2005 Mercedes-Benz E Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Mercedes-Benz E, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system360.0%
- Airbags120.0%
- Brakes120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FILLED FUEL TANK , CAME HOME ,PARKED IN GARAGE AND NOTICED A STRONG FUEL SMELL. FUEL WAS LEAKING ON FLOOR AND I HAVE TO LEAVE IT OUTSIDE NOW. *TR
I RECENTLY BOUGHT A USED 2005 MERCEDES E320 WITH 126.3K MILES. AT TIME OF TRANSACTION, CAR HAD HALF A TANK OF FUEL ONLY. COUPLE DAYS LATER, WHEN I WENT TO REFUEL, I FILLED UP TANK ALL THE WAY TO TOP, I DROVE HOME AND AS SOON AS I EXITED CAR, I COULD SMELL A VERY STRONG ODOR OF GASOLINE INSIDE CAR AND INSIDE LEFT REAR WHEEL WELL. I INSPECTED THE CAR AND AFTER LIFTING REAR SEAT CUSHION, I OPENED THE COVERS TO GAS TANK TO FIND THERE WAS A FUEL LEAK AT THE FUEL SENDING UNIT, DRIVER'S SIDE, ABOUT 1-2 OUNCES OF FUEL. TODAY I PURCHASED AN UPDATED NEW FUEL SENDING UNIT FROM MB DEALER AND WILL NEED TO GET IT INSTALLED. WHEN TANK IS THREE QUARTER FULL OR LESS, YOU DON'T SMELL THE ODOR AND NO SIGN OF LEAK IS PRESENT. THIS APPEARS TO BE A COMMON PROBLEM AMONG MERCEDES E-CLASS. I'VE LEARNED THIS THRU MY MOST RECENT ONLINE SEARCH. I'M SO DISAPPOINTED IN MERCEDES BENZ FOR THIS POOR MANUFACTURING. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
SRS SYSTEM MALFUNCTION. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
WHILE DRIVING AT APPROXIMATELY 50 MPH, THE SBS SYSTEM WARNING LIGHT CAME ON ALONG WITH LOSS OF MOST BRAKING ABILITY. I MANAGED TO STOP THE CAR, TURN AROUND AND RETURN ABOUT 8 MILES TO MY HOME IN "LIMP HOME" MODE. THERE WAS NO WARNING WHATSOEVER. I THEN CALL THE MB DEALERSHIP WHICH SENT A TRUCK TO PICK UP THE CAR. THE SBS HYDRAULIC UNIT HAD FAILED AND WAS REPLACED UNDER EXTENDED WARRANTY AT NO COST. WHILE I AM NOT COMPLAINING ABOUT THE COST (NONE), THE FAILURE COULD HAVE CAUSED AN ACCIDENT WITH THE LOSS OF BRAKE ABILITY. I TAKE ROAD TRIPS TO THE COLORADO MOUNTAINS AND IF THIS HAD HAPPENED THERE, I COULD HAVE SUFFERED A FATAL INJURY. THIS SYSTEM IS DEFECTIVELY ENGINEERED AND SHOULD BE REPLACED ON ALL MERCEDES CARS SO EQUIPPED. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .