2017 Mercedes-Benz Sprinter 2500 Problems

The contact owns a 2017 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA campaign number: 20V663000 (Steering) however, the part to do the recall repair was unavailable. The contact called the local dealer who stated that parts were not yet available. The contact was informed the parts were backordered until May 30, 2022. The contact stated the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified. The contact had not experienced a failure. Parts distribution disconnect.

LOWER POWER STEERING HOSE DETACHING FROM COOLER CAUSING LOSS OF POWER STEERING. I HAVE 8500 MILES ON THE VAN. THIS IS A KNOWN ISSUE ACROSS ALL SPRINTER FORUMS. I HAVE TO ADD A NEW CLAMP TO FIX THE ISSUE. IM SO SURPRISED TO LEARN THAT MB HAVE DONE NOTHING TO FIX THAT ISSUE ON ALL SPRINTER VAN... ITS A "TIME BOMB" TO HAPPEN 7 COULD SERIOUSLY HAVE A DEADLY CONSEQUENCE IN AN EMERGENCY LOSING YOUR POWER STEERING

Odometer Fraud. The contact purchased a 2017 Mercedes-Benz Sprinter 2500. The contact stated that it was discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the mileage was 41,000. It was later discovered upon diagnosis that the mileage was 95,000.

The contact owns a 2017 Pleasure Way RV built on a 2017 Mercedes-Benz Sprinter 2500 chassis. The contact stated while driving approximately 70 MPH, the vehicle experienced a loss of motive power, brakes, power steering, and engine functionality. The vehicle was pulled over and restarted and functioned as designed however, the failure recurred. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed with needing the engine wiring harness replaced. The dealer reported that the harness showed signs of abrasions which caused the harness to ground out leading to loss of power. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 55,000.

EVERY 400 0R SO MILES THE CHECK ENGINE LIGHT COMES ON. CODES ARE 19DE00H AND P16CC00 AND P18F100 RELATING TO THE DEF BURN. I HAVE STOPPED AT THREE MB DEALERSHIPS. THEY LOOK AT CODE AND RESET SYSTEM AND TELL ME TO DRIVE THE VEHICLE. THEY ALSO HAVE SENT SEVERAL PEOPLE LETTERS TO REQUEST THEY HAVE THE VEHICLES FOR TWO WEEKS TO STUDY THE PROBLEM. I CAN'T DO THAT.

TL* THE CONTACT OWNS A 2017 MERCEDES-BENZ SPRINTER 2500. THE CONTACT STATED THAT THE CARGO SLIDING DOOR FAILED TO OPEN FROM THE INSIDE OR OUTSIDE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.

TL* THE CONTACT OWNS A 2018 MERCEDES-BENZ SPRINTER 2500 (NA). WHILE DRIVING 10 MPH, THE TRANSMISSION WENT INTO NEUTRAL AND THE VEHICLE FAILED TO ACCELERATE. THE CONTACT HAD TO QUICKLY SHIFT GEARS WHILE IN TRAFFIC. AFTERWARDS, THE VEHICLE DROVE NORMALLY. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF PEMBROKE PINES (14199 PINES BLVD, PEMBROKE, FL 33027, (954) 644-5033) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 10.

TL* THE CONTACT OWNS A 2017 MERCEDES-BENZ SPRINTER 2500. WHILE DRIVING VARIOUS SPEEDS, A RATTLING NOISE WAS HEARD INSIDE THE CARGO AREA. ALSO, DURING EXTREME HEAT, THE PASSENGER SIDE WOULD WARP. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF TEMECULA (40910 TEMECULA CENTER DR., TEMECULA, CA 92591, (951) 216-7800) WHERE NO FAILURE WAS FOUND AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS DESIGNED IN THAT MANNER. THE VEHICLE WAS THEN TAKEN TO MERCEDES-BENZ OF LONG BEACH (2300 E SPRING ST, SIGNAL HILL, CA 90755, (562) 372-2707) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE NEEDED TO BE INSULATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE SEVERAL TIMES AND A CASE WAS OPENED. THE MANUFACTURER REFERRED THE CONTACT BACK TO THE DEALER. THE CONTACT ALSO FILED A COMPLAINT WITH THE FEDERAL TRADE COMMISSION AND WAS INFORMED OF A PENDING RECALL IN REGARDS TO THE VEHICLE STRUCTURE. THE APPROXIMATE FAILURE MILEAGE WAS 80. *TT CONSUMER STATED THE BUMPER WAS DAMAGED AND REPLACED WHEN THE TRUCK WAS DELIVERED IN THE DARK. THE CARGO FLOOR WAS DEFECTIVE 2 FLORRS WERE ORDERED. UPDATED 9/25/18*JB

The contact owns a 2017 Mercedes-Benz Sprinter 2500 equipped with Kumho Tires, Tire Line: Road Venture TR, Tire Size: LT245/75/R16, DOT Number: H211YD5F1717. The contact stated that while he was cleaning the vehicle, he noticed that the front tires had pieces of tire rubber around the tire and that the tread was delaminating. The contact inspected the rear tires and noticed that there was premature tire wear on the tread of both tires. The contact called the tire manufacturer who directed him to take the vehicle to an independent tire dealer for diagnostic testing where it was confirmed that the tires were undergoing premature wear. The manufacturer was notified of the failure. The approximate vehicle failure mileage was 18,000 and the tire failure mileage was 18,000.

The contact owns a 2017 Mercedes-Benz Sprinter 2500. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed knock sensor, debris in the EGR valve, insufficient Selective Catalytic Reduction(SCR), and low DEF. The contact was informed that the knock sensor and the SCR converter needed to be replaced, and the EGR valve needed to be cleaned. The vehicle ws not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 73,000.