1998 Mazda B-Series Truck Problems

www.downeynissan.com Titan XD king cab Vin:[XXX]. Mazdaspeed 3 turbo Vin:[XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I WOULD LIKE TO REPORT A QUALITY ISSUES ABOUT GOODYEAR'S TRACKER 2 TIRES. IN EARLY SUMMER OF 2007, I HAD 4 TIRES OF THIS BRAND INSTALLED AT WAL-MART. THESE TIRES WERE SOLD AT WAL-MART WITH CLAIMS FOR 50,000 MILES WARRANTY. BY NOW, IT HAS BEEN NOT MORE THAN 3 YEARS AND GOT CLOSE TO 40,000 MILES. ON LAST SATURDAY MORNING WHEN I WAS DRIVING ON SOUTH BOUND I-77, ABOUT 1 MILE A WAY FROM EXIT 58 IN VIRGINIA, THE TIRE ON THE BEAR DRIVER'S SIDE BLEW UP. I HAD TO CALL POLICE FOR ROAD ASSISTANCE IN ORDER TO INSTALL THE SPARE TIRE. I WAS LUCKY THAT I JUST ROTATED THE TIRES ON FRIDAY NIGHT BEFORE THIS TRIP. OTHERWISE, THIS TIRE WOULD HAVE BEEN ON THE DRIVER'S SIDE IN FRONT. WHEN I TOOK MY PICKUP TO WAL-MART TO HAVE THE TIRES CHECKED, THEY THEN FOUND SEVERE BUBBLES AND CRACKS ON OTHER 2 TIRES, RIGHT FRONT PASSENGER SIDE AND REAR. ONLY THE TIRE ON THE FRONT DRIVER'S SIDE STILL APPEARED TO BE LESS DEFECTIVE, AND BUBBLES WERE FOUND ALTHOUGH NOT AS APPARENT. WE USED TO HAVE TIRES THAT CAN RUN FOR 70,000 OR EVEN 80,000 WILES WITH A 50,000 MILE WARRANTY. NOW, THE QUALITY ISSUES SEEM INVADE INTO EVERY CORNER OF OUR DAILY LIFE. WITH THE INCIDENT I JUST HAD, I WOULD HAVE TO SAY THAT I LEARNED A LOT. I JUST HOPE THE GOVERNMENT TIGHTENS UP OUR RULES FOR THESE COMPANIES THAT PROFIT AT THE EXPENSE OF CUSTOMERS. *TR

Report s as stolen from Santa Clarita ca newhall. Reporting to the chp.gov [XXX] ca tip line [XXX] Western general insurance, clabasas www.downeynissan.com Management LLC INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 1998 MAZDA B4000. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 99V062002 (VEHICLE SPEED CONTROL) AND CONTACTED THE DEALER TO SECURE AN APPOINTMENT FOR RECALL REPAIRS HOWEVER, THE PARTS NEEDED TO COMPLETE THE RECALL REPAIRS HAD NOT YET BECOME AVAILABLE. THE CONTACT STATED THAT NEITHER THE MANUFACTURER NOR THE DEALER INFORMED THE CONTACT WHEN OR IF THE PARTS HAD BECOME AVAILABLE. THE CONTACT CALLED THE MANUFACTURER AND THE MANUFACTURER STATED THAT THE RECALL WAS CLOSED. THE VEHICLE WAS NEVER SERVICED UNDER THE RECALL. THE MILEAGE WAS 181,823. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

I HAVE HAD A HEAD GASKET REPLACE ON THIS 1998 MAZDA B4000 WITHIN 61,000 MILES. THE FIRST HEAD GASKET REPLACEMENT WAS 1-21-2008. NOW THE SAME THING SEEMS TO BE HAPPENING AT 78,100 MILES ARE THERE ANY ISSUES WITH THIS MODEL? I ONLY DRIVE THE TRUCK TO WORK AND BACK WHICH IS ONLY ABOUT 5 MILES FROM MY HOME. ALSO THE FRONT END SUSPENSION MAKES A LOUD SQUEAKING/POPPING NOISE WHEN YOU TURN THE STEERING WHEEL OR HIT A ROUGH PLACE IN PAVEMENT. THE "KEY IN THE IGNITION" BUZZER KEEPS DINGING AFTER YOU TAKE THE KEY OUT OF THE IGNITION. *TR

THROTTLE STICKS WIDE OPEN ON MY 1998 MAZDA B2500 TRUCK. ONLY RECOURSE IS TO TURN ENGINE OFF TO SLOW DOWN. HAVE HAD IT IN TO MAZDA SHOP TWICE FOR THIS PROBLEM. FIRST TIME UNDER WARRANTY, COULD NOT FIND THE PROBLEM SECOND TIME, MAZDA SAYS NOT COVERED UNDER WARRANTY, EVEN THOUGH THEY HAD A TSB FOR THIS PROBLEM. I DON'T WANT TO BE A FATAL STATISTIC, BECAUSE OF YET ANOTHER VEHICLE MANUFACTURERS FAILURE TO ACT. *TR

Mazdaspeed 3 turbo Vin:[XXX] ************************* Fuel pump EfI 400hp @ idel Turbo propultion not installed Cricket wireless broadband internet Connection.....? Swiage leakage: [XXX] [XXX] West covina sheriff dept. West covina ca INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL*THE CONTACT OWNS A 1998 MAZDA B2500. WHILE DRIVING 50 MPH AND ATTEMPTING TO DECELERATE, THE CONTACT MUST PLACE THE VEHICLE INTO NEUTRAL AND THEN TURN OFF THE IGNITION. THE VEHICLE'S ENGINE OVERPOWERS THE BRAKES. THE CONTACT FEELS THAT THIS IS A SAFETY ISSUE BECAUSE THE VEHICLE SHOULD BE STOPPED BY APPLYING THE BRAKES. IN ADDITION, THE THROTTLE STICKS AND REMAINS OPEN. THE BRAKE FAILURE HAS BEEN OCCURRING FOR THE LAST EIGHT YEARS. THE VEHICLE HAS BEEN TAKEN TO THE REPAIR SHOP THREE TIMES REGARDING THE FAILURE, BUT NO FAILURE WAS IDENTIFIED. THE FAILURE MILEAGE WAS 35,000.

I HAVE HAD A HEAD GASKET REPLACE ON THIS 1998 MAZDA B4000 WITHIN 61,000 MILES. THE FIRST HEAD GASKET REPLACEMENT WAS 1-21-2008. NOW THE SAME THING SEEMS TO BE HAPPENING AT 78,100 MILES ARE THERE ANY ISSUES WITH THIS MODEL? I ONLY DRIVE THE TRUCK TO WORK AND BACK WHICH IS ONLY ABOUT 5 MILES FROM MY HOME. ALSO THE FRONT END SUSPENSION MAKES A LOUD SQUEAKING/POPPING NOISE WHEN YOU TURN THE STEERING WHEEL OR HIT A ROUGH PLACE IN PAVEMENT. THE "KEY IN THE IGNITION" BUZZER KEEPS DINGING AFTER YOU TAKE THE KEY OUT OF THE IGNITION. *TR

I OWN A 1998 MAZDA PICKUP, 2500 MODEL. IT HAS ALWAYS BEEN A FLORIDA VEHICLE. I DID A FRONT END SUSPENSION CHECK, AND FOUND ALL 4 BALL JOINTS WITH DEEP RUST, NO RUBBER SEALS LEFT OTHER THAN BRITTLE AND CRACKED REMAINS OF THE RUBBER BOOT AROUND THE JOINTS. THE RUBBER BUSHINGS ON THE FRONT STABILIZER ASSEMBLY WERE ALSO EITHER TOTALLY DISINTEGRATED OR MISSING. THE MECHANIC TOLD ME THE CONDITION HAD BEEN PRESENT FOR SOME TIME, THE BALL JOINTS WERE BADLY WORN, AND CATASTROPHIC FAILURE WOULD HAVE OCCURRED WITHIN MONTHS. THIS VEHICLE WAS BUILT BY FORD. I BELIEVE THE QUALITY AND DURABILITY OF THE RUBBER BOOTS PROTECTING THESE VITAL PARTS WAS DEFECTIVE. ACCORDING TO SOME OTHERS I HAVE DISCUSSED THIS WITH, ROTTED BOOTS ARE NOT UNCOMMON. IN THE PAST I HAVE KEPT VEHICLES FOR OVER 20 YEARS WITHOUT ANY PROBLEM WITH BALL JOINT AND STEERING KNUCKLES GREASE COVERS. REQUEST THIS BE INVESTIGATED AS A MANUFACTURES DEFECT. THANKS IN VIEW OF THE POTENTIAL FOR ACCIDENTS, THIS NEEDS FOLLOWUP. *TR

Report s as stolen from Santa Clarita ca newhall. Reporting to the chp.gov [XXX] ca tip line [XXX] Western general insurance, clabasas www.downeynissan.com Management LLC INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I NOTICED FROM TSB#97-24-14, NOV 1997 THAT THE WIRE HARNESS TERMINAL REPAIR KIT WAS A RECALL PROBLEM FOR THE 1998 FORD RANGER PICK-UP, MY MAZDA B3000 HAD A BURNED OUT PAD SWITCH AND MODULAR FOR THE AIRBAG. THE 1998 MAZDA B3000 AND FORD RANGER ARE EXACTLY THE SAME TRUCK, HOW COME THE 98 MAZDA DOES NOT HAVE A RECALL. *AK

THE INTERIOR LIGHT STAYS ON AS A RESULT OF READING THE DOOR AJAR. THIS WILL BE THE THIRD TIME THAT I'VE HAD TO FIX THIS.*JB

THE INTERIOR LIGHT FLICKERED ON AND OFF INTERMITTENTLY.*JB INTERIOR LIGHTS ALSO STAY ILLUMINATED WHEN THE DOORS ARE CLOSED.*MR

WHILE THE DRIVER'S FOOT WAS PRESSING THE CLUTCH, THE PLASTIC COVER RIPPED OFF AND CAUSED THE DRIVER'S FOOT TO RELEASE THE CLUTCH. AS A RESULT THE VEHICLE REAR ENDED ANOTHER VEHICLE. BOTH THE MANUFACTURER AND THE DEALERSHIP WERE CONTACTED. *NLM

HAD PUSHED CLUTCH ON WAY IN AND THEN RELEASED IT. TO ENGAGE, CLUTCH PEDAL WOULD COME ALMOST ALL WAY BACK BEFORE STARTING OR MOVING VEHICLE. HAD TAKEN VEHICLE TO 4 DIFFERENT DEALERSHIPS. AT TWO DEALERSHIPS, MECHANICS INDICATED NO PROBLEM. AT OTHER 2, MECHANICS INDICATED CLUTCH WAS BAD, AND WOULD NEED TO REPLACE OR REPAIR ENTIRE SYSTEM.*AK

WITH 80K ON THE TRUCK THE LEAF SPRING MOUNTS HAD BECOME OXIDIZED TO THE POINT OF FAILURE. WHEN THIS HAPPENED MY SPRING CAME THROUGH MY BED. THERE IS NO BODY RUST, OR BED RUST. AFTER READING FORUMS I AM NOT THE ONLY ONE WITH THE PROBLEM. WITH 90K ON THE TRUCK THE FRAME RUST THROUGH AND CRACKED. THERE WAS NEVER A LARGE PROBLEM WITH FRAME RUST BEFORE 98 AS I HAVE TWO BRONCO IT'S. FORD MUST HAVE CHANGED STEEL BECAUSE THERE ARE PLENTY OF GUYS PUZZLED WITH THE SAME PROBLEM. THANK YOU FOR YOUR TIME STANLEY SHAFFER *TR

A TIRE SEPARATION/BLISTING FROM INSIDE OF THE SIDEWALL ON A 1998 MAZDA B-SERIES TRUCK, AFTERMARKET EQUIPMENT. FIRESTONE NOTIFIED. *AK THE FAILED TIRE WAS FIRESTONE WILDERNESS HT. THE TIRE WAS SLOWLY GOING FLAT AND SHOWED BUBBLES FROM INSIDE WALL WHEN THE CUSTOMER PULLED OVER AND INSPECTED THE VEHICLE. THE RIGHT SIDE DOOR STEP MOULDING CRACKED. *YH

Report s as stolen from Santa Clarita ca newhall. Reporting to the chp.gov [XXX] ca tip line [XXX] Western general insurance, clabasas www.downeynissan.com Management LLC INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I NOTICED FROM TSB#97-24-14, NOV 1997 THAT THE WIRE HARNESS TERMINAL REPAIR KIT WAS A RECALL PROBLEM FOR THE 1998 FORD RANGER PICK-UP, MY MAZDA B3000 HAD A BURNED OUT PAD SWITCH AND MODULAR FOR THE AIRBAG. THE 1998 MAZDA B3000 AND FORD RANGER ARE EXACTLY THE SAME TRUCK, HOW COME THE 98 MAZDA DOES NOT HAVE A RECALL. *AK

FOUR WHEEL DRIVE SYSTEM ENGAGED ON IT'S OWN, CAUSING SEVERE LEFT TURNS AS FRONT WHEEL LOCKS UP. HAS HAPPENED THREE TIMES, EVEN THOU FIXED TWICE. THERE IS NO LOCKING HUB CONVERSION AVAILABLE FOR THIS MODEL OR THE FORD RANGER IT'S CLONE. WILL NOT DRIVE THIS ON SNOW OR ICE COVERED ROADS. FOUR WHEEL DRIVE SYSTEM CONSISTENTLY DOES NOT ENGAGE WHEN YOU WANT IT TO. TRUCK BUILT BY FORD. *TR

TRUCK SHUDDERS 4 TO 5 TIMES COMING TO A COMPLETE STOP AND TAKING OFF FROM A COMPLETE STOP ALL THE TIME AND OCCASIONALLY ALSO SHUDDERS IN 2ND GEAR[TRUCK IS AN AUTOMATIC]. THIS HAS OCCURRED SINCE THE 1ST DAY I PICKED UP THE TRUCK. IT HAS BEEN BACK TO 2 DIFFERENT MAZDA DEALERS AFTER I HAD THE TRANSMISSION CHECKED BY AN INDEPENDENT SHOP WHICH GAVE THE TRUCK A CLEAN BILL OF HEALTH AND THEN TOOK TO INDEPENDENT SHOP FOR A DIAGNOSTIC CHECK WHERE THEY FOUND THE PROBLEM TO BE THE DRIVESHAFT. WITH THIS INFO I WENT BACK TO MAZDA WHERE THEY REGREASED AND REPACKED THE DRIVESHAFT. THE PROBLEM CONTINUES. I CALLED THE REPAIR SHOP AFTER I PICKED UP THE TRUCK AND TOLD THEM THE TRUCK WAS STILL DOING THE SAME ONLY NOW WORSE. I WAS TOLD THAT THEY CALLED IN THE DSM FOR THE AREA MAZDA DEALERS AND HE STATED THIS WAS A "CHARACTERISTIC" OF ALL THE B4000 SERIES AND NOTHING MORE WOULD BE DONE. I HAVE THE EXTENDED WARRANTY OF 6YR/100,000 AND IF I TAKE THE TRUCK FOR REPAIR BY OTHER THAN MAZDA THEN I WILL IFY THIS WARRANTY. I DON'T KNOW WHAT ELSE TO DO. THE PROBLEM IS VERY ANNOYING ESPECIALLY IN ANY STOP AND GO TRAFFIC[CITY DRIVING INPARTICULAR] ALL I WANT TO DO IS HAVE THE TRUCK FIXED. ANY INFO OR HELP IN THIS MATTER WOULD BE GREATLY APPRECIATED.

I HAVE HAD A HEAD GASKET REPLACE ON THIS 1998 MAZDA B4000 WITHIN 61,000 MILES. THE FIRST HEAD GASKET REPLACEMENT WAS 1-21-2008. NOW THE SAME THING SEEMS TO BE HAPPENING AT 78,100 MILES ARE THERE ANY ISSUES WITH THIS MODEL? I ONLY DRIVE THE TRUCK TO WORK AND BACK WHICH IS ONLY ABOUT 5 MILES FROM MY HOME. ALSO THE FRONT END SUSPENSION MAKES A LOUD SQUEAKING/POPPING NOISE WHEN YOU TURN THE STEERING WHEEL OR HIT A ROUGH PLACE IN PAVEMENT. THE "KEY IN THE IGNITION" BUZZER KEEPS DINGING AFTER YOU TAKE THE KEY OUT OF THE IGNITION. *TR

INTERIOR LIGHT STAY ON AFTER IT RAINS OR MOISTURE IS IN THE AIR. HAD DOOR SWITCH REPLACED, WORK FOR ABOUT A YEAR AND THEN RECUR AGAIN. THE INTERIOR LIGHT CAN ONLY BE SHUT OFF BY TAKING OUT THE FUSE. THE INTERIOR LIGHT GET SHOOT THAT IT CAN BURN YOUR HAND IF TOUCHED. THIS SEEMS TO BE A ONGOING PROBLEM WITH1998 MAZDA B2500 TRK. AND FOR RANDERS. IT COULD POSSIBLY CAUSE A INTERIOR FIRE. *TR

Mazdaspeed 3 turbo Vin:[XXX] ************************* Fuel pump EfI 400hp @ idel Turbo propultion not installed Cricket wireless broadband internet Connection.....? Swiage leakage: [XXX] [XXX] West covina sheriff dept. West covina ca INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

AFTER FUELING THERE IS A STRONG FUEL SMELL INSIDE VEHICLE. *AK

PASSENGER SIDE REAR-DOOR QUARTER-GLASS WAS STRUCK BY A STONE WHICH TOTALLY SHATTERED INTO SMALL PIECES (SPLINTER TOO) THE QUARTER-GLASS. THIS INCIDENT BASED ON THE SIZE OF THE MARK LEFT, ONLY LEFT A SMALL (PENCIL HEAD SIZE) CHIP ON A NORMAL WINSHIELD. HOW CAN MAZDA/FORD PRODUCE B400 AND RANGERS WIGH DIRRERENT STANDARD GLASS THAN NHTSA APPROVED.

Mazdaspeed 3 turbo Vin:[XXX] ************************* Fuel pump EfI 400hp @ idel Turbo propultion not installed Cricket wireless broadband internet Connection.....? Swiage leakage: [XXX] [XXX] West covina sheriff dept. West covina ca INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I OWN A 1998 MAZDA PICKUP, 2500 MODEL. IT HAS ALWAYS BEEN A FLORIDA VEHICLE. I DID A FRONT END SUSPENSION CHECK, AND FOUND ALL 4 BALL JOINTS WITH DEEP RUST, NO RUBBER SEALS LEFT OTHER THAN BRITTLE AND CRACKED REMAINS OF THE RUBBER BOOT AROUND THE JOINTS. THE RUBBER BUSHINGS ON THE FRONT STABILIZER ASSEMBLY WERE ALSO EITHER TOTALLY DISINTEGRATED OR MISSING. THE MECHANIC TOLD ME THE CONDITION HAD BEEN PRESENT FOR SOME TIME, THE BALL JOINTS WERE BADLY WORN, AND CATASTROPHIC FAILURE WOULD HAVE OCCURRED WITHIN MONTHS. THIS VEHICLE WAS BUILT BY FORD. I BELIEVE THE QUALITY AND DURABILITY OF THE RUBBER BOOTS PROTECTING THESE VITAL PARTS WAS DEFECTIVE. ACCORDING TO SOME OTHERS I HAVE DISCUSSED THIS WITH, ROTTED BOOTS ARE NOT UNCOMMON. IN THE PAST I HAVE KEPT VEHICLES FOR OVER 20 YEARS WITHOUT ANY PROBLEM WITH BALL JOINT AND STEERING KNUCKLES GREASE COVERS. REQUEST THIS BE INVESTIGATED AS A MANUFACTURES DEFECT. THANKS IN VIEW OF THE POTENTIAL FOR ACCIDENTS, THIS NEEDS FOLLOWUP. *TR