2023 Mazda CX-5 Engine Problems

The vehicle experienced a sudden and complete engine stall while idling immediately after fueling the gas tank to capacity on a day with high ambient temperatures (over 100°F). Leading up to the stall, the vehicle was subjected to temporary auxiliary loads (Max AC running and active steering input). Immediately following the stall, the vehicle exhibited a hard-start condition and would not catch fire. After sitting turned off for several minutes, the vehicle restarted normally. The incident left no Diagnostic Trouble Codes (DTCs) or Check Engine Lights. Independent of this event, the vehicle intermittently exhibits a raw gasoline vapor smell inside the cabin at idle, alongside slight hesitations during low-speed steering maneuvers. This presents a safety hazard due to unexpected loss of motive power immediately after refueling in high-traffic gas station environments.

NHTSA ID

11748088

Incident

Jul 2, 2026

Check Engine Light Code P0524 - Low Oil Pressure. Everything check out fine. Checked all the suggested TSB (Technical Service Bulletin) possibilities from a respected and qualified service center. Cleared the code and it keeps coming back on.

NHTSA ID

11746636

Incident

Jun 17, 2026

Vehicle is a 2023 Mazda CX-5 Signature Turbo model that had a leaking hydraulic tensioner for the serpentine belt at 15,759 miles. Mazda technician cleaned the hydraulic tensioner, and less than 500 miles later the leak returned. This is common enough in the community to expand TSB’s on this part.

NHTSA ID

11666001

Incident

May 8, 2025

Summary of Events: Purchase Date: 05/27/2023 Coolant Warning: In January 2025, I received a coolant temperature warning (code P0126) indicating insufficient coolant temperature. Repairs: I brought the vehicle in for repairs on 02/15/2025 for thermostat and related parts. The repairs were completed by 02/17/2025. New Warning: On 03/18/2025, I received a high coolant temperature warning. Upon inspection, coolant was nearly empty, and I found coolant contamination in the engine bay. Notification to Dealership: I emailed Hennessy Mazda on 03/19/2025, but after no response, I filed a claim with Mazda headquarters on 03/20/2025. Only after that, they called me and instructed me to bring the vehicle in. They claimed that after replacing the faulty parts and cleaning the engine bay, the car was ready for pickup. (While they assert that all actions were completed on 03/22, Based on the fact that the car door was opened approximately five times in April, it can be inferred that the necessary actions were likely completed in early April.) Concerns: Coolant Leak: The coolant leak persisted for nearly a month, likely causing damage to internal components due to engine overheating. Electronic Contamination: The leaked coolant likely contaminated sensitive electronic systems, wiring, and connectors, potentially leading to long-term failures due to the conductive and corrosive properties of modern coolants like Mazda FL22. Long-Term Risks: Hidden corrosion inside connectors and wiring. Potential for electrical failure, sensor malfunctions, and further degradation over time. Hennessy Mazda is currently addressing only the visible issues and claiming the car is now functioning properly, while attempting to shift the long-term and hidden risks onto me. I am requesting a vehicle replacement or compensation due to the safety and long-term reliability risks posed by the unresolved coolant leak and contamination.

NHTSA ID

11654904

Incident

Mar 20, 2025

See attached document for complaint.

NHTSA ID

11643979

Incident

Nov 2, 2024

Engine light came on. Immediately brought to dealer. Always serviced at dealership. One previous occurance of illuminated light reading major engine malfunction. Pulled car to side of road, called dealership who advised turn off and back on. Didn't tell me about ALL the problems that Mazda was aware of. Now I'm told my new car with 22k miles has a blown engine. No notification from Mazda about a known problem. Asked when buying the car if there were any major problems with this car. Mazda apparently lies.

NHTSA ID

11635586

Incident

Jan 10, 2025

The contact owns a 2023 Mazda CX-5. The contact stated that while the temperature was 45 degrees or lower, the vehicle failed to start properly, and the engine failed to warm up properly. The coolant light was illuminated, and the engine temperature gauge failed to rise above COLD. The vehicle occasionally failed to start or while started and driving at various speeds, the vehicle stalled while and engine temperature failed to reach the normal operating temperature. The check engine light was illuminated. The contact would shift to SPORT Mode to prevent the cylinder activation from occurring and causing the vehicle to stall. The contact stated that the failure persisted, and the vehicle was hesitating while driving in temperatures of 50 degrees or less. Additionally, the key fob intermittently failed to unlock the vehicle. The contact stated that the vehicle failed to start and had to be towed. The contact stated that during the recent failure, the battery was disconnected, and the vehicle was towed to the dealer to be diagnosed. The contact stated that the key fob battery had been replaced 6 times; however, the failure persisted. The vehicle had not been diagnosed or repaired for the engine failure. The contact called another dealer, J. Allen Mazda (15150 Airport Rd, Gulfport, MS 39503); however, only an appointment to inspect the vehicle was made but the vehicle was not yet inspected. The manufacturer was made aware of the failure and a case was filed. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 4,000.

NHTSA ID

11634530

Incident

Oct 7, 2023

Mileage

4,000 mi

The Low Oil Warning Light comes on between oil changes. I think this is the 3-4th time. I will have to add 1 quart of oil to the car after 3000-4000 miles. I only have about 33,000 miles on this vehichle and do the oil changes myself. I checked for leaks at the oil filter and oil drain plug. No indication of oil leaking or I would see it on the floor of my garage. What component or system failed or malfunctioned, and is it available for inspection upon request? Engine using excessive amounts of oil. It could be available for inspection How was your safety or the safety of others put at risk? Has the problem been reproduced or confirmed by a dealer or independent service center? I plan to take it into the dealer for next oil change and report it. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The Low Oil warning comes on

NHTSA ID

11633979

Incident

Jan 3, 2025

I love this car, but it has a bad habit, the vehicle accelerates on its own. If you take your foot off the gas, the car will intermittently lurch, almost jump forward. I’ve learned to deal with this by simply keeping a strong push on the break, but it is definitely is an issue. Another issue I’m having is the back lift gate. I’ve been told that the sensors are on each side of the gate and perhaps when drying the vehicle, I touch them😳 they run along each side of the liftgate fully visible. I have 17,000 miles on my car right now and when the lift gate opens closes it stops halfway and it beeps. I then have to push it down to close. I took it to the dealer and they say it will cost me if they have to check the sensors. This is extremely annoying to have an automatic lift gate, and I have to push it down myself.

NHTSA ID

11586116

Incident

Apr 30, 2024

Mazda CX-5 Premium Between May and September this year, the MyMazda app has alerted me two times that the oil level was low. I manually checked and it was indeed low. The first time I brought it to a Firestone service center to have it checked and they verified that the level was down considerably to the bottom dot on the stick. They said to bring it to the dealer. I brought it to the dealer and they said they could not find any leaks and to come back in 1000 miles. I did that and they only checked the dipstick to make sure the level was fine and sent me on my way. The same exact thing happened again a week ago and I topped off the oil then made an appointment. The dealer said that I should not have done that and now they could not verify for themselves that the oil was in fact low. They disregarded the message that the MyMazda app sent me and did not care that I documented and took photos of the dipstick. They had to see it for themselves. They said to come back 1000 miles and not add oil if it is low. I said to the representative at the dealer that I had seen mentions about high oil consumption online and they stated it was only turbo models. I bought my car October 2022 and it has had this oil issue twice in 20,000 miles. That is scary and unacceptable.

NHTSA ID

11544406

Incident

May 21, 2023

When applying the brakes car surges forward. If put in neutral engine races. Very difficult to bring to a stop with reduced braking. Multiple occurrences. Dealer states vehicle is operating within design perimeters.

NHTSA ID

11530806

Incident

Jul 4, 2023