RoadVitals

1996 Mercedes-Benz E Class Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Apr 7, 2009
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

09E012000

EXTERIOR LIGHTING

Apr 7, 2009
16,270 units potentially affected
The defect: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
SABERSPORTView on NHTSA.gov
96V058000

ENGINE AND ENGINE COOLING:ENGINE

Apr 4, 1996
149 units potentially affected
The defect: THE DRIVE BELT PULLEY ON THE ENGINE CAN DEVELOP FATIGUE CRACKS IN THE METAL AND BREAK. IF THE DRIVE PULLEY BREAKS, THE CAR WOULD NOT HAVE ENGINE COOLING, BATTERY CHARGING, AND/OR POWER STEERING.
The risk: LOSS OF THESE SYSTEMS CAN CAUSE THE CAR TO OVER HEAT, LOSE POWER FROM THE BATTERY, AND LOSS OF CONTROL OF THE CAR INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The remedy: DEALERS WILL REPLACE THE ENGINE CRANKSHAFT DAMPER-PULLEY ON THESE VEHICLES.
MERCEDES-BENZ USA, INC.Manufacturer number 96-0413View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE07021ClosedPreliminary Evaluation

FRONT SUSPENSION COIL SPRING EJECTION

Opened Apr 19, 2007
Closed Aug 9, 2007

ODI HAS FOCUSED THIS INVESTIGATION ON ASSESSING THE RISKS POSED BY A SEPARATED SPRING AS (1) A ROAD HAZARD AND (2) THE POTENTIAL FOR VEHICLE CONTROL TO BE COMPROMISED AFTER THE FRONT COIL SPRING HAS BEEN EJECTED FROM ITS INTENDED POSITION IN THE VEHICLE.BOTH RISKS ARE ASSOCIATED WITH CORROSION, FLEXING, AND FRACTURE OF THE UPPER FRONT SUSPENSION MOUNTING BRACKET.TIME-IN-SERVICE FAILURE RATES ARE NOTABLY HIGHER IN SALT BELT STATES SINCE CORROSION IS A PRIMARY CONTRIBUTOR TO THE FAILURE MODE.SINCE A NUMBER OF INCIDENTS HAVE OCCURRED WHILE THE VEHICLE WAS BEING OPERATED, ODI IS SKEPTICAL THAT OWNERS CAN ALWAYS DETECT THE SUBTLE SIDE TO SIDE DIFFERENCE IN RIDE HEIGHT AND/OR INSPECT OR NOTICE THAT THE UPPER SUSPENSION BRACKET HAS BEEN COMPROMISED BY CORROSION.(1) ROAD HAZARD - ALTHOUGH THE (APPROX. 7 LB.) FRONT SUSPENSION SPRING THAT MAY BE EJECTED AT HIGHWAY SPEEDS COULD POSE A SERIOUS ROAD HAZARD TO PEDESTRIANS AND OTHER VEHICLES, THE OCCURRENCE RATE HAS BEEN LOW (.03% BASED ON 51 REPORTED INCIDENTS OCCURRING AND AN INITIAL POPULATION OF 172,781 VEHICLES AFTER 9 - 12 YEARS OF USE / EXPOSURE) AND THERE ARE NO KNOWN INJURIES, FATALITIES, OR PROPERTY DAMAGE REPORTS DUE TO AN EJECTED SPRING.ALSO, MANY OF THE 51 INCIDENTS OCCURRED AT LOW SPEED OR WHILE THE VEHICLE WAS STOPPED OR PARKED.(2) VEHICLE CONTROL - VEHICLE HANDLING AND CONTROL COULD BE AFFECTED BY THE FRACTURE OF THE UPPER SUSPENSION MOUNT AND/OR THE ASSOCIATED SPRING EJECTION.ODI FIRST IDENTIFIED ITS CONCERN ABOUT CORROSION IN THE UPPER SUSPENSION BRACKET OF SUBJECT VEHICLES IN 2002, AT WHICH TIME MERCEDES PROVIDED A VIDEO THAT SHOWED THAT A VEHICLE COULD BE STEERED, STOPPED, AND CONTROLLED THROUGH VARIOUS MANEUVERS AT HIGH SPEEDS WITH A FRONT COIL SPRING COMPLETELY MISSING FROM THE VEHICLE. DURING PE07-021, IN ADDITION TO REVIEWING THE 2002 VIDEO-TAPE, ODI ENGINEERS DROVE AN EXEMPLAR VEHICLE WITH THE SPRING REMOVED AND SIMULATED VARIOUS COMBINATIONS OF STEERING ANGLES TO ASSESS WHETHER THERE WERE ANY POSSIBLE CONDITIONS / DISPLACEMENTS IN WHICH THE SEPARATED SPRING MIGHT INTERFERE WITH THE WHEELS. IN A VEHICLE WITH THE FRONT SPRING REMOVED, THE TOP OF THE WHEEL CAN LIGHTLY CONTACT THE BOTTOM AREA OF THE WHEEL FENDER DURING HIGH ANGLE TURNS TYPICALLY ASSOCIATED WITH SLOWER SPEED MANEUVERS SUCH AS CITY DRIVING. THE LIGHT TIRE CONTACT GENERATED AN OBVIOUS GRINDING NOISE AND WOULD LIKELY ABRADE OR BEND THE EDGE OF THE FENDER WITH CONTINUED USE.HOWEVER, THE EXTENT OF THE INTERFERENCE WAS NOT SUFFICIENT TO AFFECT VEHICLE STEERING AND DOES NOT OCCUR AT SMALLER TURNING ANGLES ASSOCIATED WITH HIGHWAY DRIVING.ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF FUTURE CIRCUMSTANCES WARRANT.

SUSPENSION:FRONT:SPRINGS:COIL SPRINGS

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .