Seat belts
Filed Aug 14, 2024
The contact owns a 2011 Mercedes-Benz Sprinter 3500. The contact stated while driving at an undisclosed speed, the SRS warning light illuminated. The contact stated that the front driver's side seat belt buckle functioned as intended; however, the SRS warning light had remained constantly illuminated for nearly two years. The vehicle was taken to a dealer where it was diagnosed with front driver's seat belt buckle failure. The contact was informed that the front driver's side seat belt buckle needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 49,857.
- NHTSA ID
- 11608566
- Incident
- Jun 14, 2022
- Mileage
- 49,857 mi
ElectricalSeat belts
Filed Feb 9, 2023
The contact owns a 2011 Mercedes-Benz Sprinter 3500. The contact stated that the SRS (Supplemental Restraint System) warning light would intermittently appear on the instrument panel. The contact had taken the vehicle to a dealer where a diagnostic test showed that the wires in the front driver’s side seat belt buckle were defective and needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was 49,587.
- NHTSA ID
- 11506458
- Incident
- Jul 1, 2021
- Mileage
- 49,587 mi
Airbags
Filed Mar 17, 2022
Takata Recall. The contact owns a 2011 Mercedes-Benz Sprinter 3500 built on a Freightliner chassis. The contact received notification of NHTSA Campaign Number: 19V003000 (Air Bags) however, the contact was unable to locate a service center to repair the vehicle. After contacting the Manufacturer and the local Mercedes-Benz dealer, the contact was referred to Freightliner to have the recall repairs performed. After contacting Freightliner Customer Service, the contact was referred back to Mercedes Benz. Several individuals from Mercedes-Benz and Freightliner had been contacted regarding the issue but neither was willing resolve the safety recall issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.
- NHTSA ID
- 11457084
- Incident
- Mar 17, 2022
Other / unspecified
Filed Sep 10, 2021
The contact owns a 2011 Mercedes Sprinter 3500 equipped with the Tyron Multiband Runflat Tyre Protection system on the inside of the front driver’s and passenger’s side tires. The contact stated that while driving above 60 mph, the vehicle would shudder as if the front driver’s and passenger’s side tires were out of balance. The Tyron Multiband system was installed on the inside of front driver’s and passenger’s side tires to prevent rollovers caused by blowouts. The tire dealer was made aware of the failure and informed the contact that since the Tyron Multiband system was installed, they could not balance the tires and the tires would self-balance after 200 miles. The dealer was made aware of the failure and referred the contact to take the vehicle to a Mercedes dealer for the chassis. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 47,900.
- NHTSA ID
- 11432465
- Incident
- May 14, 2021
- Mileage
- 47,900 mi
TAKATA RECALL. THE DEALERSHIP HAS THE PARTS ON ETERNAL BACKORDER. IT HAS BEEN SINCE THE RECALL CAME OUT THAT WE HAVE NOT BEEN ABLE TO GET THIS FIXED. VERY CONCERNED ABOUT DRIVING THE VEHICLE. WHAT CAN I DO?
- NHTSA ID
- 11092428
- Incident
- May 8, 2018
Airbags
Filed Sep 19, 2017
TAKATA RECALL. I HAVE CONTACTED MERCEDES BENZ DEALER SEVERAL TIMES TO MAKE APPOINTMENT TO REPLACE DRIVER AND PASSENGER AIR BAG. NO WORK DONE YET.
- NHTSA ID
- 11024521
- Incident
- Jun 1, 2017
Airbags
Filed Oct 25, 2016
TL* TAKATA RECALL. THE CONTACT OWNS A 2011 MERCEDES-BENZ SPRINTER 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V077000 (AIR BAGS) AND 16V379000 (AIR BAGS). THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 01/25/2017*CT UPDATED 7/9/18*JB
- NHTSA ID
- 10918820
- Incident
- Oct 3, 2016
OUR ITASCA REYO 2012 MOTOR HOME WITH MERCEDES SPRINTER ENGINE HAS HAD 5 EGR VALVE FAILURES. THE FIRST TIME IN 2012 WITH 2632 MILES. THE 5TH TIME IN MARCH 2015 WITH 11,000 MILES. THE VEHICLE GOES INTO LIMP MODE AND SPEED IS REDUCED TO 20 MPH. THIS CAUSES A VERY SERIOUS SITUATION AS THERE IS A GREAT RISK OF BEING REAR ENDED FROM HIGHWAY TRAFFIC TRAVELLING AT 60 MPH. EACH TIME MERCEDES CLAIMS TO HAVE A FIX..A CLIP...A NEW COVER ETC BUT THE FAILURES CONTINUE. THIS REQUIRES BEING TOWED OR LIMPING TO MERCEDES FOR A REPLACEMENT EGR VALVE. IT IS OUTRAGEOUS TO HAVE A LEISURE VEHICLE FAIL OVER AND OVER AGAIN AND MERCEDES REFUSES TO ACCEPT FULL RESPONSIBILITY FOR THIS CONTINUING FAILURE OF THIS PART. *TR
- NHTSA ID
- 10705179
- Incident
- Sep 20, 2012
- Mileage
- 2,632 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.