2024 Mercedes-Benz Sprinter 2500 Problems

2024 Mercedes-Benz Sprinter 2500 experienced unusually rapid brake, tire, and battery wear at low mileage. Front brakes required replacement at approximately 29,000 miles. Rear brakes were already worn low by approximately 37,000 miles. Rear tires required replacement by approximately 37,000 miles. Vehicle battery also failed and required replacement before approximately 37,000 miles. Vehicle had earlier emissions/sensor related repairs as well. This creates safety concerns because premature brake wear can reduce stopping ability and increase stopping distance. Premature tire wear can reduce traction, especially in rain, and increase risk of tire failure or blowout. Unexpected battery failure can disable the vehicle without warning in traffic or roadside conditions. Vehicle is used in normal commercial delivery service and is generally not heavily loaded. I have owned and operated multiple prior Sprinter vans over many years, and previous model years achieved substantially longer brake, tire, and battery life under similar or heavier use. A newer comparable fleet vehicle with similar mileage has not required these repairs. The issue appears abnormal compared with prior ownership experience and may indicate brake system drag, an alignment issue, defective components, battery charging issue, or another unresolved defect. Vehicle has been serviced by dealer and components were replaced, but premature wear remains the concern. In addition, rear brake wear occurring this early suggests possible imbalance or excessive brake application that should be investigated. Rapid tire wear combined with brake wear may indicate alignment or braking system issues affecting vehicle control and safety. I am submitting this complaint so the condition can be reviewed for potential defect trends affecting other similar vehicles. Defective parts may be available from prior repairs depending on service center retention.

The van has a cross wind assist mode. When it activates it aggressively activates only one front wheel brake so dramatically that the van dives down and swerves out of the lane into the adjacent lane. The front wheel happened to be on wet pavement and it was chattering from braking so hard and not getting traction. I passed a slower motorcycle on the road and the crosswind assist almost caused me to run him off the road. The problem has not been reported to the dealer because i have read on several forums that dealers wont do anything about it. many people are complaining about this and it happens without warning. the problem started as soon as I bought the van, it now has 10,000 miles on it. This is a feature that is included with the van. When the dashboard lights do come on when the cross wind assist activates. No other warnings nor is thier any warning before the wind assist activates. Thanks for reading my concern

2024 Mercedes-Benz Sprinter 2500 experienced unusually rapid brake, tire, and battery wear at low mileage. Front brakes required replacement at approximately 29,000 miles. Rear brakes were already worn low by approximately 37,000 miles. Rear tires required replacement by approximately 37,000 miles. Vehicle battery also failed and required replacement before approximately 37,000 miles. Vehicle had earlier emissions/sensor related repairs as well. This creates safety concerns because premature brake wear can reduce stopping ability and increase stopping distance. Premature tire wear can reduce traction, especially in rain, and increase risk of tire failure or blowout. Unexpected battery failure can disable the vehicle without warning in traffic or roadside conditions. Vehicle is used in normal commercial delivery service and is generally not heavily loaded. I have owned and operated multiple prior Sprinter vans over many years, and previous model years achieved substantially longer brake, tire, and battery life under similar or heavier use. A newer comparable fleet vehicle with similar mileage has not required these repairs. The issue appears abnormal compared with prior ownership experience and may indicate brake system drag, an alignment issue, defective components, battery charging issue, or another unresolved defect. Vehicle has been serviced by dealer and components were replaced, but premature wear remains the concern. In addition, rear brake wear occurring this early suggests possible imbalance or excessive brake application that should be investigated. Rapid tire wear combined with brake wear may indicate alignment or braking system issues affecting vehicle control and safety. I am submitting this complaint so the condition can be reviewed for potential defect trends affecting other similar vehicles. Defective parts may be available from prior repairs depending on service center retention.

Vehicle: 2024 Mercedes-Benz Sprinter VIN: [XXX] Mileage: 148,000 The vehicle is experiencing a serious safety-related defect where the starter motor remains engaged even after the engine is turned off. This results in the starter continuing to run and stay powered, which can cause severe mechanical damage, overheating, and presents a potential fire risk. The starter has already been replaced, but the issue persists, indicating the problem is within the vehicle’s electrical control system (such as wiring harness, relay, or control module). Additionally, I was informed that this same vehicle had a prior wire harness-related issue in 2024 under the previous owner, suggesting a recurring or unresolved electrical defect. This condition can lead to unexpected vehicle behavior and poses a safety hazard due to the risk of electrical failure or fire. The vehicle is currently at a Mercedes-Benz dealership for diagnosis, and a case has been opened with Mercedes-Benz USA under case #XXX. I am submitting this complaint to report a potential safety defect and request investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Complaint Description I am filing this complaint with the National Highway Traffic Safety Administration regarding a safety issue with my new Mercedes Benz Sprinter 2500. I purchased this vehicle brand new from Mercedes Benz Manhattan. From the first day of ownership, I began experiencing multiple serious problems with the van. The main issue is that exhaust smoke and/or crankcase gases enter the cabin while driving. In addition, the vehicle experiences strong vibrations and the transmission frequently kicks or shifts abruptly. On several occasions this issue has caused the engine to stall while driving. (Traffic light stop) These problems create a potentially dangerous situation and make the vehicle unsafe to operate. The dealership, Mercedes Benz Manhattan, has attempted to repair the vehicle many times, but the problems persist and have not been resolved. Because of the ongoing safety risks, I believe this issue should be investigated.

The drive shaft to front differential (part # A9070410-09-00) in MY23 and MY24 Sprinter AWD has structural flaw in the sense that: (1) it is so short that the shaft can easily fall off during normal road conditions. (2) the clip and O-ring to secure the A9070410-09-00 is not strong enough to handle the normal stress of this driver shaft. If A9070410-09-00 falls off, severe vibration occurs and the Sprinter can only drive 2mile/hour or even stop functioning. There is a good chance that the driver can get stuck in the middle of nowhere without the reach to any help. This is a SERIOUS design failure and needs to have a recall and permanent fix ASAP! For more information, pls refer to this Youtube video by [XXX]: [XXX] My brand-new van only has 2600 miles on it and there is no offroad at all. The front drive shaft is almost completely falling off and it sits in a MB dealer for repair now. Pls address this serious safety risk ASAP! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle was inspected and it was found that the seatbelt B-pillar anchor bolt was stripped at the factory. This problem seems widespread online.

I removed the drive side seat belt bolt in order to remove the pillar it is mounted to and found the bolt extremely hard to turn and ultimately somewhat stripped upon removal. The bolt remains defiant in re-installation procedure. The passenger side was removed without stripping but did attempt to cross-thread itself upon re-installation which was remedied by simple hand threading. Safety put at risk in that these seat belt bolts and their installation process may not restrain passengers in an accident. Not confirmed by dealer or service center - pictures should be self evident. The component hasn't been inspected by any party - I'm just going to buy a new bolt and re-tap the hole it was installed in. No warning lights for this isssue.

The driver and passenger side mirror glass on 2024 Sprinter 144" Awd Passenger Van shakes violently while driving at any speed over 50mph. This creates a safety issue where it is nearly impossible to judge the type and speed of vehicle that is in your side mirror view. The Mercedes Benz dealership has been asked to investigate the issue but has stated, "Everything is secure, shakes and rattles are inherent to these vans." This response is unacceptable given the public and personal safety risk associated with decreased visibility in such a large vehicle. There is additional anecdotal evidence of this problem spanning multiple production years on online forums dedicated to Sprinter van ownership experiences. This information and a potential remedy of investigating and replacing an improperly installed rivet nut, has been provided to the Mercedes-Benz Baton Rouge dealership.

The van has a cross wind assist mode. When it activates it aggressively activates only one front wheel brake so dramatically that the van dives down and swerves out of the lane into the adjacent lane. The front wheel happened to be on wet pavement and it was chattering from braking so hard and not getting traction. I passed a slower motorcycle on the road and the crosswind assist almost caused me to run him off the road. The problem has not been reported to the dealer because i have read on several forums that dealers wont do anything about it. many people are complaining about this and it happens without warning. the problem started as soon as I bought the van, it now has 10,000 miles on it. This is a feature that is included with the van. When the dashboard lights do come on when the cross wind assist activates. No other warnings nor is thier any warning before the wind assist activates. Thanks for reading my concern

Complaint Description I am filing this complaint with the National Highway Traffic Safety Administration regarding a safety issue with my new Mercedes Benz Sprinter 2500. I purchased this vehicle brand new from Mercedes Benz Manhattan. From the first day of ownership, I began experiencing multiple serious problems with the van. The main issue is that exhaust smoke and/or crankcase gases enter the cabin while driving. In addition, the vehicle experiences strong vibrations and the transmission frequently kicks or shifts abruptly. On several occasions this issue has caused the engine to stall while driving. (Traffic light stop) These problems create a potentially dangerous situation and make the vehicle unsafe to operate. The dealership, Mercedes Benz Manhattan, has attempted to repair the vehicle many times, but the problems persist and have not been resolved. Because of the ongoing safety risks, I believe this issue should be investigated.

Complaint Description I am filing this complaint with the National Highway Traffic Safety Administration regarding a safety issue with my new Mercedes Benz Sprinter 2500. I purchased this vehicle brand new from Mercedes Benz Manhattan. From the first day of ownership, I began experiencing multiple serious problems with the van. The main issue is that exhaust smoke and/or crankcase gases enter the cabin while driving. In addition, the vehicle experiences strong vibrations and the transmission frequently kicks or shifts abruptly. On several occasions this issue has caused the engine to stall while driving. (Traffic light stop) These problems create a potentially dangerous situation and make the vehicle unsafe to operate. The dealership, Mercedes Benz Manhattan, has attempted to repair the vehicle many times, but the problems persist and have not been resolved. Because of the ongoing safety risks, I believe this issue should be investigated.