2003 Land Rover Discovery Engine Problems

TL* THE CONTACT OWNS A 2003 LAND ROVER DISCOVERY. THE CONTACT STATED THAT THERE WAS A DEFECT IN THE BOSCHE ENGINE WHICH CAUSED THE ENGINE TO OVERHEAT. THE FAILURE CAUSED THE COOLANT TO BOIL IN THE MAIN CYLINDER HEAD AND MIX WITH THE OIL IN THE ENGINE. THE CONTACT WAS QUOTED A COST OF $7,000 FOR THE ENGINE TO BE REPLACED. THE VEHICLE WAS TAKEN TO (LAND ROVER NORTH ATLANTA 1505 MANSELL RD, ALPHARETTA, GA 30009, (770) 587-2000) TO BE DIAGNOSED. THE MANUFACTURER WAS NOT CONTACTED OR INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 144,000. *JS

NHTSA ID

11302986

Incident

Jan 16, 2020

Mileage

144,000 mi

2003 LAND ROVER DISCOVERY II OIL PUMP FAILURE: WE BOUGHT OURS PREVIOUSLY-OWNED FROM A LAND ROVER DEALER. NOTHING WAS MENTIONED ABOUT THE DEFECT IN THE MANUFACTURING OF THIS 4.6 L ENGINE OR THE ATTACHED MARCH 14, 2003 TECHNICAL ALERT. IN SPITE OF REGULAR SERVICE, THE ENGINE FAILED BECAUSE OF THIS DEFECT AND WE REPLACED THE ENGINE WITH A USED ENGINE. NOW, IT MAY ALSO BE FAILING DUE TO INTERNAL OIL STARVATION. THERE ARE MANY POSTS ONLINE ABOUT THESE ENGINE FAILURES. LAND ROVER SENT OUT THEIR ALERT, BUT DID NOT OFFER THE ONLY REMEDY TO THEIR DEFECTIVE PRODUCT - REPLACE THE ENGINE ($10-12K). LIKE MANY OTHERS, WE HAVE SPENT THOUSANDS OF DOLLARS AND BEEN WITHOUT THE CAR WHILE OURS WAS IN THE SHOP BECAUSE OF A KNOWN DEFECT THAT THE LAND ROVER DEALER CHOSE NOT TO SHARE WITH US WHEN WE PURCHASED THE CAR. ATTEMPTS BY OTHERS TO SEEK HELP FROM LAND ROVER OF AMERICA OR THROUGH LEGAL ACTIONS SEEM TO HAVE BEEN UNSUCCESSFUL. SINCE THE STATUTE OF LIMITATIONS HAS MOST LIKELY EXPIRED ON THIS MATTER, THERE IS PROBABLY NO WAY TO EVER RECOVER THE FINANCIAL LOSSES. IT SEEMED LIKE A NICE CAR, BUT LAND ROVER REALLY DROPPED THE BALL ON THIS ONE. DON'T BY A 2003-4 DISCOVERY UNLESS THE VIN HAS BEEN CHECKED TO BE SURE THE VEHICLE IS IN THE PRODUCTION SERIES INCLUDED IN THE LAND ROVER TECHNICAL ALERT -TA03 1201.

NHTSA ID

10852355

Incident

Jul 1, 2012

TL* THE CONTACT OWNS A 2003 LAND ROVER DISCOVERY. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE ACCELERATED ON ITS OWN. THE BRAKE PEDAL WAS ENGAGED AND THE VEHICLE BEGAN TO JERK WHEN COMING TO A STOP. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE THROTTLE BODY FAILED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V133000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

NHTSA ID

10714947

Incident

Jun 13, 2013

Mileage

96,000 mi

TL* THE CONTACT OWNS A 2003 LAND ROVER DISCOVERY. WHILE DRIVING AT 45 MPH, A NOISE EMITTED FROM THE FRONT OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE OIL PRESSURE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 149,562. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10702741

Incident

Dec 30, 2014

Mileage

149,562 mi

THE FIRST ISSUE IS ABOUT A SEAT FIRE. MY HUSBAND WAS JUST PULLING INTO OUR DRIVE WHEN THE DRIVERS SEAT HEATER BURNED A HOLE IN THE LEFT SIDE OF THE SEAT CAUSING HIM TO HAVE A BURN. THE SECOND PROBLEM IS THE OIL PUMP. I HEARD A NOISE COMING FROM THE ENGINE, AND ASKED OUR MECHANIC WHAT MIGHT HAVE BEEN THE CAUSE OF THE NOISE. HE SAID THE THE OIL PUMP WAS BAD AND WE WILL HAVE TO REPLACE THE OIL PUMP AND IF THERE WAS DAMAGE TO THE ENGINE WOULD HAVE TO REPLACE THAT TOO. I UNDERSTAND THAT THERE WAS A TECHNICAL ALERT DATED MARCH 14, 2003, JUST THREE MONTHS AFTER I PURCHASED MY CAR. A CLASS ACTION SUIT WAS STARTED IN MAY 2003 BUT I WAS NOT INFORMED OF THE SUIT. I CALLED LAND ROVER OF AMERICA AND WAS TOLD I WAS THE ONLY LAND ROVER OWNER TO HAVE A FIRE IN THE SEAT, WHICH I FOUND WAS UNTRUE THEN I CALLED THEM BACK WHEN THE OIL PUMP WENT AND SAID THAT MY CAR WAS OUT OF WARRANTYAND WAS TOO OLD FOR LAND ROVER TO DO ANYTHING FOR ME. THE CAR HAS ABOUT 100,000 MILES ON IT. WE LIVED IN JUNEAU AT THE TIME AND THERE ARE FEW ROADS. WE WERE THERE UNTIL 2007 WHEN WE MOVED TO MONTANA. I AM TIRED OF EXCUSES FROM THE MANUFACTURER. I PAID ALMOST $40,000DOLLARS FOR THE CAR THAT SHOULD LAST ME A LONG TIME. IT WAS TO BE MY RETIREMENT CAR. OTHER PEOPLE HAVE HAD THE SAME PROBLEMS THAT I HAVE EXPERIANCED TO NO AVAIL. *TR

NHTSA ID

10631948

Incident

Feb 1, 2013

Mileage

100,000 mi

LOW OIL PRESSURE RED LIGHT WHEN LOWERING THE SPEED TO STOP. IN 2003, LAND ROVER ISSUED AN TECH ALERT #TA03 1201 FOR THE OIL PUMP FAILURES DUE TO THEIR MANUFACTURING ERROR WITH VIN# 3A[XXX] ? 3A[XXX]. BELOW IS THE ORIGINAL TEXT FROM THEIR ALERT. WHY THEY HAVEN'T MADE THE RECALL YET? IT'S SO DANGEROUS TO DRIVE THE CAR WITH ENGINE CAN DIE OR BURN ANYTIME, AND THE ONLY SOLUTION IS TO REPLACE THE WHOLE ENGINE ACCORDING TO THEIR TECH ALERT. SEE BELOW: 2003 DISCOVERY SERIES II OIL PUMP FAILURES VEHICLES AFFECTED DISCOVERY SERIES II (LT) 3A[XXX] ? 3A[XXX] SITUATION OIL PUMP FAILURES ON 2003 DISCOVERY SERIES II VEHICLES MAY BE THE RESULT OF A MANUFACTURING ERROR. LOCATING DOWEL PINS MAY BE SLIGHTLY MISALIGNED PERMITTING ASSEMBLY OF THE OIL PUMP TO THE ENGINE BLOCK, BUT PLACING STRESS ON THE PUMP HOUSING WHICH CAN ULTIMATELY LEAD TO LEAKAGE OR FAILURE. RESOLUTION WHENEVER AN OIL PUMP FAILURE IS ENCOUNTERED ON VEHICLES WITHIN THE ABOVE VIN RANGE THE ONLY EFFECTIVE REPAIR CURRENTLY AVAILABLE IS REPLACEMENT OF THE COMPLETE ENGINE ASSEMBLY INCLUDING THE FRONT COVER/OIL PUMP MANUFACTURED TO THE LATEST TOLERANCES. USE THE FOLLOWING COMPONENTS TO AFFECT A REPAIR: ? LBB112301 4.6 ENGINE ASSEMBLY LEV ? LBB111461 4.6 ENGINE ASSEMBLY NON-LEV. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS

NHTSA ID

10585482

Incident

Apr 26, 2014

Mileage

96,700 mi

PURCHASED LAND ROVER DISCOVERY LESS THEN A MONTH AGO, SINCE THEN THE DASH BOARD LOOKS LIKE A CHRISTMAS TREE WITH THE NUMBER OF WARNING LIGHTS THAT ARE ON. WAS TOLD BY THE DEALER THAT THE ABS MODULATOR WAS OUT AND IT WOULD $3500.00 JUST FOR THE PART, EVEN THOUGH I RESEARCHED IT AND FOUND A REPAIR KIT FOR UNDER A $100. HOWEVER, THE MOST RECENT WARNING LIGHT IS THE OIL LIGHT AND THE CAR OVER HEATS IN A VERY SHORT AMOUNT OF TIME, AND KNOCKS AND BINGS. AFTER READING THE SEVERAL POST ON THIS WEB SIGHT, I TOO AM NOW PART OF A LONG LIST OF CUSTOMERS THAT HAVE MAJOR ISSUES WITH LAND ROVER. WHAT A MISTAKE IT WAS. *TR

NHTSA ID

10562976

Incident

Feb 4, 2014

Mileage

66,450 mi

TECHNICAL SERVICE REPORT FROM INDEPENDENT BRITISH LAND ROVER SPECIALISTS, BETHESDA MD: CUSTOMER STATES ENGINE MAKES A TAPPING NOISE, MOSTLY AT IDLE. DIAGNOSIS - VERIFIED NOISE. OIL LIGHT ON DUE TO LOW OIL PRESSURE, VEHICLE IN VIN RANGE FOR OIL PUMP FAILURE DUE TO MISALIGNED FRONT COVER FROM THE MANUFACTURER. OIL PUMP DAMAGE HAS OCCURRED, AND NEEDS TO BE CHANGED. CORRECT REPAIR IS ENGINE REPLACEMENT, AS DAMAGE TO BEARINGS CAN OCCUR. FAILURE ALSO CAUSED BY BLOCK ALIGNMENT POSITIONING. AT THIS POINT, NO NOTICEABLE ENGINE DAMAGE HAS OCCURRED, AND TO AVOID ENGINE REPLACEMENT CAN REPLACE OIL PUMP ASSEMBLY. OIL PUMP REPLACEMENT WOULD ONLY BE TEMPORARY X, AS PROBLEM WILL MOST LIKELY ARISE YEARS DOWN THE LINE. WILL NEED TO CHECK FRONT COVER FOR DAMAGE DURING REPAIR. ADDITIONALLY, LARGE OIL LEAK FROM INTAKE END SEALS DETECTED. RECOMMEND REPLACE OIL PUMP, ALIGN FRONT COVER, REPLACE INTAKE GASKET WHILE NOTING THERE MAY BE CHANCES OF ENGINE FAILURE, BEARING DAMAGE & DAMAGE TO FRONT COVER DETECTED DURING SERVICE. NOTES: TO AVOID ENGINE FAILURE, REPLACED OIL PUMP AT A COST OF $2,600 DUE TO MISALIGNED FRONT COVER FROM THE LAND ROVER MANUFACTURER. WILL LIKELY NEED TO REPLACE ENGINE IN THE FUTURE AT AN EXPECTED COST OF $10,000 DUE TO BLOCK ALIGNMENT POSITIONING MANUFACTURING ERRORS FROM LAND ROVER. CUSTOMER WILL HAVE TO PAY FOR THESE REPAIRS IN THEIR ENTIRETY, DESPITE THE FACT THAT THEY ARE CAUSED BY ORIGINAL MANUFACTURING DEFECTS, AS LAND ROVER HAS NOT ISSUED A RECALL. PLEASE ASSIST - THERE ARE THOUSANDS OF VERY SIMILAR COMPLAINTS POSTED ON MULTIPLE LAND ROVER FORUMS ONLINE.

NHTSA ID

10544783

Incident

Sep 17, 2013

Mileage

97,165 mi

TL* THE CONTACT OWNS A 2003 LAND ROVER DISCOVERY. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE AND OIL WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THEY ADVISED HIM THAT THERE WERE SLIGHT OIL LEAKS FOUND. THE CONTACT WAS ALSO ADVISED TO CONTINUE TO CHECK THE OIL LEVELS AND TO ADD OIL IN THE VEHICLE UNTIL REACHING HIS DESTINATION. THE CONTACT WAS LATER DRIVING 70 MPH WHEN THE VEHICLE EMITTED A LOUD BANGING NOISE. THE CONTACT MOVED TO THE SHOULDER WHERE HE OBSERVED A FOREIGN OBJECT DISCHARGE FROM THE EXHAUST PIPE AND CAUSE THE GRASS TO CATCH ON FIRE. THE POLICE AND FIRE DEPARTMENTS WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS LATER TOWED TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED THAT THE ENGINE FAILED DUE TO EXTREMELY LOW OIL PRESSURE AND A BLOWN PISTON. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 134,000.

NHTSA ID

10489103

Incident

Dec 12, 2012

Mileage

134,000 mi

TL* THE CONTACT OWNS A 2003 LAND ROVER DISCOVERY. WHILE PARKED, THE CONTACT NOTICED THAT THE ENGINE COOLANT WAS LOW AND THE VEHICLE WAS OVERHEATING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE RESERVOIR WAS LEAKING AND THE COOLANT HOSE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE CONTACT WAS THEN INFORMED THAT THE HEAD GASKET WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

NHTSA ID

10489024

Incident

Sep 17, 2012

Mileage

118,000 mi

I WAS DRIVING ON THE HIGHWAY WHEN MY ENGINE STARTED KNOCKING. I IMMEDIATELY PULLED OVER AND THEN MY OIL AND ENGINE LIGHTS CAME ON. I HAD IT TOWED TO THE DEALERSHIP AND WAS INFORMED MY OIL PUMP WASN'T ANY GOOD AND I NEEDED TO REPLACE MY ENGINE. AFTER DOING SOME INVESTIGATING I DISCOVERED THERE WAS A TECHNICAL ALERT SENT OUT TO DEALERSHIPS REGARDING 2003 LAND ROVER DISCOVERY II OIL PUMP FAILURES. I WAS NOT NOTIFIED OF THIS WHEN I PURCHASED MY VEHICLE YEARS AGO. LAND ROVER IS LIABLE FOR THIS AND I WOULD LIKE THEM TO REPLACE MY ENGINE. THEY SHOULD HAVE RECALLED THESE VEHICLES UPON DISCOVERING THE ISSUE. NOT ALL CUSTOMERS HAVE ACCESS TO TECHNICAL ALERTS AND IF I DIDN'T RESEARCH THIS MATTER I WOULD HAVE NOT HAD A CLUE THIS MATTER EXISTED. PLEASE HELP ME. I HAVE A 6 MONTH OLD SON AND NEED RELIABLE TRANSPORTATION. THANK YOU FOR YOUR TIME. *TT

NHTSA ID

10462863

Incident

Jun 18, 2012

Mileage

124,000 mi

EXTREMELY LOUD KNOCKING NOISE INSIDE THE ENGINE. *TR

NHTSA ID

10454611

Incident

Apr 9, 2012

Mileage

85,000 mi

OIL PUMP FAILURE. LAND ROVER ISSUED A TECHNICAL ADVISORY TO ALL OF THEIR DEALERS IN MARCH 2003 WARNING THAT DUE TO A MANUFACTURERS DEFECT IN THE ENGINE BLOCK DOWELS BEING MISDRILLED WHERE OIL PUMP HOUSING IS MOUNTED, THAT THE MISALIGNMENT CAUSES THE OIL PUMP HOUSING TO BE STRESSED EVENTUALLY CAUSING THE OIL PUMP TO FAIL. THE ONLY EFFECTIVE REPAIR IS TO REPLACE THE ENGINE. I PURCHASED THIS VEHICLE IN 2006 WHICH HAD COME OFF LEASE. I HAD IT SERVICED AT LAND ROVER DEALER IN SOUTHAMPTON NY AND THEY NEVER ADVISED ME THAT THIS WAS A MANUFACTURERS DEFECT AND THAT MY VEHICLE FELL WITHIN THE VIN RANGE REFERRED TO IN THE TECHNICAL ADVISORY. OTHER CONSUMERS HAVE THE SAME PROBLEM AND THERE ARE OVER 30,000 VEHICLES CURRENTLY ON THE ROAD WITH THIS SAME PROBLEM. WHY IS THERE NOT A RECALL AND WHY DOES LR NOT REPLACE THE DEFECTIVE ENGINES? *TR

NHTSA ID

10451043

Incident

Apr 25, 2009

Mileage

65,010 mi

CONDUCTED AN OIL CHANGE NOV 2010 ENGINE FAILED NOV 2010 ENGINE STILL HAS FULL OIL 2003 LAND ROVER DISCOVERY ENGINE FAILURE. DUE TO OIL PUMP FAILURE. THIS A KNOWN MANUFACTURE DEFECT THAT LAND ROVER WILL NOT REPAIR. *TR

NHTSA ID

10366783

Incident

Nov 18, 2010

Mileage

72,000 mi

I HAVE 2003 LAND ROVER, DISCOVERY CAR THAT REQUIRES CONSTANT REPLACEMENT OF THE NAVIGATION SYSTEM AND ITS RADIO/CD PLAYER. THIS IS MY FIFTH REPLACEMENT SINCE THE PURCHASE OF THE CAR. IN ADDITION TO THIS, THE ENGINE OIL CONSTANTLY LEAKS...TOOK IT IN FOR REPAIR NUMEROUS TIMES BUT THE PROBLEM CONTINUES. THE ENGINE LIGHT IS ALWAYS ON....TOOK IT IN A FEW TIMES AND THE DEALERSHIP REPAIR CENTER SAID IT WAS AN ELECTRICAL SENSOR PROBLEM. THE BRAKE AND ABS LIGHTS WOULD COME ON AND GO AWAY ON ITS OWN. SINCE MARCH 2010, THE BRAKE AND ABS LIGHTS DECIDED TO STAY LIT. WILL TAKE IT IN FOR VEHICLE INSPECTION AT THE DEALERSHIP. JUST YESTERDAY, ALL MY PASSENGER WINDOWS CAN NOT BE MOVED UP OR DOWN WITH THE WINDOW CONTROLLER. A SIMILAR PROBLEM WAS REPORTED TO THE MANUFACTURE NUMEROUS TIMES ON BOTH THE DRIVER AND THE PASSENGER WINDOWS. THEY WERE REPLACED EACH TIME IT WAS TAKEN IN. THIS IS A LEMON CAR AND I SHOULD HAVE HAD IT REPORTED BACK IN 2003 WHEN I FIRST PURCHASED THE VEHICLE. *TR

NHTSA ID

10326500

Incident

Apr 18, 2010

Mileage

102,000 mi

2003 DISCOVERY W/ 36K MILES. I WAS DRIVING OFF THE HIGHWAY AND HEARD A NOISE FROM THE ENGINE AND THAN OIL LIGHT CAME ON. PUT IN NEUTRAL AND PULLED OVER. HAD IT TOWED TO NEAREST GARAGE. OIL PUMP HAD "EXPLODED" AND RIPPED A WHOLE IN ENGINE "COVER." I SAW THE OIL PUMP GEAR IN PIECES. THERE IS A KNOWN TECHNICAL SERVICE BULLETIN FOR DISCO 2003 OIL PUMP FAILURE RESULTING IN NEW ENGINE REPLACEMENT AS ONLY PERMANENT FIX. CURRENTLY MY CAR IS AT LAND ROVER HINSDALE ILLINOIS. WILL NOT COVER B/C WARRANTY IS UP 10MOS AGO. HAVE CONTACTED CUSTOMER CARE AND THEY ARE IN THE PROCESS OF DECIDING TO EITHER GIVE ME NOTHING OR A "GOOD WILL GESTURE" W/ UNLEAR MONETARY HELP. HUGE STRESS ON A CAR THAT HAS FEW MILES AND A KNOWN PROBLEM THAT COULD HAVE BEEN FIXED FOR 500 DOLLARS OR SO AND NOW COULD BE UP TO 10,000. SOMETHING NEEDS TO BE DONE. THANKS JK *TR

NHTSA ID

10217915

Incident

Feb 9, 2008

Mileage

36,000 mi

TL*THE CONTACT OWNS A 2003 LAND ROVER DISCOVERY. THE CONTACT STATED THAT THE OIL WARNING INDICATOR LIGHT ILLUMINATED AND THERE WAS A CLUNKING NOISE COMING FROM THE ENGINE COMPARTMENT. THE MECHANIC STATED THAT THE OIL PUMP NEEDED TO BE REPLACED. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 55,000. UPDATED 01/28/08. *LJ UPDATED 02-25-08 *BF THE CONSUMER STATED AFTER RESEARCHING ONLINE, SHE DISCOVERED OIL PUMP FAILURE SEEMED TO BE A COMMON PROBLEM WITH THIS VEHICLE. UPDATED *JB

NHTSA ID

10214097

Incident

Jan 2, 2008

Mileage

96,715 mi

TL*THE CONTACT OWNS A 2003 LAND ROVER DISCOVERY. THE CONTACT DETECTED A FAINT BURNING SMELL WHILE DRIVING 70 MPH. THE VEHICLE WAS PULLED OVER AND OIL SUDDENLY BEGAN ERUPTING FROM THE REAR OF THE VEHICLE ONTO THE REAR WINDOW. THE DEALER DIAGNOSED THE FAILURE AS THE OIL PUMP. WHILE REPLACING THE OIL PUMP THE DEALER DISCOVERED THAT THE BEARING AND CRANK SHAFT WERE RUINED, AND THE ENGINE WAS DESTROYED. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGE WERE 50,300.*AK

NHTSA ID

10186697

Incident

Mar 12, 2007

Mileage

50,300 mi

DT*: THE CONTACT STATED THE STEERING WHEEL WAS MISALIGNED WHILE MAKING TURNS. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADJUSTED THE STEERING WHEEL, BUT THIS DID NOT REMEDY THE PROBLEM. THE VEHICLE WAS RETURNED TO THE DEALER AGAIN AND THE DRAG LINK WAS REPLACED, BUT THIS DID NOT REMEDY THE PROBLEM. DURING ANOTHER VISIT, THE DEALER NOTICED THE BRACKET ON THE FRAME WHERE THE FRONT TRACK BAR BOLTS WAS FRACTURED. ADDITIONALLY, THE DEALER DETERMINED THE FRACTURE WAS CAUSED BY A COLD WELD OR WAS NOT WELDED PROPERLY WHEN MANUFACTURED, HOWEVER THE VEHICLE WAS NOT REPAIRED BY THE SERVICE DEALER. THE VEHICLE WAS EVENTUALLY TAKEN TO AN INDEPENDENT FRAME SHOP FOR REPAIR. THE VEHICLE WAS PLACED ON A FRAME ALIGNMENT MACHINE; THE BRACKET WAS BENT BACK INTO PLACE AND WELDED. THE CONTACT IS CONCERNED BECAUSE THE VEHICLE WAS POSSIBLY MANUFACTURED WITH THIS DEFECTIVE FRAME WELD AND IT APPEARS TO HAVE BEEN WELDED MECHANICALLY. THE EXHAUST SYSTEM WAS MISALIGNED WHICH CAUSED THE TAIL PIPE TO RATTLE. THE WAS A FLUID LEAK COMING FROM THE TRANSFER BOX DUE TO A FAILED INPUT SHAFT SEAL. UPDATED 04/06/06. *JB

NHTSA ID

10151738

Incident

Feb 27, 2006

Mileage

47,000 mi