2007 Mazda Mazda6 Steering Problems

MAZDA 2007 MAZDA 6 WITH SEVERE CORROSION TO ENGINE SUBFRAME POSING A VERY SERIOUS SAFETY CONCERN IF BREAKS WHILE DRIVING. CURRENT MAZDA 6 IN QUESTION HAD LESS THAN 100K MILES AND WAS SPOTTED BY AN OIL CHANGE TECHNICIAN. I'VE ASKED A COUPLE MECHANICS AND WAS INFORMED THE CAR WOULD BE A POSSIBLE DEATH TRAP TO MYSELF OR OTHERS IF NOT FIXED QUICKLY. ALL PARTIES ARE AMAZED AT AMOUNT OF CORROSION, INTERNET SEARCHES SUGGEST THIS IS A VERY COMMON PROBLEM AND ALREADY A RECALL IN PLACE FOR OTHER YEAR MAZDA 6'S.

NHTSA ID

11252273

Incident

Feb 3, 2019

Mileage

92,000 mi

TL* THE CONTACT OWNS A 2007 MAZDA 6. WHILE DRIVING AT APPROXIMATELY 5 MPH, THE STEERING WHEEL FRACTURED AND CAUSED THE BALL JOINT, THE CONTROL ARM, AND THE AXLE TO FRACTURE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO REPAIRED THE BALL JOINTS, THE CONTROL ARM, AND AXLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

NHTSA ID

10782942

Incident

Sep 15, 2015

Mileage

105,000 mi

STEERING BECAME DIFFICULT, EXTREME VIBRATION, AND CAR PULLED TO THE RIGHT WHEN TRAVELING APPROXIMATELY 60 MPH APPROX MILEAGE WAS 46K WHEN ISSUE STARTED. PROBLEM CONTINUED FOR ABOUT 5 MILES AND THEN STOPPED. ISSUE OCCURRED AGAIN TRAVELING APPROX 40 MPH. TOOK VEHICLE TO MANUFACTURER AND THEY FOUND NO ISSUE, JUST STATED THAT IT WAS TIME FOR A 50K MILE SERVICE. GOT THE RECOMMENDED SERVICE. IN JANUARY '10 WHILE DRIVING APPROX 70 MPH ISSUE STARTED AGAIN, BUT WAS A LOT WORSE, APPROX MILEAGE WAS 52K DEALERSHIP WOULD NOT HONOR 50K MILE WARRANTY, TOOK CAR TO REPAIR SHOP, WHEN ARRIVING, ATTEMPTED TO PUT CAR IN REVERSE AND IT WOULD NOT GO. MECHANIC INFORMED ME THAT THE ISSUE WAS, STEERING COLUMN HAD WENT BAD. HAD TO BE REPLACED. *TR

NHTSA ID

10336364

Incident

Jan 17, 2010

Mileage

52,000 mi

TL*THE CONTACT OWNS A 2007 MAZDA 6. WHILE DRIVING AT 35 MPH, THE CONTACT NOTICED A LOUD NOISE FROM THE STEERING AREA. THE NOISE BECAME INTERMITTENT. THE CONTACT STATED THAT THE VEHICLE WAS DIFFICULT TO STEER AND SHE HAD TO HOLD THE STEERING WHEEL TIGHT TO CONTROL IT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE LOWER CHASSIS ARM WAS THE CAUSE OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT BUT THE DEALER STATED THAT THE VEHICLE WAS SAFE TO DRIVE. THE FAILURE MILEAGE WAS 66,159. THE CURRENT MILEAGE WAS 56,340.

NHTSA ID

10330331

Incident

Apr 10, 2010

Mileage

66,159 mi

TL*THE CONTACT OWNS A 2007 MAZDA, MAZDA6. THE CONTACT STATED THAT SHE COULD HEAR A MOANING SOUND WHILE TURNING THE STEERING WHEEL AND DEPRESSING THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE DEALER COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE. THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP WHERE IT WAS REPAIRED. THE FAILURE CONTINUED AFTER REPAIRS. THE REPAIRS THAT WERE PERFORMED ON THE VEHICLE WERE UNKNOWN. THE FAILURE MILEAGE WAS 55,159. THE CURRENT MILEAGE WAS APPROXIMATELY 55,500.

NHTSA ID

10330321

Incident

Apr 17, 2010

Mileage

55,159 mi

I WAS DRIVING ON THE RIGHT LANE (THE SLOW LANE) OF THE FREEWAY, GOING AROUND 60-65 MPH. AROUND 4:45 P.M ON A CLEAR DAY, I NOTICED A WHITE SEDAN NEXT TO ME STARTING TO CHANGE LANES INTO MY LANE. IT DID NOT SEE MY CAR, BECAUSE I HAD TO VEER SLIGHT RIGHT TO AVOID BEING HIT BY THE CAR. MY CAR DID NOT HANDLE THE SUDDEN MOVE WELL AND IMMEDIATELY STARTED TO SWERVE LEFT AND RIGHT UNCONTROLLABLY FOR 1-2 SECONDS. I COULD NOT REGAIN CONTROL OF THE CAR EVEN THOUGH BOTH MY HANDS WERE ON THE STEERING WHEEL, TRYING TO STRAIGHTEN THE CAR. THE CAR THEN LOST COMPLETE CONTROL AND SWERVED/SPUN ALL THE WAY LEFT (IMAGINE MAKING A COMPLETE LEFT TURN ON THE FREEWAY), INTO THE 3RD LANE. IT CONTINUED GOING IN A COUNTER-CLOCKWISE DIRECTION UNTIL A WHITE VAN RAN INTO MY CAR IN THE MIDDLE OF THE FREEWAY, STOPPING THE CAR IN A HEAD-ON COLLISION. THE AIR BAGS POPPED, SMOKE STARTED COMING FROM THE CAR. I WAS AMAZINGLY UNHURT FOR THE MOST PART. I TOOK MY HANDS OF THE STEERING WHEEL AND MANAGED TO OPEN THE DRIVER SEAT DOOR TO EXIT THE VEHICLE. THE FINAL POSITION OF THE CAR WAS FACING EXACTLY THE OPPOSITE DIRECTION OF TRAFFIC. SEVERAL FIREFIGHTERS/PARAMEDICS ARRIVED AND PROCEEDED TO CLEAN UP THE DEBRIS SCATTERED AROUND THE ROADS AND PUSHED THE CAR TO THE SIDE OF THE FREEWAY. THE CAR INSURANCE COMPANY HIRED FORENSIC ENGINEERS TO RECONSTRUCT THE ACCIDENT AND INSPECT THE CAR FOR DAMAGES. UNFORTUNATELY, THERE WAS NOTHING CONCLUSIVE TO REPORT (ALTHOUGH THE FRONT ROTORS WERE SUSPECT). *TR

NHTSA ID

10279100

Incident

Dec 16, 2008

Mileage

28,983 mi

I HAVE HAD MY MAZDA 6 FOR 2 YEARS. TWO DAYS AGO, IT GOT VERY COLD, AND WHEN I DROVE THE NEXT DAY, I HEARD THIS SQUEAKY NOISE FROM THE STEERING COLUMN AND FROM THE SUSPENSION WHEN TURNING. NOT SURE WHAT PROBLEM IS, BUT IT SEEMED THAT ONCE THE ENGINE WAS WARM THE SQUEAKING WAS GONE. I DID CHECK THE POWER STEERING FLUID, AND IT WAS LOW, SO POWER STEERING FLUID WAS ADDED. ALSO ADDED BRAKE FLUID DUE TO IT WAS ALSO LOW. I HEARD PROBLEM SLIGHTLY THE DAY AFTER A LITTLE. HOPEFULLY THE POWER STEERING FLUID WILL SOLVE THE PROBLEM. IF IT PERSISTS, I WILL CALL THE DEALERSHIP. PLEASE ADVISE IF THERE HAS BEEN ANY OTHER COMPLAINTS ON THIS. MY CAR CURRENTLY HAS OVER 50,000 MILES, AND THIS IS THE FIRST SOUNDS I HAVE HEARD. *TR

NHTSA ID

10252048

Incident

Dec 15, 2008

Mileage

50,425 mi

MY 2007 MAZDA 6 WAS BOUGHT BACK IN JANUARY 07. MY PROBLEM COMES FROM THE STEERING COLUMN WHICH WAS MAKING A SMALL SOUND WHEN I PULL OUT OF MY DRIVEWAY BUT NOW IT'S GETTING WORST I HAVE NOT TAKEN IT BACK TO THE DEALER BECAUSE OF MY TIGHT SCHEDULE. *JB

NHTSA ID

10203312

Incident

Jul 20, 2007

Mileage

3,400 mi