2004 Mazda Mazda3 Body & structure Problems

There has been no accident- the vehicle is my mother in laws vehicle- my concern is while at work she has at times loaded our daughter into the vehicle- I inspected the vehicle one day while as an employee of Les Schwab- the driver cvc axle vibrates so bad from the boot being torn and having no lubrication- these axles power the vehicle forward and if not maintained can snap and cause damage- the wipers no longer work correctly- the tires are 2017 and old and weather cracked- potential to separate while driving or blow out on the heated pavement. upon inspection also found that the front shocks are blown out and bouncing in the mounts under the hood- causing the tires to not have the correct contact patch on the road thus decreasing traction and control- on top of all this the vehicle hasn't been registered since 2020 and has no insurance on the vehicle- again there has been no accident...yet- this is my concern- that if this vehicle continues to remain operational and on the road it not only puts the driver and occupants at risk but also other drivers- kids- teens and anyone that may be on the other end o the crash when the vehicle does snap the cvc axle or blow i out a tire

NHTSA ID

11538237

Incident

Aug 13, 2023

TL* THE CONTACT OWNS A 2004 MAZDA 3. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED SEVERE CORROSION AND THE DOOR FRAME WAS STARTING TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THAT PORTIONS OF THE VEHICLE COULD BE REPAIRED; HOWEVER, THE CORROSION WAS IN AREAS THAT WERE BEYOND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA ID

10743883

Incident

Dec 17, 2014

Mileage

130,000 mi

2004 MAZDA 3. PURCHASED CAR USED IN MARCH 2007. PER OWNER SERVICE RECORDS, MOTOR MOUNT #3 FAILED AND IN 11/2006, PER SERVICE BULLETIN, AND WARRANTY, LOCAL DEALER PERFORMED PARTIAL ENGINE REPLACEMENT, INCLUDING RUBBER ON MOUNT #3. NO PROBLEMS WITH CAR LEADING UP TO INCIDENT, REGULAR MAINTENANCE PERFORMED DURING OWNERSHIP 2007 - CURRENT. CAR USED PRIMARILY TO AND FROM WORK, APPROX. 12K PER YEAR DRIVEN. ON 8/29, CAR JUST STOPPED, MOTOR AND TRANSMISSION FELL OUT OF CASING, CAR CRASHED ON HWY 9. TOWED TO MAZDA DEALERSHIP. INITIAL ESTIMATE OF REPAIR $990 APPROX. ESTIMATE REVISED TO $3500 APPROX. TRANSMISSION BRACKET SHEARED/BROKEN AT METAL. MOTOR MOUNT #4 & TRANSMISSION MOUNT SCREW COMPLETELY DISLODGED. RECOMMENDED REPAIR INCLUDES COMPLETELY NEW TRANSMISSION CASE AND MOUNTS. NOT SURE IF ANY DAMAGE DONE TO TRANSMISSION ITSELF. FAILURE REPORTED TO DSM AND MAZDA CORPORATE. DUE TO CAR OUT OF WARRANTY AND MILEAGE ON CAR $100K, DENIED ANY RECOURSE FROM MAZDA FOR STRUCTURAL FAILURE. *TR

NHTSA ID

10422904

Incident

Aug 29, 2011

Mileage

100,000 mi

I BOUGHT A CAR RECENTLY, AND IT HAD SOME RUST ON BOTH REAR WHEEL WELLS IN THE SAME EXACT SPOTS. I HAVE A 2004 MAZDA 3I AND I TOOK IT TO ABOUT 4 BODY SHOPS TO HAVE IT WORKED ON. I GOT PRICES RANGING FROM 1000.00 DOLLARS TO 2500.00 DOLLARS TO FIX THE RUST. ALL OF THESE BODY SHOPS SAID THEY HAVE HAD AT LEAST ONE OTHER PERSON WITH THE SAME CAR AND THE SAME COMPLAINT AS I DID. MAZDA NEEDS TO FIGURE OUT WHAT THE PROBLEM IS. I CAN NOT AFFORD TO PAY 1000 DOLLARS TO GET MY CAR FIXED. MAZDA NEEDS TO TAKE RESPONSIBILITY AND FIX IT. *TR

NHTSA ID

10407303

Incident

Jan 4, 2011

I HAVE A 04 MAZDA 3 W/ AUTOMATIC TRANS / DRIVING INTO PARKING LOT HEARD A LOUD NOISE , CAR QUIT MOVING , DRIVER SIDE AXLE WAS HANGING / THE ENGINE HAD ALMOST DROP TO THE FLOOR , VEHICLE WAS TOWED TO A SHOP , THEY FOUND OUT THAT THE BRACKET WHICH HOLDS TRANSAXLE / ENGINE , ON DRIVER SIDE HAD BROKEN !! IT IS A ALUMINUM BRACKET WITH 3 BOLTS THAT CARRY ALL THE WEIGHT OF ENGINE / TRANSAXLE IT DAMAGED BOTH AXLE SHAFTS , CAUSED ABOUT $ 950.00 ON REPAIRS MY CONCERN IS THAT IT A VERY BAD / POOR / WEAK / DESIGN / THE GOOD THING IT HAPPENED AT LOW SPEED , IF IT WOULD HAVE BROKEN AT FREEWAY SPEED IT WOULD HAVE CAUSED A MAJOR DAMAGE / ACCIDENT !! *TR

NHTSA ID

10332666

Incident

May 20, 2010

Mileage

137,671 mi

I CURRENTLY OWN A 2004 MAZDA3 SPORT GT WHICH I PURCHASED BRAND NEW IN 2004. THE CAR HAS BEEN RUSTPROOFED BY KROWN SINCE IT'S FIRST YEAR, IS WASHED AT LEAST ONCE PER WEEK (MORE OFTEN IN WINTER MONTHS), AND IS OTHERWISE VERY WELL MAINTAINED. CURRENTLY I AM HAVING TO DEAL WITH A MAJOR RUST ISSUE WHICH, FROM READING MAZDA FORUM ENTRIES, IS PROVING TO BE EXTREMELY COMMON IN MY YEAR AND MAKE OF CAR. FOR THE PAST 2 YEARS THERE HAS BEEN COMPLETE RUSTING ON THE INSIDE OF THE REAR WHEEL WELLS WHICH HAS BEEN MENTIONED TO MY DEALERSHIP, TO NO AVAIL. NOW I ALSO HAVE RUSTING AT THE BOTTOM OF BOTH REAR PASSENGER DOORS, AND AT THE SEAMS BY THE BUMPER. ASIDE FROM THAT ISSUE, THE PAINT ON ALL 4 DOORS AND ON THE LIFTGATE (IT IS A HATCHBACK) IS BLISTERING! I DID BRING MY CAR TO THE DEALERSHIP BUT WAS FLATLY TOLD THAT THERE IS ONLY A "PERFORATION" WARRANTY WHICH ONLY PERTAINS TO ACTUAL HOLES. MAZDA CANADA IS THEREFORE UNWILLING TO HELP DEFRAY ANY PART OF THE CONSIDERABLE REPAIR BILL. I BROUGHT MY CAR IN TO 3 SHOPS TO GET REPAIR ESTIMATES WHICH RANGE IN COST FROM $1000 TO FIX JUST THE OBVIOUS RUST SPOTS TO $1800 TO ALSO ADDRESS ALL THE BLISTERING. BASICALLY MOST OF THE CAR, WITH THE EXCEPTIONS OF THE FRONT HOOD (WHICH I HAD COVERED IN CLEAR COATING WHEN I GOT IT) AND THE ROOF, NEEDS TO BE SANDBLASTED AND COMPLETELY REFINISHED TO PROPERLY ADDRESS THE ISSUE. ALL SHOPS I'VE SPOKEN TO FIND THIS RUSTING/BLISTERING ISSUE ON A 2004 WELL-MAINTAINED CAR TO BE VERY UNUSUAL AND ATTRIBUTE IT TO A MANUFACTURING DEFECT. ONE PLACE EVEN MENTIONED THAT HE RECENTLY REFINISHED TWO OTHER MAZDA 3S IN THE SAME COLOR AS MINE (WINNING BLUE). SINCE THIS IS CLEARLY AN ISSUE WITH THE ORIGINAL PAINTING OF THE CARS, MAZDA CANADA SHOULD RECOGNIZE THIS AND OFFER ITS CUSTOMERS SOME LEVEL OF ASSISTANCE. ESPECIALLY SINCE THE PAINT REPAIRS ARE QUITE COSTLY, THE COMPANY SHOULD TAKE THIS MATTER SERIOUSLY. AS IS, MY COMPLAINTS HAVE BEEN BRUSHED OFF AND IGNORED. *TR

NHTSA ID

10228764

Incident

Feb 1, 2006

ON 4/17/08 MY WIFE HAPPENED TO BE FOLLOWING ME AND SHE CALLED ME ON MY CELL PHONE AND SAID IT APPEARS YOU HAVE SOMETHING HANGING UNDER YOUR CAR. I IMMEDIATELY PULLED OVER AND IT WAS THE SPLASH SHIELD AGAIN. THREE OF THE FRONT BOLTS WERE MISSING BUT FOUR OTHER BOLTS, TWO ON EACH SIDE,WERE STILL ATTACHED, SO IT WAS JUST THE CENTER THAT WAS BOWING DOWNWARD. I MADE AN APPOINTMENT IMMEDIATELY AND THE CAR WAS SERVICED ON 4/18/08. ORIGINALLY THE DEALER WAS GOING TO CHARGE ME FOR THE SPLASH SHIELD. HE SAID IT APPEARS SOMETHING STRUCK THE PART. SO, AFTER MUCH DISCUSSION AND AFTER I RETRIEVED THE PART FROM THE MECHANICS WORK BENCH I WAS ABLE TO PROVE THE PART WAS DRAGGING WHICH CAUSED THE SPLASH SHIELD TO BREAK APART. THERE WERE ROAD ABRASION MARKS ON THE SPLASH SHIELD. THIS IS THE SECOND SHIELD TO BE REPLACED ON MY CAR. IS MAZDA HAVING ISSUES WITH THESE SHIELDS. THE DEALER KEEPS A SUPPLY OF THEM IN STOCK. *TR

NHTSA ID

10224946

Incident

Apr 18, 2008

Mileage

59,151 mi

EXCESSIVE REAR BRAKE DISC/PAD WEAR. DRIVER DOOR RATTLING. *AK

NHTSA ID

10074639

Incident

Mar 19, 2004