1996 Mercury Cougar Problems

TL * THE CONTACT OWNS A 1996 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING ANTI FREEZE ABNORMALLY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS ADVISED THAT THE PLASTIC INTAKE MANIFOLD WAS FRACTURED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED TO REPORT THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 140,000.

WHILE DRIVING MY 1996 COUGAR THIS PAST SEPTEMBER, WHICH HAS ONLY 40,360 MILES ON IT AND IS STORED MOST OF THE YEAR FOR THE PURPOSES OF COLLECTING AND PRESERVING THE VEHICLE INDEFINITELY, AT LOW SPEEDS I NOTICED THE OBVIOUS SIGN OF COOLANT AND THE SMELL OF COOLANT COMING FROM UP UNDER THE HOOD. I THEN SHUT THE VEHICLE DOWN RIGHT AWAY AND DISCOVERED COOLANT RUNNING ONTO THE GROUND BELOW. NOW, BEING OF AN EXPERIENCED NATURE WITH AUTOMOBILES AND USING CLOSE OBSERVATION OF THE PROBLEM IT APPEARED TO BE EMANATING FROM THE FRONT OF THE INTAKE MANIFOLD. I THEN DISCOVERED AFTER THE FACT THAT THESE 4.6 LITER ENGINES ARE NOTORIOUS FOR THIS INTAKE CRACKING PROBLEM, SO NOW I WILL BE PURCHASING AN UPGRADED AND IMPROVED INTAKE FOR AROUND $223.00 THAT IS DESIGNED AS A REPLACEMENT FOR THIS DEFECTIVE MANIFOLD. I THEN HAD MY VEHICLE TOWED TO MY PLACE OF RESIDENCE AT THE COST OF AROUND $100.00 QUESTION IS? WHY THEN AM I ONE OF THOSE OWNERS THAT WERE NOT GIVEN THE OPPORTUNITY TO GET A COVERED REPLACEMENT WHEN IT IS VERY APPARENT THAT MY YEAR 1996 MERCURY COUGAR SHOULD HAVE BEEN INCLUDED IN THE 4.6 ENGINES RECALL. THIS COULD HAVE BEEN A DISASTROUS SITUATION DAMAGING OR SHORTENING THE LIFE OF A WELL CARED FOR ENGINE. THE INTAKE MANIFOLD IS SIMPLY NOT A COMPONENT THAT SHOULD FAIL, I REALIZE THAT THIS DOESN'T APPLY TO EVERY COMPONENT ON A VEHICLES ENGINE BUT IT DOES AND SHOULD APPLY TO THIS COMPONENT BECAUSE OF THE IMPORTANCE OF THIS PART, SINCE THE POTENTIAL COST INCURRED TO AN OWNER IF IT OVERHEATS THE ENGINE COULD BE QUITE HIGH AND THIS IS COMPLETELY SOLVABLE BY PROPER COMPONENT DESIGN AS IS WELL PROVEN WITH GOOD DESIGNS IN THE MANY AUTOMOBLES PRODUCED IN PAST YEARS. *CN

DT: WITHOUT WARNING WHILE STEPPING ON BRAKE THE CAR WILL ACCELERATE, AND THE ENGINE WILL REV UP. CALLER HAS TO STOMP ON BRAKE HARD TO GET IT TO STAY STILL. CAR CAN BE IN GEAR OR IN PARK WHEN THIS HAPPENS. DEALER HAS NOT BEEN CONTACTED YET. MANUFACTURER HAS NOT BEEN CONTACTED YET. EVERY TIME HE HAS TAPPED THE BRAKE JUST BEFORE THIS HAPPENS.*AK

CHECK FOR COOLANT LEAK AT INTAKE MANIFOLD. REPLACED INTAKE MANIFOLD. THERE WERE REGULAR OIL CHANGES AND TIRE ROTATION. *BF THE ENGINE LIGHT HAD COME ON, AND THE COOLANT LIGHT WOULD COME ON AND OFF. THE DEALER HAD TO REPLACE THE ENGINE SENSOR LIGHT AND ADDED A CUP OF WATER. THE CONSUMER'S SON IN LAW WAS DRIVING THE VEHICLE AND WHITE SMOKE COMING FROM UNDER THE VEHICLE, THE RUBBER STRIP ON THE INSIDE OF THE VEHICLE WAS COMING OFF, THE RIGHT REAR TRIM PANEL COMING LOOSE, THE BRAKES MADE RUBBING NOISE INTERMITTENTLY, GLOVE BOX DOOR WON'T SHUT, THE AIR BAG WOULD RATTLE, THE RIGHT FRONT DOOR RATTLED WHILE THE VEHICLE WAS IN MOTION, AND THE DOOR SWITCH TRIM PANEL WAS DISCOLORED. *SC

TL* THE CONTACT OWNS A 1996 MERCURY COUGAR. THE CONTACT STATED THAT THE CLIMATE CONTROL ADJUSTER FAILED. AS A RESULT, THE BLOWER WOULD ONLY FUNCTION ON HIGH AND THE CONTACT WAS UNABLE TO ADJUST THE DEFROST SYSTEM. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO HAVE THE FAILURE DIAGNOSED, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 61,000 AND THE CURRENT MILEAGE WAS 62,000. THE VIN WAS UNAVAILABLE. UPDATED 05/24/12*LJ

TRUNK LID WILL OPEN WHILE DRIVING, THIS HAS HAPPENED NUMEROUS TIMES. DEALER DETERMINED AN ELECTRICAL PROBLEM. *AK *JB

CHECK FOR COOLANT LEAK AT INTAKE MANIFOLD. REPLACED INTAKE MANIFOLD. THERE WERE REGULAR OIL CHANGES AND TIRE ROTATION. *BF THE ENGINE LIGHT HAD COME ON, AND THE COOLANT LIGHT WOULD COME ON AND OFF. THE DEALER HAD TO REPLACE THE ENGINE SENSOR LIGHT AND ADDED A CUP OF WATER. THE CONSUMER'S SON IN LAW WAS DRIVING THE VEHICLE AND WHITE SMOKE COMING FROM UNDER THE VEHICLE, THE RUBBER STRIP ON THE INSIDE OF THE VEHICLE WAS COMING OFF, THE RIGHT REAR TRIM PANEL COMING LOOSE, THE BRAKES MADE RUBBING NOISE INTERMITTENTLY, GLOVE BOX DOOR WON'T SHUT, THE AIR BAG WOULD RATTLE, THE RIGHT FRONT DOOR RATTLED WHILE THE VEHICLE WAS IN MOTION, AND THE DOOR SWITCH TRIM PANEL WAS DISCOLORED. *SC

WHILE DRIVING, THE HOOD FLEW UP WITHOUT WARNING. AS A RESULT THE WINDSHIELD SHATTERED. THERE IS A DEFECTIVE DESIGN TO THE HOOD LATCH. *JB *MR

ON FIVE OCCASIONS WHILE DRIVING VEHICLE STARTED TO ACCELERATE INTERMITTENTLY. VEHICLE BEEN TO DEALER ON TWO OCCASIONS, AND THEY COULD NOT DUPLICATE THE PROBLEM. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

ENGINE IDLE PULLEY REPLACED.

TL*THE CONTACT OWNS A 1996 MERCURY COUGAR. THE CONTACT STATED THAT THE DRIVERS SIDE FRONT DOOR AND THE PASSENGERS SIDE FRONT DOOR WOULD OPEN WHILE DRIVING AT ANY SPEED. WHEN SHE CLOSED THE DOORS THEY COULD BE PUSHED OPEN WITH LITTLE EFFORT. FORD WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS. NHTSA CAMPAIGN ID NUMBER: 96V070000, LATCHES, LOCKS, LINKAGES, AND DOOR LATCH WAS, ISSUED FOR HER YEAR, MAKE AND MODEL VEHICLE. THE CONTACT WAS ADVISED OF THE 10 YEAR EXPIRATION PERIOD. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 114,000.

DRIVER'S DOOR LATCH MALFUNCTIONED. THEREFORE, THE DOOR DIDN'T CLOSE FULLY, AND COULD FLY OPEN WHILE DRIVING. THE ENTIRE LATCH HAD TO BE REPLACED. *AK

WHILE TRAVELING ON I-4 FROM TAMPA, THE LEFT REAR TIRE TREAD SEPARATED FROM THE TIRE. APPROXIMATELY 15 TO 20 INCHES OF TREAD BECAME SEPARATED.*AK

TIRE BLEW OUT ON CITY STREET GOING APPROX 35MPH. TIRE PRESSURE WAS CHECKED ON 5-28-98 AND ALSO 9-2-98 BY FORD DEALER. HAVE INFO ON SERVICE TICKETS. FIRESTONE REP SAID TIRE HAD BEEN DRIVEN WITH LOW PRESSURE AND ALSO ON GLASS. SIDEWALL BLEW OUT. THIS PERSON WAS NOT WORTH TALKING TO. PURCHASED ANOTHER BRAND AND DISCARDED CARCASS.*AK( DOT NUMBER: TIRE SIZE: P215 70R/1 )

HEADLIGHT SWITCH HAS SHORTED OUT MANY TIMES. LOCAL DELARSHIP KNOWS THE PROBLEM AND I HAVE HAD IT REPLACED BY A LOCAL SHOP THREE TIMES. FOD HAD CHECKED FOR ELECTRICAL SHORTS AND SAID THEY WERE ALL FINE.*AK AUTOMATIC TRANSMISION WENT OUT BECAUSE THE FILTER WASNT GETTING ENOUGH FLUID BECAUSE THE FILTER WASNT CLOSE ENOUGH TO THE BOTTOM OF THE FAN 96 COUGAR 41,000 ORIGINAL MILES

TRANSMISSION PROBLEM EXISTED BUT I DIDN'T RECOGNIZE "SHUDDER". DEALER RECCOMMENDED ADDITIVE TO TRANSMISSION. FLUID JUST AFTER I PURCHASED CAR (NEW). NOW SHUDDER IS SO BAD I HAVE TO GET TRANSMISSION WORK.*AK

MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE. RECALL # 97V159000 1992-93 MERCURY COUGARS...FORD RECALL LETTER TO YOU DATED 9-17-1997..MY COUGAR BUILT 4-'96...1996 WAS THE LAST YEAR FOR THIS CAR. ALL COUGARS 1992 TO 1996 SHOULD HAVE BEEN RECALLED, FOR THE CONVOLUTE COVERING PREVENTION TO BE INSTALLED AROUND THE FUEL LINES PER FORD RECALL LETTER 573.5 (C) (8) CAMPAIGN # 97S84. PURSUANT TO PART 573 OF TITLE 49 OF THE CODE OF FEDERAL REGULATIONS. *NM

GAS LINE LEAK POSITIONED OVER ELECTRICAL WIRE. *AK

WHEN AIRBAGS DEPLOYED, SEATBELT BECAME UNLATCHED

SEAT BELT LOCKS UP.

VEHICLE WAS GOING 20MPH RIGHT BALL JOINT LOCKED UP. VEHICLE STEERED STARIGHT, BUT WAS PULLING RIGHT. EVERTUALLY, VEHICLE STOPPED ITSELF. MERCURY DEALER WAS NOTIFIED.*AK

THE FIRST TIME THE FRONT ROTORS HAD TO BE RESURFACED THE VEHICLE ONLY HAD 10,000 MILES ON IT, THAN IT WAS RESURFACED AGAIN AND FINALLY WE HAD TO HAVE NEW ROTORS INSTALLED. THE SAME PROBLEM STARTED HAPPENING AGAIN CAUSING THE BRAKES TO WEAR, ROTORS RESURFACED AGAIN, THAN NEW TIRES IN THE FRONT WERE WEARING OUT OF ROUNDS, NOW THIS WILL BE THE FIFTH TIME WE HAVE TO HAVE THE ROTORS REPAIRED (RESURFACED). THE STEERING WHEEL VIBRATES TERRIBLY WHEN APPLYING THE BRAKES DUE TO THIS PROBLEM.*AK

HEADLIGHT SWITCH HAS SHORTED OUT MANY TIMES. LOCAL DELARSHIP KNOWS THE PROBLEM AND I HAVE HAD IT REPLACED BY A LOCAL SHOP THREE TIMES. FOD HAD CHECKED FOR ELECTRICAL SHORTS AND SAID THEY WERE ALL FINE.*AK AUTOMATIC TRANSMISION WENT OUT BECAUSE THE FILTER WASNT GETTING ENOUGH FLUID BECAUSE THE FILTER WASNT CLOSE ENOUGH TO THE BOTTOM OF THE FAN 96 COUGAR 41,000 ORIGINAL MILES

THE IGNITION HAS FAILED ON TWO OCCASIONS. CAR WOULDN'T SHUT OFF BY IGNITION KEY. HAD TO SHUT OFF VIA FUEL SHUTOFF. MR

POWER STEERING FAILS INTERMITTENTLY, CAUSING LOSS OF CONTROL.

POWER STEERING CONTROL MODULE FAILED.

THE GAS DID NOT SHUT OFF DURING IMPACT,ALONG WITH THE AIRBAGS NOT DEPLOYING. THE DRIVER COULD OF BEEN KILLED TODAY. PLEASE FIND OUT WHY THE AIR BAGS DID NOT DEPLOY. THANK YOU JAYNE HOWARD. *AK

PROBLEMS WITH VEHICLE'S INTAKE MANIFOLD. *MR ONE WEEK BEFORE THE INTAKE MANIFOLD PROBLEM THE VEHICLE WAS IN FOR A PROBLEM WITH THE BACK UP AND BRAKE LIGHTS, THE FAN BELT, AND THE VEHICLE OVER HEATED AFTER ATTEMPTING TO PASS ANOTHER VEHICLE ON THE HIGHWAY. *SC *JB

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK