Owner-reported complaints naming the interior system, filed with NHTSA
Data refreshed
Reports naming seats, latches, locks, linkages and interior fittings. Every record below is an owner-reported complaint about the 2006 Mercedes-Benz ML350 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 17 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
ON JAN. 6, 2017 NORTHBOUND ON HWY 52. DRIVERS SEAT HEATER HAD BEEN ON APPROXIMATELY 10 MINUTES WHEN I FELT A VERY HOT SPOT ON MY UPPER LEFT SIDE. THEN I SMELLED SOMETHING BURNING. THE SEAT HEATER HAD BURNED THROUGH THE UPHOLSTERY ON THE OUTBOARD BOLSTER OF THE DRIVERS SEAT AND STARTED BURNING THROUGH MY COAT.
TURNED ON THE DRIVER SIDE HEATED CAR SEAT AND AFTER A FEW MINUTES, THERE WAS A BURNING SMELL. PULLED OVER AND FOUND IT HAD BURNED A HOLE THROUGH THE FOAM AND LEATHER ON THE LOWER LEFT SIDE OF THE SEAT ABOUT 1" WIDE AND 2" LONG.
AFTER DRIVING ONLY 30 MIN IN MORNING TRAFFIC W/SEAT HEAT ON, I SMELLED A BURNING SMELL AND THE HIP AREA OF THE SEAT WAS VERY HOT. PULLED OVER, TURNED CAR OFF, AND FOUND SEAT HEAT HAD BURNED THROUGH THE SEAT UPHOLSTERY MAKING A HOLE APPROX. 1" H X 1/2" W. QUESTION BELOW ASKS Y/N IF THERE WAS A FIRE. ANSWERED Y DUE TO BURNING; DID NOT SEE ANY FLAMES. USED SOME WATER ON IT IMMEDIATELY AND A FEW MINUTES LATER AT HOME TO MAKE SURE THERE WAS NO BURNING/SMOLDERING INSIDE THE SEAT. *TR
I WAS DRIVING WITH THE DRIVER'S SIDE ELECTRIC SEAT HEATER TURNED ON. I NOTICED A BURNING SMELL AND FELT A BURNING PAIN ON MY BACK. AFTER EXITING THE VEHICLE I SAW THAT THE SEAT HEATER HAD BURNED A HOLE THROUGH THE LEATHER DRIVER'S SEAT AND THROUGH MY JACKET. *TR
I WAS DRIVING AND I TURNED ON MY SEAT HEATER, AND I SAW SMOKE. I BURNED MY CLOTHING AND HAVE A LITTLE BURN ON MY BACK. THE SEAT WAS BURNING AND HAD A LITTLE FIRE. *TR
CONTACT WAS DRIVING, APPROX. 15 MIN. AFTER ENGINE START AND SEAT HEATER TURN-ON. CONTACT FELT A BURNING SENSATION ON POSTERIOR/HIP. CONTACT STOPPED CAR AND GOT OUT. THERE WAS A BURN HOLE IN THE DRIVER'S SEAT BACK AT LOWER LEFT. THERE WERE TWO BURN HOLES THROUGH CONTACTS PANTS. LATER EXAMINATION SHOWED A SECOND DEGREE (BLISTER) BURN ON CONTACTS HIP. THIS IS NOT A WARRANTY CLAIM AS THE DEALER SUGGESTS, BUT, RATHER A SERIOUS MANUFACTURER DEFECT THAT CAUSES BURN INJURY (CHECK THE HISTORY OF DOCUMENTED COMPLAINTS ON THE INTERNET)... *TR
TL* THE CONTACT OWNS A 2006 MERCEDES BENZ ML350. THE CONTACT STATED THAT THE SEAT WARMER OVERHEATED AND CAUSED THE COILS TO BURN THROUGH. THE CONTACT MENTIONED THAT SHE SUSTAINED SECOND DEGREE BURNS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE SEAT HEATER HAD MALFUNCTIONED AND THE SEAT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 86,000.
AFTER DRIVING FOR A FEW MINUTES, MY HUSBAND SMELLED SOMETHING BURNING. HE COULD NOT FIGURE OUT WHERE IT WAS COMING FROM UNTIL HE FELT HIS BACK BEING BURNED. HE IMMEDIATELY TURNED OFF THE HEATED SEAT AND PULLED OVER. THERE WAS SMOKE AND A HOLE BURNED THROUGH THE SEAT ABOUT 2 INCHES IN DIAMETER. THE SEAT BURNED A HOLE THROUGH HIS FLEECE JACKET & T-SHIRT LEAVING WHAT LOOKED LIKE A CIGARETTE BURN ON HIS BACK. IF MY HUSBAND HAD NOT BEEN DRIVING MY CAR, I PROBABLY WOULD NOT HAVE MADE THE CONNECTION THAT IT WAS CAUSED BY THE HEATING MECHANISM, BECAUSE I THOUGHT THAT ONLY THE BOTTOM OF THE SEATS WERE WIRED FOR THAT. THIS OCCURRED ON THE BACK PORTION OF THE SEAT ON HIS LEFT SIDE. I JUST FEAR THAT SOMEONE WOULD PANIC OR IT COULD TURN INTO A FULL BLOWN FIRE (I AM SURE WE WERE JUST SECONDS AWAY FROM SEEING FLAMES IF THE MECHANISM HAD NOT BEEN TURNED OFF SO FAST). FURTHERMORE, IF WE WERE DRIVING ON THE HIGHWAY AT A HIGHER SPEED IT VERY EASILY COULD HAVE CAUSED A FATAL ACCIDENT BECAUSE IT CAUSED HIM TO VEER INTO THE OTHER TRAFFIC LANE (LUCKILY NO CARS WERE IN THE LANE AT THE TIME). I HAVE READ MANY STORIES ABOUT THIS HAPPENING TO OTHER PEOPLE AND I HAVE CHECKED ALL ONLINE SOURCES FOR SAFETY RECALLS ON THIS CAR. WHAT A DISSERVICE IT WOULD BE IF MERCEDES DOES NOT REPLACE THIS SEAT AND MAKE IT RIGHT FREE OF CHARGE. ONE BAD ACCIDENT IS TOO MANY, WE SHOULD NOT WAIT UNTIL SOMEONE GETS BADLY BURNED OR KILLED BEFORE SOMETHING IS DONE. WE HAVE AN APPT. TO DROP OFF THE CAR NEXT WEEK FOR EVALUATION OF THE PROBLEM AND THE SERVICE ADVISOR AT THE DEALER HAS BEEN VERY HELPFUL SO FAR, SO I AM HOPING FOR A POSITIVE OUTCOME. BUT I COULD NOT GO WITHOUT REPORTING THIS BECAUSE IT IS A VERY SERIOUS SAFETY RISK AND I WOULD HATE TO SEE ANYONE ELSE GET INJURED. IT IS CLEARLY A MANUFACTURING/ELECTRICAL PROBLEM AND THE DRIVER HAS NO CONTROL OVER IT'S SPONTANEOUS OCCURRENCE. *TR
I STARTED THE VEHICLE AND AS IT WAS A COLD MORNING I PUT MY DRIVERS SEAT HEATER ON. SHORTLY AFTER PUTTING IT ON I FELT A BURNING ON THE LEFT SIDE OF MY BACK, I PULLED THE CAR OVER AND NOTICED A FIRE ON THE LOWER PORTION OF THE DRIVERS SEAT(BACK WING). THE FIRE BURNED THROUGH MY JACKET AND BURNED MY LOWER BACK. *TR
SEAT WARMER MALFUNCTION, I WAS DRIVING AND HAD TO PULL OVER AS MY SEAT WARMER CREATED A FIRE INSIDE MY SEAT AND BURNED 3 HOLES THRU MY SEAT AND SINGED MY CLOTHING. DRIVERS SIDE SEAT ON LEFT SIDE OF SEAT. MERCEDES ML 350 2006
I'M THE OWNER OF A 2006 MERCEDES BENZ ML350 4MATIC, CURRENTLY AT 58,645 MILES WITH OUTSIDE EXTENDED WARRANTY UNTIL 2013. RECENTLY I HAD THE HEATED SEAT TURNED ON WHICH I STARTED THE CAR AND AFTER ABOUT 2 MINUTES I SMELLED A BURNING SMELL COMING FROM INSIDE THE CABIN AND THEN STARTED SEEING SMOKE COMING FROM THE LEFT SIDE OF THE DRIVER SIDE SEAT BOLSTER AROUND THE WAIST AREA. I FOUND A HOLE BURNT THE SIZE OF A NICKEL AND SMOKE WAS COMING OUT FROM IT. IT WAS BRIGHT RED AS I COULD SEE INSIDE THE HOLE I IMMEDIATELY TURNED OFF THE HEAT SEAT AND SLOWLY THE BURNING WENT AWAY. I TOOK MY CAR TO A MERCEDES BENZ DEALER THE NEXT AND THEY DENIED THAT THERE IS NO HEATING ELEMENT IN THAT PART OF THE SEAT AND REFUSED TO COVER UNDER OUTSIDE WARRANTY. AT THE DEALERSHIP I DID TRY TO TURN THE HEATED SEAT ON BUT NO SMOKE WAS COMING OUT SO I WASN'T ABLE TO PROOF THE SEATING ELEMENT WAS ACTUALLY CAUSING THE PROBLEM. BUT I READ NUMEROUS INCIDENTS ONLINE WITH THE SAME EXACT PROBLEM. *TR
TL* THE CONTACT OWNS A 2006 MERCEDES BENZ ML 350. THE CONTACT STATED THAT THE PASSENGER SIDE DOOR WOULD NOT LOCK. APPROXIMATELY ONE MONTH LATER WHILE ATTEMPTING TO EXIT THE VEHICLE, THE CONTACT NOTICED THAT THE FRONT PASSENGER DOOR REMAINED STUCK FROM THE INSIDE. SHE WAS FORCED TO CRAWL TO THE DRIVER SIDE SEAT TO EXIT THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY PERFORMED A DIAGNOSTIC TEST AND REPLACED THE RIGHT SIDE DOOR ACTUATOR. THE CONTACT DID INFORM THE MANUFACTURER OF THE FAILURE. THE CURRENT MILEAGE WAS 73,240 AND THE FAILURE MILEAGE WAS 73,000. UPDATED 10/27/2011 *LN *TR
I WAS DRIVING MY 2006 MERCEDES ML 350, WITH THE SEAT WARMER TURNED ON. I NOTICED A SMELL OF SMOKE COMING FROM INSIDE THE VEHICLE, SO I TURNED OFF THE SEAT WARMER AND THE SMELL WENT AWAY. THE NEXT DAY I DISCOVERED THAT THE SEAT WARMER HAD BURNED A SMALL HOLE IN THE SEAT COVERING ON THE LEFT SIDE OF THE DRIVER'S SEAT JUST ABOVE THE DRIVER'S WAIST. WHEN I TOOK IT TO THE DEALER, THEY TOLD ME THAT THE VEHICLE WAS OUT OF WARRANTY, AND THAT IT WOULD COST $800-$1000 TO CORRECT THE PROBLEM. THE MECHANIC THAT I TALKED WITH 1-ON-1 TOLD ME THAT THEY GET THIS PROBLEM FREQUENTLY. SINCE THE DAY OF THE BURN THROUGH, I HAVE NOT USED THE SEAT WARMER. I FEEL VERY FORTUNATE THAT I NOTICED THE SMOKE AND SHUT THE SEAT WARMER DOWN BEFORE THE SITUATION RESULTED IN A FIRE OR PERSONAL INJURY. SYSTEMS WITH THESE TYPES OF RISKS SHOULD HAVE SOME KIND OF "EXTENDED" WARRANTY COVERAGE WHEN THEY FAIL, TO HELP COVER THE RISK OF FIRE OR INJURY. *TR
ABOUT 2 MINUTES AFTER TURNING ON THE DRIVER'S SEAT HEATER, THE DRIVER'S SEAT CAUGHT ON FIRE. A HOLE BURNED THROUGH THE DRIVER'S SEAT AND BURNED MY BACK. LUCKILY, I RECOGNIZED THE PROBLEM QUICKLY ENOUGH THAT I WAS ONLY SLIGHTLY BURNED. MY HUSBAND AND MY 1 YEAR OLD DAUGHTER WERE IN THE CAR WITH ME. I WAS DRIVING AT THE TIME, SO MY CLOTHES COULD HAVE CAUGHT FIRE. IF WE HAD TURNED ON THE SEAT WARMER WHILE WARMING UP THE CAR, THE ENTIRE CAR COULD HAVE GONE UP IN FLAMES.
2006 MERCEDES ML350 AT 91,100 MILES DRIVER SMELLED A BURNING SMELL AND LATER FOUND A BURNED HOLE IN THE DRIVERS SEAT, DRIVER NOTICED SMELL WHEN SEAT WARMER WAS TURNED ON. DEALERSHIP IS REQUIRING THE DRIVER TO PAY FOR THE REPAIRS. THIS ISN'T NORMAL WEAR AND TEAR AND IS EXTREMELY DANGEROUS TO THE DRIVER AS WELL AS OTHER DRIVERS SHOULD THE SEAT CATCH A FLAME. WHY IS THERE NO RECALL? *TR
WHEN I WAS DRIVING MY MERCEDES BENZ ML350, THE MALFUNCTION LIGHT CAME ON REGARDING THE REAR LIFT GATE. SHORTLY THEREAFTER, I SMELLED SMOKE AND TOOK THE CAR TO THE DEALER. THE DEALER INFORMED ME THAT THERE WAS SOME KIND OF LIQUID SPILL IN THE CARGO AREA. THE LIQUID THAT SPILLED GOT INTO THE CENTRAL PROCESSING UNIT, CAUSING AN ELECTRICAL SHORT IN THE SYSTEM AND THE REAR LIFT GATE WOULD NOT OPEN. THE VEHICLE CPU CAUGHT FIRE DUE TO THE SPILL. THERE ARE NO WARNING MESSAGES POSTED IN THE CARGO AREA, CAUTIONING THE OWNER THAT THE CAR COULD CATCH ON FIRE IF THERE IS A LIQUID SPILL IN THIS AREA. ADDITIONALLY, THERE IS NO INFORMATION IN THE OWNERS MANUAL NOTIFYING OF THIS POTENTIAL DISASTROUS EVENT. SEEING THAT THE CARGO TRUNK IS THE MOST COMMON PLACE WHERE LIQUIDS WOULD BE TRANSPORTED FROM THE GROCERY STORE, MERCEDES SHOULD PROPERLY PROTECT THAT PART OF THE VEHICLE FROM LIQUIDS IF IT CONTAINS COMPUTER CIRCUITRY AND A SPILL CAN CAUSE A FIRE. THIS SHOULD HAVE BEEN CONSIDERED A SAFETY HAZARD. AS A RESULT OF THIS INCIDENT, THE COMPUTER SYSTEM, REAR LIFT GATE LATCH AND BODY COMPONENT WILL NEED TO BE REPLACED. *TR
DT*: THE CONTACT STATED THERE WAS ONE CUP OF WATER IN A BAG IN THE CARGO AREA. THE WATER SPILLED ONTO THE CENTRAL PROCESSING UNIT, CAUSING AN ELECTRICAL SHORT IN THE SYSTEM AND THE REAR LIFT GATE WOULD NOT OPEN. THE VEHICLE WAS REPAIRED AT THE DEALERSHIP.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .