2007 Mazda Mazdaspeed3 Owner Complaints

I WAS DRIVING ON THE FREEWAY ON MY WAY TO WORK AND I WAS GOING ABOUT 70 MPH WHEN THE CAR SUDDENLY AND VIOLENTLY JERKED AND DROPPED INTO 3RD GEAR FROM 5TH GEAR.IT HAPPENS AT RANDOM TIMES MY A.T. LIGHT AND CHECK ENGINE LIGHT CAME ON AND NOW MY CAR IS STUCK IN 4TH GEAR. I HAVE HAD MY TRANSMISSION FLUSHED AND MY SPEED SENSOR REPLACED BUT IM STILL HAVING ISSUES WITH IT I DONT LIKE TO TAKE MY KIDS IN MY CAR DUE TO THE FACT THAT IT IS VERY DANGEROUS WHEN THAT DOES OCCUR I AM SCARED THAT I AM GOING TO GET INTO A CAR ACCIDENT DUE TO THIS ISSUE. I BOUGHT THE CAR FROM A USED DEALERSHIP IN FONTANA CA ON APRIL 19 2016 THE VERY NEXT DAY THE CAR STARTED TO TRIP UP FROM 4TH TO 3RD GEAR. THE A.T LIGHT CAME ON AND SINCE THEN IT HAS GOTTEN WORSE I CALLED THE GENTLEMAN WHO SOLD ME THE CAR AND TOLD HIM WHAT WAS GOING ON WITH THE CAR HE TOLD ME TO BRING IT IN AND HAVE THE FLUIDS FLUSHED AND IT WAS PROBABLY JUST A SENSOR . SO I TOOK IT IN AND THE DROVE FINE FOR A LITTLE WHILE THEN OUT OF NO WHERE THE CAR STARTED TO GO FROM 5TH GEAR TO 3RD GEAR VERY VIOLENTLY SO I REPLACED THE OUTPUT SPEED SENSOR AND IT STILL HAD THE SAME PROBLEM. I HAD THE TRANSMISSION SERVICED AGAIN AND THE TRANSMISSION FILTER REPLACED AND MY CAR IS STILL GOING FROM 5TH GEAR TO 3RD GEAR ERATICALLY.

NHTSA ID

10893328

Incident

Apr 20, 2016

Mileage

138,120 mi

TAIL LIGHT DOME ASSEMBLY IS MELTED BY THE BULB FROM BOTH SIDE. *TR

NHTSA ID

10649006

Incident

Oct 14, 2014

Mileage

63,000 mi

ON SATURDAY 19 JULY 2014, MY WIFE AND I WERE DRIVING NORTH ON HIGHWAY 131, 18 MILES SOUTH OF GRAND RAPIDS, MI WHEN WITHOUT NOTICE THE ENGINE'S NUMBER 1 CYLINDER BLOW A HOLE THROUGH THE CASTING AND DAMAGING THE INNER AXLE SHAFT CARRIER BEARING. WHEN THE ENGINE BLEW, IT CAUSED THE CAR TO SHAKE VIOLENTLY CAUSING ME, THE DRIVER, TO LOSE CONTROL OF THE VEHICLE. I WAS ABLE TO REGAIN CONTROL OF THE VEHICLE BEFORE THE CAR SWERVED INTO AN ADJACENT LANE. PRIOR TO THE INCIDENT THE VEHICLE WAS IN GOOD RUNNING CONDITION AND HAD JUST PASSED THE VIRGINIA STATE INSPECTION A FEW MONTHS PRIOR. ALL OF THE REGULAR VEHICLE MAINTENANCE WAS COMPLETED ACCORDING TO THE VEHICLES MAINTENANCE SCHEDULE. EACH SERVICING THAT WAS COMPLETED WAS DOCUMENTED IN MY OWN PERSONAL RECORDS FOR REFERENCE. THIS BEING SAID, THIS VEHICLE CAUSED A MAJOR SAFETY INCIDENT WITHOUT NOTICE, WHICH UNDER CERTAIN CIRCUMSTANCES COULD HAVE CAUSED SERIOUS DAMAGE OR EVEN A FATALITY. THERE ARE SEVERAL CASES OF THESE MAZDA 2.3 LITER TURBO MRZ ENGINES BLOWING UNDER NORMAL OPERATING CONDITIONS. THERE IS A MAJOR DESIGN OR MANUFACTURING DEFECT WHICH MAZDA NEEDS TO ADDRESS. *TR

NHTSA ID

10625871

Incident

Jul 19, 2014

Mileage

74,200 mi

ON SATURDAY 19 JULY 2014, MY WIFE AND I WERE DRIVING NORTH ON HIGHWAY 131, 18 MILES SOUTH OF GRAND RAPIDS, MI WHEN WITHOUT NOTICE THE ENGINE'S NUMBER 1 CYLINDER BLOW A HOLE THROUGH THE CASTING AND DAMAGING THE INNER AXLE SHAFT CARRIER BEARING. WHEN THE ENGINE BLEW, IT CAUSED THE CAR TO SHAKE VIOLENTLY CAUSING ME, THE DRIVER, TO LOSE CONTROL OF THE VEHICLE. I WAS ABLE TO REGAIN CONTROL OF THE VEHICLE BEFORE THE CAR SWERVED INTO AN ADJACENT LANE. PRIOR TO THE INCIDENT THE VEHICLE WAS IN GOOD RUNNING CONDITION AND HAD JUST PASSED THE VIRGINIA STATE INSPECTION A FEW MONTHS PRIOR. ALL OF THE REGULAR VEHICLE MAINTENANCE WAS COMPLETED ACCORDING TO THE VEHICLES MAINTENANCE SCHEDULE. EACH SERVICING THAT WAS COMPLETED WAS DOCUMENTED IN MY OWN PERSONAL RECORDS FOR REFERENCE. THIS BEING SAID, THIS VEHICLE CAUSED A MAJOR SAFETY INCIDENT WITHOUT NOTICE, WHICH UNDER CERTAIN CIRCUMSTANCES COULD HAVE CAUSED SERIOUS DAMAGE OR EVEN A FATALITY. THERE ARE SEVERAL CASES OF THESE MAZDA 2.3 LITER TURBO MRZ ENGINES BLOWING UNDER NORMAL OPERATING CONDITIONS. THERE IS A MAJOR DESIGN OR MANUFACTURING DEFECT WHICH MAZDA NEEDS TO ADDRESS. *TR

NHTSA ID

10621872

Incident

Jul 19, 2014

Mileage

74,200 mi

I WAS USING A MICHELIN GREEN X TIRE FOR ABOUT 2 YEARS AN MILEAGE OF 50000. IN A 45 DEGREE CURVE SUDDENLY MY TAIL WENT OUT OF CONTROL AND I RAN INTO THE MIDDLE SEPARATE OF ROAD,CAUSED A LOT OF WRECKAGE . I WAS TOLD THAT THIS WAS BECAUSE OF LOW REAR TIRE GRIP TO THE ROAD. *TR

NHTSA ID

10549666

Incident

Oct 23, 2013

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2007 MAZDA MAZDA SPEED3. THE CONTACT STATED THAT WHILE TRAVELING 65 MPH, THE ENGINE SUDDENLY FAILED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT OIL PRESSURE MODULE HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 96,000.

NHTSA ID

10532479

Incident

Jul 23, 2013

Mileage

96,000 mi

TL* THE CONTACT OWNS A 2007 MAZDA, MAZDASPEED3. WHILE DRIVING APPROXIMATELY 30 MPH ON AN UNEVEN ROAD SURFACE, THE CONTACT HEARD A CLUNKING NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THERE WAS A TECHNICAL SERVICE BULLETIN UNDER NHTSA ACTION NUMBER: 10023313 (SUSPENSION: FRONT). THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 41,000.

NHTSA ID

10406246

Incident

Mar 4, 2011

Mileage

41,000 mi

I OWN A 2007 MAZDASPEED 3, PURCHASED FROM A DEALER IN , LANGLEY BC., IN JUNE 2008. IT WAS A US IMPORTED CAR ( BY THE DEALER) AND I WAS TOLD I INHERITED THE BALANCE OF THE WARRANTY. IT WAS BUILT IN MAY 2007, AND HAD APPROX 22,646 MILES ON THE ODOMETER. ON FRIDAY 27 MAY AT ABOUT 7 AM, I HAD JUST ACCELERATED FROM A TRAFFIC LIGHT WHEN AN ENGINE MOUNT SUDDENLY FAILED, PITCHING THE COMPLETE ENGINE AND TRANSMISSION FORWARD AND DOWN ONTO THE ROAD , WITH DISASTROUS CONSEQUENCES. I WAS REALLY FORTUNATE TO BE TRAVELING QUITE SLOWLY ( ABOUT 20 MPH) AS THE 'CV' JOINT DISINTEGRATED AND THE CAR SLEWED ALARMINGLY TOWARDS THE KERB. I DID NOT HAVE MUCH DIRECTIONAL CONTROL, BUT MANAGED TO STEER THE CAR TOWARDS THE KERB WHERE IT (RAPIDLY ) CAME TO A STOP. FORTUNATELY, I WAS TRAVELING SLOWLY ENOUGH FOR THIS NOT TO BE SERIOUS ACCIDENT, BUT IF I HAD BEEN TRAVELING AT 70 MPH DOWN THE FREEWAY, I MIGHT NOT HAVE BEEN HERE TODAY TO WRITE THIS. I HAD TO HAVE THE CAR TOWED TO A MAZDA DEALERSHIP ( AT MY EXPENSE ) WHERE A INSPECTION SHOWED THAT THE #4 ENGINE MOUNT HAD FAILED, DROPPED THE ENGINE AND TRANSMISSION AND DESTROYED THE 'CV' JOINT, IN THE PROCESS DAMAGING THE TURBO WASTEGATE VALVE. THEY CHECKED THE VIN AND FOUND THAT THE VEHICLE WAS INDEED BUILT MAY 2007, AND THAT THERE HAD BEEN A RECALL TO CHANGE THE ENGINE MOUNT, ALSO IN 2007 ( BEFORE I PURCHASED THE CAR). THIS CHANGE WAS PRESUMABLY DONE AT A US DEALER AS IT DID NOT COME TO THE IN BC DEALER UNTIL JUST BEFORE I PURCHASED IT IN 2008. THERE WAS ABSOLUTELY NO OVERT WARNING SIGNS- THE ONLY THING WAS THE DAY BEFORE WHEN I NOTICED A FAINT VIBRATION COMING FROM THE FRONT , WHICH SOUNDED LIKE A PIPE CLAMP OR SOMETHING VIBRATING. I STOPPED AND MADE A VISUAL INSPECTION OF THE ENGINE BAY AND UNDERNEATH , BUT COULD NOT SEE ANYTHING. BANG AS IT LET GO. THE PARTS WERE REPLACED FREE UNDER MAZDA WARRANTY. *TR

NHTSA ID

10405516

Incident

May 27, 2011

Mileage

22,600 mi

LIFTED PARKING BRAKE LEVER TO ENGAGE PARKING BRAKE, AND IT CAME UP WAY FURTHER THAN NORMAL WITHOUT OFFERING THE NORMAL RESISTANCE. AFTER THREE ATTEMPTS AT RESETTING THE BRAKE, IT ENGAGED NORMALLY. MALFUNCTION OCCURRED AGAIN LATER. *TR

NHTSA ID

10376538

Incident

Jan 11, 2011

Mileage

30,000 mi

ON APRIL 28, 2009 WHILE DRIVING HOME FROM WORK I SHIFTED GEARS FROM SECOND INTO THIRD I HEARD A BIG THUNK FROM THE TRANSMISSION. I STOPPED THE CAR AND LOOKED UNDER THE BODY BUT DID NOT NOTICE ANY BROKEN OR LOOSE PARTS. OCCASIONALLY IN THE PAST WHILE DRIVING THE CAR THE GEAR WOULD SLIP AND MOVE INTO NEUTRAL, AND I THOUGHT THIS MIGHT BE RELATED TO THAT SEEMINGLY MINOR PROBLEM. HOWEVER, AS I STARTED TO DRIVE I NOTICED THE GEARS WERE VERY HARD TO CHANGE AND CLUTCH WAS NOT AS SMOOTH AS IT USED TO BE. EARLY THE NEXT MORNING I TOOK THE CAR TO O'BRIEN AUTO PARK OF URBANA. THIS BUSINESS IS LOCATED AT 1111 O'BRIEN DRIVE, URBANA, IL 61802 (TELEPHONE 217-367-1222). I SPOKE TO JOSH BERBAUM, THE SERVICE CONSULTANT FOR MAZDA O'BRIEN, AND EXPLAINED TO HIM WHAT HAPPENED. ON MONDAY, MAY 4, 2009 AND TOLD ME THAT THE CLUTCH HAS FAILED AND THE FLYWHEEL HAD HOT SPOTS AND COULD NOT BE REPAIRED. HE APOLOGIZED AND SAID THIS IS 'WEAR AND TEAR' AND MAZDA WOULD NOT COVER IT UNDER NEW VEHICLE LIMITED WARRANTY OR THE POWERTRAIN LIMITED WARRANTY. HE ALSO STATED THAT THIS IS A VERY BIG JOB AND WOULD COST OVER $1575 IN PARTS AND $1045 IN LABOR AND THAT IT WOULD TAKE A COUPLE OF DAYS TO FIX THE CAR. AFTER O'BRIEN KEPT THE CAR FOR 10 BUSINESS DAYS I PAID $2352.99 TO GET MY CAR AND MAZDA DECLINED MY CLAIM. I HAVE TAKEN THE ISSUE WITH MY CREDIT CARD AND LET WHAT THEY CAN DO FOR ME. *TR

NHTSA ID

10277580

Incident

Apr 28, 2009

Mileage

35,730 mi

2007 MAZDASPEED3. DRIVING 25 MPH AND SUDDENLY HUGE LOAD SOUND UNDERHOOD FOLLOWED BY MUCH CLANKING AND KNOCKING AS I COASTED TO A STOP ON THE SIDE OF THE ROAD. CAR COULD NOT BE ROLLED. ENGINE DROPPED 2-3 INCHES AND DRIVER SIDE AXLE BROKE AND DANGLED FROM WHEEL. CAR WENT TO SHOP AND AXLE, CV JOINT, COMPLETE TRANSMISSION, FAN, AND A VARIETY OF SMALLER PARTS ALL HAVE TO BE REPLACED. CAR IS CURRENTLY STILL IN SHOP. *TR

NHTSA ID

10264029

Incident

Mar 29, 2009

Mileage

11,700 mi

I HAVE AN 2007 MAZDA MAZDASPEED3 BOUGHT IN MAY 2007. I HAD THE MOTOR MOUNT BOLT REPLACED DURING AN ASSOCIATED RECALL IN AUGUST 2007. A FEW MONTHS LATER IT FAILED (JULY 2008). THE BOLT HAD BACKED OUT, AND SHEARED THROUGH THE LAST FEW THREADS. I HEARD THIS LOUD BANG, FOLLOWED BY CLUNK-CLUNK NOISES AND IMMEDIATELY PULLED OVER INTO A GAS STATION. I WAS FORTUNATE TO BE ON THE RIGHT LANE AT 30 MPH IN 3RD GEAR. I HAD IT TOWED TO JIM ELLIS MAZDA OF MARIETTA (GA). THEY TOLD ME THAT THE ENGINEERS FROM MAZDA HAD A LOOK AT IT AND THE WHOLE MOUNT BRACKET AND THE BOLT WAS REPLACED UNDER WARRANTY. BUT OVER THE PAST TWO WEEKS I'VE BEEN HEARING A SLIGHT CLUNKING NOISE ESPECIALLY DURING SLOW TURNS, SO I TOOK IT BACK TO THE DEALER AGAIN ON LAST MONDAY (03/02/09) TO HAVE THEM LOOK AT IT. THEY FOUND THAT THE STEERING RACK FLOW CONTROL VALVE WAS POPPING AT TIMES AND REPLACED IT UNDER WARRANTY. I HAD ALSO ASKED THEM TO HAVE A LOOK AT MY MOUNTS, JUST TO BE SURE. I GOT MY CAR BACK ON THURSDAY AND WAS TOLD THAT MY MOUNTS WERE FINE. BUT ON FRIDAY (03/06/09) I STILL HAD THOSE CLUNKING SOUNDS ON SLOW TURNS AND WHILE PULLING OUT OF PARKING LOTS/BACKING UP. I ALSO NOTICED SOME ODD VIBRATIONS ON THE CLUTCH PEDAL WHILE GIVING GAS AND DURING IDLE. THE LAST TIME HAD THESE VIBRATIONS WERE JUST BEFORE THE MOTOR MOUNT FAILED ON ME. SO I DECIDED TO HAVE A LOOK INTO MY MOUNTS. I ALSO NOTICED THAT MY CLOCK AND TRIP METERS WERE NOT RESET. IF THE DEALER HAD INSPECTED MY MOUNTS THEY WOULD'VE BEEN RESET WHEN THE BATTERY IS BEING REMOVED. THAT RAISED MY SUSPICIONS. I REMOVED THE BATTERY AND TRIED TURNING THE MOUNT BOLT. IT WAS I COULD TURN IT WITH JUST ONE HAND. I IMMEDIATELY CALLED THE DEALER AND ASKED THEM WHAT TO DO. THE ASKED TO BRING THE CAR OVER AFTER TIGHTENING IT, OR GET IT TOWED IF I COULDN'T. I TIGHTENED THE BOLT AND IT TOOK ME ABOUT 6 TURNS TO FULLY TIGHTEN IT!!! THE BOLT WAS ALMOST OUT AND I CAUGHT IT BEFORE SOMETHING SERIOUS HAD OCCURRED. THE DEALER HAS RE TIGHTENED THE BOLT NOW. *TR

NHTSA ID

10261307

Incident

Mar 6, 2009

Mileage

33,800 mi

HAD MOTOR/TRANSMISSION MOUNT RECALL DONE ON MY 2007 MAZDASPEED3 DONE AS SOON IT RELEASED IN 2007. FEB 2009 WITH 26000 MILES ON THE CAR THE MOTOR/TRANSMISSION MOUNT BRACKET TORE APART WHILE DRIVING. AXLES, AND ALOT OF OTHER PARTS, DAMAGED. NEEDLES TO SAY THANK GOD I WAS ONLY DOING 5MPH WHEN INCIDENT OCCURRED. CAR WAS REPAIRED AT MAZDA DEALER, AND BEFORE I PICKED UP VEHICLE AFTER SUPPOSEDLY BEING FIXED, MOTOR/TRANSMISSION MOUNT FAILED AGAIN WHILE THE MAZDA TECH WAS DRIVING VEHICLE. MAZDA HAS A VERY SERIOUS PROBLEM WITH THESE CARS THAT THEY DO NOT SEEM TO WANT TO ADDRESS PROPERLY. THEY REALLY NEED TO FIX THIS PROBLEM NOW BEFORE SOMEONE GETS INJURED SERIOUSLY. NOT AN ACCEPTABLE PROBLEM ON ANY CAR. *TR

NHTSA ID

10258514

Incident

Jan 29, 2007

Mileage

26,478 mi

MAZDA SPEED 3 ENGINE MOUNT FAILURE, ENGINE FELL OUT OF B OTTOM OF CAR. *TR

NHTSA ID

10236548

Incident

Jul 30, 2007

Mileage

16,900 mi

MY TRANSMISSION OCCASIONALLY POPS OUT OF SECOND GEAR WHEN I LET OFF THE GAS. *TR

NHTSA ID

10233220

Incident

May 22, 2008

Mileage

11,390 mi

I INSTALLED THE AFTERMARKET MAZDASPEED LOWERING SPRINGS ON MY MAZDASPEED3, CAREFULLY FOLLOWING THE SUPPLIED INSTRUCTIONS. THE INSTRUCTIONS REQUIRE REMOVING THE BUMP STOPS FROM THE STRUT MOUNTS. I THOUGHT THIS WAS STRANGE, BUT I DID IT, AND LATER FOUND THAT MY RIGHT-FRONT TIRE TREAD SURFACE HAD MADE CONTACT WITH THE TOP OF THE INSIDE OF THE FENDER. THE RESULT WAS DEEP CIRCUMFERENTIAL GROOVES IN THE TIRE, AND THE PLASTIC FENDER LINER WAS COMPLETELY WORN AWAY IN ONE AREA. THIS IS POTENTIALLY VERY DANGEROUS SINCE IT COULD LEAD TO A TIRE BLOWOUT. AND YES, I AM CERTAIN THAT THE INSTRUCTIONS SHOW THE REMOVAL OF THE BUMP STOPS. I HAVE THE INSTRUCTIONS AND PHOTOS OF THE DAMAGE. *TR

NHTSA ID

10224508

Incident

Nov 1, 2007

Mileage

15,000 mi

AT 8,811 MILES THE NUMBER 4 ENGINE MOUNT (DRIVER'S SIDE TRANSAXLE TO FRAME) FAILED EVEN THOUGH RECALL 4607F HAD ALREADY BEEN PERFORMED AT 826 MILES ~8 MONTHS AGO. *TR

NHTSA ID

10222709

Incident

Mar 28, 2008

Mileage

8,811 mi

TL*THE CONTACT OWNS A 2007 MAZDA SPEED 3. WHILE DRIVING LESS THAN 10 MPH, THE VEHICLE WENT INTO A FULL SKID AND STRUCK A CURB. FIVE MILES LATER, THE VEHICLE LOST STEERING ABILITY AND THE WHEEL TURNED COMPLETELY AROUND. THE VEHICLE WAS TAKEN TO A DEALER AND THEY REPLACED THE FAILED STEERING RACK. THE CONTACT STATED THAT THE DEALER WAS SELLING VEHICLES WITH SUMMER TIRES. THERE WERE NO INJURIES. THE CURRENT MILEAGE WAS 8,800 AND FAILURE MILEAGE WAS 8,780. UPDATED 01-30-08. *KB THE CONSUMER STATED FAILURE WARN ABOUT TO SUMMER RATED TIRES. UPDATED 01/18/08 *TR

NHTSA ID

10212489

Incident

Dec 8, 2007

Mileage

8,780 mi

TL*THE CONTACT OWNS A 2007 MAZDA SPEED 3. WHILE DRIVING 40 MPH, THE MOTOR MOUNT BROKE WHEN HE SHIFTED FROM FIRST TO SECOND GEAR. AS A RESULT, THE DRY SHAFT PULLED FROM THE TRANSMISSION AND TORE THE CB AXLE BOOT. THE CONTACT INSTALLED AN INTAKE MANIFOLD PRIOR TO THE FAILURE. THERE IS A SAFETY RECALL FOR THE ENGINE AND ENGINE COOLING (NHTSA CAMPAIGN ID #07V295000) HOWEVER, THE DEALER REFUSED TO REPAIR DUE TO THE INSTALLATION OF THE INTAKE MANIFOLD. THE CURRENT AND FAILURE MILEAGES WERE 11,700.

NHTSA ID

10210923

Incident

Nov 29, 2007

Mileage

11,700 mi

REAR WHEEL STABILIZER BOLT LOOSE AND DAMAGED. MAKES A "CLUNK" SOUND WHEN GOING OVER SMALL BUMPS. BOLT IS LOOSE AND WILL COME OFF. *TR

NHTSA ID

10210062

Incident

Nov 27, 2007

Mileage

9,900 mi

MOTOR MOUNT FAILURE. MY TRANSMISSION/MOTOR MOUNT FAILED CAUSING THE ENGINE TO FALL IN THE ENGINE BAY. THIS HAS HAPPENED TO SEVERAL OTHERS AS POSTED ON HTTP://WWW.MAZDA3FORUMS.COM/INDEX.PHP?TOPIC=68975.0. *TR

NHTSA ID

10191833

Incident

May 28, 2007

Mileage

16,000 mi

I HAVE A BRIDGESTONE POTENZA TIRE WITH 5K MILES ON IT AND IT HAS A BULGE IN THE SIDEWALL.

NHTSA ID

10191740

Incident

May 24, 2007

Mileage

5,130 mi

2007 MAZDA ASPEED 3 IS PRONE TO MOTOR MOUNT FAILURE, I AM TAKING THE VEHICLE TO THE DEALERSHIP TO HAVE THEM ADDRESS LOOSE MOTOR MOUNT, WHICH ACCORDING TO RECENT DATA ON THE WEB , IS PRONE TO POTENTIALLY CATASTROPHIC FAILURE IF THE MOUNT FAILS AT HIGHWAY SPEEDS. *AK

NHTSA ID

10191205

Incident

May 17, 2007

HEARD RATTLE IN REAR OF CAR. THE PASSENGER'S SIDE ANTI ROLL BAR LINKAGE WAS LOOSE. THE NUT THAT SECURED THE LINKAGE WAS SO LOOSE THAT I WAS ABLE TO TURN IT WITH MY FINGER. DEALER FOUND THE NUT TO BE LOOSE AND TORQUED IT TO 40 FEET-LB PER THE MANUAL. *AK

NHTSA ID

10190852

Incident

May 3, 2007

Mileage

2,600 mi

SHIFTING FROM 1ST TO 2ND GEAR WAS ROUGH SOMETIMES. I CHECKED THE TORQUE ON BOLT OF DRIVER'S SIDE ENGINE MOUNT AND IT WAS LOOSE. IT TURNED UNDER 30 FEET-LB. BOLT WAS SUPPOSED TO BE 70-80 FEET-LB FROM THE FACTORY. AFTER BOLT WAS TIGHTENED TO SPEC SHIFTING BECAME A LOT SMOOTHER. I WAS CONVINCED THAT IF BOLT WAS NOT TIGHTENED FAILURE OF DRIVER' S-SIDE ENGINE MOUNT BOLT WOULD HAVE EVENTUALLY RESULTED IN A COUPLE THOUSAND MORE MILES. VEHICLE ONLY HAD 3000 MILES ON IT -ENGINE WOULD HAVE DROPPED OVER LEFT SIDE DRIVESHAFT, CAUSING LOSS OF CONTROL OF VEHICLE. REFER TO INVESTIGATION PE07015 . *AK

NHTSA ID

10190851

Incident

May 15, 2007

Mileage

2,000 mi