2010 Mercedes-Benz GL350 Owner Complaints

THIS VEHICLE WHICH IS THE X164 CHASSIS HAS A REAR FIXED PANORAMIC SUNROOF THAT IS MADE OUT OF POLYCARBONATE. THE POLYCARBONATE SUNROOF GLASS IS BREAKING DOWN ON THE INSIDE OF THE PANEL AND IS CRACKING. THIS POSES A SAFETY CONCERN DUE TO THE FACT THAT ONCE IT CRACKS AND DEGRADES TO A CERTAIN POINT IT WILL BREAK. IF THIS PANEL BREAKS WHILE TRAVELING DOWN THE ROAD ESPECIALLY AT HIGHWAY SPEEDS IT CAN FLY OFF THE VEHICLE IN TURN HITTING CARS BEHIND ME CAUSING AN ACCIDENT. THE OTHER SAFETY CONCERN IS THAT WHEN IT BREAKS IT MORE THAN LIKELY WOULD CAUSE INJURY TO OCCUPANTS OF MY VEHICLE THAT WOULD BE SITTING IN THE BACK OF THE CAR. I HAVE TAKEN THIS TO A BODY SHOP AS WELL AS THE MERCEDES BENZ DEALER AND THEY HAVE AGREED THAT IT IS CRACKING AND IS BREAKING DOWN STRUCTURALLY SPEAKING AND THAT IT IS A MATTER OF TIME BEFORE IT BREAKS. IT IS NOT A MATTER OF IF, BUT WHEN. I ALSO HAVE DONE RESEARCH AND FOUND THAT POLYCARBONATE SHOULD NOT HAVE BEEN INSTALLED ON THESE VEHICLES DUE TO THE FACT THAT BETWEEN THE HEAT AND BODY FLEX WHICH CAUSES THE STRESS CRACKS. THIS IS A FACT THAT POLYCARBONATE PANELS SHOULD NOT BE INSTALLED IN ANY CASE WHERE THERE WILL BE STRESS. DUE TO THE BODY FLEX THESE PANELS INSTALLED ON THESE MERCEDES BENZ SUV'S HAVE A PRETTY GOOD AMOUNT OF STRESS AND COUPLED WITH THE INTENSE UV EXPOSURE BEING ON THE TOP OF THE VEHICLE IS CAUSING THESE TO BREAK DOWN. THIS IS A VERY COMMON PROBLEM ON THESE SUV'S BUT MERCEDES BENZ DOESN'T WANT TO DEAL WITH IT. I CAN'T GET ANYBODY TO RETURN CALLS ON THIS AND MERCEDES HAS NOT WANTED TO DEAL WITH IT. THIS SHOULD BE AT THE TOP OF THE SAFETY RECALL LIST FOR THESE VEHICLES. I CAN'T STRESS ENOUGH HOW THIS IS ANMAJOR SAFETY CONCERN. PLEASE ADDRESS THIS AND MAKE MERCEDES RECALL THESE VEHICLES FOR THIS REPAIR. THANK YOU!

NHTSA ID

11121748

Incident

Aug 17, 2018

Mileage

102,000 mi

TAKATA RECALL

NHTSA ID

11091606

Incident

Sep 14, 2017

TL* THE CONTACT OWNED A 2010 MERCEDES BENZ GL350. THE CONTACT STATED THEY WERE INVOLVED IN A FRONT END COLLISION WHILE DRIVING AT APPROXIMATELY 55 MPH. THE VEHICLE AIR BAGS DEPLOYED AS A RESULT THE CONTACT SUSTAINED BRUISING TO BOTH ARMS, MODERATE TO SEVERE PAIN AND A BROKEN RIGHT FOOT THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A SALVAGE YARD AND DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE AS THE VEHICLE WAS NOT TAKEN TO A DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 117,132.

NHTSA ID

11081553

Incident

Mar 17, 2018

Mileage

117,132 mi

TAKATA RECALL AIRBAG DEFECTIVE

NHTSA ID

11056797

Incident

Jan 1, 2010

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 MERCEDES-BENZ GL350. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V081000 (AIR BAGS). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE LOCAL DEALER (CENTENNIAL IMPORTS MERCEDES-BENZ, 30550 W. NAVY BLVD, PENSACOLA, FL 32505) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11045992

Incident

Mar 14, 2017

TAKATA RECALL VERY CONCERNING THAT MY CAR IS INCLUDED IN THE AIRBAG RECALL YET THE AIRBAG MFR HAS FILED FOR CHAPTER 11. I WANT THIS RESOLVED AND CORRECTED SO I CAN FEEL SAFE DRIVING MY CAR!

NHTSA ID

11044185

Incident

Nov 6, 2017

TAKATA RECALL

NHTSA ID

11015252

Incident

Dec 6, 2010

THIS CAR HAS A OIL COOLER LEAK AFTER OUR OIL CHANGE AT THE MERCEDES DEALER WE STARTED HAVING AN OIL LEAK AND THE MERCEDES DEALER TOLD US IT'S THE OIL COOLER LEAK.

NHTSA ID

10824096

Incident

Jan 1, 2016

Mileage

76,000 mi

THE "CHECK ENGINE LIGHT" IS ON, WHEN I TOOK THE CAR TO THE DEALER, THEY TOLD, " THE AD BLUE TANK IS CORRODED." I HAVE ALWAY FUELED WITH DISEL RECOMMENDED BY MERCEDES. HOW CAN TANK GET CORRODED SO EARLY. I SUSPECT FAULTY IN THE MANUFACTURING. I REQUEST YOU TO DO NECESSARY INVESTIGATION INTO IT. I HAVE HEARD SIMILAR INCIDENT ABOUT FAULTY AD BLUE TANK FROM MANY OTHERS ON FORUM: HTTP://MBWORLD.ORG/FORUMS/GL-CLASS-X164/396987-2010-GL350-BLUETEC-FUEL-SYSTEM-CORROSION-BIG-PROBLEM.HTML

NHTSA ID

10781223

Incident

Aug 27, 2015

AFTER A LONG TRIP WITH THE 2010 MERCEDES GL350 BLUETEC, I NOTICED FRESH OIL ON THE GARAGE FLOOR. I TOOK THE GL350 TO A LOCAL MECHANIC FOR AN OIL CHANGE THE DAY AFTER, AND THE MECHANIC NOTED THAT THERE IS SIGNIFICANT OIL UNDER THE ENGINE. FEW DAYS AFTER, CHECK ENGINE LIGHT CAME ON, AND I TOOK THE GL350 IN FOR A CHECK, AND ANOTHER MECHANIC CONFIRMED THAT THE ENGINE OIL COOLER SEAL IS BROKEN CAUSING THE OIL LEAK. IT SEEMS THAT THIS IS A VERY COMMON FAULT WITH MERCEDES OM642 ENGINE IN MY GL350.

NHTSA ID

10747970

Incident

Aug 3, 2015

Mileage

65,000 mi

TL* THE CONTACT OWNS A 2010 MERCEDES BENZ GL350. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. THE FAILURE OCCURRED TWELVE TIMES PRIOR TO THIS INCIDENT. AFTER EACH FAILURE, THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ABS SENSOR MALFUNCTIONED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,848. UPDATED 8/21/15*CN UPDATED 10/26/2017*CN

NHTSA ID

10726898

Incident

Dec 12, 2013

Mileage

37,848 mi

AFTER EXTENSIVE REVIEWS OF TDI FORUMS, COMMON RAIL FORUMS, DIESEL FORUMS I HAVE FOUND A COMMONALITY IN THE FAILURES IN THE HIGH PRESSURE FUEL PUMP (HPFP). MAINLY THOSE FAILURES WERE ATTRIBUTED TO METAL SHAVINGS/PARTICLES/RUST FOUND IN DIESEL FUEL SYSTEMS. THE FUEL LEVEL SENDING UNITS ARE USUALLY RUSTED IN EACH CASE AND MOST LIKELY IS THE SOURCE OF METAL/RUST CONTAMINATION AND ULTIMATELY CAUSE OF THE HPFP FAILURE. FAILURE OF THE HPFP CAUSES THE CR TO LOSE PRESSURE THEREFORE THE INJECTORS ARE STARVED OF FUEL OR WORSE CLOGGED WITH RUSTED METAL PARTICLES. THIS SUDDEN LOSS OF FUEL CAUSES THE ENGINE TO SHUT DOWN INSTANTLY ALONG WITH POWER STEERING AND POWER BRAKES. DEPENDING ON THE RESERVE VACUUM VOLUME IN THE BOOSTER, CONSUMERS MAY OR MAY NOT HAVE ENOUGH VACUUM TO ADEQUATELY BRING THE VEHICLE TO A SAFE STOP. ALSO THE STEERING WHEEL WOULD FEEL VERY HEAVY AND THE CONSUMER MAY OR MAY NOT BE ABLE TO STEER CLEAR OF AN ACCIDENT. I WROTE TO MBUSA NOTING THIS CAUSE AND URGED THEM TO INVESTIGATE THIS MATTER SERIOUSLY BEFORE ANY INJURY OR DEATH HAPPENS, ALSO TO INSTITUTE A VOLUNTARY SAFETY RECALL OF ALL CR DIESELS TO DETERMINE IF RUST FROM THE FUEL LEVEL SENDING UNIT IS PRESENT. I PROPOSED A REMEDY TO MBUSA TO CHANGE OUT THE RUSTED UNITS FOR STAINLESS STEEL ONES. I ALSO REQUESTED THAT MBUSA PROVIDE UNLIMITED WARRANTY REPLACEMENT FREE OF CHARGE TO ALL BLUETEC OWNERS AND REIMBURSE ALL THOSE PRIOR TO THE RECALL, INCLUDING ANY RENTAL CAR USE. *TR

NHTSA ID

10565780

Incident

Feb 12, 2014

Mileage

49,000 mi

ABOUT A WEEK AGO I BOUGHT DIESEL FUEL FROM A TRUCK STOP IN LONG BEACH, NOT MY USUAL PURCHASE FROM MY LOCAL GAS STATION. ONE WEEK LATER I GET A MESSAGE TO CHANGE MY FUEL FILTER AND GOT A TROUBLE CODE INDICATING A LOW FUEL RAIL PRESSURE. I HAD THE FILTER CHANGED AND EXPERIENCED HARD STARTING LATER ON. THE OLD FILTER HAD WATER AND SOME ALGAE CONTAMINATION WHICH IS VERY COMMON IN DIESEL ENGINES. I SUSPECTED WATER FROM THE TRUCK STOP WHERE I GOT FUEL FROM AND TRIED TO REMOVE IT USING A DIESEL ADDITIVE, SEA FOAM. STARTING MY CAR GOT WORSE TO THE POINT WHERE IT WOULD NO LONGER START. I CALLED A TOW TRUCK TO TAKE IT TO THE DEALER WHERE I BOUGHT THE CAR FROM AND THEY CLAIM I BOUGHT BAD FUEL AND THE ADDITIVE RUINED THE ENTIRE SYSTEM. NOW THE DEALER IS CLAIMING MY CAR NEEDS THE ENTIRE FUEL SYSTEM REPLACED INCLUDING THE INJECTORS, HIGH PRESSURE FUEL PUMP, ALL THE FUEL LINES, FUEL FILTER, FUEL TANK, LOW PRESSURE FUEL PUMP, AND FUEL SENSOR, WITH ESTIMATED COST OF $15,000+. NHTSA HAS IDENTIFIED THE HIGH PRESSURE FUEL PUMP FAILURES (HPFP) ON A MAJORITY OF GERMAN VEHICLES, INCLUDING VOLKSWAGEN, MERCEDES, AUDI, JUST TO NAME A FEW. THE FUEL QUALITY IS DIFFERENT IN THE US COMPARED TO EUROPEAN STANDARDS AS MOST OF THE US USES ULTRA-LOW SULFUR DIESEL. I BELIEVE THIS IS THE REASON WHY A LARGE NUMBER OF IMPORTED DIESELS ARE FAILING, COSTING THE AMERICAN TAXPAYERS INCREASED INSURANCE CLAIMS AND VEHICLE FAILURES. *TR

NHTSA ID

10564368

Incident

Feb 12, 2014

Mileage

49,000 mi

I HAVE BEEN NOTICING AN INCREASING SMALL LEAK IN ENGINE OIL ON MY GARAGE FLOOR. RECENTLY I SAW A VERY LARGE PUDDLE WHILE PARKED AT A LOT AND HAD THE CAR TAKEN TO NEAREST DEALER. DEALERSHIP ADVISED REPLACING OIL COOLER AND ASSOCIATED SYSTEM PARTS. I BELIEVE IF I HAD NOT NOTICED LEAK/PUDDLE, ENGINE MAY HAVE SEIZED WHILE DRIVING. ALSO, ON MANY MB FORUMS, THE OIL COOLER IS IMPLICATED AS THE CULPRIT FOR A LARGE OIL LEAK. *TR

NHTSA ID

10546126

Incident

Sep 20, 2013

Mileage

46,213 mi

2010 MERCEDES BENZ GL 350. CONSUMER WRITES IN REGARDS TO A FRACTURED STEERING COLUMN, WATER PUMP LEAK AND ENGINE OIL LEAK. *SMD THE CONSUMER STATED AT 11,763 THE STEERING COLUMN JACKET TUBE COVERING MOUNT FRACTURED, WHICH CAUSED BINDING AND WEAR ON THE SURROUNDING TRIM. THE COVERING AND TRIM WERE REPLACED. AT 26,163 THE WATER PUMP AND GASKET WERE REPLACED. THEN AT 50,548 MILES, AN ENGINE OIL LEAKED DEVELOPED FROM THE OIL COOLER, R&R TURBO CHARGER, R&R LEFT AND RIGHT CHARGE AIR MANIFOLDS. ALL OF THE SEALS WERE REPLACED.

NHTSA ID

10515243

Incident

Jun 1, 2011

Mileage

11,763 mi

TL* THE CONTACT OWNS A OWNS A 2010 MERCEDES BENZ GL350. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ABS WARNING LAMP ILLUMINATED. IMMEDIATELY AFTER THE FAILURE, THE BRAKES SEIZED AND PREVENTED THE VEHICLE FROM MOVING. THE VEHICLE WAS TOWED TO THE DEALER, WHO DIAGNOSED THAT THE FRONT SPEED SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 24,226. UPDATED 08/28/12*LJ UPDATED 08/29/12

NHTSA ID

10462284

Incident

Jun 9, 2012

Mileage

24,226 mi