2020 Mercedes-Benz Sprinter (vs30) Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2020 Mercedes-Benz Sprinter (vs30), grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Driver assistance233.3%
- Body & structure116.7%
- Electrical116.7%
- Other / unspecified116.7%
- Powertrain (other)116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
When the object proximity sensors in the front or rear bumpers detect an object, the vehicle completely or severely limits the throttle. For instance, the rear bumper sensors detect the bike rack attached to my van and therefore limit the throttle response, regardless of transmission direction (forward or reverse). This seems to happen intermittently. When I mute the bumper sensor’s warning by tapping a button, then the throttle responds as expected. This is a known problem on the 2019+ VS30 Mercedes Sprinters, which affects all vans; it is not isolated to my specific van. This presents a safety issue, when the driver expects the vehicle to move but it does not. For instance, when rolling into traffic yet the throttle does not respond.
Active brake assist inoperable and cruise control is not available when this occurs
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2022 Winnebago View built on a 2020 Mercedes-Benz Sprinter chassis. The contact received notification of NHTSA Campaign Number: 22V695000 (Structure, Equipment) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The contact owns a 2020 Mercedes-Benz Sprinter 3500. After the purchase of the vehicle, the contact was informed that he was unable to take possession of the vehicle because of NHTSA Campaign Number: 21V055000 (Electrical System) and that the parts for the recall repair were not yet available. The manufacturer was notified of the recall and initially informed him that the recall update would be available in mid-June however, the contact was recently informed that the update was still unavailable and there was no estimated date for the availability for the update. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Vin tool confirms parts not available.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The contact owns a 2022 Winnebago View built on a 2020 Mercedes-Benz Sprinter chassis. The contact received notification of NHTSA Campaign Number: 22V695000 (Structure, Equipment) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
When the object proximity sensors in the front or rear bumpers detect an object, the vehicle completely or severely limits the throttle. For instance, the rear bumper sensors detect the bike rack attached to my van and therefore limit the throttle response, regardless of transmission direction (forward or reverse). This seems to happen intermittently. When I mute the bumper sensor’s warning by tapping a button, then the throttle responds as expected. This is a known problem on the 2019+ VS30 Mercedes Sprinters, which affects all vans; it is not isolated to my specific van. This presents a safety issue, when the driver expects the vehicle to move but it does not. For instance, when rolling into traffic yet the throttle does not respond.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .