2009 Kia Sportage Brakes Problems

The contact owns a 2009 Kia Sportage. The contact received notification of NHTSA Campaign Number: 22V800000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was determined that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact to contact the dealer for assistance. The contact had heard an abnormal sound and noticed that the wiring harness had melted. The vehicle was not repaired. The failure mileage was unknown. Parts distribution disconnect.

NHTSA ID

11547820

Incident

Oct 2, 2023

The contact owns a 2009 Kia Sportage. The contact received notification of NHTSA Campaign Number: 22V800000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11532970

Incident

Oct 24, 2022

The contact owns a 2009 Kia Sportage. The contact stated that upon starting the vehicle in the dealer's parking lot after the recall repair of NHTSA Campaign Numbers: 16V815000 (Electrical System) and 22V800000 (Service Brakes, Hydraulic) had been completed, the HECU, the ABS, the TPMS warning lights and other unknown warning lights illuminated. The contact drove the vehicle back to the residence. The contact notified the dealer of the failure. The dealer advised the contact to take the vehicle in for the repair however, there would be a fee for the repair. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 93,157.

NHTSA ID

11520410

Incident

Apr 21, 2023

Mileage

93,157 mi

Reference Kia SC138, Rev 1: DTC code C2380 has been pulled and the recall specifically calls for replacement of the HECU should this code occur. My dash panel's brake light, ESC light and ABS light all have come on alerting me to my car's problem. This recall was initially addressed on 2/6/2017 in Arizona checking for corrosion and/or moisture reaching the circuit board which I was told is common in harsh environments. I am told the cover was replaced. Cars in Arizona do not have a moisture or road salt issue reaching the engine compartment. Now it does. I purchased this low mileage Sportage with 55K miles in Iowa and I live in Wisconsin and now there is a failure of the circuit board from exposure to our weather. The dealer that examined the control unit during its first recall exam lengthened two of the brake lines 3-4 inches making it easier to reconnect the brake lines. This is why my dealer, Bergstrom Kia in Appleton, WI initially claimed they can not address the replacement of this HECU. Since I challenged their excuse with the assistance of my mechanic at Whitcomb Automotive in Kaukauna, WI Bergstrom now is saying they cannot fix my car under this recall because it is no longer under warranty and that it was examined in Arizona back in 2017. I was not of the understanding that safety recalls had a time limit. I currently am not allowing my family to drive the car fearing there could possibly be an engine compartment fire as described in the recall bulletin. The folks at Bergstrom have now given me 3 different reasons why they cannot perform this recall at 3 different challenges I have made with regard to their excuses, they just keep changing their story. I have spoken with Kia America and they tell me this is completely up to the dealer regarding the repair and that Kia Corp has zero influence for this being fixed. Can you help me?

NHTSA ID

11458771

Incident

Mar 24, 2022

ON 12 JULY 2018 AT 0530 AM I WAS DRIVING DOWN COUNTY ROAD 26 MANKATO MN TO PICKUP MY SEMI AS I WAS APROACHING 3RD AVE STOP SIGN I APPLIED THE BRAKES PEDAL WENT TO FLOOR I WENT THROUGH INTERSECTION SLAMMED INTO A BOULDER WALL HEAD ON AT AN ESTIMATED SPEED OF 40-45MPH. AIR BAGS DID NOT DEPLOY,SEAT BELT TENSIONER BROKE,WONT RETRACT BACK INTO HOLDER. AFTER GETTING CAR TOWED CAN SEE THAT THE AIR BAG SENSOR WAS CRUSHED BUT NO DEPLOYMENT SPENT 2 DAYS IN HOSPITAL. THANKFULLY NOTHING BROKE JUST ALOT OF BRUISING. CANNOT FIGURE OUT WHY BRAKES DIDNT WORK ENDED UP USING EMERGENCY BRAKE TO TRY SLOWING DOWN IMPACT.

NHTSA ID

11111418

Incident

Jul 12, 2018

Mileage

145,000 mi

TL* THE CONTACT OWNS A 2009 KIA SPORTAGE. WHILE THE VEHICLE WAS BEING DRIVEN, THE ESC WARNING INDICATOR ILLUMINATED AND REMAINED LIT. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 13V114000 (SERVICE BRAKES, HYDRAULIC, EXTERIOR LIGHTING); HOWEVER THE FAILURE RECURRED. SMITHTOWN KIA (726 MIDDLE COUNTRY RD, ST JAMES, NY 11780, (631) 724-8008) WAS CONTACTED. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000.

NHTSA ID

11067015

Incident

Feb 2, 2018

Mileage

53,000 mi

TL* THE CONTACT OWNS A 2009 KIA SPORTAGE. WHILE DRIVING 40 MPH, THE ESC INDICATOR ILLUMINATED AND THE BRAKES ENGAGED WITHOUT THE BRAKE PEDAL BEING DEPRESSED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT AND OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC CONTROL UNIT FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 86,000.

NHTSA ID

10908211

Incident

Jun 15, 2016

Mileage

86,000 mi

TL* THE CONTACT OWNS A 2009 KIA SPORTAGE. THE CONTACT STATED THAT SMOKE APPEARED FROM THE IGNITION SWITCH, WHICH WAS LOCATED ON A CORNER CONNECTED TO THE STEERING COLUMN AND DASHBOARD. THE BRAKES FAILED TO WORK WHEN THE FAILURE OCCURRED AND THE CONTACT WAS UNABLE TO DRIVE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 55,498.

NHTSA ID

10701559

Incident

Mar 25, 2015

Mileage

55,498 mi

TL*THE CONTACT OWNS A 2009 KIA SPORTAGE. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE VIOLENTLY JERKED FORWARD. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE AND A CURB. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED INJURIES TO THE RIGHT FOOT THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 13V114000 (EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC) BUT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10690085

Incident

Feb 17, 2015

I WAS GETTING MY OIL CHANGED AT VALVOLINE OIL CHANGE IN LIVERPOOL, NY. DURING THE ROUTINE LIGHT CHECK, THE TECH SAID THAT MY BRAKE LIGHTS WEREN'T COMING ON WHEN I BRAKE, ONLY THE TOP BRAKE LIGHT STRIP IN REAR MIDDLE. I HAD SEEN THE "ESC OFF" LIGHT COME ON WITHOUT ANY REASON IN THE LAST FEW WEEKS. I ALSO NOTICED THAT WHEN GETTING ON AN INTERSTATE HIGHWAY, MY CRUISE CONTROL WOULD TURN ON, BUT NOT SET/ENGAGE. I RESEARCHED ONLINE FOR THESE SYMPTOMS, AND FOUND THERE WAS A RECALL OF KIA SPORTAGES BOTH IN 2009 AND IN 2013 FOR A STOP LAMP SWITCH CAUSING THE EXACT SAME SYMPTOMS. THE NHTSA CAMPAIGN WAS #13V114000. IN CALLING THE BURDICK KIA TO GET THIS REPLACED BECAUSE OF THE RECALL, THE SERVICE MANAGER TOLD ME THAT THE SWITCH WAS REPLACED ON AUGUST 2013, IN COMPLIANCE WITH THE RECALL. BECAUSE OF THIS, I CAN'T GET THE SWITCH REPLACED FOR FREE. I AM JUST LETTING YOU KNOW THAT THERE IS STILL AN ISSUE WITH THIS CONDITION, EVEN WITH THE 2013 RECALL AND REPLACEMENT. *TR

NHTSA ID

10683798

Incident

Feb 16, 2015

Mileage

51,000 mi

MY ANTI LOCK BRAKES MODULE OR CALLED ABS. I TOOK THE CAR TO MY MECHANIC AND HE SAID, THE ABS SHOULD NOT HAVE WENT OUT THIS SOON. HE ALSO SAID THE ABS IS LEAKING BRAKE FLUID. THIS IS A SAFETY HAZARD. A ABS MODULE SHOULD NOT LEAK BRAKE, EVEN IF IT IS NOT WORKING. IF I HAVE NOT WENT TO MY MECHANIC, I COULD HAVE LOST MY BRAKES. I GOT IT AT KIA OF BRADLEY 1010 TIGHE DR, BRADLEY, IL 60914 (815) 932-1000. THEY WANT TO CHARGE AROUND $2500.00 TO REPLACE WHEN IT IS A DEFECTIVE PART AND SAFETY HAZARD. MY WINDOWS ICE UP ON THE INSIDE IN THE WINTER. I TOOK IT TO THEM, THEY TOLD DRILL HOLES IN MY DOOR SEALS. I HAVE HAD NOTHING BUT PROBLEMS WITH THIS DEALERSHIP. SOMETHING NEEDS TO BE DONE. *TR

NHTSA ID

10648371

Incident

May 31, 1991

CPSC: I1480398A. 2009 KIA SPORTAGE. CONSUMER STATED THAT THE FRONT BRAKES WERE WITH REPLACED WITH LESS THAN 80,000. *LN IT WAS REPORTED THAT SALT CORRODES THE GREASE ON THE CALIPERS LOCKING THEM UP.

NHTSA ID

10637895

Incident

Aug 21, 2014

Mileage

80,000 mi

THE SPORTAGE WAS GARAGED DURING A WINTER VACATION. UPON RETURN WE FOUND THE BRAKES SEIZED UP. AFTER GETTING THEM RELEASED, WE TOOK IT TO THE DEALER FOR SERVICE. THERE WAS CORROSION SO THE REAR BRAKE ROTORS AND PADS WERE REPLACED ON JUNE 11, 2010. THE SAME FAILURE HAPPENED AGAIN IN 2011, 2012 AND IN 2013 THE SEIZURE AND CORROSION ARE SEVERE. THIS WILL LEAD TO PREMATURE BRAKE FAILURE. *TR

NHTSA ID

10519698

Incident

May 17, 2010

Mileage

2,800 mi

TL* THE CONTACT OWNS A 2009 KIA SPORTAGE. THE CONTACT STATED THAT THE ESC OFF SWITCH ILLUMINATED AS THE BRAKE LIGHTS FAILED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE STOP LAMP SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER : 13V114000 (EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 25,848. *TR

NHTSA ID

10511311

Incident

May 6, 2013

Mileage

25,848 mi

I WAS DRIVING 30 MPH AND THE ROAD STARTED TO SLOPE DOWNWARDS, SO I STARTED TO BRAKE TO SLOW DOWN. THE CAR DID NOT STOP. BRAKES MADE A GRINDING NOISE BUT DID NOT STOP THE VEHICLE. I DROVE STRAIGHT INTO THE INTERSECTION. *TR

NHTSA ID

10317125

Incident

Mar 1, 2009

Mileage

4,000 mi