2021 Mercedes-Benz GLE 350 Problems

At approximately 87,000 miles, my 2021 GLE350 (M264 2.0T engine) experienced a severe engine misfire resulting in a flashing check engine light, rough idle, engine shaking, significant loss of power, and near-stall condition. The vehicle was taken to Speedhaus Automotive (Newbury Park, CA) where all four ignition coils and spark plugs were replaced. Total repair cost was approximately $635. This failure pattern is consistent with the documented M264 exhaust valve seat wear issue acknowledged by Mercedes-Benz technicians. A Mercedes dealer service report on an identical 2021 GLE350 explicitly states: "COMMON ISSUE FOR EXHAUST VALVE SEATS TO WEAR — KNOWN ISSUE WITH 260 AND 264 MOTORS." Mercedes-Benz has extended the warranty on the M260 engine (transverse variant) for this identical failure mode but has not extended it for the longitudinally-mounted M264 despite the same defect being present. Repair costs for full cylinder head failure on the M264 are being quoted at $6,000–$13,000. I am requesting NHTSA investigate whether a safety recall is warranted for the M264 engine across all affected GLE350, GLC300, C300, and E350 vehicles.

While driving at night all error light showed up. I slowed down to the side of the road and while I was slowing down the engine died. I tried to start the car which worked but when I pressed the gas the engine died again. Tried it two more times with the same results. Then turned the car and waited a bit with the engine running. slowly started driving and was able to get home driving 20 mph. The next day took it to a shop that said that the battery was weak and they replaced the battery. Drove out of the shop and started hearing nosies from the engine. Immediately came back and was advised to take it to the dealer. Towed it to the dealer that checked it and said that they found metal in the oil filter and that I need to install a new engine. I read online and found many complains about the same engine issue with 2021 Mercedes GLE 350. Mercedes refuses to take responsibility that they built a faulty engine.

The contact owns a 2021 Mercedes-Benz GLE350. The contact stated that while reversing, the back over prevention camera screen was black and there was no image displayed, causing a visibility hazard for the driver. The vehicle was taken to the local dealer, who indicated that the VIN was not included in NHTSA Campaign Number: 21V354000 (BACK OVER PREVENTION, ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The vehicle was not repaired. The failure mileage was 29,000.

Not sure vehicle was parked and caught on fire from the drivers side completely burning

The contact owned a 2021 Mercedes-Benz GLE 350. The contact stated that warm air was blowing from the A/C unit while activated. The vehicle was taken to an independent mechanic, and the contact was informed that a leak had caused the A/C unit failure. The mechanic referred the contact to the dealer for assistance. The vehicle was taken to the dealer where a diagnostic test was performed. The contact was informed that the HVAC system was inoperable and an estimate for the repair was provided. The manufacturer was notified of the failure, and the contact was provided a case number. The manufacturer denied responsibility for the failure but offered a monetary credit towards the repair. The vehicle was not repaired. The contact later traded the vehicle due to the A/C unit failure. The failure mileage was approximately 66,000. The VIN was not available.

The contact owns a 2021 Mercedes-Benz GLE350. The contact stated that the floor mats were wet after it had rained, and mold had formed on the floor mats. The rear hatch door occasionally unlocked unintendedly, and the radio would change stations independently. The contact stated that other electrical malfunctions occurred suddenly and intermittently. The vehicle was taken to the dealer, and the contact was informed that the sunroof drains were clogged and caused the water to build up, which then caused the electrical shortages inside the vehicle. The contact learned that the failure occurred due to the ends of the drainage system for the sunroof being tapered. The vehicle was not repaired. The manufacturer was informed of the failure, and a case was opened. The failure mileage was approximately 49,200. The VIN was unavailable.

While driving on the highway on three separate occasions the blind spot warning will pop up and show as inoperative, next the active break assist warning flashes as inoperative, and then the entire vehicle shows as inoperative and loses all acceleration and breaks down. This has happened three times. Stayed over night at the dealership they “drove it for 70 miles” it didn’t happen to them. They released the truck back to me saying it was perfectly fine. A day later it happened again while on the highway. Highly unsafe!

The vehicle has repeatedly experienced a sudden loss of acceleration, entering a reduced-power state while driving. Most recently, this occurred less than one week after I was advised that the issue had been fully resolved through a relay replacement. Critically, these incidents have occurred while my [XXX] child was in the vehicle, creating an unsafe and unacceptable situation. Below is a summary of the work that was done to resolve the safety concern. October: Drivetrain/Powertrain control unit internal fault Replacement of gateway/powertrain control module Wiring, grounding, and software inspections November: Active Brake Assist, ESP, and voltage supply faults Failure of both rear wheel speed sensors Replacement of left and right rear wheel speed sensors December: Dealership identified a faulty relay as the root cause Relay replaced and vehicle returned to service January, the vehicle again lost acceleration. And now, again in February. The same loss in acceleration incident. At this point, the vehicle has demonstrated a pattern of unresolved, safety-critical electrical failures. Given the repeated nature of the issue, the prior replacement of major components, and the involvement of braking and drivetrain systems, I no longer feel confident that additional part replacement without corporate oversight will result in a safe or permanent resolution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Original owner of a 2021 GLE, purchased on April 21, 2021. The vehicle is currently 4 years and 6 months and 22 days old with approximately 49,000 miles. Despite meticulous adherence to all scheduled maintenance performed and no warning lights activated the vehicle suddenly shutdown and would not restart. According to MB maintenance department it suffered a catastrophic and complete engine failure. This type of premature and total engine failure in a properly maintained, low-mileage vehicle is clearly a defect in material or workmanship. This is a serious safety defect that rendered the vehicle completely inoperable with no warning. Issues are resulting from valve guide wear issues, camshaft codes, valve openness, and no-compression symptoms, camshaft, timing chain, etc.

Location: Dallas, TX – Woodall Rodgers Freeway near North Hall Street exit Mercedes-Benz USA Case #: 18469650 What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle’s 48-volt electrical architecture appears to have failed, specifically the DC/DC converter or Integrated Starter-Generator (ISG) that provides 12-volt power to all control modules. When this component failed, it caused a total loss of propulsion and electrical power. The vehicle is currently at a Mercedes-Benz dealership in Dallas and available for inspection upon request by NHTSA or Mercedes-Benz USA (case #18469650). How was your safety or the safety of others put at risk? While driving approximately 50 mph on the Woodall Rodgers Freeway with my family in the car, the vehicle suddenly lost all engine power and throttle response without warning. The accelerator stopped responding, and the engine stalled completely within seconds. I was able to coast partially onto an exit ramp, but once stopped, the car would not restart and could not be shifted into Neutral. We were stranded in live traffic with limited steering assist and no way to move the vehicle, placing my family and other motorists at serious risk of collision. Has the problem been reproduced or confirmed by a dealer or independent service center? The vehicle is currently at a Mercedes-Benz authorized dealer, and the failure has been logged with Mercedes-Benz USA under case #18469650. Initial findings point to a malfunction of the DC/DC converter or 48-volt system. Full STAR diagnostic data and fault codes are pending. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? Mercedes-Benz USA has been notified and opened case #18469650. The vehicle has been inspected by the dealership’s certified technicians and is awaiting official diagnostic reporting and possible engineering review through Mercedes’ Technical Assistance

I reported multiple times to Mercedes USA that the vehicle was experiencing electrical issues as I was periodically loosing power and/or control over the vehicle. The vehicle was returned twice to the dealership but the problem always came back pretty much immediately. On the day of the accident, I was driving the vehicle on a straight road. The road was a little bit humid as it has been raining few minutes/hours before but it wasn't raining at the time I was driving. I was maintaining a speed of 55mph (speed limit on this portion of the road). The vehicle started to suddenly move by itself on the right side. A minute later, the vehicle moved a second time on the right without any apparent reason. The third time, the vehicle suddenly accelerated and made a sharp turn to the right. The turn to the right was so sharp that the vehicle made a 180 degrees turn and was projected on the side of the road. The vehicle stopped in a ditch and engine stopped. I wasn't braking or turning the wheel when the vehicle started to act-up. I didn't feel any movement in the steering wheel and I couldn't control the brake or direction. I restarted the engine and the brakes and directions were back up again. I contacted Mercedes who wants to inspect the vehicle but didn't set a date yet. Sheriff arrived on the spot less than a minute after the crash (was driving back home after his shift). He confirmed no collision with another vehicle, no marks of tires on the road, no standing water on the road or any other reason for the crash. No ticket was given to me by the sheriff.

I can be driving on a flat surface with out the car been on eco mode and the car shuts off for no reason without and light on the dash board I have to wait a few secs to restart the car ,brakes don't stop like they should very loud grinding noise and comes. I have report this problem lots of times and my car was not fix it stay more in the shop then with me the car senc don't work the light up red like if someones next to me

The car has stalled 4 or 5 times, while driving in traffic. This can obviously be life threatening. The check engine light came on yesterday. We recently brought the car to Mercedes Benz in Daytona Beach, Florida. They told us we had low pressure in the cylinders, and needed a new cylinder head for $10,000. The cylinder pressures on their test however were all normal. They never mentioned a recall for a fuel pump defect causing cars to stall. A local independent repair company confirmed the cylinder pressure test was normal. Mercedes recalled 324,000 vehicles for this defective fuel pump between 2012 and 2020 (abc news). They recalled over 143,000 vehicles from June 2021 to 2023. My model, GLE350, was included in both recalls. I called Mercedes customer service. They said my car was built in February 2021, and there is no recall for this vehicle. There have been recalls for defective fuel pumps from 2012 to 2020, and June 2021 to 2023. I strongly suspect my vehicle built in February 2021 has the same defective fuel pump. I will bring the vehicle to an independent well qualified service center. If they diagnose a fuel pump problem. I would like Mercedes to reimburse me for the repair.

WE BOUGHT OUR VEHICLE -2021 MERCEDES-BENZ GLE 350 - ON JANUARY 12TH AND THREE DAYS LATER WE NOTICED THAT HALF OF THE MBUX DUAL SCREEN WAS BLACK AND INOPERABLE. THE CAR WAS IN SERVICE 10 DAYS. TODAY, 02,1, 2021 THE CAR STOP, THE ENGINE AND LIGHTS, CONTROL, ON HIGHWAY!!!??? I CALL POLICE TO PROTECT ME. MERCEDES DEAD. NO HAZARD LIGHTS. I STAY IN DANGEROUS TRAFFIC ONE HOUR FOR MERCEDES ROAD ASSISTANCE. I CALL FROM MY CEL PHONE, NO ENERGY IN THE CAR?! AFTER ONE HOUR THE LIGHTS OF CAR START??!!! THIS WAS AT 6:45 AM (NIGHT). AFTER 7 MINUTES, THE CAR STOP TOTALLY, BUT WITH THE LIGHTS FLASHING. FINALLY, THE ROAD ASSISTANCE FROM MERCEDES ARRIVE. NOW THE CAR IS IN SERVICE, BUT NEVER DRIVE THIS CAR. I WAS IN A VERY BIG DANGEROUS WIT MY LIFE.

Sunroof makes loud, high pitched noise when it’s windy or driving high speeds. Sunroof complaints found online for bad seals or components of sunroof being bad or unaligned. Sounds could cause driver not to hear other safety issues with vehicle as well as leaking if water.

On Thursday, [XXX], I called Mercedes Benz of Naperville at 7:23 AM, 12:34 PM and missed the call 3:03 PM. I reported Sandy in service on Thursday morning. That I smelt a burning plastic smell on Wednesday afternoon at 2:30PM. While picking up my grandchildren from their schools. I came home and parked my car. Later on, Wednesday night My Daughter drove my car and then told me. My car smelt of plastic burning. I call Mercedes Benz Thursday morning. I told them to send me a tow truck. My call needs to be towed into their service department. I ask to speak with Kevin. My service agent of Mercedes Benz service department. Sandy told me he was with a customer. I spoke to Sandy three times. I then went and checked my car for any. Displays on my car dashboard. There were no displays, and I started the car and let it run. I did not smell any burning plastic. On Sunday [XXX]. I drop my car to family dollars and return back home. I did not smell any burning plastic. At 3:04PM Stacy Wright and myself were driving on the way to a meeting in Naperville, Il. At 3:14 PM my car started smelling like burning plastic. At 3: 16 PM heavy black smoke was coming through the vent. I immediately turned left on [XXX] in front of White Castle and stopped the car. At this time the front engine of the car was on fire and the car was full of thick black smoke. I told my passengers on the passenger side to get out of the car and run. It’s on fire. I ran towards White Castle leaving my driver's door opened. I turned around to take a picture of my car on fire burning severely at 3:18 PM. Fire was coming from the front hood of the car. At 3:20PM. The car was engulfed in flames and burning the entire car. The Blue Island Police and Fire Department got to the scene of the fire at 3:18PM. To put the fire out. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 Mercedes-Benz GLE 350 W. APROX: 30,000 MILES. PURCHASED THE VEHICLE 3 YEARS AGO, WHEN IT HAD 17,000 MILES ON IT. WHEN DRIVING AT TIMES THE PASSENGER REAR SHOCK WILL START MAKING SQEAKING / CREAKING NOISES. BEEN LIKE THIS FOR ALMOST 1 YEAR NOW. I DONT DRIVE THE VEHICLE VERY OFTEN, BUT WHEN I DO DRIVE IT IT IRRITATES ME. THE DEALERSHIP SAID THE SHOCK NEEDS TO BE REPLACED. THERE ARE NO VISIBLE LEAKS, NO ABNORMAL RIDE QUALITY, ETC.

The contact owns a 2021 Mercedes-Benz GLE350. The contact stated that after exiting the vehicle, the doors unintendedly locked with the keys inside the vehicle. Additionally, the contact’s child was still inside the vehicle during the failure. The contact stated that the doors were not supposed to lock with the keys inside. The contact called a locksmith to have the vehicle unlocked. The vehicle was not taken to a local dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 49,045.