RoadVitals

2024 Lion Lionc Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Mar 12, 2025
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2024 Lion Lionc, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Electrical2100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

2
reports

From owner reports, verbatim

I was experiencing low voltage inside the School bus , erratic lighting and 2 way radio was cycling on and off due to LOW VOLTAGE. I noticed the smell of smoke inside the school bus, upon further investigation, I opened the hood and noticed smoke rising from the positive electrical "pass Through" 12-volt connector on the driver side. apparently, the connector insulator failed and was shorting to the body and was getting extremely hot and could cause a fire. the connector on the inside of the bus, under the dash, was blackened from the heat. i have a photo of it. I took the bus out of service and notified LION Bus about the problem, they ordered parts and sent a technician out to repair it. I have a video of the smoking connector. This issue could cause a School Bus fire. I will try to send the photos and video. If I cannot send them please reach out with a good e-mail address to send them.

NHTSA ID 11647804 · filed Mar 12, 2025

Front heater fan smelling of smoke

NHTSA ID 11642408 · filed Feb 13, 2025

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .