1994 Mercury Cougar Problems

TRANSMISSION FAILURE, NUMEROUS TIMES. *JB

I BOUGHT A 1994 MERCURY COUGAR VIN# [XXX]. I WAS THE SECOND OWNER AND IT HAD ONLY 29K ON IT BACK IN JULY 1997. WELL MY TRANSMISSION WENT OUT BEFORE 68K AND THE COUGAR IS RATTLING APART. I HEARD LATER THAT THERE WAS A RECALL ON THE 3.8 MOTOR FOR THE BLOWER BY WHICH I'M HAVING NOW BUT BEING OVER 100K THEY SAID IT HAD TO BE BY A CERTAIN DATE AND UNDER 100K BUT I WAS NEVER TOLD OR NOTIFIED. FOUND OUT FROM A MECHANIC FRIEND. DON'T KNOW WHAT I CAN DO ABOUT IT. I HAD TO REPLACE THE TRANSMISSION COMPLETELY BECAUSE THE LOW END SHIFT PLATE WAS FAULTY ON THOSE MODELS TOO. ENGINE KEEPS GETTING HOT AND BURNING OFF RADIATOR FLUID. *JB UPDATED 07/16/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

CAR OVERHEATS DUE TO A BAD HEAD GASKET. PER FORD'S TSB 00M10, THIS IS A KNOWN DESIGN ISSUE THAT THEY FIXED ONLY IF THERE WAS A PROBLE DURING THE FIRST 7 YEARS AFTER THE WARRANTY INCEPTION DATE FOR 1994 AND 1995 VEHICLES WITH A 3.8L ENGINE. THIS DEFECT CAN EASILY RESULT IN A SAFETY CONCERN DUE TO THE POSSIBILITY OF AN ENGINE FIRE DUE TO THE EXTREME HEAT IF OIL LEAKS ON THE ENGINE WHEN THE GASKET FAILS. *AK

WE BOUGHT A MERCURY COUGAR 1994 AND DISCOVERED WE HAVE A BLOWN HEAD GASKET. WE JUST FOUND OUT THAT IT IS VIRTUALLY IMPOSSIBLE TO FIND AN ENGINE FOR THE V6 MODEL AT A REASONABLE PRICE. WE ALSO FOUND OUT THAT THIS 1994 MODEL IS FAMOUS FOR BLOWN HEAD GASKETS. *LA

3RD BRAKE LIGHT/HIGH MOUNT STOP LAMP IN THE REAR WINDOW. THE EXCESSIVE HEAT FROM THE BULBS THAT ARE USED CAUSED THE PLASTIC HOUSING THAT THE BULBS ARE IN TO MELT AROUND THE BULB ALONG WITH THE ACTUAL HARNESS THAT THE BULB IS PLUGGED INTO. SINCE I AM NOT THE FIRST OWNER OF MY CAR, I'M SURE THE INCIDENT DATE IS NOT TODAY BUT HAS BEEN AN ONGOING PROBLEM. *JB

VEHICLE BEGAN SPONTANEOUS ACCELERATION WHILE IDLE AND STOPPED ON 10 OCCASIONS SINCE 5/1/2002. IT TOOK ALL OF MY STRENGTH TO DEPRESS THE BRAKE TO KEEP THE CAR FROM JOLTING FORWARD AT A HIGH SPEED. WHILE PULLING INTO MY GARAGE TODAY, TRAVELLING AT LESS THAT 1 MPH, THE CAR ACCELEARATED ON ITS OWN AND I HAD TO SLAM ON THE BRAKE TO PREVENT FROM CRASHING INTO A HEATING OIL TANK. VEHICLE HAS BEGUN TO RANDOMLY SHUDDER WHEN APPLYING BRAKES AT VARIOUS SPEEDS FROM 10 TO 65 MPH. THIS IS NOT A CONSISTENT PROBLEM BUT VERY DANGEROUS WHEN IT OCCURRED ON HIGHWAY YESTERDAY. POWER WINDOW ON DRIVER SIDE NOW RANDOMLY SHUDDERS WHEN LOWERING. THIS IS NOT A CONSISTENT PROBLEM AND IS NEW. THE PASSENGER POWER WINDOW IS INOPERABLE AND TOO EXPENSIVE FOR ME TO HAVE FIXED. THIS APPEARS TO BE A VERY COMMON PROBLEM WITH OTHER OWNERS OF THIS VEHICLE. THE "CHECK ENGINE" LIGHT HAS BEEN ON SINCE 1997 AND THIS IS ALSO A COMMON PROBLEM WITH THIS CAR, FROM WHAT I UNDERSTAND. I WAS TOLD THAT IT WOULD COST ME $150 TO FIX AND THAT IT IS MERELY A SENSOR DEFECT AND NOT A AFETY ISSUE. HOWEVER, IF THIS IS A COMMON PROBLEM, FORD SHOULD OVER THE COST FOR REPAIR, NOT THE CONSUMER.

VEHICLE BEGAN SPONTANEOUS ACCELERATION WHILE IDLE AND STOPPED ON 10 OCCASIONS SINCE 5/1/2002. IT TOOK ALL OF MY STRENGTH TO DEPRESS THE BRAKE TO KEEP THE CAR FROM JOLTING FORWARD AT A HIGH SPEED. WHILE PULLING INTO MY GARAGE TODAY, TRAVELLING AT LESS THAT 1 MPH, THE CAR ACCELEARATED ON ITS OWN AND I HAD TO SLAM ON THE BRAKE TO PREVENT FROM CRASHING INTO A HEATING OIL TANK. VEHICLE HAS BEGUN TO RANDOMLY SHUDDER WHEN APPLYING BRAKES AT VARIOUS SPEEDS FROM 10 TO 65 MPH. THIS IS NOT A CONSISTENT PROBLEM BUT VERY DANGEROUS WHEN IT OCCURRED ON HIGHWAY YESTERDAY. POWER WINDOW ON DRIVER SIDE NOW RANDOMLY SHUDDERS WHEN LOWERING. THIS IS NOT A CONSISTENT PROBLEM AND IS NEW. THE PASSENGER POWER WINDOW IS INOPERABLE AND TOO EXPENSIVE FOR ME TO HAVE FIXED. THIS APPEARS TO BE A VERY COMMON PROBLEM WITH OTHER OWNERS OF THIS VEHICLE. THE "CHECK ENGINE" LIGHT HAS BEEN ON SINCE 1997 AND THIS IS ALSO A COMMON PROBLEM WITH THIS CAR, FROM WHAT I UNDERSTAND. I WAS TOLD THAT IT WOULD COST ME $150 TO FIX AND THAT IT IS MERELY A SENSOR DEFECT AND NOT A AFETY ISSUE. HOWEVER, IF THIS IS A COMMON PROBLEM, FORD SHOULD OVER THE COST FOR REPAIR, NOT THE CONSUMER.

ON DECEMBER 23 MY WIFE WAS DRIVING MY 1994 MERCURY COUGAR AND SHE EXPERIENCED SUDDEN ACCELERATION. *AK,

TAKATA RECALL.... JUST LOOKING FOR ANY RECALLS ON MY CAR,,,,WHOLE FRONT END FELL OUT..

AFTER STARTING THE VEHICLE THE CONSUMER HEARD A LOUD BEEPING NOISE COMING FROM THE PASSENGER SIDE AIR BAG COMPARTMENT. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK *NM

VEHICLE BEGAN SPONTANEOUS ACCELERATION WHILE IDLE AND STOPPED ON 10 OCCASIONS SINCE 5/1/2002. IT TOOK ALL OF MY STRENGTH TO DEPRESS THE BRAKE TO KEEP THE CAR FROM JOLTING FORWARD AT A HIGH SPEED. WHILE PULLING INTO MY GARAGE TODAY, TRAVELLING AT LESS THAT 1 MPH, THE CAR ACCELEARATED ON ITS OWN AND I HAD TO SLAM ON THE BRAKE TO PREVENT FROM CRASHING INTO A HEATING OIL TANK. VEHICLE HAS BEGUN TO RANDOMLY SHUDDER WHEN APPLYING BRAKES AT VARIOUS SPEEDS FROM 10 TO 65 MPH. THIS IS NOT A CONSISTENT PROBLEM BUT VERY DANGEROUS WHEN IT OCCURRED ON HIGHWAY YESTERDAY. POWER WINDOW ON DRIVER SIDE NOW RANDOMLY SHUDDERS WHEN LOWERING. THIS IS NOT A CONSISTENT PROBLEM AND IS NEW. THE PASSENGER POWER WINDOW IS INOPERABLE AND TOO EXPENSIVE FOR ME TO HAVE FIXED. THIS APPEARS TO BE A VERY COMMON PROBLEM WITH OTHER OWNERS OF THIS VEHICLE. THE "CHECK ENGINE" LIGHT HAS BEEN ON SINCE 1997 AND THIS IS ALSO A COMMON PROBLEM WITH THIS CAR, FROM WHAT I UNDERSTAND. I WAS TOLD THAT IT WOULD COST ME $150 TO FIX AND THAT IT IS MERELY A SENSOR DEFECT AND NOT A AFETY ISSUE. HOWEVER, IF THIS IS A COMMON PROBLEM, FORD SHOULD OVER THE COST FOR REPAIR, NOT THE CONSUMER.

THE CARS ENGINE HAS BEEN REPLACED(SO THEY SAID) ON JULY 1997 AND NOW THE ENGINE IS GONE AGAIN. THE SPEED CONTROL DOES NOT WORK. WE HAVE HAD TO REPLACE THE BRAKES 4 TIMES ALREADY. THE DOOR ON THE DRIVERS SIDE THE WINDOW SOMETIMES DOES NOT WORK THE WINDOWS ARE POWER AND WILL NOT GO UP OR DOWN.ALSO THE TRANSMISSION HAS BEEN REPLACED ALSO THE CAR HAS TIRE VIBRATION THANK YOU THIS CAR IS NOW BROKE DOWN AGAIN AND WE STILL ARE MAKING PAYMENTS I CALLED THE DEALER ON 4-5-2000 AND THEY SAID THERE WAS NOTHING THEY COULD DO THANK YOU AGAIN FOR LOOKING AT OUR CAR PROBLEMS. *AK

TAKATA RECALL.... JUST LOOKING FOR ANY RECALLS ON MY CAR,,,,WHOLE FRONT END FELL OUT..

THE FRONT COIL SPRINGS BROKE WITHOUT WARNING. AS A RESULT WHEN DRIVING AT ANY SPEED THE VEHICLE VEERED TO THE RIGHT. *JB

ENGINE IDLES ROUGHLY AND SURGES AT STOP LIGHTS, DEALERS HAVE STATED THAT THERE ARE NO PROBLEMS AND THAT ALL MERCURYS ACT THIS WAY. *JG

WATER IS DRAINING INTO INTAKE MANIFOLD AND THEN INTO ENGINE, CAUSING DAMAGE TO ENGINE.TSB HAS BEEN ISSUED . *AK

DT: ON 6/21/2005 WHILE DRIVING AT NIGHT IN CLEAR CONDITIONS ON DRY PAVEMENT THE VEHICLE STALLED AND CAUGHT ON FIRE. THE SPEED WAS ABOUT 5-7 MPH. THERE WERE NO BRAKES, NO ELECTRICAL SYSTEM, NO POWER STEERING, NO ENGINE SOUND, NO LIFE IN THE VEHILCE AT ALL. THERE WAS NO WARNING LIGHTS THAT CAME ON. THE VEHILCLE HAD BEEN DRIVEN FOR ABOUT 45 MINUTES AND 40 MILES BEFORE THIS OCCURRED. THEN, THE VEHICLE SAT FOR ABOUT 2 HOURS.THE VEHICLE WAS DRIVING FINE, AND WAS SERVICED A A WEEK PRIOR TO THE INCIDENT. THE VEHICLE WAS PUT ON THE DIAGNOSTIC THAT DAY AND EVERYTHING LOOKED FINE, BESIDES THE BRAKE LIGHTS HAD TO BE REPAIRED, BUT IT WAS NOT THE FUSE THAT HAD TO BE REPAIRED, OWNER WAS UNSURE WHAT COMPONENT CAUSED THE BRAKE LIGHTS TTO FAIL. THERE WERE ALSO NO TAIL LIGHTS .EITHER.THE BACK LIGHTS WERE COMPLETELY OUT. AFTER REPAIR EVERYTHING WAS FINE UNTIL FIRE. WHEN THE CAR STALLED ON 6/21/05, THE VEHICLE STOPPED ON THE SIDE OF THE ROAD. THERE WAS SMOKE COMING FROM HOOD, THEN THERE WAS A MAN WHO CAME TO HELP AND SPRAYED THE FIRE WITH EXTINGUISHER. .*AK

THE VEHICLE FAILED TO START DUE TO A FAILURE IN THE IGNITION STARTER SYSTEM. THE STARTER WAS REMOVED AND INSPECTED BY A STARTER SPECIALIST, HOWEVER NO PROBLEM WAS FOUND. THE STARTER WAS REINSTALLED. THE VEHICLE STILL FAILED TO START. THE IGNITION CYLINDER TURNS ALL THE WAY AROUND ALSO. THE VEHICLE HAS BEEN SITTING IN THE GARAGE FOR A YEAR DUE TO THIS PROBLEM BECAUSE THE CAUSE COULDN'T BE FOUND. *JB

TAKATA RECALL.... JUST LOOKING FOR ANY RECALLS ON MY CAR,,,,WHOLE FRONT END FELL OUT..

LANDUA LIGHTS RUSTED CAUSING SHORT IN TAIL, AND DASH LIGHTS. ALSO, DOOR LOCKS AND INTERIOR LIGHT FUSE KEEPS BLOWING. AND UNKNOWN CAUSING LEAK ON THE FRNT PASSENGER SIDE FLOOR.

FRONT PASSENGER SIDE SEAT BELT RELEASE BUCKLE FAILED TO LATCH, GAVE FALSE LATCH, THEN FAILED COMPLETELY. BUCKLE WAR ORIGINAL EQUIPMENT. REPAIR COST WAS $140.00. *AK

WHILE DRIVING AT 10 MPH REAR ENDED A PARKED VEHICLE. UPON IMPACT, DRIVER'S SIDE AND PASSENGER'S SIDE AIR BAGS DIDN'T DEPLOY. ALSO, SEAT BELTS DIDN'T RESTRAIN THE CONSUMERS FROM HITTING THE WINDSHIELD. *AK

LANDUA LIGHTS RUSTED CAUSING SHORT IN TAIL, AND DASH LIGHTS. ALSO, DOOR LOCKS AND INTERIOR LIGHT FUSE KEEPS BLOWING. AND UNKNOWN CAUSING LEAK ON THE FRNT PASSENGER SIDE FLOOR.

ENGINE CHECK LIGHT GOES ON AND OFF ,WAS TOLD IT REQUIRED TWO SENSORS-/ SOMETHING IS WRONG WITH THE WIRING, AUTOMATIC DOOR LOCKS WORK SOMETIMES AND THE CLOCKS GOES ON & OFF NEVER KEEPING THE CORRECT TIME/ LOST EMERGENCY BRAKE/ AND SPIDER CRACKS IN THE BLACK CLEARCOART ON ROOF, HOOD, AND TRUNK. *AK

ENGINE CHECK LIGHT GOES ON AND OFF ,WAS TOLD IT REQUIRED TWO SENSORS-/ SOMETHING IS WRONG WITH THE WIRING, AUTOMATIC DOOR LOCKS WORK SOMETIMES AND THE CLOCKS GOES ON & OFF NEVER KEEPING THE CORRECT TIME/ LOST EMERGENCY BRAKE/ AND SPIDER CRACKS IN THE BLACK CLEARCOART ON ROOF, HOOD, AND TRUNK. *AK

THE DISC BRAKES ON THE FRONT TEND TO VIBRATE AND CAUSE LOSS OF CONTROL OF THE STEERING WHEEL. PLEASE DESCRIBE. TT

THE HEADLIGHT LENSES ARE PLASTIC AND ARE NOW SEVERLY CRAZED AND YELLOWED TO A POINT THAT DRIVING AT NIGHT IS A VERY DEFINITE HAZARD. I AM REPLACING THEM BECAUSE OF THIS HAZARD. THERE IS NO WAY THAT THIS PART SHOULD HAVE FAILED IN SUCH A SHORT TIME SPAN.*AK

LANDUA LIGHTS RUSTED CAUSING SHORT IN TAIL, AND DASH LIGHTS. ALSO, DOOR LOCKS AND INTERIOR LIGHT FUSE KEEPS BLOWING. AND UNKNOWN CAUSING LEAK ON THE FRNT PASSENGER SIDE FLOOR.

POOR TREADING PLACED ON THE TIRE. CAUSING INCREASED STOPPING DISTANCE. TT

ENGINE WAS REPLACED AT 87,000 MILES UNDER RECALL FOR HEAD GASKET FAILURE. 30,000 MILES LATER ENGINE HEAD BLEW UP AGAIN DUE TO THE PLACEMENT OF A HELICOIL IN THE RE-MANUFACTURED ENGINE. THIS HELICOIL WAS PRESENT IN THE RE-MANUFACTURED ENGINE FROM THE FACTORY. I CONSIDER THIS TO BE A DEFECT IN THE RE-MANUFACTURED ENGINE, AS THE HEAD SHOULD HAVE BEEN MACHINED BY THE FACTORY NOT JUST HAVE A HELICOIL STUFFED IN. THIS IIS THE CAUSE OF THE NEW FAILURE AND FOR REFUSES TO REPAIR. *NLM

WHENEVER CONSUMER OPENS DOORS, DOORS DO NOT LATCH BACK, DOORS WILL BEGAN TO CLOSE, HITTING CONSUMER ON KNEES. EVN WHEN PARKED ON SLIGHTEST INCLINE DOORS WILL NOT STAY OPEN. *AK