2004 Mazda B-Series Truck Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Mazda B-Series Truck, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags2076.9%
- Body & structure311.5%
- Brakes13.8%
- Suspension13.8%
- Tires & wheels13.8%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
AIRBAGS CHANGED IN MAZDA RECALL. BAG SWITCH ON DASH WONT TURN ON.
TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA B-SERIES TRUCK. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 17V806000 (AIR BAGS) AND 17V807000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. SMAIL MAZDA IN GREENSBURG, PENNSYLVANIA WAS MADE AWARE OF THE RECALL AND STATED THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
Chassis is rusting out. Drivers side rear spring shackle, bracket fell off and need to be replaced costing me about $500.00. Mazda b2300 is also a Ford Ranger which also has similar issues. My truck has about 170,000 miles on the odometer. The drive train is strong; idles and runs smooth, does not burn oil.
I BROADSIDED A PICK UP TRUCK THAT RAN A STOP SIGN. ENOUGH DAMAGE WAS DONE THAT MY VEHICLE HAD TO BE TOWED AND LIKELY WILL BE WRITTEN OFF BY THE INSURANCE COMPANY AS TOTALED. I WAS DIAGNOSED WITH BLUNT TRAUMA TO THE CHEST WALL WITH CONTUSIONS. MY AIRBAG NEVER DEPLOYED. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
MY MAZDA B3000 PICKUP WOULD NOT STOP AT A RED LIGHT CAUSING AN ACCIDENT. WHEN I ENGAGED THE BRAKE THE FRONT END SHOOK AND THEN THERE WERE NO BRAKES. THE DAY OF THE ACCIDENT THERE WAS A LIGHT RAIN BUT I HAD NOT DRIVEN THROUGH ANY PUDDLES, THEREFORE I DON'T THINK IT WAS DUE TO "WET" BRAKES AS I HAVE BEEN TOLD. ULTIMATELY MY BRAKES DID NOT WORK, I ONLY HAVE 30K MILES ON THE VEHICLE, AND I WILL FEAR DRIVING IT ONCE THE BODY HAS BEEN FIXED. I HAVE NEVER HAD A VEHICLE THAT WOULDN'T STOP AND I FEEL THERE IS SOMETHING MECHANICALLY WRONG. I HAD OVER 2 CAR LENGTHS AND DUE TO THE FACT THIS IS A FAIRLY NEW VEHICLE, THERE IS NOT REASON IT SHOULD NOT HAVE STOPPED PRIOR TO IMPACTING ANOTHER VEHICLE. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
Chassis is rusting out. Drivers side rear spring shackle, bracket fell off and need to be replaced costing me about $500.00. Mazda b2300 is also a Ford Ranger which also has similar issues. My truck has about 170,000 miles on the odometer. The drive train is strong; idles and runs smooth, does not burn oil.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
I HAVE FOUR GOODYEAR WRANGLER SILENT ARMOR TIRES ON MY PICKUP TRUCK. ONE TIRE WENT FLAT DUE TO TEARS ON THE SIDEWALL OF THE TIRE. SO I THEN INSPECTED THE OTHER TIRES AND FOUND TEARS STARTING IN EACH OF THE OTHER TIRES AS WELL AS THE RUBBER IS PEELING OFF THE SIDEWALLS LIKE SNAKESKIN. THEN THE LAST COUPLE MONTHS MY STEERING WHEEL AS BEGUN TO SHAKE VIOLENTLY AT ANY SPEED OVER 40MPH. TWO OF THE TIRES ARE FALLING APART AND BEGINNING TO GET BUBBLES ON THE SIDEWALLS. THESE TIRES ONLY HAVE 24,000 MILES ON THEM AND ARE ABOUT 2-3 YEARS OLD. I HAVE HEARD SIMILAR STORIES TO MINE ABOUT THESE TIRES AND ALL OF THEM OCCUR AROUND 25,000 MILES BUT GOODYEAR WARRANTY'S THESE TIRES FOR 50,000. I HAVE HAD NO LUCK WITH GOODYEAR WORKING WITH ME. PEOPLE COULD DIE FROM THESE TIRES EXPLODING AND ITS TIME FOR SOMETHING TO BE DONE AGAINST THIS COMPANY. THANK YOU FOR YOUR TIME. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .