2007 Kia Spectra

The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,

Passenger Air bag sensor light has come on and stayed on. Took to AutoZone and have them put it on the code reader and said it was something faulty in the sensor mat under the seat.

NHTSA ID

11566976

Incident

Sep 1, 2022

I purchased my 2007 Spectra5 used with 155,000 miles on it. The engine had no codes or any stored codes. It ran fine until I filled it up with gas. I DO NOT overfill the tank because I understand EVAP issues. After filling up the vehicle would stall at idle and occasionally lose power (momentarily) at highway speeds (55 mph and up). Obviously this is an extremely dangerous situation! Once the gas level got below 1/2 tank the issues went away…but now I ONLY fill the tank to halfway and the problems arise again every so often. Since there are no codes present I cannot replicate the issue without possibly damaging components further and I already replaced the battery, plugs, IAC valve, MAF sensor, and oil to try to remedy this problem. From reading other’s comments about this same problem I do not want to keep pouring money into a problem that KIA itself seems unable, and unwilling, to fix. This is extremely frustrating and dangerous as occasionally the vehicle loses all power on the highway at speeds exceeding 55mph and I feel an accident is inevitable. I’m not financially well off enough to just eat the cost of this vehicle and get a new (used) vehicle though so KIA has really put me (AND OTHER DRIVERS) in a difficult and dangerous position. As others have stated from mechanics who have tried to diagnose this issue, there may be a serious issue with the EVAP system including, but not limited to, the charcoal canister and purge valve. I will try replacing the fuel filter in the gas tank but I do not have high hopes that this will fix this problem. Once again, there are no codes present before or after these stalling/power loss problems and live data from and OBD2 scanner is within parameters for this vehicle and it’s age. I need to report this now so everyone, ESPECIALLY KIA, is aware of this issue and information.

NHTSA ID

11521552

Incident

May 5, 2023

I first noticed my air bag light (the one by the clock) coming on and off when my granddaughters weight went from under weight to appropriate weight to ride in the front seat. It would come on and off as she would adjust herself or move around in the seat. Sometimes it would stay on or sometimes it would stay off. When that light stopped coming on and off the one in the dash console where the speedometer is, that light has been coming on and staying on warning there's a problem with the airbag according to the manual. I entered my VIN number because I know Kia has had problems with some of there airbags but my VIN number was not listed. I did go by an auto parts house to make sure that was indeed the airbag warning light and I was told that the airbag may or maynot go off in a cash or it could go off at anytime. THIS IS VERY DANGEROUS if I was told correctly and felt that this needed to be looked into further. Thank You

NHTSA ID

11485851

Incident

Sep 1, 2021

I was drive my 2007 Kia Spectra EX in Bakersfield, CA. All of a sudden I parked my car at the gas station, I filled the car up, and I tried putting the transmission into drive but the car would not go forward. I went and searched why the car would not go forward, and I found out other Kia Spectra owners had the same problem. Is there any way to make Kia recall those cars and replace or repair the transmissions under a national recall.

NHTSA ID

11464679

Incident

May 12, 2022

Doors LOCK and UNLOCK on their own. I have been locked out numerous times, some with the engine still running.I brought car to Kia numerous times, and was told there was nothing that could be done, it was a manufacturing defect. I feel this could prevent a very serious problem , both in a collision, or if a child were to be locked in the car. At times the car locks by itself so quickly, I cannot even turn the key fast enough to open the door. I have owned this car since 2009, and it has happened at least 50 or more times.

NHTSA ID

11436947

Incident

Oct 15, 2009

I WAS SHOPPING AT THE GROCERY STORE AND AS I AM BACKING OUT OF THE PARKING SPACE, MY STEERING WHEEL BECAME VERY VERY STIFF AS I CUT THE WHEEL TO POSITION MY CAR TO MOVE FORWARD. I WAS ABLE TO DRIVE FORWARD, BUT WHEN MAKING A RIGHT OR LEFT TURN THE STEERING WHEEL WAS VERY RESISTANT TO THE POINT THAT I ACTUALLY HAD TO TURN THE WHEEL ALL THE WAY TO RIGHT OR LEFT TO MAKE MY TURN.ON 3/10/2020, I TOOK MY CAR TO THE MECHANIC AND AT FIRST I WAS TOLD I NEED THE BELTS FOR A/C, ALT AND PS, REPLACED WHICH I AUTHORIZE AND PAID $171.60 TAX INCLUDED. ON 3/26/2020 I HAD TO RETURN MY CAR TO THE MECHANIC DUE TO SAME HARD TO STEER PROBLEM. I WAS THEN TOLD I NEEDED TO HAVE MY POWER STEERING PUMP REPLACED WHICH I AUTHORIZED AND PAID $353.93 TAX INCL. NEXT ON 4/7/20 THE SAME PROBLEM OF STEERING HAPPENED. I TOOK IT BACK TO MECHANIC AND WAS TOLD I NEEDED A RACK AND PINION (P/S RACK), AT A COST OF $848.63 TOTAL, WHICH I PAID. I HAD TO TAKE IT BACK FOR THE SAME PROBLEM ON 7/14/202 AND 8/17/2020 AND 9/16/2020. I WAS NOT CHARGED THE LAST THREE DATES OF REPAIR. I RECENTLY GOOGLE SEARCHED FOR RECALLS AND SAW THAT THE 2007 KIA SPECTRE HAD INDEED BEEN RECALLED. I CALLED 800-333-4542 AND WAS TOLD MY VIN NUM SHOWS NO SERVICE CAMPAIGN. I CONTEST THEIR FINDINGS I WOULD LIKE MY COMPLAINT TO BE INVESTIGATED. I AM ALSO REQUESTING A TOTAL REIMBURSEMENT OF $1374.16. THANK YOU, [XXX]. I LOOK FORWARD TO HEARING FROM YOU. REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *CC

NHTSA ID

11390505

Incident

Mar 10, 2020

Mileage

85,106 mi

THE 2007 KIA SPECTRA WAS IN MOTION ON THE HIGHWAY AND WAS IN AN ACCIDENT WITH MAJOR IMPACT. THE AIRBAG DID NOT DEPLOY. THE KIA HIT ANOTHER CAR AND HAD MAJOR DAMAGES.

NHTSA ID

11162490

Incident

Dec 14, 2018

Mileage

140,000 mi

PASSENGER SIDE OCS SENSOR FAILING.

NHTSA ID

11100118

Incident

May 31, 2018

Mileage

79,000 mi

TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.

PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.

TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.? It is critical for technicians to be aware that ALL such locking fasteners, regardless of type, are for ?one time use? only.

TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?

"REVISION: OWNER LETTER: WTY001 - 2007-2009 MY SPECTRA VEHICLES FRONT PASSENGER OCS SENSOR MAT KIA NEW VEHICLE LIMITED WARRANTY EXTENSION - DEAR KIA SPECTRA OWNER: KIA MOTORS AMERICA’S HIGHEST COMMITMENT IS TO YOUR SAFETY. TO THAT END, KIA IS EXTENDING THE WARRANTY COVERAGE FOR THE FRONT PASSENGER OCCUPANT CLASSIFICATION SYSTEM (OCS) SENSOR MAT TO 15 YEARS WITH UNLIMITED MILEAGE, STARTING FROM THE DATE OF FIRST SERVICE. THIS WARRANTY EXTENSION ADDRESSES FAILURES OF THE OCS SENSOR MAT AS REPORTED BY SOME VEHICLE OWNERS. THE SENSOR MAT IS INTENDED TO DETECT CHILD SEATS AND SMALL STATURE OCCUPANTS WHO COULD BE HARMED BY DEPLOYMENT OF THE PASSENGER FRONTAL AIR BAG. IF THE SENSOR MAT IS NOT WORKING PROPERLY, THE OCS WILL NOT SUPPRESS THE AIR BAG. ACCORDINGLY, IF A CRASH OF SUFFICIENT SEVERITY OCCURS, THE AIR BAG WILL DEPLOY EVEN IF THE PASSENGER SEAT IS OCCUPIED BY A CHILD OR SMALL STATURE PERSON."

REVISION: DEALER PARTS AND SERVICE MANAGER MEMO: WTY001 - 2007-2009 MY SPECTRA (LD) FRONT PASSENGER OCS SENSOR MAT WARRANTY EXTENSION (WTY001) - KIA MOTORS IS RE-NOTIFYING THE OWNERS OF THE 2007-2009 MY SPECTRA VEHICLES OF THE WARRANTY COVERAGE EXTENSION ON THEIR VEHICLES AND HAS REVISED THE OWNER INSTRUCTIONS.