2020 Lincoln Nautilus Problems

I bought my 2020 Lincoln nautilus in February 2025 soon after I noticed a jerking from my lower gears,it has 80000 miles.i took it to the dealer I bought it from and they said the transmission is falling and will cost $10,188 to replace. They told me there was no recall and it wasn't covered under any warranty.

I bought my 2020 Lincoln nautilus in February 2025 soon after I noticed a jerking from my lower gears,it has 80000 miles.i took it to the dealer I bought it from and they said the transmission is falling and will cost $10,188 to replace. They told me there was no recall and it wasn't covered under any warranty.

My 2020 Lincoln Nautilus has an intermittent jerk during light acceleration with no diagnostic codes. This was confirmed when I had a professional mechanic drive it.

While driving low speed between 1-55 mph my car feels like it’s stuttering, jerking or about to shut down.

The contact owns a 2020 Lincoln Nautilus. The contact stated while driving downhill at 55 MPH with the cruise control activated, the vehicle failed to maintain the set speed and accelerated to 70-75 MPH. The vehicle was taken to the dealer, and the contact was informed that the vehicle had standard cruise control; not adaptive cruise control that could automatically apply the brakes while driving and maintain the set speed. The vehicle was then taken to Ellsworth Ford, Inc. (424 Industrial Rd, Ellsworth, WI 54011), where an unknown repair was performed; however, the failure persisted. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 24,000.

The contact owns a 2020 Lincoln Nautilus. The contact stated that while his wife was reversing in the rain, the back-up camera image was distorted. There were no warning lights illuminated. The contact called the local dealer and was informed that the failure might be due to a leak. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 40,009.

1. Vehicle Purchase I purchased a 2020 Lincoln Nautilus Reserve from Carvana on February 2, 2026. The vehicle was delivered to me on February 8, 2026. The vehicle was represented as inspected and safe to drive. Within 20 days of ownership, the vehicle experienced a serious mechanical failure involving the wheel assembly. 2. Major Safety Failure While driving, the wheel assembly failed due to damaged or missing wheel studs, causing the wheel to detach/loosen from the vehicle. This created an extreme safety hazard and risk of serious injury or death. The vehicle became unsafe to operate. Evidence includes: Photographs of the wheel hub and broken/missing studs Mechanical inspection documentation 3. Inspection Findings A professional inspection revealed mechanical issues with the vehicle, including: Fuel filter failure Engine air filter failure Evidence of wheel stud damage Potential improper installation or pre-existing mechanical defect These issues indicate the vehicle was not properly inspected prior to sale, despite Carvana advertising a comprehensive inspection. 4. Warranty Claim Denied A claim was submitted to Carvana's warranty department. The claim was denied under the explanation of “outside influence.” However: The vehicle had only been in my possession 20 days There was no accident or outside event The failure appears to be due to pre-existing mechanical issues 5. Resulting Harm Because of this defect and Carvana's refusal to repair the vehicle: I am currently without reliable transportation I am still responsible for the loan payments on a defective vehicle I have experienced significant emotional distress and physical symptoms My physician has prescribed Parafon Forte (muscle relaxer) due to stress-related muscle pain. I have also experienced: Sleep disruption Anxiety about driving Financial hardship due to being unable to use the vehicle 6. Attempts to Resolve I have attempted to resolve this matter with Carvana by: Filing a warranty claim Contacting BBB

Manual Park--release cable escaped its locking position, locking front wheel brakes ON. The locked brakes resulted in the car being dragged until we noticed the problem and exited the motor home to reinstate the cable into its locking position (to re-seat the metal bead in the pocket, locking it in the override position). Dragging the locked wheels creates a fire and traffic hazard with large plumes of blue smoke, potential towed-vehicle fish-tail out of control affecting nearby/adjacent traffic lanes. This issue was confirmed by my long-time mechanic (Deckard Pham) as a design deficiency that could fail due to road vibrations, that it was intended for limited use for emergency towing. This incident has occurred four times over the past year; twice, at low speed (so tire damage was minimal). Most recently, it was discovered too late to prevent tire damage -- [XXX], while traveling at 45 mph, severe flat spot (7" long, full width of both front tires), wore tread down to the steel belts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

3rd brake light not working , they have had this issue over several years such as recall on 2025 (25C39) burnt diode in the LED Driver Modules and may cause other lighting failures

MILEAGE: 487,615 27TAWD On [XXX] at [XXX]., the weather was wet from rain. I pushed the reverse button and the car accelerated quickly forward with engine revving. The car kept moving forward while the brake pedal was not responsive for at least 10 times as the car drove through my fence and damaged my neighbor’s garage. The car finally stopped when it hit the garage. Estimate for repairs on vehicle $1485.25. Estimate for damage to wooden fence $2560, neighbor's garage $8000. Engine code scan report on Oct 10, 2025 engine code U3003-16 Battery Voltage Below Threshold. EEC test at dealer on Oct 14, 2025: "no codes in any systems..." Vehicle damage noted. No indicated warning lamps INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

MILEAGE: 487,615 27TAWD On [XXX] at [XXX]., the weather was wet from rain. I pushed the reverse button and the car accelerated quickly forward with engine revving. The car kept moving forward while the brake pedal was not responsive for at least 10 times as the car drove through my fence and damaged my neighbor’s garage. The car finally stopped when it hit the garage. Estimate for repairs on vehicle $1485.25. Estimate for damage to wooden fence $2560, neighbor's garage $8000. Engine code scan report on Oct 10, 2025 engine code U3003-16 Battery Voltage Below Threshold. EEC test at dealer on Oct 14, 2025: "no codes in any systems..." Vehicle damage noted. No indicated warning lamps INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Manual Park--release cable escaped its locking position, locking front wheel brakes ON. The locked brakes resulted in the car being dragged until we noticed the problem and exited the motor home to reinstate the cable into its locking position (to re-seat the metal bead in the pocket, locking it in the override position). Dragging the locked wheels creates a fire and traffic hazard with large plumes of blue smoke, potential towed-vehicle fish-tail out of control affecting nearby/adjacent traffic lanes. This issue was confirmed by my long-time mechanic (Deckard Pham) as a design deficiency that could fail due to road vibrations, that it was intended for limited use for emergency towing. This incident has occurred four times over the past year; twice, at low speed (so tire damage was minimal). Most recently, it was discovered too late to prevent tire damage -- [XXX], while traveling at 45 mph, severe flat spot (7" long, full width of both front tires), wore tread down to the steel belts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

3rd brake light not working , they have had this issue over several years such as recall on 2025 (25C39) burnt diode in the LED Driver Modules and may cause other lighting failures

High mount brake light failure (2nd occurrence) November 2023 at 13,400 miles. Vehicle was repaired under warranty. This occurrence appears to be a repeated faulty part. Failure of high mount brake light creates rear collision potential in low visibility scenarios. The part (13613A High Mount Stop Lamp Assembly) appears to be a known faulty part by manufacturer or vehicle design. There are no warning lamps or messages to warn driver that failure has occurred. Problem could go unnoticed for an extended time.

We were driving down the highway, when a huge explosion sound occurred. We pulled off at the next safe spot to look what happened. The sunroof had exploded and a huge hole was in the sunroof. Glass shards were everywhere. Thankfully the interior cover was shut. We might not be alive today if it would have been open. Glass in my eyes, crash into other vehicles, use your imagination on how bad this could have turned out. Looking online reveals this is happening a lot. Someone will eventually get killed.

The contact owns a 2020 Lincoln Nautilus. The contact stated that after refueling the vehicle, the vehicle jerked upon starting and shifting to drive(D) intermittently. The contact stated that the failure initially occurred after refueling the vehicle, but the failure had become consistent and was occurring erratically. Additionally, the contact stated that while driving and accelerating between 35-40 MPH, the vehicle jerked. There was no warning light illuminated. The contact had added a fuel additive to the vehicle, and the failure was reduced temporarily. The contact stated that the failure had been recurring while driving. The dealer was contacted and advised that there would be a charge for a diagnostic test. The vehicle was not diagnosed or repaired. The contact related the failure to an unknown recall. The manufacturer was not notified of the failure. The failure mileage was approximately 85,000.

According to Lincoln, in their manual, the 2020 Lincoln Nautilus is designed such that it can be recreational towed behind a motorhome. My first experience towing this vehicle resulted in a violet "wobble" that shook a 43 foot motorhome when making a normal left hand turn. A second incident occurred when a dip in the road caused the wobble. In both incidents it was necessary to come to a complete stop and then proceed and the wobble disappeared. This problem has been discussed on RV Forums over the years but I'm not sure if it has been report. It was stated that in one incident the hitch of the RV snapped causing the towed vehicle to crash. I believe this is a potential danger on our roads.

We were driving down the highway, when a huge explosion sound occurred. We pulled off at the next safe spot to look what happened. The sunroof had exploded and a huge hole was in the sunroof. Glass shards were everywhere. Thankfully the interior cover was shut. We might not be alive today if it would have been open. Glass in my eyes, crash into other vehicles, use your imagination on how bad this could have turned out. Looking online reveals this is happening a lot. Someone will eventually get killed.