2016 Mercedes-Benz C 300 Owner Complaints

NHTSA Safety Complaint – 2016 Mercedes-Benz C300 Vehicle: 2016 Mercedes-Benz C300 | Mileage: 74,662 miles What Happened I’m filing this complaint because my 2016 Mercedes-Benz C300 suffered a sudden, complete engine failure at 74,662 miles, and I believe it’s a safety risk that deserves investigation. I’ve owned this car since 2016 and followed every recommended service interval. All available warranties were purchased and maintained. The car showed absolutely no signs of trouble before this happened. Last week before filing, I was driving normally when the check engine light came on without any prior warning — no oil pressure light, no temperature alert, nothing else. Within minutes, the engine shut off completely. The car rolled to a stop and I noticed oil leaking from the front of the engine. It was towed to an authorized Mercedes-Benz dealership, where they confirmed the engine suffered a catastrophic internal failure and needs to be fully replaced. Why This Is a Safety Concern No advance warning. The check engine light appeared only minutes before the engine died. That’s not enough time to safely exit a highway or busy road. A sudden total engine failure at speed affects steering, braking assist, and reaction time — it could easily cause a serious accident. Engine failure at 74,662 miles is not normal. A complete engine failure on a well-maintained luxury vehicle at under 75,000 miles strongly suggests a manufacturing defect or design flaw, possibly affecting other vehicles of the same model year. Oil leak at engine front. The leak observed at failure likely points to a specific component or seal failure. If this is a design weakness, other 2016 C300 owners may be at risk without knowing it. What I’m Requesting 1.Open an investigation into the 2016 Mercedes-Benz C300 for sudden engine failure and inadequate warning systems. 2.Determine whether other owners have reported similar incidents. 3.Evaluate whether a safety recall is warranted.

NHTSA ID

11739458

Incident

May 11, 2026

I’ve been driving my car since September when it was purchased I just got it from dealership 4/9/26 spent over $1100 and have been working like regular full time schedule, I wake up today 4/27/26 trying to work and car is stalling. Not sure what’s going on with these mechanics and technicians. I pay to dollar to ensure my family safety on the road here I am stuck without support due to my circumstances. Also, my car just idles the shuts off doesn’t turn mall the way on, magically a check engine light flashed then car just immediately stalled and won’t turn back over all the way.

NHTSA ID

11733961

Incident

Apr 27, 2026

Panoramic sunroof fails to open/ close evenly due to binding issue and plastic track failure. One side binds while the other moves, causing glass to tilt and jam. Risk of dangerous injury including glass shattering, sudden detachment, distraction while driving, and water intrusion affecting airbags/electronics.

NHTSA ID

11733700

Incident

Feb 27, 2026

My C300 MBZ, 2016 is experiencing the same symptoms as indicated in a recall, but my vehicle is not included in that recall. Camshaft: GENERAL REPAIR A cam is a rotating or sliding piece in a mechanical linkage used especially in transforming rotary motion into linear motion or vice versa. Cams act as a vital component to your automobile's engine. A camshaft is a shaft to which a cam is fastened or of which a cam forms an integral part. Camshafts provide power to the cams which are vital for basic engine operation. The cost of fixing this approximately $10,000 per Mercerdes dealer and estimate from Keyes Mercerdes. The Brief: Mercedes-Benz issued a recall for some model cars tied to a faulty drive shaft.T he problem not only can cause vehicles to lose power but may elevate crash risk, according to the National Traffic Safety Administration. Owners of the affected vehicles can take them to their local dealership to receive free repairs, however per MBZ corporate 2016 C300 not included? Mercedes-Benz is recalling 24,092 cars connected to a drive shaft universal joint that may break, resulting in a sudden loss of drive power.

NHTSA ID

11733625

Incident

Feb 5, 2026

I am reporting a structural failure of the rear subframe (axle carrier) on my 2016 Mercedes-Benz C300 (W205). The component is exhibiting significant internal-to-external corrosion (perforation), specifically at the suspension mounting points. Safety Impact: The vehicle is currently exhibiting unstable handling and a 'skittish' 'swerving' sensation causing the car to 'fishtail' under braking during normal braking and at highway speeds, indicating a compromise in the structural integrity of the rear axle. This poses an immediate risk of a 'loss of directional control' should the suspension components fully detach from the corroded subframe. The Structural Integrity, Loss of Directional Control, Sudden Suspension Failure, and causes extremely dangerous Safety Hazard for my family and other on the road. The corrosion has compromised the mounting points of the rear suspension, creating a risk that the axle will detach while the vehicle is in motion, leading to a catastrophic loss of control. Context: Mercedes-Benz has acknowledged this defect in previous years (2008-2015) via a 20-year extended warranty and in Service Information S135.00-P-0009A. However, they have failed to include the 2016 W205 in the safety remedy despite identical failure modes and documented safety hazards. Currently, as of April 2026, a 2024/2025 federal court ruling [XXX] v. Mercedes-Benz) allowed a class-action lawsuit to proceed specifically covering 2010–2022 models—including the2016 C300 W205—alleging the exact same manufacturing defect. A thorough inspection of the undercarriage of the vehicle shows severe corrosion to the subframe as well as a cracked hub along the drive-train shaft and differential. I have submitted photos along with this Vehicle Complaint From to document the corrosion of the subframe and other defects associated with the devices and systems that transmit power from the engine or propulsion device to the wheels such as the cracks in hubs, shafts, differentials. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM

NHTSA ID

11732985

Incident

Apr 17, 2026

A lot of times when I park even on flat surfaces my parking brake engages and It’s hell being able to leave because I have to turn the car off open the door close door start the again put in drive while my foot is on the brake and pull and push the parking brake button 4 times. Then I’m able to drive. This has been happening more frequently and there is an open recall for the parking brakes calLED ESP RECALL

NHTSA ID

11727959

Incident

Mar 10, 2026

Spontaneous explosion of sunroof while car is in motion on the expressway 83 and could have caused an accident while my daughter was driving

NHTSA ID

11719197

Incident

Feb 13, 2026

The contact owns a 2016 Mercedes-Benz C300. The contact stated that while driving approximately 20 MPH and turning the steering wheel to the right or the left, there was an abnormal clicking sound coming from the rear of the vehicle. There was no warning light illuminated. The contact had taken the vehicle to a local dealer where it was diagnosed and determined that the rear sub frame of the vehicle had severe corrosion and needed to be replaced. The contact was advised by a service technician that there had been a recall for corrosion failures, but the year and the model were not included. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 130,000.

NHTSA ID

11716937

Incident

Sep 10, 2025

Mileage

130,000 mi

Strong fuel smell in cabin Can maybe cause a fire

NHTSA ID

11716863

Incident

Jan 2, 2026

fuel lines/ clamps defective causing a fuel leak. vehicle could catch on fire and fumes are extremely strong inside the cabin. issue confirmed by Mercedes dealer, mentioned there is an extended warranty up to 120,000 miles. rejected mine because i was at 120,300 miles. had to pay out of pocket. no warning lights or anything just the really strong smell of fuel and fuel range dropping. this is a very common issue thats known and should be a recall.

NHTSA ID

11714200

Incident

Jan 28, 2026

The contact owns a 2016 Mercedes-Benz C300. The contact stated that whenever the fuel tank was full, there was a fuel-burning odor coming from the engine and entered the vehicle through the A/C vents. In addition, when the vehicle was cold, the odor was entering the vehicle through the A/C vents. No warning lights were illuminated. The vehicle was taken to a collision center specializing in foreign vehicles, where it was diagnosed that the fuel rail and injectors had a fuel leak. The vehicle was not repaired. The contact stated that the failure persisted. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 21V961000 (FUEL SYSTEM, GASOLINE). However, the VIN was not included. The contact stated that his mother owned the vehicle in the past and gave the vehicle to the contact two years ago. The contact's mother remembered receiving a recall letter; however, the contact's mother was unsure if the vehicle had been repaired in the past. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 60,000.

NHTSA ID

11708321

Incident

Oct 25, 2017

Mileage

60,000 mi

I am writing to formally report the premature failure and subsequent replacement of the electronic rack and pinion on my 2016 Mercedes-Benz C300 4Matic sedan. This repair was performed at Sears Imported Autos on 4/19/2024, at a cost of $5,840.14. Invoice number at Sears Imported Autos is XXX. My vehicle, VIN [XXX] , had only 74,427 miles at the time of the failure. The failure of a critical steering component at such a low mileage is highly unusual and, I believe, directly attributable to a latent manufacturing defect. I have recently become aware of a prior recall (NHTSA Campaign Number 18V850000) concerning the electronic power steering rack on these EXACT vehicles. While I acknowledge that my vehicle VIN was not included in the official scope of the previous NHTSA recall, the nature and timing of my component's failure strongly mirror the documented issues of MY power steering failure. Mercedes-Benz USA Customer Care Center just informed me that my VIN does NOT qualify for the recall, but they did NOT say the failure on my car was a different part. The fact that the very same exact part failed so prematurely, a component that is expected to last for the lifetime of the vehicle under normal conditions, points to a systemic quality control issue beyond the scope of the original recall. The recall should be expanded to include my VIN and likely a few others. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11705891

Incident

Apr 19, 2024

Vehicle developed OBD-II code P052E related to crankcase ventilation/PCV system malfunction. Issue causes improper crankcase pressure, rough idle, oil vapor smells, and check engine light. Independent research shows this is a common failure on 2015–2017 Mercedes C300 models. Repair requires replacement of crankcase vent/PCV assembly. This appears to be a premature emissions system failure.

NHTSA ID

11704880

Incident

Dec 5, 2025

An independent service center diagnosed my car as having a fuel leak stemming from the fuel rail and fuel injectors. This is a fire hazard due to a gas leak. There is a gas smell in the interior cabin that I noticed approximately one month ago. I believe this pertains to NHTSA ID #21V961, and I would like NHTSA to consider including my VIN in this recall.

NHTSA ID

11704054

Incident

Nov 7, 2025

My 2016 Mercedes Benz C300 started giving off funky fumes last year in 2024, now the fumes have turned into the smell of gas in 2025. Everytime that I call the dealership on Rockside Rd./ Broadway, located in Bedford Ohio, they give me an excuse as to why it's not their responsibility to correct the issue. What can I do?

NHTSA ID

11703213

Incident

Mar 4, 2024

CHECK ENGINE LIGHT appeared on dash at approximately 72k miles. Had code read and diagnosed by certified mechanic and he had an active code P06DA00(this code signifies an electrical fault, open circuit, or high resistance in the circuit for the oil pump control valve on vehicles with two stage oil pump, which can lead to incorrect oil pressure, which can cause engine damage if not addressed). Vehicle was taken to Harriman Mercedes in New York. They did not acknowledge an active code but wanted to diagnose and repair a stored code for a small evap leak, which was rectified with a new gas cap. After prying about the P06DA00 code, they finally admitted it did have a stored code but to ignore it because it had something to do with domestic and foreign car engine computers issues. How do you ignore an active code with a potentially serious engine issue and told to ignore it. I know for a fact that this is a common problem with these 2.0L engines in these cars for many years.

NHTSA ID

11699485

Incident

Nov 8, 2025

IT'S RIDICULOUS I TOOK MY CAR TO THE DEALER (MERCEDES-BENZ OF NOVI, MI) YESTERDAY 2016 MERCEDES C300 4MATIC FOR EXTENDED WARRANTY ON LOW PRESSURE FUEL HOSE AS THE CAR CABIN SMELLS LIKE GAS FUMES TO THE POINT WHERE IT GOT ME DIZZY AND NAUSEOUS AND THREW ME IN BED FOR A DAY. WHEN I ARRIVED THERE I WAS TOLD YEAH THIS IS COMMON ON THESE CARS AND WARRANTY WILL TAKE CARE OF IT. GOT A CALL LATER SAYING IT WILL NOT BE COVERED AS THE 10 YEAR EXTENDED WARRANTY SURPASSED MY CAR AS MY CAR PRODUCTION DATE IS 09/15, I WAS LIKE PLEASE ITS ONLY A COUPLE MONTH AFTER AND ITS A FIRE HAZARDOUS AND HEALTH MATTER THEY WERE LIKE NO, NOW MY CAR IS THERE AND I HAVE TO PAY THEM $850 TO CHANGE AN ISSUE THAT WAS SUPPOSED TO BE TAKEN CARE FROM THE BEGINNING FROM THE MANUFACTURER.

NHTSA ID

11699111

Incident

Nov 12, 2025

The contact owns a 2016 Mercedes-Benz C300. The contact stated that there was a gasoline odor inside and outside the vehicle on several occasions, while driving at various speeds and while parked. The contact stated that the vehicle failed to accelerate as needed. The contact stated that there was no warning light illuminated, the fuel consumption increased, with the fuel gauge lowered more quickly. The vehicle was taken to an independent mechanic who saw gasoline pooling near the fuel injector, and the coils were leaking between the fuel injector and the fuel rail, and the fuel rail or possibly the injector seals needed to be replaced. The vehicle was not repaired. The contact believed that the vehicle should be included in a recall. The manufacturer was notified of the failure. The failure mileage was approximately 98,000.

NHTSA ID

11698896

Incident

Mar 1, 2025

Mileage

98,000 mi

The contact owns a 2016 Mercedes-Benz C300. The contact stated that while driving at an undisclosed speed, the contact smelled a gasoline odor in the interior of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the fuel hose downstream of the fuel pump was leaking. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 18V837000 (Fuel System, Gasoline); but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown.

NHTSA ID

11694990

Incident

Feb 15, 2025

The contact owns a 2016 Mercedes-Benz C300. The contact stated that while at a stoplight, the energy saver START/STOP feature engaged, but the vehicle stalled and failed to restart. There were no warning lights illuminated. The vehicle was towed to an independent mechanic who determined that the START/STOP function failed to operate as designed. The mechanic informed the contact about NHTSA Campaign Number: 17V114000 (Electrical System, Engine and Engine Cooling). The local dealer was not contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 56,000.

NHTSA ID

11675352

Incident

Jul 15, 2025

Mileage

56,000 mi

Upon purchasing my 2016 C300, I starting experiencing a right pull whenever I press on the brakes. I was very concerned as I use this vehicle to assist with dropping and pick up of my 2 grandchildren. The more I drove the car, the more unsafe especially when I attempt to bring my car to a stop. I took the car to a local mechanic and I was advice to take it to a Mercedes dealership. The mechanic also advice that it was an issue with the REAR SUB FRAME. A week later I took the car in to Mercedes as suggested and a day later I received a call and video from Mercedes that the subframe was broken and that is why I am getting that hard pull whenever I brake. Mercedes also stated that the control arm bracket is barely on and it is causing the vehicle to flex.

NHTSA ID

11671654

Incident

Apr 30, 2025

Picked my 5 year old Granddaughter up from camp we had a down tornado warning and we were driving home suddenly the sunroof opens it starts raining on us I hurried and pushed the button to close it when I did it made a loud crunch noise and almost shut but stayed vented and one side is higher than the other. When you try to close it or open it it does move a like but I’m scared it will break on us

NHTSA ID

11669488

Incident

Jun 18, 2025

Positive Crankcase Ventilation Regulator Valve Performance Code P052E indicates a fault in the Positive Crankcase Ventilation Regulator Valve Performance for a predetermined.

NHTSA ID

11665952

Incident

Jun 9, 2025

While driving my 2016 Mercedes-Benz C300 on Route 12 in Utica, NY around 8:10 PM on May 29, 2025, the panoramic sunroof spontaneously exploded while in the tilted vent position. It sounded like a gunshot and sent glass raining into the cabin, causing multiple cuts to my hand, ear, arm, and lower back while I was driving. The shock nearly caused me to lose control of the vehicle. Conditions were clear and dry, around 60°F, and I was driving about 50–55 mph. I have reported the incident to Mercedes-Benz USA (Case #14443457). This is a serious safety hazard, and I am concerned about residual glass in the vehicle’s ventilation system and potential future injuries. I am also concerned about paint and interior damage from the explosion.

NHTSA ID

11663900

Incident

May 29, 2025

While driving, my vehicle suddenly shut down in the middle of traffic without any prior warning. I was left stranded in the hot sun, fearing for my safety and praying that I wouldn’t be rear-ended. The incident was not only terrifying but also unacceptable for a vehicle of this caliber. I contact Mercedes customer service. I spoke to a representative name Stephanie. She called the Mercedes dealership service department in Columbus, Ga and received confirmation that my car did shut completely down on me without warning. Stephanie stated she will notate the incident. I told her there should be more than just a notation because this put me in grave danger, not only was my life in jeopardy this is a serious potential threat to others.

NHTSA ID

11662614

Incident

May 19, 2025