be driven home. Got Refill inverter coolant alert.

NHTSA ID

11662012

Incident

Dec 12, 2024

The contact owns a 2022 Kia Sorento PHEV. The contact stated that while reversing the vehicle, the rearview camera failed to display a clear image, and the grid lines were not properly aligned. The contact crashed the vehicle into his mailbox. There were no injuries sustained and no police report was filed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 23V610000 (Back Over Prevention); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 22,500.

NHTSA ID

11641051

Incident

Jan 11, 2025

Mileage

22,500 mi

Several times over the past 12 months, the car has applied emergency braking when a car approaches me from behind in the lane to my left. The dealer was not able to replicate the problem but I have captured it twice on my dash cam. I was only able to intentionally replicate the problem once on my own but it has happened 15-20 times. If I do not press the accelerator, the car will come to a stop without me pushing the brake. When the emergency brake is applied, the warning sound is heard in the car and the dash lights up with the emergency braking icon and emphasizes the left rear of the vehicle. I have been to the dealer twice for this issue. The first time they told me it was due to a faulty camera mount under recall. It was replaced but the issue continued. The second time they told me they decreased the sensitivity of some sensor. The issue continued.

NHTSA ID

11638383

Incident

Jan 24, 2025

While driving down the highway the EV side of my PHEV wouldn't switch to gas. The car wouldn't accelerate past 40-50 mph and drained the remaining battery till my car shut off and forced me to the side of the road. Been to the dealer multiple times (over 4) for the same issue. They claim they recreate it and no resolution has been done.

NHTSA ID

11627399

Incident

Nov 21, 2024

The contact owns a 2022 Kia Sorento PHEV. The contact stated the upon starting the vehicle, an abnormally loud revving sound was coming from the engine while the vehicle was idling. Additionally, the contact stated that the vehicle hesitated upon the depression of the accelerator pedal while traveling at various speeds. No warning light was illuminated. The vehicle was initially taken to Seelye Kia of Battle Creek (791 W Dickman Rd, Battle Creek, MI 49037) where the contact was informed that the acceleration issue was normal vehicle operation due to the Hybrid feature. The vehicle was then taken to another dealer where the contact was provided the same issue as the dealer. The contact stated that the hesitation had worsened and had become more frequent. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 20,000.

NHTSA ID

11593737

Incident

May 11, 2022

Mileage

20,000 mi

When accelerating to pull out of driveway and enter traffic, while struggles to find correct gear causing tires to spin and loud clunking noise. Forward collision detects objects that are not there causing vehicle emergency breaking to engage

NHTSA ID

11582034

Incident

Feb 13, 2024

My 2022 KIA Sorrento PHEV periodically gives a "Check Hybrid System, Stop Safely" emergency warning. When this happens the vehicle will not accelerate and can only be limped to a stop. This has occurred 4 times in 18 months. In three instances the vehicle was limped to a safe stop but on the other occasion it left us stranded in an intersection. This problem creates imminent danger and potential peril. KIA maintenance looked at the vehicle after the last two events and reported that they can't do anything because there aren't any recorded fault codes. From a technical perspective, it appears that an electronic problem occurs where the hybrid control either fails to recognize the low battery status or fails to command the engine to run when needed. Once stopped I can see that the hybrid electric battery charge has depleted and the engine failed to start. Cycling power off and on a couple of times appears to reset the circuitry allowing the engine to restart and the hybrid battery to begin recharging. Unfortunately, the KIA OBD is not detecting this particular failure.

NHTSA ID

11560570

Incident

Dec 8, 2023

The contact owns a 2022 Kia Sorento. The contact stated while driving approximately 65 MPH up an incline in inclement weather, the vehicle rolled backward. The contact stated that the AWD failed to lock the wheels. The contact then stated that all four tires started to spin while in AWD. Additionally, the contact stated that while attempting to turn on the heat, she smelled a burning odor through the vents. The contact also stated that there was an alert indicating to activate the heat in hybrid mode; however, the vent was blowing cold air. Additionally, the contact stated that previously the sensor malfunction warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure, but no further assistance was provided. The failure mileage was approximately 17,000.

NHTSA ID

11504669

Incident

Jan 30, 2023

Mileage

17,000 mi

The contact owns a 2022 Kia Sorento. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches) however, the part to do the repair was unavailable. The vehicle was taken to a local dealer; however, the contact was informed that the remedy was not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11503236

Incident

Sep 19, 2022

Multiple times I have experienced weirdness with the Transmission in my 2022 Sorento PHEV. One specific situation has happened to me multiple times and is a safety risk. Occasionally while stopped at a red light or stop sign with a reasonable incline it seems the electric motor fails to engage and it never switches to the ICE engine either. Step by step 1 - Stopped at Stop Sign or Red light 2- Release Brake an Hit Gas 3- Vehicle does not move forward no matter how hard you hit the gas (Doesnt seem to engage electric or traditional engine) 4 - Instead the vehicle seems like its in neutral and starts rolling backwards 5 - I slam on the brakes, and then try the gas again and everything is fine. I took it to the Anderson, SC kia dealer and they just told me they couldn't replicate it. It has happened to me or my wife probably 4 times over the last year. Just wanted to report it because it feels like a good chance this is eventually going to cause a wreck.

NHTSA ID

11498899

Incident

Dec 26, 2022

The contact owns a 2022 Kia Sorento PHEV. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11495184

Incident

Sep 19, 2022

The contact owns a 2022 Kia Sorento PHEV. The contact stated that upon depression of the accelerator pedal, the vehicle would hesitate without warning. The contact also stated that while attempting to park the vehicle, the gear shifter remained stuck in neutral(N) and the vehicle could not be moved or turned off. The contact called the dealer and had the vehicle towed to the dealer. A diagnostic test was performed; however, the failure could not be duplicated. The manufacturer had also been notified of the failure. The vehicle was not repaired. The failure mileage was approximately 500.

NHTSA ID

11486970

Incident

Apr 10, 2022

Mileage

500 mi

I received a recall notice for a problem with the front seat seat-belt pretensioners, which apparently deploy abnormally and may project metal fragments into the passengers. Despite being told the repair should only take 1 hour, I cannot get an appointment for 2 months to get it fixed. I have also called Kia corporate but they were unhelpful as well. I do not think 2 months to get a safety recall repaired is reasonable or safe and want to lodge a complaint.

NHTSA ID

11481343

Incident

Aug 26, 2022

While driving our brand new car from dealership, a small stone must have hit. It made a 2-3 inch crack and by the time we were home it was already 12 inch crack. It had happened to me in my Audi and the only thing I could see is a small point in the windshield which I was able to fix. Googling around it seems like I am not the only one who is facing this issue and there was in fact some recall too in the past with Kia cars.

NHTSA ID

11479782

Incident

Aug 12, 2022

This has been recalled after the car arrived to the dealership but before I purchased (it was a special order). I have not been able to purchase for over a week while I wait for the part. My complain is the timely action on this recall.

NHTSA ID

11471905

Incident

Jun 23, 2022

Breaks failed to engage while driving on the highway, which almost caused us to have an accident. The car was leased a few months ago so very concerned and will be taking it to the dealership. The autonomous emergency breaking system engaged and prevented the accident.

NHTSA ID

11466724

Incident

May 31, 2022

I was traveling on the highway with no cars around, under no overpasses, and the panoramic sunroof exploded. It sounded like a gunshot. It was around 50 degrees and there was no previous sunroof damage.

NHTSA ID

11462366

Incident

Apr 13, 2022

Purchased the car new in early February 2022. Within about six weeks, heard a loud bump from under the car as I was pulling away from the driveway, this happened 2-3 times. After these incidents the car felt like it was stuck in first gear, with whining upon acceleration and deceleration. I use the car locally and the speed limit is 25mph, so luckily I didn't have to drive it on the highway. The service center asked me to wait a month for an appointment but allowed me to bring it in when I stated I believed there was a safety issue. The car at this point had just over 700 miles on it after 9+ weeks of driving. The diagnostic performed that day showed the transfer case fluid was black, had a burnt smell, and pieces of metal in the fluid, and the service center informed me this was covered by warranty and they would be holding onto the car for safety reasons. I am now in the 3-5 business day period where the service center is waiting for Kia to approve the repair and hopefully provide a new transfer case within that timeframe. The service center confirmed to me they would be testing the new part before they install it. I am concerned about it breaking again if it is coming from the same place as the faulty part, and endangering my family's safety on a long road trip. This major failure in the transfer case, occurring within months of new purchase, is a major concern for the quality and safety of Kia's 2022 Sorento Hybrid.

NHTSA ID

11460732

Incident

Mar 25, 2022