Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 28 NHTSA owner-reported complaints for the 2021 Mercedes-Benz GLB 250. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 28 · page 1 of 2
Family and I were driving on the interstate and heard a loud bang (like a shotgun) followed by immediate glass everywhere. The panoramic sunroof exploded. We had to drive 4 hours like this - lucky we didn’t jerk the wheel on the interstate with the noise. Absolutely sickening that this is so prevalent and Mercedes won’t do anything about it.
When my car sits in the rain for long periods of time, while driving, it will automatically switch into neutral and give me a "transmission malfunction stop" & "service required do not shift gears visit dealer" sign on the dash. This has happened at least 7 times in 2 years since March 2024. The latest time it happened was last week. I will get into my car after a day at work, when it has been raining, drive a few miles and the car will switch into neutral and display those signs. This is incredibly dangerous for my safety as the driver, any passengers and any other cars on the road. While going 55+ miles an hour, my car, without any warning shifts into neutral. I have taken it to my local dealership for inspection every time that it happens and they have repeatedly told me they cannot find a fix for it and do not know why it is happening besides a electrical problem due to water. They advised me to file a claim with corporate Mercedes but that was denied. I have photos and documentation from the dealership of when I have brought it in for inspection and they have confirmed the issue. They will not help with a solution for this problem. They have told me to pull over, turn the car on and back off to get it to go away but it continues to do the same repeated problem.
The component that appears to have malfunctioned is the front axle integral carrier (front subframe) and the related front suspension geometry, as the vehicle now exhibits a persistent pull to the left and degraded steering stability after the dealer replaced the front lower control arms, engine mounts, and performed alignments; this area of the vehicle is fully available for inspection upon request. My safety and the safety of others were put at risk because the vehicle requires constant steering correction to avoid drifting left, creating a danger of unintended lane departure and loss of control, which aligns with the steering‑related risks described in NHTSA Recall 21V990 / MBUSA 2022070009, where failure of the integral carrier can impair steering and increase crash risk. The problem has been reproduced by me on every drive, though the dealer stated they “did not find anything,” despite alignment printouts showing front camber imbalance and lack of caster correction. The vehicle has been inspected twice by the authorized Mercedes‑Benz dealer, but they did not inspect or address the front axle integral carrier even though the recall documentation shows that corrosion or structural issues in this part can affect steering performance and connection to other components. There were no warning lamps or dashboard alerts; the symptoms began immediately after the dealer’s suspension and mount repairs, and the steering pull and unstable handling have continued ever since.
I purchased this vehicle in May 28 2025. I certified car. I took in for oil change Nov 17-2025. Found out they had lot of issues., left front bushing arm leaking. Rt engine mount leaking. Bad brakes battery low. Bad tire rt back passage side.front wheel axle and rear wheel axle is bad and screw on the engine mount is missing. Screw and leaking..?and the vehicle needed a alignment.
Engine locked up while driving out of state on the interstate. Vehicle lost all power and engine stopped functioning. Managed to pull over and stop the vehicle on the side of the interstate. Had truck towed to repair shop where they diagnosed connecting rod/crankshaft bearing failure, as well as lifter and cylinder misfire/failure on cylinder 7. Metal shavings were discovered in the oil, and engine locked up and cannot be repaired. I am currently in the process of having the engine replaced, but yes currently an inspection can still be performed, and I can provide statements and diagnostics from the mechanic. This failure put myself and my family in a scary situation. The engine was shaking violently before it stopped functioning and this made the truck very difficult to steer, not to mention this was during rush hour and we were in heavy traffic moving at speeds of 70mph+. Luckily we managed to get off the road, and to a safer location, but this left us stranded on the side of the road for 2 hours waiting on a tow. The vehicle was inspected by a GMC dealership initially where they only diagnosed lifter and cylinder misfire/failure. Due to the price of their quote to repair that issue, I took the vehicle to a certified mechanic, and thats when we found there was also connecting rod/crankshaft bearing failure prior to repairing the lifter/cylinder misfire. There were no prior warnings to this happening. No check engine lights, no noises, and no noticeable changes in the vehicle. Everything seemed to be operating normally.
IT APPEARS AS IF THERE IS AN ISSUE WITH THE TRANSMISSION. IN THIS VEHICLE. WHEN YOU COME TO A STOP THE TRANSMISSION HAS A LOUD CLUNKING NOISE COMING FROM LEFT SIDE OF VEHICLE. THE CLUNKING OCCURS WHEN THE VEHICLE DOWNSHIFTS. IT CLUNKS FROM D4 TO D3, THEN D3 TO D2 , AND AGAIN AT D2 TO D1. I HAVE TAKEN IT TO THE DEALER NUMEROUS TIMES TO HAVE IT CHECKED. THE SERVICE MGR WENY FOR S TEST DRIVE WITH ME AND HEARD IT. I WAS THEN TOLD THE CLUNKING WAS " NORMAL" . I PURCHASED THE VEHICLE AS A CERTIFIED USED VEHICLE FROM THE SAME DEALER . THIS HAS BEEN OCCURING SINCE PURCHASE IN MAY 2024
Driving on north bound of Merritt Parkway between exit 17 and 18. Today 12/10/25 9:28 AM My panoramic sunroof exploded ! all catch on video, driver on the vehicle behind me , came to check on me; and told me the glass went over four feet up in the air and then hit his vehicle windshield, I call Mercedes Benz customer service support to report the incident and open a case, they told me to drive to the closest dealer from the incident (Mercedes Benz of Fairfield) when I arrived and show the vehicle to the technician, he was trying to tell me that was my fault and he never heard such a thing of a sunroof explosion… and was looking for a reason to blame me, I told him I got all on video due to I have a dash camera that records the our side and the inside of the vehicle.. the outside temperature was 30 degrees Fahrenheit, and the inside temperature in the vehicle was set to 69 degrees… My speed was 55 to 56 miles per hour. Light to moderate traffic, the explosion sound like a gunshot, that was my first impression, some one shoot at me… The dealer, told me that I should call my insurance or Mercedes Benz and the only think they can do, is to tell me how much will cost to repair the damage.. and that they will park my car on a different building so don’t get rain on it, until I decided what I want to do.
Engine showed signs of loss of power and excess noise. It was taken to dealership via MB roadside assistance. At the dealership, they diagnosed it with engine catastrophic failure due to metal parts found in the oil filter. At no time was the engine disassembled to ensure known defects and still under warranty parts were not the cause. Dealer estimated the repair to cost in excess of $22K. MBUSA was contacted and they made no efforts to make the situation whole. The cost estimated was for the complete engine replacement. An engine that only has 53k miles. Although all routine maintenance have been conducted, engine failure was certainly pre-mature. Issues exhibited were excessive engine vibration, loss of power and excess noise.
Escalating Safety Concern – Loud Clunking, Thumping, and Cracking from Front Axle at Low Speeds We are long-time loyal customers and currently own four identical Mercedes-Benz models. Unfortunately, one of our vehicles, a 2021 mb glb250 has recently developed severe clunking, thumping, and loud cracking noises originating from the front axle area, noticeable especially at low speeds. The problem appeared suddenly and is rapidly worsening. After researching the issue, we’ve discovered that many owners of the exact same model and model year report identical symptoms. This appears to be a widespread and recurring problem that raises serious safety concerns, particularly as it affects the front axle and is uncommon in other modern vehicles of this class and young age. Given the potential safety implications and the growing number of affected owners, we respectfully request that Mercedes-Benz investigate this issue promptly, acknowledge it as a known concern, and provide an appropriate inspection and repair at no cost to us. We love the brand and have always trusted its engineering and safety standards, which makes this experience especially distressing. We would greatly appreciate your immediate attention and a clear response on next steps.
While driving, the panoramic moonroof on my 2021 Mercedes-Benz GLB 250 (VIN: [XXX] ) suddenly shattered without any visible impact or prior damage. It sounded like an explosion, and glass rained down into the vehicle. This could have caused serious injury to myself or my child. There was no indication that a rock or debris hit the vehicle. No vehicles were in front of me, and I have no history of impact damage. This seems to have happened spontaneously, and after researching the issue, I found it is a common problem across various Mercedes-Benz models. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
In April 2025, my 2021 Mercedes-Benz GLB 250 (81,000 miles) suffered repeated engine issues caused by a cylinder head failure. The dealer attempted a cylinder head replacement, but during their own test drive after repairs, the engine completely seized and failed again on their property. This indicates a severe defect in the engine assembly that risks sudden power loss while driving, which could cause an accident. Prior to the failure, there were warning messages about misfires and rough idle. The problem has been confirmed by an authorized Mercedes-Benz dealer and the car has been kept at their shop since April, with no resolution. I am concerned this is a recurring safety defect affecting other GLB 250 vehicles. The vehicle is available for inspection and remains undriveable due to the failed engine. I request NHTSA to investigate for possible safety-related design or manufacturing defects that could cause sudden engine seizure and loss of power while driving.
Seat belt failure.Driver side…mechanism… it feels unsafe…the retractor is not locking
Jerking and loud noise from the engine after attempting to accelerate from a red light stop. Vehicle is idling very roughly and almost sounds like a diesel engine. Check engine light came on. Inspection at the dealership found multiple faults for camshaft positions deviating from the specified value. When the oil filter was removed, the shop reported finding some metal particles in the oil. The conclusion was that a mechanical fault caused a metal part in the engine to brake and clog up the engine. The car did not run smoothly after the jerking sound and could have caused an accident if the car was in active motion. The recommendation now is that the engine needs to be replaced.
The contact owns a 2021 Mercedes-Benz GLB250 equipped with Continental Tires, Tire Line: ProContact GX SSR, Tire Line: 235/55/R18, DOT Number: A33LWXX41220. The contact stated while driving 70 MPH, the vehicle began to vibrate with a flapping sound coming from the vehicle. Despite the failure, the contact was able to drive the vehicle to the residence. The contact then drove the vehicle to an independent mechanic where three humps were discovered on the front driver’s side tire that had formed due to thread separation on the inside of the tire. The mechanic referred the contact to a dealer who then referred the contact to the Continental tire manufacturer. The manufacturer informed the contact that the tire should be sent to the headquarters for an inspection. The tire was replaced. The failure mileage was approximately 30,600.
Glass that’s in between the windshield and sunroof
Cylinder Head gone bad at 35,000 miles
My fuel tank cover would not open. Car was under warranty so MB was able to replace the motor of the fuel cap release. Problem, there is no manual release for the fuel cap so if you are low on fuel and need to fill up, you would be stranded. They need a manual release for the fuel cap for safety.
Entire electrical system went out while driving causing check engine light to come on after the failure of system; there was no dashboard working at all when the system went out; without the dashboard out it was not certain if the vehicle was safe to drive anymore; the dealer has not been able to reproduce the problem; the vehicle has been with the dealer repair system for several weeks and have not been able to determine what happened; they have indicated that the vehicle had some type of water intrusion which short circuited the electrical system; the believes that the water entered into from the windshield area with a possible clogged water drain; there was no prior warning
The contact owns a 2021 Mercedes-Benz GLB250. The contact stated that the vehicle was parked in the garage; however, after driving out of the garage, the contact became aware of a crack on the windshield from the rear-view mirror ten inches downward. The contact stated that the crack seemed to be on the inside over the sensors. The vehicle had not yet been diagnosed or repaired. The dealer nor manufacturer was notified of the failure. The failure mileage was 13,716.
The horn randomly starts honking while driving posing a serious safety risk. it makes driving the vehicle seem like it is stolen.
The car has 29,000 miles and I took it on a two day trip across part of the country. It was driven hard but had a oil change before leaving. After arriving home it started to sputter and have no "energy". I had the cabin filter and engine filter changed and another oil change just in case. took it to deal as it continued to sputter, even worse, jerk forward. It blew a cylinder head. Checking the internet I find that this is a usual problem with this year and model car. Why isn't it in the recall if a lot of this model has this problem?
The contact owns a 2021 Mercedes-Benz GLB250. The contact received notification of NHTSA Campaign Number: 21V354000 (Back Over Prevention, Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that several unknown local dealers were contacted, and the contact was referred to the manufacturer for further assistance. The manufacturer was contacted, and a case was opened. The contact had not experienced a failure. Parts distribution disconnect. The contact stated that the manufacturer was able to complete the repairs necessary to fix the issue and no longer wishes to keep this complaint.
Front right ball joint separated from lower control arm with no advance warning and the drive shaft was disconnected from the vehicle body. I was travelling at about 15 mph in a straight line through an intersection on a flat surface with no potholes. Then I saw a warning of a transmission fault in my instrument cluster, followed by a loud grinding sound. My car then came to a stop and I was unable to move the vehicle in Forward or Reverse gear. I ignition cycled the vehicle and tried forward/reverse, then someone told me that my front right wheel had separated. Upon inspecting my car from the outside, I then saw the mechanical failure that had occurred. The ball joint separated from the lower control arm . The drive shaft from the front right wheel also separated from the vehicle body. I also noticed that a ring-connector for the drive shaft had been flung maybe 4 feet from my car. My car was in a non-driveable condition and I could not engage drive with the transmission, my car had to be towed from the scene. If this had happened on a busier street or at higher speeds this would have been a severe collision. My car was just delivered to a Mercedes Dealership after sitting in a tow yard for several days, they have not yet fully inspected the vehicle. My insurance has not yet sent a representative to see the vehicle. The indication I had was a "TRANSMISSION FAULT" displayed on my instrument cluster, but I did not notice any other telltales on the instrument cluster after coming to a stop. To the best of my knowledge I did not collide with any objects before the event. There is damage to the outside of my front right rim and tire in the photos, I believe this damage occurred as part of the mechanical failure and how the tire may have deformed and the rim contacted the ground.
On September 3, 2022 while traveling east on AL highway 110 the sunroof exploded as i was driving. Notified Montgomery county sheriff Department but they refuse to do a report because it wasn’t an accident. The dealership said something had to hit the sunroof for it to Shadder. Explained to the service advisor that there were no other vehicles in the area when the incident happened, so what could have hit it. Was informed by the service advisor that the car didn’t have a recall for the sunroof on this particular model.
Detached wheel arch covers while driving
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .