2006 Mercedes-Benz E350 Fuel system Problems

PZEV fuel tank leaks at top but is not repairable. Replacement requires complete tank replacment which is not economically feasilble. This forces owners to continue to operate vehicle with fuel leakage since repair of the tank is not possible. In older models a simple gasket change would resolve such leaks, in the PZEV tank leaks can not be repaired and thus are left uncorrected. Many of these vehicles are now owned by minority owners who are unable to pay $5000 to repair a defective design. MB refuses to support owners.

NHTSA ID

11512596

Incident

Mar 13, 2023

I recently started smelling gas in my car after refueling. I was told by my mechanic that Mercedes was replacing fuel pumps and fuel tanks free of charge . Mercedes Benz customer care has advised this isn't so. This is an expensive repair and I am hoping Mercedes Benz can cover the cost of this repair and if not, offer substantial assistance.

NHTSA ID

11497476

Incident

Dec 14, 2022

In June 2017, I received a letter from Mercedes-Benz of America informing me that the warranty of the fuel system in my vehicle is extended to 15 years. In that same year, I had my whole fuel tank replaced by an authorized Mercedes Benz dealer in San Jose, California due to strong smell of fuel by the rear wheel well on the driver side of the car. The repair was fully cover by MB-America under this extended warranty. On November 3, 2022, I experienced the same fuel smell from the same place of the car (i.e., driver side rear wheel well) and was told that the repair will not be cover at all, even though the fuel system in my car is only 5 years old. I am writing to suggest that you impose a 15 years warranty on the fuel leak replacement parts. MB needs to stand behind their product if it was their OEM parts and done by their authorized dealer. In my case the new fuel smell was due to a cracked Fuel Pump Assembly (Part # 211 470 60 94) which was found in the brand new fuel tank installed in my car in 2017. My car is now repaired at a local shop at a fraction of the cost that MB-San Jose would have charged me. My hope is for you to help future similar customers who will experience similar issue avoiding this unjust expense. Thank you very much, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11493193

Incident

Nov 3, 2022

THE CAR WOULD NOT START AS THE FUEL PUMP WAS FAULTY AND IS PART OF THE TANK DESIGN. MBZ KNEW OF THE PROBLEM BECAUSE THEY REPAIRED OR REPLACED SOME OF THE CARS BUT I WAS NEVER NOTIFIED TILL THE PROBLEM. IT COST ME UNDER $3,800 TO REPAIR AND REPLACE THE GAS TANK EVEN THOUGH THEY REPAIRED A LOT OF CARS. MY REPAIR WAS FINISHED ON 05/14/18. I PAID $3,409.33 FOR THE REPAIR AND I WANT TO BE REIMBURSED FOR IT. I FILED A COMPLAINT BACK IN 05/31/2018 UNDER THE COMPLAINT NUMBER [XXX]. I NEED HELP TO GET MY MONEY BACK. THIS WAS A BAD DESIGN ON THEIR PART. THANK YOU, [XXX] THE CAR WOULD NOT START FUEL PUMP FAULTY AND IS PART OF GAS TANK BAD DESIGN COST ME CLOSE TO $3800, SOME PAID BY MBZ. MBZ REPLACED 2009 GAS TANKS FOR FREE UNDER WARRENTY BUT WOULD NOT DO MINE. THIS IS A BAD DESIGN THEY SHOULD HAVE TOLD ME ABOUT IT SO I WOULD NOT BUY THE CAR. IT IS STUPID TO HAVE TO REAPLCE GAS TANK IN ORDER TO REPLACE A FUEL PUMP IN 2012 I HAD GAS LEAKAGE FROM THE SAME AREA AND I PAID TO FIX IT THEY SHOULD HAVE TOLD ME THIS WOULD BE A PROBLEM. INSTEAD THEY KEP SILENT WHEN I TAKE MY CAR FOR SERVICE THEY ALWAYS LIST OF THINGS TO DO SO I CAN SPEND MORE MONEY AT THE DEALERSHIP WHY THE [XXX]NO BODY BOTHERED TO TELL ME ABOUT THIS PROBLEM THAT IT WOULD COST ME A LOT OF MONEYTO FIX . THIS CAR HAS COST OVER $60,000 TO BUY AND I DID NOT PAY THAT KIND OF MONEY FOR A CAR TO LAST ME ONLY 12 YEARS. MBZS ARE SUPPOSED TO LAST 30 YEARS OR MORE SO IFEEL CHEATED BIG TIME I THINK THEY ARE HIDING THIS BECAUSE THEY WILL GET SUED BIG TIME AND I HOPE THEY DO BOTHE THE DEALERSHIP AND THE MBZ COMPANY. THE DEALERSHIP IS MERCEDES BENZ OF VALENCIA IN VALENCIA, CA 91355. PHONE NUMBER 661-753-5555. I HAVE THE NECESSARY PAPERWORK. I WOULD LIKE TO BE REIMBURSED FRO ALL THE COST, THE 3 WEEKS WITHOUT A CAR AND FRO THE PAIN AND SUFFERING THEY HAVE CAUSED ME AND SO IT WILL BE A LESSON TO MBZ AND THEIR DEALERS NOT TO PRATICE THIS FRAUD. I AM AVAILABLE FOR AN INTERVIEW OR MORE INFORMATION AS NEEDED. REGARDS, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT

NHTSA ID

11480254

Incident

Apr 30, 2018

The contact owns a 2006 Mercedes-Benz E350. The contact stated that while the vehicle parked, fuel was noticed leaking from the vehicle onto the driveway. The vehicle was not diagnosed or repaired. The approximate failure mileage was 184,000.

NHTSA ID

11452787

Incident

Oct 4, 2021

Mileage

184,000 mi

Noticed strong gasoline odor in left rear wheel well after filling the vehicle with fuel. Since the vehicle had just been repaired for an unrelated issue at a local Mercedes dealer, I took it back to them for troubleshooting. They diagnosed the problem as a leak at the seal on the fuel pump in the tank. I researched this issue and found it is a recurring problem for which Mercedes had offered a warranty extension of 15 years. This extension expired for my vehicle in July 2020. Cost to repair was $3,256 as after a 10% discount. I was not informed of this issue or the extended warranty despite having the vehicle serviced at Mercedes dealers multiple times since purchasing it in 2008.

NHTSA ID

11445710

Incident

Dec 7, 2021

Leaking fuel tank and gaskets. A strong smell of fuel internally in the vehicle and externally with a full tank of fuel. Mercedes Benz Warrantee extension PE#12001 "Covered Fuel Tank Components." Mercedes Benz denied claim because of PZEV vs non-PZEV type of vehicle. Both vehicles PZEV and non-PZEV, both use the same plastic gas tank, sending units, and fuel pump in their respective vehicles. How did NHTSA agree to cover non-PZEV vehicles only.

NHTSA ID

11427304

Incident

Jul 14, 2021

The contact owns a 2006 Mercedes-Benz E350. The contact stated while the vehicle was stationary, she started to smell an abnormal fuel odor from the rear driver’s side seat. The contact stated there was no warning light illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the fuel level sending unit and the seals and gaskets to be replaced. The vehicle was repaired however, the failure recurred. The contact stated that she was unable to continue driving the vehicle due to odor. The contact towed the vehicle to another local dealer, Mercedes-Benz of Myrtle Beach (936 Jason Blvd, Myrtle Beach, SC 29577, (843) 848-6800) where it was diagnosed with needing the fuel tank, fuel pump, fuel line and all the seals and gaskets needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 104,000.

NHTSA ID

11421151

Incident

Sep 1, 2011

Mileage

104,000 mi

I NOTICED THAT ANOTHER OWNER OF A 2006 E350 NOTED THAT HE/SHE HAD A FUEL LEAK. I HAVE HAD ONE, TOO. THE EXTENDED WARRANTEE RAN OUT IN 2020, SO MERCEDES WOULDN'T COVER THE REPAIR EXPENSES. BUT IF THEY KNEW FOR 15 YEARS THAT THIS WAS A PROBLEM, THEY SHOULD HAVE RECALLED THE CARS. AND IF THEY AREN'T GOING TO RECALL IT, THEY SHOULD COVER REPAIR EXPENSES. THIS IS A SERIOUSLY DANGEROUS SITUATION. IT'S LIKELY THAT OUR TANK HAS BEEN LEAKING FOR A WHILE. WE'VE SMELLED GAS FOR ABOUT A YEAR, BUT DIDN'T REALIZE IT WAS LEAKING UNTIL RECENTLY WHEN THERE WAS A CLEAR PUDDLE IN THE GARAGE.

NHTSA ID

11406404

Incident

Mar 25, 2021

VEHICLE HAS LESS THAN 50K MILES, WE STARTED NOTICING AN INTERMITTENT STRONG FUEL SMELL IN THE CABIN IN THE SPRING OF 2020. WE FOUND OUT THAT THIS IS A KNOWN ISSUE AND MERCEDES HAD ISSUED AN EXTENDED WARRANTY DUE TO THIS ISSUE. UNABLE TO GET THE VEHICLE TO THE DEALER DUE TO COVID. WHEN WE DID GET IT DIAGNOSED RECENTLY, WE WERE INFORMED THE REPAIR WOULD EXCEED $3400 AND WE WERE OUT OF THE WARRANTY PERIOD. THE REPAIR CONSISTS OF REPLACING THE FUEL TANK AND FUEL SYSTEM COMPONENTS. MERCEDES BENZ NA HAS OFFERED US A $400 DEALER SERVICE CREDIT. WE CANNOT AFFORD TO DO THIS REPAIR AND THEREFORE HAVE A VEHICLE WE ARE UNABLE TO SAFELY OPERATE. WE HAVE READ REPORTS ONLINE OF THIS ISSUE WHERE FUEL IS SITTING ON TOP OF THE FUEL TANK RIGHT BELOW THE REAR PASSENGER SEATS.

NHTSA ID

11399089

Incident

Feb 24, 2021

Mileage

47,500 mi

THERE IS FUEL LEAKING AND FLOODING ON TOP OF THE DRIVER SIDE FUEL SENDER UNIT UNDERNEATH THE REAR DRIVER SIDE SEAT WHERE IT IS LOCATED AT THE FUEL TANK. THIS WAS PREVIOUSLY A NHTSA FUEL LEAK INVESTIGATION FOR THESE WITH THE 2003-2008 E CLASS VEHICLES WHICH WAS LATER CLOSED DUE TO A RECALL BEING ISSUED. MY VIN DOES NOT SEEM TO BE PART OF THE RECALL GROUP, HOWEVER, THE PROBLEM REMAINS THE SAME AS EVERYTHING DETAILED IN THE REPORT AND FINDINGS OF THE INVESTIGATION DONE BY THE U. S. DEPARTMENT OF TRANSPORTATION NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION FOR REPORT VRTC-DCD-3206 EA13-003 IN DEC 2014. (ALSO ATTACHED). THE FUEL SEAPS OUT TO THE TOP OF THE SENDING UNIT DUE TO A FAILED PRESSURE SENSOR OR OTHER PART IN THE SYSTEM WHEN THE TANK IS FULL. WHEN THE TANK IS LATER LESS FULL AS A RESULT OF CONSUMPTION, THERE IS NO LONGER AN ISSUE WITH FUEL SPILLING OUT OF THE TOP AND FUMES GETTING INTO THE CABIN. VIDEO OF THE AREA WIPED SHOWS HOW IT IMMEDIATELY RETURNS TO THE TOP. THE PHOTO ATTACHED IS OF THE FUEL COMING BACK AFTER BEING WIPED UP.

NHTSA ID

11374592

Incident

Oct 17, 2020

Mileage

106,885 mi

EXTREME SMELL OF FUEL WHEN MAKING SHARP OR EXTENDED TURNS (FREEWAY ON/OFF RAMPS). ESPECIALLY, WHEN FULL TANK IS FULL. CALLED LOCAL DEALER AND MBUSA WAS TOLD THIS IS NOT COVERED UNDER THE 15 YEAR ' FUEL LEAK' EXTENDED WARRANTY! PLEASE NOTE THE PUDDLING OF FUEL NEAR THE BOTTOM OF WIRE HARNESS IN PICTURE ATTACHED.

NHTSA ID

11363069

Incident

Mar 10, 2019

Mileage

120,000 mi

THIS VEHICLE IS A THREAT TO MY HEALTH WITH ALL THE PROBLEMS I'M HAVING WITH IT. I HAVE TO PRESS EXTRA HAD TO STOP . HAD BRAKES CHECKED AND THERE WAS NO PROBLEM. THERE IS A BAD GASOLINE LEAK AND LOUD SMELL OF GAS WHEN I FILL UP. LOOKED UNDER REAR SEAT AND SAW GAS ON GAS TANK. DRIED GAS UP AND THE BIG PUDDLE RETURNED. CAN I DRIVE THIS CAR? I NEED SOMEONE TO TELL ME WHAT TO DO. THE LAST AND MOST WORRISOME THING TO ME IS THAT THERE ARE 2 DTC CODES COMING UP CAUSING THE CHECK ENGINE LIGHT TO COME ON. HAD MECHANIC TO CLEAR THEN BUT THEY COME RIGHT BACK WHEN CAR IS STARTED. I NEED TO GET THIS CAR INSPECTED. SOMEONE TELL ME WHAT TO DO. MECHANIC SAID THAT THE CODE INDICATE A PROBLEM WITH THE ENGINE AND THAT IT MIGHT TAKE $8700 TO REPAIR EVERY THING. I DONT HAVE THAT TYPE OF MONEY. THIS IS THE CAR MAKERS PROBLEM. WHO IS LOOKING OUT FOR ME. IS THE GOVERMENT DOING THERE JOB WHEN IT COMES TO THIS CAR. HEARD THERE ARE MORE CARS LIKE THIS. OH THIS IS A 2006 MERCEDES E350. WILL THE GOVERMENT, DEALER OR MANUFACTURER BUY THIS CAR FROM ME. THIS IS A PLEA FOR HELP FROM ANYWHERE. THEY SAY THERE IS A RECALL ON THIS CAR BUT WHEN IT CAME OUT THERE WAS 1 YEAR LEFT ON CAR WARRANTY BEFORE IT RAN OUT. THE CAR DIDN'T QUIT RUNNING WHEN THE STALLING TO REPAIR THESE CARS TOOK PLACE. SOME ONE IS IN SOMEONES BACK POCKET. SOMEONE NEEDS TO DO THEIR JOB AND GET THIS PROBLEM TAKEN CARE OF ONCE AND FOR ALL. YOU MAY LOSE SOME FRIENDS IN THE PROCESS BUT THIS IS BETTER THAN SOMEONE LOSING THEIR LIFE. THIS VEHICLE HAS HAAD PROBLEMS STATIONARY AND WHILE MOVING.

NHTSA ID

11310454

Incident

Dec 20, 2019

Mileage

154,000 mi

CAR HAD QUARTER TANK WHEN BOUGHT. DROVE OUT GAS AND PUT ABOUT ANOTHER QUARTER TANK OF GAS IN. DROVE THIS OUT. SMELLED NO FUMES. FILLED TANK UP. HAVE SMELLED LOUD GAS SMELL FOR 1 WEEK NOW.

NHTSA ID

11299956

Incident

Jan 7, 2020

Mileage

157,451 mi

REGARDLESS OF VEHICLE MOVEMENT GAS LEAK FROM FUEL TANK LOCATED UNDER BACK SEAT ABOVE EXHAUST SYSTEM. CONSTANT GAS SMELL, AND FUEL GAUGE ALWAYS JUMPING UP AND DOWN AGAIN REGARDLESS OF MOTION. CHECK ENGINE LIGHTS INDICATE FAULTY COOLANT TEMPERATURE SENSOR, AND FAULTY FUEL LEVEL SENSOR. DEALERSHIP IS REFUSING TO COVER TANK ASSEMBLY REPLACEMENT UNDER PZEV WARRANTY OF 15YRS / 150,000 MILES IN STATE OF CALIFORNIA. VEHICLE IS 2006, WITH 109K MILES. DOCUMENTATION OF TROUBLE CODES NOT AVAILABLE AT TIME OF REPORTING, BUT CAN BE PROVIDED UPON FUTURE REQUEST. FUEL RUNS DOWN THE SIDE OF THE TANK NARROWLY MISSING THE EXHAUST, POTENTIAL FIRE HAZARD.

NHTSA ID

11286778

Incident

Nov 1, 2019

MY 2006 MERCEDES BENZ E350 HAS A STRONG ODOR OF GASOLINE, PARTICULARLY STRONG AFTER FILLING THE TANK. MY UNDERSTANDING IS THAT THERE WAS A NHTSA INVESTIGATION INTO THIS PROBLEM IN THE PAST AND THE MANUFACTURER AGREED TO EXTEND THE WARRANTY TO REPAIR THE PROBLEM WHICH RESULTED IN NHTSA CLOSING THE PROBE. I CONTACTED MY LOCAL DEALERSHIP REGARDING THIS PROBLEM AND THEY INDICATED THAT THE WARRANTY IS NOT EXTENDED. THIS IMPLIES THAT THE MANUFACTURER IS NOT COMPLYING WITH THEIR AGREEMENT OR THE PROBE SHOULD BE REOPENED?

NHTSA ID

11286681

Incident

Dec 3, 2019

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2006 MERCEDES-BENZ E350. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL. THE FUEL FROM THE FUEL SENDING UNIT WAS LEAKING AND THERE WAS A POOL OF FUEL UNDERNEATH THE REAR SEAT OF THE VEHICLE, WHICH LEAKED INTO THE REAR SEATS. THE CONTACT ALSO SMELLED A FUEL ODOR THROUGHOUT THE VEHICLE AND NOTICED A DRIED FUEL FILM ON TOP OF THE VEHICLE'S ACCESS PANEL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO MERCEDES-BENZ OF WEST COVINA (2010 E GARVEY AVE S, WEST COVINA, CA 91791, 626-859-1200). THE CONTACT INFORMED THE DEALER OF AN ARTICLE FROM NHTSA THAT STATED THEY WOULD OFFER AN EXTENDED WARRANTY (P-BQ-FUEL-3WA) TO THEIR CONSUMERS REGARDING THIS DEFECT. THE MANUFACTURER REFUSED TO COVER THE VEHICLE BECAUSE THE SPECIFIC DEFECT PART WAS NOT COVERED UNDER THE WARRANTY. THE CONTACT WAS PROVIDED A QUOTE FOR THE REPAIR OF THE DEFECTIVE PART. THE MANUFACTURER AGREED WITH THE CONTACT THAT THE DEALER SHOULD COVER THE VEHICLE UNDER THE WARRANTY; HOWEVER, THE CONTACT WAS INFORMED THAT THE LOCAL DEALER REFUSED TO HONOR THE WARRANTY AND HAD THE RIGHT TO REFUSE THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 147,647.

NHTSA ID

11253433

Incident

Aug 31, 2019

Mileage

147,647 mi

FUEL PUMP LEAKING FUMES (AND FUEL?). WHILE PARKED AND PREPARING TO COME HOME THE FUEL PUMP FAILED AND THE CAR REFUSED TO START. IT WILL NOT BE REPAIRED UNLESS IT IS UNDER THE EXTENDED WARRANTY. I AM TRYING TO LEARN IF IT WILL BE COVERED UNDER A EXTENDED WARRANTY.

NHTSA ID

11101525

Incident

May 31, 2018

Mileage

155,600 mi

THE CAR WOULD NOT START FUEL PUMP FAULTY AND IS PART OF GAS TANK BAD DESIGN COST ME CLOSE TO $3800, SOME PAID BY MBZ. MBZ REPLACED 2009 GAS TANKS FOR FREE UNDER WARRANTY BUT WOULD NOT DO MINE. THIS IS A BAD DESIGN THEY SHOULD HAVE TOLD ME ABOUT IT SO I WOULD NOT BUY THE CAR. IT IS STUPID TO HAVE TO REPLACE GAS TANK IN ORDER TO REPLACE A FUEL PUMP IN 2012 I HAD GAS LEAKAGE FROM THE SAME AREA AND I PAID TO FIX IT THEY SHOULD HAVE TOLD ME THIS WOULD BE A PROBLEM. INSTEAD THEY KEPT SILENT WHEN I TAKE MY CAR FOR SERVICE THEY ALWAYS LIST OF THINGS TO DO SO I CAN SPEND MORE MONEY AT THE DEALERSHIP WHY THE [XXX] NO BODY BOTHERED TO TELL ME ABOUT THIS PROBLEM THAT IT WOULD COST ME A LOT OF MONEY TO FIX . THIS CAR HAS COST OVER $60,000 TO BUY AND I DID NOT PAY THAT KIND OF MONEY FOR A CAR TO LAST ME ONLY 12 YEARS. MBZS ARE SUPPOSED TO LAST 30 YEARS OR MORE SO IFEEL CHEATED BIG TIME I THINK THEY ARE HIDING THIS BECAUSE THEY WILL GET SUED BIG TIME AND I HOPE THEY DO BOTH THE DEALERSHIP AND THE MBZ COMPANY. THE DEALERSHIP IS MERCEDES BANZ OF VALENCIA IN VALENCIA, CA 91355. PHONE NUMBER 661-753-5555. I HAVE THE NECESSARY PAPERWORK. I WOULD LIKE TO BE REIMBURSED FRO ALL THE COST, THE 3 WEEKS WITHOUT A CAR AND FRO THE PAIN AND SUFFERING THEY HAVE CAUSED ME AND SO IT WILL BE A LESSON TO MBZ AND THEIR DEALERS NOT TO PRATICE THIS FRAUD. I AM AVAILABLE FOR AN INTERVIEW OR MORE INFORMATION AS NEEDED. REGARDS, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11099075

Incident

May 14, 2018

Mileage

168,870 mi

TL* THE CONTACT OWNS A 2006 MERCEDES-BENZ E350. WHILE DRIVING VARIOUS SPEEDS, THE "REDUCE BRAKING POWER" WARNING MESSAGE DISPLAYED. THE CONTACT STATED THAT THE SENTRO SONIC BRAKE CONTROL UNIT FAILED. IN ADDITION, THE FUEL TANK UNDER THE DRIVER'S SEAT FRACTURED AND SPILLED FUEL IN THE VEHICLE. CENTENNIAL IMPORTS IN PENSACOLA, FLORIDA WAS MADE AWARE OF THE FAILURE AND DIAGNOSED THAT THE SENTRO SONIC BRAKE CONTROL UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 104,000.

NHTSA ID

11074980

Incident

Jan 14, 2018

Mileage

104,000 mi

FUEL SMELL INSIDE CABIN. WAS TOLD FULLY COVERED ON EXTENDED WARRANTY DUE TO TSB NO. P-47-10-63 PARTS COVERED ARE FUEL TANK, FUEL FILTER/SENDER, FUEL PUMP, GASKET, SEALS AND RETENTION RINGS. DEALER CALLS TO SAY IT IS THE FUEL SENSOR AND IS NOT COVERED! AND COST IS 1400.00. FUEL SENSOR IS SITTING ON TOP OF THE FUEL FILTER/SENDER AND IS PLUGGED INTO IT!!! HOW CAN YOUR AGENCY ALLOW MB TO SKIRT COVERING SUCH A CLOSELY RELATED PART IN THIS SAFETY INVESTIGATION BY THE ODI????

NHTSA ID

11062863

Incident

Jan 15, 2018

AFTER REFUELING MY MERCEDES W211 I GETTING FUEL LEAK FRO THE FUEL PUMP. I FOUND A INFO THAT NHSA CLOSED CASE 2014 BECAUSE MERCEDES EXTENDED WARRANTY FOR 25 YEARS REGARDLESS ON MILEAGE. THEY ARE TELLING THAT IS NOT FOR MY CAR. BUT I HAVE ISSUE LIKE ALL THOSE CARS: PLASTIC PUMP COVER IS CRACKED AND FUEL IS LEAKING FROM THE TOP OF PUMP AND RUNNING OUTSIDE. LOOKS LIKE TOTAL SCAM FROM MERCEDES SIDE. THEY TELLING THAT MY TANNK IS DIFFERENT AND NOT COVERED BY THAT EXTENDED WARRANTY, BUT LEAK IS FROM THE PUMP AND THERE IS TONS COMPLAINS ABOUT SAME ISSUE FROM THPSE TANKS TOO. FOR ME LOOKS THAT THEY EXTENDED WARRANTY ON CHEAPER REPAIR TANKS AND NOT FIXING EXPENSIVE ONES WITH SAME ISSUES. PLEASE, PLEASE HELP ME BECAUSE THEY WANNA CHARGE ME 4200$ FOR THIS REPAIR AND NOT FIXING UNDER EXTENDED WARRANTY.

NHTSA ID

11025071

Incident

Sep 7, 2017

Mileage

100,000 mi

MY MERCEDES BENZ E350 2006 FAILED TO START INTERMITTENTLY DUE TO FUEL PUMP FAILURE. MY CAR WAS HIT BY AN UNINSURED MOTORIST, SINCE THEN, MY CAR BECAME UNRELIABLE TO START, MY CAR FALLS INTO A METAL TYPE OF FUEL TANK. THERE WAS A RECALL #08V303000 WHICH STATES THAT IN THE EVENT OF VEHICLE CRASH, THE ELECTRICAL FUEL PUMP MAY FAIL TO DELIVER THE NEEDED FUEL TO START THE ENGINE, BUT MY VIN IS NOT ON THE LIST, HOWEVER, DURING INVESTIGATION EA 13-003 FOR FUEL SYSTEM, WARRANTY HAS BEEN EXTENDED TO 15 YEARS, WARRANTY HAS BEEN EXTENDED TO 15 YEARS WITH UNLIMITED MILES FOR THE FUEL PUMP ON THE SUBJECT VEHICLE. PENSKE REFUSE TO HONOR THE REPLACEMENT OF MY FUEL TANK BECAUSE ACCORDING TO THE ASST. SERVICE MANAGER, THE WARRANTY ONLY AFFECT ON THE PLASTIC TYPE OF FUEL TANK. IS THIS REALLY TRUE? MY CAR HAS 161,927 MILES AND HE SAID THE METAL TYPE FUEL TANK CAN ONLY BE REPLACED 150,00 OR BELOW. BY THE WAY, IN ORDER REPLACE THE FUEL PUMP, THE WHOLE FUEL TANK SHOULD BE REPLACED BECAUSE MERCEDES BENZ SYSTEMATICALLY INTEGRATED AND REDESIGNED THE WHOLE FUEL PROPULSION TO AVOID THE NAGGING PROBLEM OF AVOIDING THE NAGGING PROBLEM OF FUEL LEAK FROM FUEL PUMP. PLEASE, I NEED YOUR ADVICE ON THIS MATTER WHETHER IF THE METAL TYPE OF FUEL TANK OF 2006 MERCEDES BENZ E350 IS NOT INCLUDED IN 15 YEARS WARRANTY WITH UNLIMITED MILEAGE.

NHTSA ID

11021840

Incident

Jun 20, 2017

Mileage

161,580 mi

TL* THE CONTACT OWNS A 2006 MERCEDES BENZ E350. THE CONTACT STATED THAT A STRONG FUEL ODOR WAS PRESENT INSIDE AND OUTSIDE THE VEHICLE. THE CONTACT STATED THAT THE FAILURE OCCURRED WHEN THE VEHICLE WAS REFUELED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL TANK, PUMP AND CONNECTORS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONATACTED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE, THEY INFORMED THE CONTACT THAT HER VIN WAS NOT INCLUDED IN THE SCOPE OF THERE INVESTIGATION (EA13003). NO ADDITIONAL ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.

NHTSA ID

11006356

Incident

Jul 14, 2017

Mileage

95,000 mi

TL* THE CONTACT OWNS A 2006 MERCEDES-BENZ E350. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR IN THE VEHICLE AFTER THE VEHICLE WAS REFUELED. THE WALTERS MERCEDES-BENZ DEALER WAS CONTACTED AND CONFIRMED THAT IT WAS KNOWN ISSUE WITH THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.

NHTSA ID

11004881

Incident

Apr 1, 2017

Mileage

150,000 mi