2021 Kia Sorento Owner Complaints

My car will randomly go into limp mode and I am unable to accelerate. The auto stop/start light will flash orange on the dashboard. I need to pull over and restart car and it seems to reset. I see there is a recall for a 2021 KIA Sorrento but I don't think it affected my vehicle even though the issue is exactly the same. Recall #22V6000. It happened once a few months ago then didn't reoccur until about two weeks ago and it has happened three times since. It is scary because I am afraid to cross traffic in fear that the car won't move fast enough

NHTSA ID

11756015

Incident

Apr 1, 2026

I was driving up a hill and my car stalled. Contacted Kia of Bowie for assistance had a diagnostic asked for a goodwill repair because of this being a safety issue with my car stalling while driving up a hill life threating situation and they have denied the goodwill repair the service tech is saying because I didnt get my car serviced there and they have no records I informed them that I have and had been taking care of the maintenance at the Kia dealership in Temple hills md. They are just overlooking the severity of the situation of a safety issue.

NHTSA ID

11755593

Incident

Jul 14, 2026

"The vehicle has twice suffered a sudden, catastrophic loss of motive power at highway speeds (approx. 70 MPH) on the interstate, forcing the driver to coast across active traffic to the shoulder without engine pull. The engine revs freely in 'Drive' but the transmission fails to engage any gears. No dashboard warning lights, check engine lights, or diagnostic trouble codes are triggered during or after the failure. The failure resets temporarily only after cycling the ignition key off and on.The vehicle previously had Safety Recall SC250 (8-speed Electric Oil Pump) performed by an authorized dealer, but the software flash completely failed to prevent this catastrophic hydraulic/electronic failure mode or provide the federally mandated dashboard warning countdown. The vehicle is entirely unsafe to drive,

NHTSA ID

11752940

Incident

Jul 24, 2026

Recall 22V-760 was performed, but the remedy failed, the exact same safety code has returned, and the manufacturer is refusing to replace the failed hardware component.

NHTSA ID

11752489

Incident

Jul 11, 2026

previous warranty repair for a failed fuel injector (RO #1103175) resulted in severe gasoline dilution of the engine oil. the vehicle now vents raw fuel vapors into the cabin (Fire Hazard) and hesitates/jerks when braking at stoplights (Stall/Crash Hazard). Kia Corporate has refused to communicate for over two weeks while the dealer holds the car.

NHTSA ID

11751993

Incident

Jun 23, 2026

I am filing this complaint regarding my 2021 Kia Sorento, which has suffered a transmission failure. The transmission slips, shifts harshly, hesitates during acceleration, loses power unexpectedly, and has become unsafe to drive. This defect has put my safety and the safety of others at risk. On several occasions the vehicle failed to respond properly when accelerating, including while entering highways and driving in traffic. The hesitation and sudden loss of power created fear and anxiety because I could not trust the vehicle to operate as expected. The problem has been reproduced and confirmed by a repair facility, and the symptoms are consistent with a transmission torque converter clutch failure. I also contacted Kia and provided the vehicle information. Kia informed me that they would not repair the vehicle because it has exceeded 100,000 miles and that the recall or warranty extension had expired. However, my vehicle is experiencing the same transmission-related symptoms reported by many other Kia owners.I never received any recall notification because I purchased the vehicle from a dealership as the second owner. Had I been properly notified, I would have taken the vehicle in for inspection much earlier or would never have purchased the dangerous vehicle in the first place. It is extremely frustrating and costly to be denied assistance solely because of mileage when the failure appears to be related to a known transmission defect.Before the failure, the check engine light illuminated and then went away even though the issue did not. Prior to that warning, the vehicle had already shown delayed shifting, slipping, hesitation, rough gear changes, and loss of power, which became progressively worse. I reported this to Kia on a previous service visit to Romeo Kia in Lake Katrine, NY and was told they did not find anything wrong. This situation has caused significant emotional stress and anxiety. I am requesting a full review and a fair resolution from kia. Thank

NHTSA ID

11751825

Incident

Jul 21, 2026

The vehicle experienced a sudden and dangerous loss of motive power while driving due to a failure of the 8-speed dual-clutch transmission's (DCT) high-pressure electric oil pump causing loss of shifting and dropping to lower gears at a very high rpm and slowing the car almost instantly creating a hazard for a crash with following vehicles. ​This vehicle was previously serviced under Kia Safety Recall Campaign SC250 (NHTSA ID: 22V-760). However, the initial recall remedy failed to permanently resolve the underlying defect. Despite the recall work being marked as completed, the transmission component has failed again.

NHTSA ID

11751596

Incident

Jul 11, 2026

Motor will not turn over, starter/electrical failure.

NHTSA ID

11751187

Incident

Jul 15, 2026

I am filing this complaint regarding my 2021 Kia Sorento, which has suffered a serious transmission failure. The vehicle is displaying diagnostic code P0741, indicating a torque converter clutch malfunction. The transmission slips, shifts harshly, hesitates during acceleration, loses power unexpectedly, and has become unsafe to drive. The vehicle is available for inspection upon request.This defect has put my safety and the safety of others at risk. On several occasions the vehicle failed to respond properly when accelerating, including while entering highways and driving in traffic. The hesitation and sudden loss of power created fear and anxiety because I could not trust the vehicle to move when needed to avoid a dangerous situation. The problem has been reproduced and confirmed by a repair facility, and the symptoms are consistent with a transmission torque converter clutch failure. I also contacted Kia and provided the vehicle information. Kia informed me that they would not repair the vehicle because it has exceeded 100,000 miles and that the recall or warranty extension had expired. However, my vehicle is experiencing the same transmission-related symptoms reported by many other Kia owners.I never received any recall notification because I purchased the vehicle from a dealership as the second owner. Had I been properly notified, I would have taken the vehicle in for inspection much earlier. It is extremely frustrating and financially devastating to be denied assistance solely because of mileage when the failure appears to be related to a known transmission defect.Before the failure, the check engine light illuminated and code P0741 appeared. Prior to that warning, the vehicle had already shown delayed shifting, slipping, hesitation, rough gear changes, and loss of power, which became progressively worse.This situation has caused significant emotional stress, anxiety, and financial hardship. I am requesting a full investigation and a fair resolution from kia.

NHTSA ID

11750887

Incident

Mar 1, 2026

The vehicle suddenly lost power when in drive or reverse but will idle fine in park or neutral.

NHTSA ID

11750122

Incident

Jul 13, 2026

Car losing power

NHTSA ID

11746909

Incident

Jun 27, 2026

The contact owns a 2021 Kia Sorento. The contact stated that while parking the vehicle, the vehicle jerked abnormally. The contact stated that while the vehicle was in drive, the vehicle jerked and unexpectedly accelerated while driving 55 MPH and was dragging. There were no warning lights illuminated. The contact stated that the vehicle was serviced by the dealer for a transmission failure, but the failure persisted. The contact stated that the manufacturer was made aware of the failure. The failure mileage was approximately 35,000.

NHTSA ID

11745634

Incident

Jan 1, 2024

Mileage

35,000 mi

The vehicle is suffering from a chronic, cascading powertrain and fuel management defect that has resulted in a critical safety hazard: sudden engine stalling. Over the last 17,000 miles, the vehicle has experienced three severe engine/emissions failures that the manufacturer has been unable to permanently resolve. At approximately 30,000 miles (on 29-Jun-2025), the engine suffered a severe Cylinder 3 misfire (Code P0303). At approximately 39,000 miles (on 02-Jan-2026), the unresolved fuel issue caused a failure of the Catalytic Converter (Code P0420) and an Evaporative Emission System leak (Code P0456). At 47,000 miles (Current Event), the fuel delivery system failed completely. The engine began running excessively rich (Code P2178), causing the engine idle to drop dangerously low (Code P0506). This defect caused the vehicle to suddenly stall out, resulting in a complete loss of motive power and leaving me stranded. Because the manufacturer's authorized repair facilities have only addressed the symptoms rather than the root cause of the fuel system failure, the vehicle repeatedly loses power and stalls without warning. This poses a severe safety risk to myself and other motorists, especially when operating the vehicle in traffic or at highway speeds.

NHTSA ID

11743204

Incident

Jun 8, 2026

My vehicle lost power and accelerated quickly yet unpredictably, and the check engine light came on. A local shop told me it was "an old code" for the transmission and that if it does that again to take it to dealer. It occurred again. Kia dealer states this vehicle has a recall and has been repaired twice, but that they will not repair it again. This is such an unsafe issue they will not allow me to drive the vehicle. I will have to pay almost $7,000 to replace the transmission.

NHTSA ID

11740972

Incident

May 29, 2026

Intermittently, when coming from a stop (stop sign, red light, etc) or recent start of the vehicle, the Sorento will not accelerate past approximately 30 miles per hour and the auto-stop light will flash orange in the panel. Once the vehicle is stopped, turned off, and restarted, it goes back to operating as it should and accelerates like normal. This has happened when driving on small, low speed limit roads and on large, high speed limit roads. My safety and the safety of those driving around me is put at risk when vehicles around me are expecting me to drive a certain speed but I can't and am looking for a safe place to pull over to stop and restart the vehicle. To date, the vehicle acceleration has not suddenly dropped from a high speed to a low speed thankfully, but when the issue presents itself, it will not allow the vehicle to accelerate above the 30mph range. The vehicle is available for inspection upon request. It is currently at a dealership that is working to reproduce and confirm the problem. There are Reddit threads that discuss other Sorento owners experiencing this same issue. To my knowledge, there were not any warning lamps, messages, or other symptoms of the problem prior to this issue presenting itself. It has been happening on and off for the last 1-2 years. My vehicle has not been inspected by the manufacturer, police, insurance representatives, or others but I am happy to have any of them do so. A simple battery replacement has not resolved the issue - it was happening before I had my battery replaced and it has happened since having my battery replaced.

NHTSA ID

11740792

Incident

Jan 27, 2025

The contact owns a 2021 Kia Sorento. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly jerked and then lost motive power with the check engine warning light illuminated. The vehicle was able to restart. The vehicle was taken to an independent mechanic, where it was diagnosed that the low-pressure and high-pressure fuel injectors and gasket had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 92,779.

NHTSA ID

11738166

Incident

May 15, 2026

Mileage

92,779 mi

The contact owns a 2021 KIA Sorento. The contact stated while driving the vehicle on a hill he states the vehicle stutters very hard and moves back and forth with hesitation to accelerate. The vehicle was seen by a dealer 3 months before and was made aware of a transmission failure starting, the contact moved to an area that has much more hills and is now experiencing hard transmission failure symptoms. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage 136,577.

NHTSA ID

11737858

Incident

Feb 1, 2026

Mileage

136,577 mi

The contact owns a 2021 Kia Sorento. The contact stated that while driving rotating noise coming from and louder when accelerating. The was taken to local mechanic transmission. The vehicle was taken to the local dealer who diagnosed that the transmission needed to the be replaced. A transmission software update was performed but the failure continued to occur. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the vehicle was previously service under the NHTSA Campaign Number: 22V760000(POWER TRAIN). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 80,000.

NHTSA ID

11737857

Incident

Feb 1, 2026

Mileage

80,000 mi

COMPONENT: 2.5L T-GDI engine failed completely at 102,971 miles, requiring full replacement (~$8,000). Vehicle available for inspection at [XXX] Kia, [XXX] . SAFETY RISK: Engine lost power during normal operation. Sudden, uncontrolled loss of engine power creates a direct collision risk at highway speeds for the driver, passengers, and surrounding vehicles. CONFIRMED BY DEALER: Mark Kia performed a borescope inspection on April 10, 2026 confirming cylinder wall scoring, oil-fouled pistons, and worn honing patterns across multiple cylinders. Findings are consistent with Kia TSB ENG235 (January 2022), which documents a defective PCV check valve on 2021–2022 Sorento 2.5T engines allowing oil to contaminate combustion chambers. Vehicle was serviced exclusively at Mark Kia for all 17 visits since 2021. TSB ENG235 does not appear in any service record. PRIOR SYMPTOMS: No warning lamps or messages before failure. A certified 36-point inspection one week prior showed zero cautions. Spark plugs replaced at 74,534 miles (Jan 2025) were found fouled at ~102,000 miles, only 28,000 miles later — indicating silent, progressive oil contamination. The defect is undetectable by the driver until catastrophic failure. Kia America has not responded to two formal written dispute requests (Case #XXX, April–May 2026). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11737713

Incident

Apr 10, 2026

The contact owns a 2021 Kia Sorento. The contact stated that while driving 50-60 MPH, the check engine warning light illuminated. The vehicle hesitated and jerked while depressing the accelerator pedal. The vehicle was taken to Firestone, where the spark plugs and ignition coils were replaced; however, the failure recurred. The vehicle was taken back to Firestone, where it was diagnosed with transmission failure, and the contact was referred to the dealer for assistance. The vehicle was taken to the dealer, where the fuel injectors were replaced, and the transmission oil pump was replaced under NHTSA Campaign Number: 22V760000 (Power Train); however, the failure recurred after driving 6,000 miles. The vehicle was taken back to the dealer, where the transmission oil pump was replaced under warranty; however, the failure worsened. The contact stated that while driving approximately 30 MPH, the vehicle stalled in the middle of the roadway. The contact was unable to pull over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was filed. The contact was referred to another dealer for a second opinion. The failure mileage was approximately 86,000.

NHTSA ID

11733941

Incident

Apr 27, 2025

Mileage

86,000 mi

My windshield randomly cracked from driver side top edge and down in a diagonal direction. There is no visible impact from an object hitting my windshield, which might be a manufacturer defect. This is my daily drive vehicle but the crack is in my line of sight while driving and is not safe. This crack happened yesterday while driving and I contacted KIA service department and left a message since it was on a Saturday afternoon.

NHTSA ID

11733862

Incident

Apr 25, 2026

I am writing to formally file a complaint regarding my 2021 Kia Sorento and the repeated lack of resolution from the dealership where the vehicle was purchased and serviced. I have taken my vehicle to the dealership multiple times to address ongoing and serious safety concerns. Despite having active warranties on the transmission and powertrain, I have continually been told that there is nothing they can do, and my concerns have not been properly addressed. The vehicle is experiencing persistent issues, including: The transmission jerking and jarring when shifting gears The dashboard and center display screen intermittently go completely black while driving These issues do not occur constantly, but they happen frequently enough to pose a significant safety risk. I regularly have my grandchildren in the vehicle, and their safety, as well as my own, is my highest priority. Each time I have contacted the dealership to report these problems, I have been met with excuses and resistance to even scheduling an appointment. Due to the lack of cooperation, I felt I had no choice but to drop off my vehicle on April 13, 2026, without an appointment in order to have it addressed. I am extremely disappointed in the level of service and treatment I have received. As a loyal customer—this being my third vehicle purchased from the same dealership—I have never experienced this type of disregard. I also feel that I have not been treated fairly and, at times, have been dismissed in a way that is concerning and unacceptable. I am requesting the following: A full and thorough diagnostic of my vehicle, specifically addressing the transmission and electrical issues Proper repair under warranty Clear communication regarding findings and next steps Immediate attention to these safety concerns I purchased this vehicle with the expectation of reliability and safety. At this time, I do not feel safe driving it, and I am requesting that Kia take this matter seriously

NHTSA ID

11731071

Incident

Apr 13, 2026

Our 2021 Kia SORENTO has been to Elmhurst kia service numerous times . The chief complaint is the Kia Sorrento keeps losing power while in drive reverse middle traffic even on the highway but yeah every time we take it in, they say either it’s the battery .you can’t use it in the Eco mode .turn off the shut off while in drive mode when at stops ! always a different excuse, but yet no recall and it’s not showing up on their computer, but yeah it’s happening and Kia does not want to take ownership. The vehicle has been left there for numerous weeks at a time leaving us without a vehicle no loaner . But because cannot duplicate issue release vehicle back with no repairs or maintenance. Kia prefer you taking the car getting into a car accident before they decide to do anything or even a lawsuit because not enough people having same issue with the 2021 kia SORENTO s model ! If you also have these issues please report them here so they can be forced to open a recall !!! Before someone gets seriously hurt my SORENTO has loss power on highway and in the middle of train tracks with my little ones in SORENTO and we drove the vehicle from day one original owners not a used SORENTO

NHTSA ID

11731006

Incident

Apr 3, 2026

The system that failed is the high-pressure fuel pump and the intake fuel pump. The fuel system pressure is too low, and the cold start fuel pressure is too high. This is defective because I purchased the car used in November 2023. The car is a safety risk as it stalled immediately yesterday while I was driving with my children and it began smelling like gas fumes from exhaust. The vehicle has been diagnosed by a certified mechanic at Mike and Nick's Tires and Services in Canyon Country, California No warning lights or messages appeared prior to the failure. The engine light came on as soon as the car began to stall and shake/lose power.

NHTSA ID

11730855

Incident

Apr 12, 2026

I am submitting a complaint regarding a 2021 Kia Sorento SX that experienced a premature and catastrophic transmission failure at approximately 76,000 miles. The vehicle developed loss of power, hesitation, and erratic shifting at low speeds (0–30 mph), creating a potentially dangerous condition when attempting to accelerate into traffic or cross intersections. A Kia dealership diagnosed the issue as TCM code P193B79 and determined that the failure involved an internal high-pressure oil pump within the transmission, requiring full transmission replacement. This failure occurred despite proper maintenance and completion of Kia’s SC250 software update, which appears to address transmission-related drivability concerns. My maintenance records confirm compliance with manufacturer recommendations. The symptoms and failure mode closely align with the type of transmission issues addressed in Kia service campaigns and recalls (including SCN-520), yet Kia has refused to provide coverage or reimbursement, stating that my specific diagnostic code does not exactly match the recall criteria. As a result, I was forced to pay approximately $5,300 out of pocket for a full transmission replacement on a vehicle with relatively low mileage. This raises serious concerns that: * The underlying transmission issue may extend beyond the narrow criteria defined in the recall * Software updates may not fully address an underlying mechanical defect * Consumers may be experiencing similar failures without coverage Additionally, the loss of power and hesitation at low speeds presents a clear safety risk, particularly in normal driving conditions. I am requesting that NHTSA investigate whether transmission failures in the 2021 Kia Sorento are broader than currently recognized and whether affected consumers should receive expanded coverage or reimbursement.

NHTSA ID

11730260

Incident

Jan 10, 2026