2015 Mercedes-Benz GL450 Problems

My 2015 Mercedes-Benz GLE 450 experienced an unexpected vehicle fire on Feb 13th 2026. The vehicle was just parked when I noticed smoke from the engine. The vehicle caught fire within a short period of time, and 911 was called. There was no known external cause for the fire. The incident appeared to originate from the engine compartment. This created a serious safety hazard and posed a risk of injury and property damage. The fire required immediate response from the fire department, and the vehicle was declared a total loss. The vehicle is currently in the possession of the insurance company. This incident raises concerns about a potential mechanical or electrical defect. A vehicle should not catch fire under normal operating or parked conditions. I am requesting that this incident be reviewed as a potential safety defect.

To Whom It May Concern: I am writing to formally request the National Highway Traffic Safety Administration’s assistance regarding a critical safety defect in my 2015 Mercedes‑Benz GL 450 (M278 engine). I purchased this vehicle in October 2024 with 76,000 miles, and it now has about 87,000 miles. Alarmingly, I recently received a quote for $13,000 to repair a camshaft failure and extensive electrical damage. I was unaware of these issues when I purchased this car. I bought it under the illusion that it would be a safe vehicle for me and my children. As a single parent and teacher I invested in this vehicle what I could afford and felt I had purchased a safe, reliable vehicle. I am devasted to have a proposal for repairs in excess of $13,000 from a Mercedes dealership who diagnosed the car. This caused me to do some research and I found the GL450 has a known and widespread defect. I also found, that this causes the cam shaft to need to be repaired and that this is not normal wear-and-tear—it is a systemic design vulnerability common across GL450 models. This can result in the engine seizing from what I was told and that directly poses a substantial risk when driving. From what I found this is a common issue with this car and I did not know that when I purchased it. This is a design flaw, not a misuse of the vehicle. Finally, a $13,000 repair to make this car safe and road ready is astronomical and is not aligned with a normal maintenance cost- manufacturer accountability is warranted here. I respectfully request that the NHTSA: Investigate whether a safety recall or extended warranty program is appropriate for this known defect in the GL450. Require Mercedes‑Benz to provide a comprehensive repair solution for me and repair this defect in my car's engine under the manufacturer's expense. And finally, for Mercedes to make customers affected by this aware of this engine defect and long term risks associated with this issue. Respectfully, Alyssa Begin

The airmatic system in this vehicle fails continuously, causing the vehicle to bump up and down while driving. Unsafe to drive

ON 12/30/2017 WE PURCHASED A MERCEDES-BENZ CERTIFIED PRE-OWNED 'CPO' VEHICLE FROM MERCEDES BENZ OF NORTH PALM BEACH. WE ARRIVED AT THE DEALERSHIP IN THE AFTERNOON SENT BY MERCEDES BENZ OF WEST PALM BEACH THEIR AFFILIATED DEALERSHIP FOR THE SPECIFIC VEHICLE WE PURCHASED. WHEN WE ARRIVED AT THE DEALERSHIP TO VIEW THE VEHICLE, IT WAS NOT DETAILED FROM THE PREVIOUS OWNER. ON THE TEST DRIVE WITH OUR SALES PERSON I NOTED UNUSUAL NOISES AND RIDE CONDITIONS IN THE VEHICLE. THE SALESPERSON ASSURED US THAT IT IS A CPO VEHICLE WITH AN UNLIMITED MILEAGE WARRANTY BACKING UP BUMPER TO BUMPER FACTORY WARRANTY. HE GAVE US AN IMPLIED ORAL WARRANTY THAT THE VEHICLE WOULD BE REPAIRED TO OUR SATISFACTION - 'NOT TO WORRY'!

ON 12/30/2017 WE PURCHASED A MERCEDES-BENZ CERTIFIED PRE-OWNED 'CPO' VEHICLE FROM MERCEDES BENZ OF NORTH PALM BEACH. WE ARRIVED AT THE DEALERSHIP IN THE AFTERNOON SENT BY MERCEDES BENZ OF WEST PALM BEACH THEIR AFFILIATED DEALERSHIP FOR THE SPECIFIC VEHICLE WE PURCHASED. WHEN WE ARRIVED AT THE DEALERSHIP TO VIEW THE VEHICLE, IT WAS NOT DETAILED FROM THE PREVIOUS OWNER. ON THE TEST DRIVE WITH OUR SALES PERSON I NOTED UNUSUAL NOISES AND RIDE CONDITIONS IN THE VEHICLE. THE SALESPERSON ASSURED US THAT IT IS A CPO VEHICLE WITH AN UNLIMITED MILEAGE WARRANTY BACKING UP BUMPER TO BUMPER FACTORY WARRANTY. HE GAVE US AN IMPLIED ORAL WARRANTY THAT THE VEHICLE WOULD BE REPAIRED TO OUR SATISFACTION - 'NOT TO WORRY'!

TL* THE CONTACT OWNS A 2015 MERCEDES BENZ GL450. WHILE IN PARK, THE VEHICLE STARTED TO ROLL FORWARD AS IF THE VEHICLE WERE IN DRIVE. THE VEHICLE ROLLED OVER A CURB AND CRASHED INTO A TREE. THE VEHICLE WAS DRIVEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT WAS NOT REPAIRED. NO INJURIES WERE SUSTAINED AND A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 5,000. THE VIN WAS NOT AVAILABLE.

The rubber sealing around the lift gate failed on the vehicle and water seeped inside the vehicle and entire bottom of the vehicle underneath the floor board thereby damaging the electronic components, engine wire harness and headliner thereby rendering the vehicle was beyond repair. This issue led to mold to grow on the roof liner inside and on the seats which caused breathing issues for me and my family. This put our safety at risk! After talking the vehicle to authorized Mercedes Benz dealer in San Jose CA I was told that this is a known defect with the vehicle about which Mercedes Benz Inc is well aware for years and has not fixed it or recalled vehicles having this safety issue. I had purchased this vehicle from Mercedes Benz of Pleasanton on 6/10/2015 as Certified Pre Owned (CPO) but I was not informed that this safety issue existed. I was informed by Mercedes Benz of San Jose that the vehicle could not be repaired as mold would pose a health hazard for the occupants and the vehicle was deemed to be beyond repair and totaled. I had also purchased extended warranty at the time of purchase in 2015 but the dealership did not honor it for repairs.

TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ GL450. WHILE DRIVING 40 MPH, THE VEHICLE STALLED AND THE PRE-SAFETY FUNCTION LIMITED WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PUSHED OVER TO THE SIDE OF THE ROAD BY THE CONTACT AND PASSENGER. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT IT FAILED TO START. THE VEHICLE WAS TOWED TO MERCEDES-BENZ OF ARCADIA (101 N SANTA ANITA AVE, ARCADIA, CA 91006, (626) 701-8904) WHERE IT WAS DIAGNOSED THAT A LOOSE SCREW WAS NOT FASTENED BY THE MANUFACTURER AND AN UNKNOWN WIRE WAS DETACHED, WHICH CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

SECOND ROW HEAD REST DOES NOT ADJUST TO DIFFERENT POSITIONS MAKING IT UNSAFE FOR CHILDREN.

TRIED TO INSTALL CHILD SAFETY SEATS IN 2ND ROW SEATS. THE 2ND ROW HEADRESTS PREVENT THE PROPER INSTALLATION OF THE CHILD SAFETY SEATS. THE HEADRESTS CANNOT BE REMOVED, OR MOVED OUT OF THE WAY SO THAT THE CHILD SAFETY SEATS CAN BE INSTALLED PROPERLY. I HAVE REPORTED TO OUR MERCEDES-BENZ DEALER. THEY ARE WORKING ON A RESPONSE. *TR

WINDSHIELD HAS CRACKED ON VEHICLE TWICE JUST SITTING IN THE DRIVEWAY HAS TO BE A MANUFACTURER DEFECT.

ON 12/30/2017 WE PURCHASED A MERCEDES-BENZ CERTIFIED PRE-OWNED 'CPO' VEHICLE FROM MERCEDES BENZ OF NORTH PALM BEACH. WE ARRIVED AT THE DEALERSHIP IN THE AFTERNOON SENT BY MERCEDES BENZ OF WEST PALM BEACH THEIR AFFILIATED DEALERSHIP FOR THE SPECIFIC VEHICLE WE PURCHASED. WHEN WE ARRIVED AT THE DEALERSHIP TO VIEW THE VEHICLE, IT WAS NOT DETAILED FROM THE PREVIOUS OWNER. ON THE TEST DRIVE WITH OUR SALES PERSON I NOTED UNUSUAL NOISES AND RIDE CONDITIONS IN THE VEHICLE. THE SALESPERSON ASSURED US THAT IT IS A CPO VEHICLE WITH AN UNLIMITED MILEAGE WARRANTY BACKING UP BUMPER TO BUMPER FACTORY WARRANTY. HE GAVE US AN IMPLIED ORAL WARRANTY THAT THE VEHICLE WOULD BE REPAIRED TO OUR SATISFACTION - 'NOT TO WORRY'!

TL* THE CONTACT OWNS A 2015 MERCEDES BENZ GL450. THE CONTACT STATED THAT THE HEADREST PREVENTED THE CONTACT FROM PROPERLY INSTALLING A CHILD SAFETY SEAT IN THE REAR OF THE VEHICLE. THE CONTACT MENTIONED THAT THE HEADREST COULD ONLY BE REMOVED BY THE DEALER. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 2,000.

Steering wheel will not go up and down. It will go in and out. This needs a recall! This is a HUGE problem with many Mercedes.

The rubber sealing around the lift gate failed on the vehicle and water seeped inside the vehicle and entire bottom of the vehicle underneath the floor board thereby damaging the electronic components, engine wire harness and headliner thereby rendering the vehicle was beyond repair. This issue led to mold to grow on the roof liner inside and on the seats which caused breathing issues for me and my family. This put our safety at risk! After talking the vehicle to authorized Mercedes Benz dealer in San Jose CA I was told that this is a known defect with the vehicle about which Mercedes Benz Inc is well aware for years and has not fixed it or recalled vehicles having this safety issue. I had purchased this vehicle from Mercedes Benz of Pleasanton on 6/10/2015 as Certified Pre Owned (CPO) but I was not informed that this safety issue existed. I was informed by Mercedes Benz of San Jose that the vehicle could not be repaired as mold would pose a health hazard for the occupants and the vehicle was deemed to be beyond repair and totaled. I had also purchased extended warranty at the time of purchase in 2015 but the dealership did not honor it for repairs.