2006 Kia Sportage Engine Problems

I purchased this vehicle from a private seller in August 2021 and attempted to obtain records of the vehicle Kia America Case ID #14353653 which Kia America has yet to provide me any information. I had a full diagnostic done by a certified mechanic at Borst Automotive in the state of Arizona on 09/18/21 where several concerns were reported to me that Kia failed to report. There is a new and concerning grinding with the engine on my 2006 Kia Sportage LX that sounds like it might be an exhaust leak. I hear loud grinding sounds now when turning on the car that immediately sound when it is fired up, and when accelerating is the worst, but the sound starts loud and is immediate when I turn on the vehicle and fire up the engine. Two days ago on 10-01-21 which was the last night I drove it as it feels unsafe to drive now, I did not get far before the front driver's tire closest to the engine completely blew out/ and exploded coming off of it's wheel and cap hinting at a potential engine problem or recalled defect. I had to immediately pull over and call AAA to come put the spare donut on my car to get it back home to park. The engine appears to have something wrong with the exhaust system and it sounds bad. I reported this today to Kia America case ID #14407655. I always make it a point to to check fluids and something is not right here. The car is overheated but Radiator is fine and coolant, and all other engine fluids are full but could be an engine issue that is dangerous. This engine sounds like it will burst at any minute its grinding and stalling so bad. Made an appointment with Royal Kia in my hometown Tucson, AZ for October 12, 2021 to have the fuel tank straps replaced and towed as apparently they are faulty and this was the soonest this dealership could perform this. I know the 2010-2021 Sportage models were recalled under Safety Recall 20V-750 but since this recall is somewhat new and yet to discover other Kia Sportage’s that might also be affected. Consumer also noticed malfunctioning of brake and tail lig

NHTSA ID

11435323

Incident

Oct 1, 2021

I WAS RIDING DOWN THE ROAD AND THE AIRBAG LIGHT CAME ON. TWO DAYS LATER THE CHECK ENGINE LIGHT CAME ON. MY MECHANIC THINKS IT IS A SENSOR FOR THE CHECK ENGINE LIGHT. HAVING TROUBLE WITH COVID-19 GETTING THE PART, BEEN WAITING FOR OVER A WEEK. MY MECHANIC HAS RECOMMENDED ME TAKING THE CAR TO A KIA DEALER SHIP WITH THE AIRBAG LIGHT COMING ON. HE THOUGH FOR SURE IT WOULD HAVE A RECALL BUT I DO NOT SEE ONE LISTED.

NHTSA ID

11385351

Incident

Oct 23, 2020

Mileage

146,367 mi

THIS CAR CONTINUES TO HAVE PROBLEMS WITH SPEEDING UP AND SLOWING DOWN ON ITS OWN, AT THIS POINT IT SHUT OFF ANY TIME I WAS SLOWING DOWN FOR A LIGHT OR STOP. IT CUT OFF MULTIPLE TIMES ON A HIGHWAY GOING 75 MPH. VERY SCARY WITH KIDS IN CAR. WAS ABLE TO GET HOME AND IT WILL NOT TURN OVER OR START BACK UP GETTING DIAGNOSED TODAY, THERE NEEDS TO BE SOMETHING DONE ABOUT THIS ISSUE, I HAVE READ 100S OF SIMILAR PROBLEMS LIKE THIS! KIA YOUR PUTTING OUR LIVES IN DANGER, PREGNANT WITH 2 KIDS AND CAR SHUTTING OFF ON HIGHWAY, OR SPEEDING UP AND SLOWING DOWN BY IT SELF IS TRAUMATIZING. DO SOMETHING BEFORE SOMEONE IS BADLY HURT!! ALSO I AM BIG AND PREGNANT AND DRIVER DOOR DOES NOT OPEN I AM ASSUMING THAT TOO IS AN ELECTRIC ISSUE EITHER WAY I HAVE TO CLIMB OVER SEATS, THIS CAR LOOKED GREAT AFTER 1 DAY DOOR STOPPED WORKING AND WITHIN A FEW WEEKS OF OWNING IT NOW SPEED! KIA YOU REALLY NEED TO FIX ALL THESE ISSUES SEEMS TO ME THERE IS ELECTRIC PROBLEMS ALL THROUGHOUT THE CAR. PLEASE HELP

NHTSA ID

11376365

Incident

Nov 21, 2020

Mileage

130,000 mi

MY FRIEND AND I WERE DRIVING HOME AT 55 MPH WHEN MY SPORTAGE STARTING SPEEDING UP ON ITS OWN. THEN WHEN I TRIED TO STOPPED FOR A RED LIGHT IT WANTED TO CUT OFF. SO WHEN THE LIGHT CHANGED IT STARTED SPEEDING UP AND SLOWING ON IT'S OWN. THIS WENT ON FOR ABOUT 15 MILES. I HAVE NEVER HAD A CAR DO THIS. IT WAS REALLY SCARY. AT ONE POINT IT CUT OUT IN THE MIDDLE OF THE HIGHWAY. THANK GOD THERE WAS NOONE ELSE BEHIND ME. I DID MAKE IT HOME AND IT DIED PULLING IN THE DRIVE.

NHTSA ID

11365239

Incident

Oct 18, 2020

Mileage

122,000 mi

I PREVIOUSLY COMPLAINED OF REPEATED STUCK ACCELERATOR PEDAL. AT 179,510 MILES ACCELERATOR PEDAL BEGAN TWISTING OUT OF ITS STANDARD POSITION. AN INSPECTION REVEALED THE BOLT SECURING THE ACCELERATOR PEDAL AND THE THREADED HOLE IN FLOOR CRACKED AND SEPARATED FROM THE FLOOR

NHTSA ID

11256294

Incident

Sep 15, 2019

Mileage

179,510 mi

PREVIOUSLY REPORTED ENGINE SURGES / ERRATIC IDLE AT 177800 MILES, AND THROTTLE BODY CLEANED AT 177900 MILES. AT 178345 THE IDLE AIR CONTROL VALVE WAS CLEANED AS A PRECAUTION, DUE TO THE PREVIOUS SYMPTOMS. AT 178377 WHILE DRIVING ON THE HIGHWAY I FOUND THE THROTTLE STUCK IN THE FULL OPEN POSITION. AFTER SAFELY STOPPING THE VEHICLE, I HAD TO MANUALLY RETURN THE THROTTLE TO THE NORMAL POSITION. UPON RESTARTING THE VEHICLE I BEGAN EXPERIENCING ERRATIC IDLING 3000 TO 4000 RPM. ONCE PARKED AT 178382 THE IDLE AIR CONTROL VALVE WAS RECHECKED, AND ENGINE IDLE RPM RETURNED TO NORMAL. I CHECKED THE OBDII AND FOUND NO PREVIOUS OR PENDING CODES. I WILL REPLACE THE IDLE AIR CONTROL VALVE.

NHTSA ID

11243525

Incident

Aug 12, 2019

Mileage

178,377 mi

I PREVIOUSLY REPORTED AT 177,800 MILES THAT I WAS EXPERIENCING ENGINE SURGES. WHILE DRIVING IF I DEPRESSED THE CLUTCH ENGINE WOULD RISE TO 2000 RPMS. IF I PULLED THE ACCELERATOR PEDAL UP WITH TIP OF MY FOOT, THE ENGINE RPMS WOULD RETURN NORMAL. AT 177, 900 MILES THE THROTTLE BODY ASSEMBLY WAS CLEANED, AND I AM NO LONGER EXPERIENCING ENGINE SURGES.

NHTSA ID

11242925

Incident

Aug 9, 2019

Mileage

177,900 mi

WHILE BRAKING THE VEHICLE APPEARED TO BE PICKING UP SPEED. WHEN I DEPRESSED THE CLUTCH THE ENGINE SURGED PAST 2000 RPM. WHILE DRIVING ON A DOWNGRADE THE VEHICLE WAS PICKING UP SPEED, AND I DEPRESSED THE CLUTCH AND THE ENGINE RPM WENT 2000 RPM FOR SEVERAL SECONDS. FROM MY EXPERIENCES WITH OTHER VEHICLES I THOUGHT: MAYBE THE DRIVER'S MAT SHIFTED, OR SOME OTHER OBJECT MAY HAVE FALLEN AND WAS INTERFERING WITH THE ACCELERATOR PEDAL. I FELT AROUND THE PEDAL WITH MY FOOT, BUT FOUND NO FOREIGN OBJECTS. I USED THE TIP OF MY FOOT TO MAKE THE ACCELERATOR PEDAL WAS UP ALL THE WAY, AND THEN ENGINE RPM APPEARED TO GO TO NORMAL. WHEN I REACHED MY DESTINATION I TAPPED ON THE ACCELERATOR PEDAL A FEW TIMES TO RE-CREATE THE PROBLEM. THE ENGINE WENT TO 2000 RPM FOR ABOUT 3 SECONDS, AND CAME BACK DOWN. I CHECKED FOR ANY CODES USING AN OBD II SCANNER, HOWEVER NONE WERE FOUND.

NHTSA ID

11242745

Incident

Aug 8, 2019

Mileage

177,800 mi

VEHICLE STALLED WHILE DRIVING ON HIGHWAY AT APPX. 40 MPH. VEHICLE DID NOT RESTART, AND WILL NOT RESTART. MECHANICS HAVE PROBLEM CONNECTING SCANNERS TO PMC AND EFFECTING REPAIRS. SEVERAL SCANNERS, INCLUDING PROFESSIONAL SCANNERS ARE UNABLE TO RETRIEVE VEHICLE'S DATA. SCANNERS, SAYS "CHECK CONNECTION TO VEHICLE COMPUTER" AND "WAITING FOR RESPONSE FROM VEHICLE". VEHICLE IS COMPLETELY DISABLED. TOTAL OPERATING MILAGE OF VEHICLE IS 38,500 MILES.

NHTSA ID

11164234

Incident

May 28, 2018

WHILE DRIVING, MY CAR JUST SHUTS DOWN. THE ENGINE DIES. ON SEVERAL OCCASIONS, DRIVERS BEHIND ME HAD TO SLAM ON BRAKES OR SWERVE OUTOF THE WAY. THIS IS DANGEROUS WHILE TRAVELING ON THE HIGHWAY. TOOK VEHICLE TO MECHANIC, THEY DON'T KNOW WHAT THE PROBLEM IS. WENT ON INTERNET, AND MANY CUSTOMERS HAVING THE SAME PROBLEM.

NHTSA ID

11051134

Incident

Nov 13, 2017

Mileage

64,500 mi

MOTOR BLEW UP WHILE DRIVING ON A HWY, CAR STALLED, WHICH CAUSED THE STEERING WHEEL TO LOCK UP, AND THE BREAKS TO STOP RESPONDING.

NHTSA ID

11011007

Incident

Jul 25, 2017

Mileage

119,000 mi

TL* THE CONTACT'S GRANDDAUGHTER OWNS A 2006 KIA SPORTAGE. WHILE DRIVING AT AN UNKNOWN SPEED, THE DRIVER HEARD A BANGING SOUND COMING FROM THE FRONT OF THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND BELIEVED THAT THE HARMONIC BALANCER HAD FAILED. THE CONTACT SPOKE WITH GLASSMAN KIA (28000 TELEGRAPH RD, SOUTHFIELD, MI 48034) WHO ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 38,430.

NHTSA ID

11010254

Incident

Jul 22, 2017

Mileage

38,430 mi

TL* THE CONTACT OWNS A 2006 KIA SPORTAGE. WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER SEIZED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE, RADIATOR, AND TIMING BELT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED SEVERAL TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

NHTSA ID

10936400

Incident

May 12, 2014

TL* THE CONTACT OWNS A 2006 KIA SPORTAGE. WHILE DRIVING AT 30 MPH, THE POWER STEERING FAILED AND THE ALTERNATOR LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE ENGINE CRANK SHAFT PULLEY DETACHED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.

NHTSA ID

10747862

Incident

Jun 29, 2015

Mileage

119,000 mi

DEAR NHTSA, I HAVE A 2006 KIA SPORTAGE WITH 69,245 MILES AND HAVE BEEN IN THE DEALER ON 12/4/14, 12/8/2014, 12/13/14, FOR ENGINE SHUTTING OFF WHILE BRAKING TO ENTER ANOTHER LANE OR TO TURN. ENGINE SHUT OFF AGAIN WHILE BRAKING TO TURN AT 9:00PM ON 12/16/14.ENGINE LIGHT HAVE COME ON AT LEAST 6-8 TIMES BEFORE AT WHICH EACH TIME I WENT INTO THE SERVICE DEALER ON 12/3/14, 12/8/14 AND 12/10/14. SOMETIMES IF IT WAS DURING THE DAY I TOOK THE KIA DIRECTLY TO THE DEALER. HOWEVER I NOTICED WHILE RESEARCHING THAT THIS IS AN ELECTRICAL ISSUE WITH A FAULTY THROTTLE SYSTEM. IN ADDITION KIA WANTS TO CHARGE ME $248 TO REPLACE A THROTTLE. FROM THE REVIEWS ISSUED ONLINE THIS IS A SAFETY RELATED DEFECT THAT KIA MANUFACTURER IS AWARE. ACCORDING TO SAFECAR.GOV THE CONSUMER SHOULD NOT HAVE TO PAY FOR A FAULTY THROTTLE (E.G. OR FAULTY PARTS) AND SHOULD BE REPLACED BY THE SERVICE DEALER. FINALLY COBB COUNTY SERVICE (CUSTOMER # [XXX]) SUGGESTED REPAIR INVOICE STATED THAT AFTER REPLACING TPS NEED MORE DIAGNOSIS TIME WITH VEHICLE IN ORDER TO FIND OUT ISSUE? I SHOULD HAVE TO PAY FOR A SAFETY RELATED DEFECTS (E.G. 267 OR MORE COMPLAINTS ONLINE NOT TO MENTION THE SAFETY DEFECTS OF THE 2006 SPORTAGE ENGINE SHUTTING OFF), ESPECIALLY TO PAY FOR A PART THAT WILL NOT GUARANTEE THAT THE ENGINE WILL NOT CUT OFF. I ALSO FILED AN INQUIRY WITH KIA ON TODAY 12/16/2014, CUSTOMER IDENTIFICATION REFERENCE NUMBER (#[XXX]).I AM AWAITING A CALL FROM KIA ABOUT THIS INQUIRY. I ALSO BELIEVE THAT THIS IS A SAFETY RELATED DEFECT AND THE COST OF REPAIRS SHOULD BE REMEDIED AT NO COST TO ME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10664484

Incident

Dec 3, 2014

Mileage

69,200 mi

2006 KIA SPORTAGE. CONSUMER WRITES IN REGARDS TO MALFUNCTION OF AIRBAG LIGHT. *SMD THE CONSUMER WAS INFORMED THE CONNECTIONS WERE BAD, WHICH CAUSED THE AIR BAG LIGHT TO ILLUMINATED. THE CRUISE CONTROL STOPPED WORKING, THE ESC LIGHT ILLUMINATED, AND THE RADIATOR COVER WAS BROKEN. THE DEALER AGREED TO FIX THE CONSUMER'S VEHICLE AT NO CHARGE. UPDATED 01/07/13

NHTSA ID

10485509

Incident

Nov 2, 2009

AFTER SEVERAL TIMES THAT THE ENGINE STOPPED RUNNING AND KIA DEALERSHIP COULDN'T FIND THE PROBLEM, AS I TURNED INTO THE DEALERSHIP THE ENGINE STOPPED RUNNING AND I COASTED INTO THE PARKING LOT. REPAIR ORDER STATED POSSIBLE SOLENOID FAILURE (CODE P0665) AND REPLACED BANK 2 INTAKE MANIFOLD TUNING VALVE SOLENOID.THIS WAS ON 10/2010. THE CAR WAS BOUGHT BY US AS NEW. AGAIN, THE ENGINE HAS STOPPED WHILE DECELERATING AND/'OR TURNING (DEC. 21, 2011). THIS IS THE THIRD TIME IN 3-4 WEEKS. CALLED KIA CONSUMER TELEPHONE NUMBER IN OWNER'S MANUAL AND THEY HAVE NO OTHER INCIDENTS REPORTED FOR THIS PROBLEM. CAR KNOW HAS 90,000 MILES ON IT AND THEY SAID WE'RE OUT OF WARRANTY AND WE SHOULD TAKE IT TO OUR KIA DEALER IN OUR TOWN. CALLED THEM AND EARLIEST APPOINTMENT IS NEXT WEEK AS THEIR TECHNICIAN IS IN SCHOOL. THE WIFE AND I ARE WORRIED THAT WE MAY BE "REAR-ENDED" AS THIS HAPPENED ON A BUSY HIGHWAY, AS WE WERE BRAKING TO STOP AT A TRAFFIC LIGHT OR TURNING INTO A DRIVEWAY. *TR

NHTSA ID

10440892

Incident

Feb 23, 2010

Mileage

61,200 mi

2006 KIA SPORTAGE EX WITH V-6 HAS A HABIT OF COMPLETELY SHUTTING DOWN ELECTRICALLY, KILLING THE ENGINE AND THUS ALL LIGHTS, POWER ASSIST TO STEERING/BRAKES, ETC. PREVIOUSLY THIS OCCURRED ONLY WHEN TAKING OFF FROM A STOP (PREVIOUSLY REPORTED). THIS TIME OUR DAUGHTER WAS DRIVING AT HIGHWAY SPEEDS AT NIGHT IN THE MIDDLE OF UTAH WHEN THIS OCCURRED AGAIN. SHE WAS ABLE TO GET IT OFF THE HIGHWAY SAFELY WITHOUT INCIDENT IN COMPLETE DARKNESS AND NO POWER ASSISTS. CAR WAS RUNNING ON CRUISE CONTROL SO NO DRIVER FUNCTION COULD HAVE CAUSED THE INCIDENT. NO WARNING SUCH AS ENGINE STUMBLE, FLICKERING LIGHTS, ETC,, IT JUST SHUT OFF!!! ONCE SAFELY STOPPED, OUR DAUGHTER WAS ABLE TO RESTART THE CAR AND GET TO THE DESTINATION WITHOUT INCIDENT. DEALER IS AWARE OF THIS PROBLEM BUT IS UNABLE TO FIX IT. ONLY HAS BEEN TAKEN TO DEALER FOR REPAIRS. *TR

NHTSA ID

10358922

Incident

Oct 2, 2010

Mileage

33,000 mi

TL* THE CONTACT OWNS A 2006 KIA SPORTAGE. THE CONTACT STATED HE VEHICLE HAS EXPERIENCED MANY FAILURES. WHILE DRIVING THE VEHICLE STALLED OUT AND WOULD NOT RESTART. THE VEHICLE WAS TAKEN TO THE DEALER AND THE HEAD GASKET WAS REPLACED BUT THAT DID NOT REMEDY THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AGAIN AND THEY ADVISED THE SENSOR NEEDS TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 91,000. THE VIN WAS UNKNOWN.

NHTSA ID

10354629

Incident

Aug 6, 2010

Mileage

91,000 mi

2006 KIA SPORTAGE EX HAS REPEATED PROBLEM WITH ENGINE SHUTDOWN/STALL UPON STARTING FROM A STOP AT AN INTERSECTION. BOTH LEFT AND RIGHT TURNS. BOTH WITH AND WITHOUT AIR CONDITIONING, AND IN ALL WEATHER CONDITIONS ALSO WITH AND WITHOUT LIGHTS. NO CODE HAS SHOWN UP ON THE COMPUTER. NO WARNING. FIRST INDICATION THERE IS A PROBLEM IS WHEN WE TAKE OFF AND STEERING IS STIFF (E.G. NO PS) AND THE CAR DOESN'T MOVE. *TR

NHTSA ID

10319668

Incident

Mar 5, 2010

Mileage

28,000 mi

THE CONTACT HAS 2006 KIA SPORTAGE THAT HAS BURNED OFF ANTI-FREEZE COMING THROUGH THE AIR VENT. THE COIL IS THINING AND CAUSING IT TO COME THROUGH THE WINDOW. THERE WAS AN IN CABIN AIR FILTER PLACED IN THE VEIHICLE THAT DID NOT HELP. THIS PROBLEM STARTED AROUND NOVEMBER OF 2008. 35000 MILES WHEN PROBLEM STARTED AND 45962 NOW

NHTSA ID

10295344

Incident

Nov 14, 2008

Mileage

35,000 mi

TL*THE CONTACT OWNS A 2006 KIA SPORTAGE. WHILE MAKING A TURN AT 5 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. WHEN THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, HE WAS REAR ENDED BY ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE IS AT THE BODY SHOP AND WILL BE TAKEN TO THE DEALER FOR A DIAGNOSIS. THE CURRENT AND FAILURE MILEAGES WERE 25,380. UPDATED 03-05-08 *BF

NHTSA ID

10211116

Incident

Dec 1, 2007

Mileage

25,380 mi

I HAVE A 2006 KIA SPORTAGE. FROM THE DAY I BOUGHT IT ,IT'S MADE A BOILING SOUND IN THE DASH BROAD WHEN I TURN MY CAR OFF. I TOOK IT TO THE DEALERSHIP AND DROPPED IT OFF TO HAVE IT LOOKED AT. WHEN I PICKED IT UP I WAS TOLD THAT MY COOLING SYSTEM HAD NOT BEEN BURPED RIGHT. SO THEY DRAINED THE SYSTEM AND RE-FILLED IT. AND THAT AT SHOULD TAKE CARE OF THE PROBLEM. WELL IT DIDN'T !!!!!!! IT'S WORSE NOW THAN BEFORE. AND TO ADD TO IT, IT LOOKS LIKE I'M GROWING MAGIC ROCKS ON THE LEFT AND RIGHT SIDE OF THE RADIATOR. IT'S SO GREEN IN COLOR PLUS IT LOOKS FUZZY. AT THE SAME TIME WHEN THE CAR IS HOT THE COOLING FAN WILL GO ON. BUT AS SOON AS I TURN THE CAR OFF THERE'S NO MORE FAN, EVER. AND FOR THE LAST COUPLE DAYS THE TRACTION CONTROLS LIGHT ON THE DASH IS LIT UP AND WON'T TURN OFF UNLESS I TURN THE MOTOR OFF AND WAIT ABOUT 10 MINS. WHEN I TOOK IT IN FOR THIS I WAS TOLD THERE WAS A RECALL ON THIS, BUT THERE IS TWO DIFFERENT SYSTEMS AND THE SYSTEM I HAVE ISN'T THE ONE WITH THE RECALL. *TR

NHTSA ID

10192421

Incident

Jul 24, 2006

Mileage

1,000 mi