2005 Lincoln Navigator Owner Complaints

Fire inside of the motor, behind the engine computer. Upon researching recalls for Lincoln Navigators I found these other recalls online for possibly the same fire issue: "Ford has issued a recall for some of its 2021 Ford Expedition and Lincoln Navigator SUVs due to a potential engine fire risk. Over 65,000 2021-year model vehicles manufactured between December 2020 and April 2021 have been affected." "We've discovered a vehicle safety issue in some 2021 model-year Lincoln Navigator® vehicles built from July 30, 2020 to August 31, 2021. Some of these vehicles have experienced an under-hood fire, even while parked and off."

NHTSA ID

11584238

Incident

Apr 1, 2024

The drivers side door does not latch in the cold temperatures.

NHTSA ID

11448555

Incident

Jan 20, 2022

THERE WASNT A RECALL ON MY AIRBAGS PER MY VIN NUMBER HOWEVER JUST YESTERDAYMY VEHICLE WAS TOTALED DUE TO BRAKE FAILURE WHICH UPON IMPACT ONLY THE PASSENGER SIDE AIRBAG DEPLOYED WHILE THE DRIVER SIDE DIDNT. THERE WAS NO PASSENGER...

NHTSA ID

11190349

Incident

Mar 19, 2019

AS I WAS MERGING ON FREEWAY, I EXPERIENCED SUDDEN LOSS OF POWER AND IT COULD HAVE RESULTED IN FATALITIES SINCE IT WAS AT RUSH HOUR. AS I PULLED OVER, THE ENGINE WAS BUCKING BUT REGAINED POWER WITH SPORADIC BOUTS OF LOSS DURING MY DRIVE HOME. THERE WAS A MISFIRE ON CYLINDER ONE AND I REPLACED AND TESTED ALL RELATED COMPONENTS AND THEN FOUND OUT IT WAS THE CAM PHASER ISSUE THAT PLAGUES THE TRITON ENGINE. FROM READING OTHER COMMENTS FROM BOTH CONSUMER AND REPAIR SHOP OWNERS, IT IS SIMPLY A DEFECTIVE PRODUCT FROM WHO ELSE, THE FORD CORP. OF COURSE THEY BLAME THE OWNER FOR LACK OF MAINTENANCE.

NHTSA ID

11128843

Incident

Aug 17, 2018

Mileage

159,000 mi

WHILE TRAVELING 50 MPH IN THE LINCOLN, ANOTHER DRIVER ATTEMPTED TO MAKE AN ILLEGAL LEFT TURN IN FRONT OF THE NAVIGATOR RESULTING IN IMMEDIATE SEVERE COLLISION. THE FRONT IMPACT DESTROYED THE FRONT END OF THE LINCOLN, AND ALSO CAUSED IT TO SPIN 180 DEGRESS RESULTING IN A SECOND COLLISION WITH THE AT FAULT DRIVER. THE DRIVER AIRBAG DID NOT DEPLOY AND RESULTED IN SEVERE INJURY TO THE DRIVER.

NHTSA ID

11093345

Incident

Jul 21, 2017

Mileage

80,000 mi

THE SPARK PLUGS ARE RECALL, MY LINCOLN HAS ONLY 68,000 MILES I PURCHASED NEW IN JULY 2005, NOW AIR SUSPENSION HAS PROBLEMS TOO HOW CAN I RECEIVE A REFUND ON THE RECALLS AFTER I PAID $1,800.00 IN REPAIRS.

NHTSA ID

10966267

Incident

Jul 20, 2013

Mileage

57,000 mi

AIR SUSPENSION DOES NOT WORK IN COLD WEATHER BELOW 45 DEGREES YOU LOOSE CONTROL AND BOUNCES HAVE OWNED CAR SINCE 2006 LIVED IN FL AND HAD NO PROBLEMS MOVED TO NY AND HAVE PROBLEM EVERY TIME TEMP DROPS BELOW 45 HAVE SPENT THOUSANDS FOR REPAIRS THAT DIDNT WORK CKECKED INTERNET AND FOUND OUT IT A PROBLEM WITH 2003-2006 AND NOBODY CAN FIX INCLUDING FORD

NHTSA ID

10948653

Incident

Jan 20, 2017

Mileage

100,000 mi

2005 NAVIGATOR HAS ONLY 60,000 MILES, SPARK PLUGS DEFECTED, DEALER WANTS $1,500 TO $2,500 TO REPLACE THEM, WHICH IS DEFECT FROM MANUFACTURE. THESE SPARK PLUGS SHOULD BE REPLACED DUE TO DEFECTS FROM MANUFACTURE, AND THE RECALL ONLY WANTS TO PAY $1,040 FOR THE REPLACEMENT OF THE SPARK PLUGS, WHY SHOULD I PAY UP FRONT IF THEY ARE MANUFACTURE FAULT AND MY NAVIGATOR ONLY HAS 60,00 MILES NOW AND I PURCHASED IT NEW FROM THE DEALER IN 2005.

NHTSA ID

10853334

Incident

Dec 1, 2015

Mileage

60,000 mi

AIR SUSPENSION DOES NOT WORK / INFLATE WHEN CAR IS COLD, THERE SOMETIMES NO WARNING THAT THE SHOCKS ARE DOWN AND COULD MAKE DRIVING DANGEROUS . MAKING CAR UNCONTROLLABLE WHEN THE CAR WILL ROLL OVER BUMPS OR UNEVEN TERRAIN PLEASE ISSUE A RECALL FOR ALL NAVIGATORS SINCE 2003 OR OLDER WITH AIR SUSPESION SHOCK DOES NOT INFLATE WHEN STATIONARY / DOES NOT INFLATE WHEN IN MOTION TIRE RUBS ON FENDER WALL MAKING TURNS, THERE IS COMPLETELY NO SHOCK ABSORPTION WHEN CAR IS ON FREEWAY OR ON SURFACE WHICH MAKES CEHICLES VERY UNSTABLE AND COULD CAUSE MAJOR ACCIDENTS IF DRIVEN BY INEXPERIENCED OR EXPERIENCED DRIVERS

NHTSA ID

10816278

Incident

Dec 26, 2015

Mileage

75,000 mi

ENGINE STARTS TO KNOCK AN SHAKE VERY LOUDLY WHILE COMING TO A COMPLETE STOP FROM SIMPLY DRIVING 45MPH OR IT COMPLETELY LLOSES ALL POWER AS I'M DRIVING AN A LOUD POPPIG EXPLOSIONS COMING FROM THE EXHUAST AN THEY ARE LOUD ENOUGH WERE PEOPLE HEHHAVE PULLED UP NEXT TO ME TO LET ME KNOW AN AFRAID THE CAR MAY BLOW UP. AIR SUSPENSION DOSE NOT COME ON WHEN IT'S COLD AN DRIVES VERY POORLY AN MISLEADING TO OTHER DRIVERS AN LAW ENFORCEMENT SINCE I'VE BEEN PULLED OVER FOR POSSIBLE DUI BECAUSE THE CAR IS ALL OVER THE PLACE AN JUMPY. THE RADIO CUTS IN AN OUT AS I DRIVE, THE CRUISE CONTROL DOESN'T WORK. I'VE TAKEN IT TO 3 DIFFERENT MECHANICS THEY ALL SAY THE SAME THING TAKE IT TO THE DEALER BECAUSE THEY CAN'T SEEM TO FIGURE IT OUT. SO I TOOK IT TO GALPIN LINCOLN IN VAN NUYS, CA ON ROSCOE BLVD AN SEPULVEDA AN THEY JUST FOUND ONE FUEL INJECTOR NEEDING REPLACED AN WANTED ME TO $2,500 FOR LABOR ALONE TO COMPLETELY OPEN UP MY ENGINE AN SEE IF IT COULD POSSIBLY BE THE TIMING CHAIN AN REALINE THE CAMSHAFTS BUT THEY ARE NOT CERTAIN THAT'S ACTUALLY THE PROBLEM WITH MY NAVIGATOR BECAUSE THEY CAN COMPLETELY DO ALL THAT AN COME UP TO BE FINE AN BE SOMETHING ELSE BUT UNLESS I PAY $2,500 FOR LABOR TO JUST SEE IF IT IS AN HAVE THE CHANCE IT COULD NOT BE I STILL LOSE THOSE $2,500 BECAUSE IT'S A NON REFUNDABLE. WHERE AM I GOING TO COME UP WITH THAT KIND OF MONEY NOT ALONE WHY AM I HAVING TO PAY THAT FIRST TO SEE IF IT'S A MAYBE THE REASON OF ALL MY CAR PROBLEMS. HONESTLY THAT IS RIDICULOUS AN NOT GOING TO PAY THAT KIND OF MONEY ON A MAYBE ANSWER NOT A 100 PERCENT WE ARE SURE THAT'S THE PROBLEM. SOMETHING NEEDS TO GIVE AN HEAVEN FORBID MY CAR DOES BLOW UP WITH MY SON'S IN THE CAR DRIVING IT JUST BECAUSE I NEEDED TO PAY THAT AMOUNT ON A MAYBE ANSWER IS UN CALLED FOR.

NHTSA ID

10808625

Incident

Nov 16, 2015

HAS HAPPENED A FEW TIMES RECENTLY TWICE IN ONE WEEK.DRIVING AND MY TRUCK SHUTS OFF,STEERING LOCKS UP AND NO POWER.THE WARNING INDICATOR TELLS ME. "CHECK THROTTLE COMPUTER SYSTEM,I SHUT OFF TRUCK AND AFTER A COUPLE TIMES IT STARTS BACK UP... *TR

NHTSA ID

10693190

Incident

Mar 4, 2015

Mileage

151,000 mi

2005 LINCOLN NAVIGATOR CURRENTLY WITH 97000 MILES. MAJOR FRAME RUST IN FRONT END,RADIATOR SUPPORTS ARE ALMOST COMPLETELY ROTTED THROUGH. HAVE READ NUMEROUS COMPLAINTS ABOUT RADIATORS DROPPING DUE TO FRAME ROTTING. MAIN SECTION OF TRUCK FRAME HAS A HOLE IN IT DUE TO RUST AS WELL. FRAME INTEGRITY IS COMPROMISED AND COULD CAUSE MAJOR SAFETY ISSUES. *TR

NHTSA ID

10652218

Incident

May 16, 2013

Mileage

75,000 mi

I STARTED MY LINCOLN NAVIGATOR PUT THE CAR IN DRIVE AS I PROCEEDED DRIVE 1/4 WAY,HAD TO STOP,BUT COULD NOT PUT THE VEHICLE IN ANY POSITION AFTER THAT,IN THE MIDDLE OF THE ROAD,COULD NOT MOVE THE TRUCK FROM THAT POSITION. *TR

NHTSA ID

10586708

Incident

May 1, 2013

Mileage

1 mi

THE AIR SUSPENSION SYSTEM FAILS TO WORK WHEN COLD. ITS VERY BOUNCY AND HARD TO DRIVE SAFELY. I HAVE REPLACED THE HEIGHT SENSORS. I'VE SPENT OVER $5000 ON REPAIRS IN THE PAST 6 MONTHS. IT STILL ISN'T FIXED. I'VE SEEN NUMEROUS COMPLAINTS ON THE INTERNET ABOUT THE SAME SUSPENSION PROBLEMS. THIS IS A FAULTY DESIGN. THIS NEEDS TO BE RECALLED. *TR

NHTSA ID

10569398

Incident

Oct 25, 2013

Mileage

65,000 mi

OUR 05 LINCOLN NAVIGATOR WE JUST PURCHASED ABOUT 7-8 MONTHS AGO. THE RETRACTABLE RUNNING BOARDS BROKE ON THE DRIVER SIDE REAR IN THE SWIVELING BUSHING AREA. THE STRUCTURE CRACKED AND WOULD NOT HOLD IT UP. I GOT TOLD THERE ARE NO PARTS AVAILABLE FOR THIS AND ITS $3,000.00 FOR A NEW RUNNING BOARD. I AM SUPER UPSET, ESPECIALLY BECAUSE I PURCHASED THIS VEHICLE FOR MY WIFE'S DAYCARE, AND WHILE ONE OF THE CHILDREN STEPPED UP ON IT, IT BROKE; THEREFORE THEY FELL ON THE GROUND TWISTING THEIR ANKLE. I CAN'T AFFORD TO SPEND $3K ON A NEW RUNNING BOARD. I THINK ITS INSANE THAT THERE IS NOT REPLACEMENT PARTS FOR THIS. I CANT GET THE KIDS IN AND OUT ON THE DRIVER SIDE NOW. I AM SO UPSET. WHY HASN'T SOMEONE FIXED THIS. SOUNDS LIKE IT HAPPENS TO ALL OF THEM IN THIS YEAR RANGE. NO ONE CAN AFFORD TO FIX THEM. *TR

NHTSA ID

10562758

Incident

Jan 28, 2014

Mileage

106,000 mi

AIR SUSPENSION FAILURE. *TR

NHTSA ID

10554161

Incident

Nov 24, 2013

Mileage

103,459 mi

I HAVE NO SUSPENSION SYSTEM OR MONEY TO FIX. SEEMS LIKE WHEN ONE THING BREAK ON THE LINCOLN NAVIGATOR EVERYTHING QUIT WORKING. WINDOW GRIND, NO SUSPENSION,SHIFT BREAKS UP. ENGINES MAKE WEIRD GEARING SOUND. DRINKS GAS WITH NO END TO IT. AIR CONDITIONER FAILURE, MULTIPLE CD PLAYER QUIT, DVD PLAYER QUIT. *TR

NHTSA ID

10506089

Incident

Apr 8, 2013

Mileage

135,000 mi

TL* THE CONTACT OWNS A 2005 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE SITTING IDLE IN TRAFFIC, THE THROTTLE WARNING LIGHT ILLUMINATED AS THE VEHICLE STALLED SIMULTANEOUSLY. THE CONTACT WAS ABLE TO RESTART THE ENGINE. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 55,875.

NHTSA ID

10489175

Incident

Dec 18, 2012

Mileage

55,875 mi

TL* THE CONTACT OWNS A 2005 LINCOLN NAVIGATOR EQUIPPED WITH MICHELIN CROSS TERRAIN TIRES, LINE SIZE 255/70/R18. THE CONTACT STATED THAT THE FRONT DRIVER AND REAR PASSENGER SIDE TIRES CONTINUOUSLY FLATTEN. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSED THE FAILURE AND STATED THAT THE TIRES HAD BEEN DISCONTINUE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE TIRES WERE NOT INCLUDED ON ANY RECALLS. THE TIRES WERE NOT REPLACED. THE DOT NUMBER WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 111,000.

NHTSA ID

10472826

Incident

May 5, 2012

TL* THE CONTACT OWNS A 2005 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED IMMEDIATELY AFTER THE CHECK ENGINE AND ELECTRONIC THROTTLE CONTROL WARNING LAMPS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 82,000.

NHTSA ID

10444286

Incident

Jan 5, 2012

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2005 LINCOLN NAVIGATOR. THE CONTACT STATED BOTH RUNNING BOARDS ON THE LEFT AND RIGHT SIDE OF THE VEHICLE WERE COVERED WITH RUST AND CORRODED. THE RUNNING BOARDS RETRACT IN AND OUT IN ORDER TO CLIMB INTO THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO REMOVED THE RUNNING BOARDS BUT DID NOT REPAIR THE VEHICLE DUE TO THE REPAIR COST WHICH WAS OVER $2000. THE MANUFACTURER WAS CONTACTED AND STATED THE REASON FOR THE RUST AND CORROSION WAS DUE TO THE CONTACT LIVING IN A SALT STATE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 72,000. THE CONSUMER STATED IT LOOKED AS IF THE METAL USED WAS A MILD STEEL PLATE ON 1/8 INCH THICK AND THE RUNNING BOARDS HAVE RUSTED AWAY COMPLETELY. THE METAL USED TO MAKE THE RUNNING BOARDS WAS NOT SUFFICIENTLY STRONG FOR NORMAL USE NOR HAD IT BEEN PROTECTED FROM CORROSION. UPDATED 09/27/11 UPDATED 9/19/11 *CN UPDATED 2/23/12 *CN

NHTSA ID

10422367

Incident

Jul 24, 2011

Mileage

72,000 mi

WHILE DRIVING MY 2005 LINCOLN NAVIGATOR THE VEHICLE STOPPED IN THE MIDDLE OF TRAFFIC WITHOUT ANY WARNING. EVENTUALLY RESTARTED THE VEHICLE AND TOOK IT TO THE DEALER. THE PROBLEM WAS A FAULTY THROTTLE BODY ASSEMBLY. WE HAD TO GET THE THROTTLE BODY ASSEMBLY REPLACED. THE OLD PART IS NOT AVAILABLE. *LN

NHTSA ID

10375231

Incident

Dec 29, 2010

Mileage

89,573 mi

VEHICLE HAS PROBLEMS WITH AIR RIDE SUSPENSION. THIS OCCURS ABOUT EVERY TWO WEEKS, THIS CAUSES THE VEHICLE TO OPERATE ERRATICALLY. THE DEALER TRIED TO FIX THE PROBLEM BUT IT STILL CONTINUES TO HAVE ISSUES. *TR

NHTSA ID

10364081

Incident

Oct 3, 2010

Mileage

72,000 mi

AIR BAGS ARE VERY LOUD AND THEY RUN OFTEN AIR CONDITIONING IN REAR MAKES A POPPING NOISE AIR CONDITIONING IN BLOWS THROUGH FLOOR VENTS WHEN I ACCELERATE I HAVEN'T BEEN ABLE TO FIX IT BECAUSE IT IS TOO EXPENSIVE. *TR

NHTSA ID

10361607

Incident

Sep 1, 2010

Mileage

120,000 mi

TL*THE CONTACT OWNS 2005 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THEY HAD TO REPLACE THE ENGINE SINCE THE HEAD GASKET WAS DEFECTIVE AND THERE WAS A PISTON THAT CAUSED METAL SHAVINGS TO ENTER THE ENGINE. THE VEHICLE WAS DIAGNOSED BY THE DEALER SEVERAL TIMES SINCE A KNOCKING SOUND WAS IN THE ENGINE. THE DEALER WAS UNABLE TO FIND THE SOURCE OF THE KNOCKING SOUNDS IN THE ENGINE. SINCE THE VEHICLE WAS 5000 MILES OVER THE WARRANTY THE ENGINE FAILED. THE DEALER INSPECTED THE ENGINE AND STATED THAT IN NEEDED TO BE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 55000. UPDATED 11/05/10. *LJ

NHTSA ID

10348137

Incident

Jul 21, 2010

Mileage

55,000 mi