2008 Mercury Mariner Hybrid Problems

TL* THE CONTACT OWNS A 2008 MERCURY MARINER HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOSS MOTIVE POWER AND STALLED WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO ANDY MOHR FORD LOCATED AT 2713 E. MAIN ST, PLAINFIELD, IN 46168 HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 87,000.

STOP SAFELY NOW CHIMES AND DISPLAYED ON DASH FOLLOWED BY NO ACCELERATION UNTIL VEHICLE STALLS AND STOPS.STARTS RIGHT BACK UP BUT CONTINUES TO HAPPEN ESPECIALLY IN LA RUSH HOUR TRAFFIC. VERY DANGEROUS! HAD RECALL WORK DONE ON THE MECS 3YRS AGO BUT PROBLEM HAS CONTINUED. THIS HAPPENS WHILE IN MOTION ON THE 110 FREEWAY IN DOWNTOWN LOS ANGLELES, CA. COULD BE THE ELECTRIC THROTTLE BODY OR REAR ACTUATOR. OR ANY OTHER COMPONENT THAT WORKS WITH THE ELECTRIC MOTOR AND BATTERY.

ABS BRAKE LIGHT WARNING CAME ON. BRAKES PRETTY MUCH STOPPED WORKING WITHOUT ANY PRIOR WARNING TO THE LIGHTS. HAD TO DEPRESS THE PEDAL ALL THE WAY TO GET BRAKES. VERY UNSAFE. NOW THE BRAKE IS STUCK ON AND THE CAR DOESN'T MOVE. HAVE TALKED TO AND READ ABOUT SEVERAL PEOPLE THAT HAD THE SAME ISSUE. WHY HASN'T THERE BEEN A RECALL YET?

"TAKATA RECALL" WHEN I WAS LEAVING A STORE YESTERDAY I NOTICED THAT MY ABS, BRAKE LIGHT CAME ON ALONG WITH A DESCRIPTION INDICATING MY CHECK BRAKE SYSTEM. I NEVER NOTICED AN ISSUE WITH MY BREAKS PRIOR TO THESE SIGNALS COMING ON AND MY FIANC'S CAR HAD BEEN FUNCTIONING WELL FOR THE LAST FOUR YEARS. I NORMALLY DRIVE THE SUV SO WHEN I NOTICED IT SAID THAT I MADE SURE THE BREAKS WERE WORKING WHEN I STARTED TO MOVE. I DID NOTICE THAT THE BREAKS REQUIRED MORE OF A FIRM PUSH WHEN I WAS NEEDING TO COME TO A SPOT. I DIDN'T HAVE ANY ACCIDENTS OR CAUSED ME TO RUN ANY STOP LIGHTS OR STOP SIGNS. HOWEVER, AFTER DOING MY OWN RESEARCH I DID FIND OUT THAT THIS IS A PROBLEM FOR THE 2008 MERCURY MARINERS AND FROM SOME OF THE WARNINGS I HAVE READ STATED THE BREAKS ENDED UP FAILING AFTER THIS ALL ACCRUED AND ABOUT GOT THEM INTO ACCIDENTS. WITH THE NHTSA ALREADY INVESTIGATING THE '2006-2012 FUSION AND LINCOLN MKZ AND THE 2006-2011 MERCURY MILAN' MODELS WITH THE SAME ISSUES, IT SEEMS THE ISSUE IS BIGGER THAN JUST THE MERCURY MARINER.

The contact owns a 2008 Mercury Mariner Hybrid. The contact stated while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The Power Steering Assist Fault message was displayed. The contact was able to drive to her destination. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 226,118.

The contact owns a 2008 Mercury Mariner Hybrid. The contact stated while driving 5-10 MPH, the vehicle inadvertently lost power steering functionality. There was no warning light illuminated. The contact was able to continue driving however, extra effort was needed to steer the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that the power steering control module needed to be replaced. The contact became aware of NHTSA Campaign Number: 14V284000 (Steering) and the vehicle was taken to the dealer who informed the contact that he would be responsible for the cost of the repair. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000.

WE BOUGHT VEHICLE IN JAN, 2018 FROM A PRIVATE PARTY, AS A WORK VEHICLE FOR MY HUSBAND, WHO IS A USPS RURAL ROUTE CARRIER. TWO WEEKS AFTER PURCHASE, THE ANTI-LOCK BRAKE LIGHT WENT ON, AND THE CAR WOULD NOT STOP WHEN IT WAS SUPPOSED TO, WHICH WAS VERY DANGEROUS IN WINTER. WE BELIEVE THE PRIOR OWNER KNEW ABOUT THIS. THE LIGHT WOULD JUST GO ON & OFF WITH NO PATTERN. ABOUT 1 1/2 MONTHS LATER, HE WAS DRIVING ON A 2 LANE HGWY (55 MPH) DELIVERING MAIL. HE WENT TO PULL FORWARD BUT THE CAR MADE A BRIEF NOISE AND THEN EVERYTHING JUST STOPPED WORKING. THE CAR WOULDN'T START, NO ELECTRICAL OR LIGHTS, HE COULD NOT EVEN ROLL THE VEHICLE BY HIMSELF TO A SAFE PLACE W/OUT HELP. THE ELECTRICAL AND PROPULSION SIMPLY STOPPED WORKING; PERIOD. WE ENDED UP DRAGGING IT HOME. DEALERSHIP GAVE EST. AMT OF REPAIRS AROUND $18K. I FOUND THE RECALL IN 2014 (14S19) FOR THE SAME THING. THE MEC PUMP WAS REPLACED IN 2014, WITH A "SUPPLEMENTAL" FIX IN 2015 SAME ISSUE. THIS IS THE EXACT SAME ISSUE AS THE PREVIOUS RECALL, WHICH NEITHER MERCURY OR ANY DEALERSHIP WANTS TO HONOR. I'M GUESSING THERE ARE MORE HYBRID MARINERS W/ SIMILAR ISSUES, BUT NOT ENOUGH TO ISSUE A FOLLOW-UP RECALL. SO HERE WE ARE STUCK IN CAR REPAIR PURGATORY. I DO BELIEVE THEY SHOULD HONOR THE RECALL NOW AND FIX THE PUMP AND REPLACE THE HYBRID BATTERY. NOT SURE ABOUT THE BRAKES, BUT I HAVE SEEN A LOT OF COMPLAINTS ABOUT THEM AS WELL - AGAIN, NOT ENOUGH FOR A RECALL, WHICH AGAIN. PURGATORY. MY HUSBAND WAS VERY LUCKY. HAD IT BEEN A DIFF TIME OF DAY THERE WOULD HAVE BEEN MUCH MORE CAR & SEMI-TRUCK TRAFFIC ON THE HWY (SPEED LIMIT IS 55) AND WITH HIM LITERALLY JUST STOPPED DEAD IN HIS TRACKS, THERE SURELY WOULD HAVE AN IMMINENT RISK OF A SERIOUS REAR-END COLLISON, WITH POTENTIALLY DEADLY INJURIES. I AM LOOKING FOR HELP, ASSISTANCE, GUIDANCE AND ANYTHING ELSE FROM ANY SOURCE POSSIBLE TO RESOLVE THIS ISSUE. WE ARE AT OUR WITTS END!!

STOP SAFELY NOW CHIMES AND DISPLAYED ON DASH FOLLOWED BY NO ACCELERATION UNTIL VEHICLE STALLS AND STOPS.STARTS RIGHT BACK UP BUT CONTINUES TO HAPPEN ESPECIALLY IN LA RUSH HOUR TRAFFIC. VERY DANGEROUS! HAD RECALL WORK DONE ON THE MECS 3YRS AGO BUT PROBLEM HAS CONTINUED. THIS HAPPENS WHILE IN MOTION ON THE 110 FREEWAY IN DOWNTOWN LOS ANGLELES, CA. COULD BE THE ELECTRIC THROTTLE BODY OR REAR ACTUATOR. OR ANY OTHER COMPONENT THAT WORKS WITH THE ELECTRIC MOTOR AND BATTERY.

WE BOUGHT VEHICLE IN JAN, 2018 FROM A PRIVATE PARTY, AS A WORK VEHICLE FOR MY HUSBAND, WHO IS A USPS RURAL ROUTE CARRIER. TWO WEEKS AFTER PURCHASE, THE ANTI-LOCK BRAKE LIGHT WENT ON, AND THE CAR WOULD NOT STOP WHEN IT WAS SUPPOSED TO, WHICH WAS VERY DANGEROUS IN WINTER. WE BELIEVE THE PRIOR OWNER KNEW ABOUT THIS. THE LIGHT WOULD JUST GO ON & OFF WITH NO PATTERN. ABOUT 1 1/2 MONTHS LATER, HE WAS DRIVING ON A 2 LANE HGWY (55 MPH) DELIVERING MAIL. HE WENT TO PULL FORWARD BUT THE CAR MADE A BRIEF NOISE AND THEN EVERYTHING JUST STOPPED WORKING. THE CAR WOULDN'T START, NO ELECTRICAL OR LIGHTS, HE COULD NOT EVEN ROLL THE VEHICLE BY HIMSELF TO A SAFE PLACE W/OUT HELP. THE ELECTRICAL AND PROPULSION SIMPLY STOPPED WORKING; PERIOD. WE ENDED UP DRAGGING IT HOME. DEALERSHIP GAVE EST. AMT OF REPAIRS AROUND $18K. I FOUND THE RECALL IN 2014 (14S19) FOR THE SAME THING. THE MEC PUMP WAS REPLACED IN 2014, WITH A "SUPPLEMENTAL" FIX IN 2015 SAME ISSUE. THIS IS THE EXACT SAME ISSUE AS THE PREVIOUS RECALL, WHICH NEITHER MERCURY OR ANY DEALERSHIP WANTS TO HONOR. I'M GUESSING THERE ARE MORE HYBRID MARINERS W/ SIMILAR ISSUES, BUT NOT ENOUGH TO ISSUE A FOLLOW-UP RECALL. SO HERE WE ARE STUCK IN CAR REPAIR PURGATORY. I DO BELIEVE THEY SHOULD HONOR THE RECALL NOW AND FIX THE PUMP AND REPLACE THE HYBRID BATTERY. NOT SURE ABOUT THE BRAKES, BUT I HAVE SEEN A LOT OF COMPLAINTS ABOUT THEM AS WELL - AGAIN, NOT ENOUGH FOR A RECALL, WHICH AGAIN. PURGATORY. MY HUSBAND WAS VERY LUCKY. HAD IT BEEN A DIFF TIME OF DAY THERE WOULD HAVE BEEN MUCH MORE CAR & SEMI-TRUCK TRAFFIC ON THE HWY (SPEED LIMIT IS 55) AND WITH HIM LITERALLY JUST STOPPED DEAD IN HIS TRACKS, THERE SURELY WOULD HAVE AN IMMINENT RISK OF A SERIOUS REAR-END COLLISON, WITH POTENTIALLY DEADLY INJURIES. I AM LOOKING FOR HELP, ASSISTANCE, GUIDANCE AND ANYTHING ELSE FROM ANY SOURCE POSSIBLE TO RESOLVE THIS ISSUE. WE ARE AT OUR WITTS END!!

STOP SAFELY NOW CHIMES AND DISPLAYED ON DASH FOLLOWED BY NO ACCELERATION UNTIL VEHICLE STALLS AND STOPS.STARTS RIGHT BACK UP BUT CONTINUES TO HAPPEN ESPECIALLY IN LA RUSH HOUR TRAFFIC. VERY DANGEROUS! HAD RECALL WORK DONE ON THE MECS 3YRS AGO BUT PROBLEM HAS CONTINUED. THIS HAPPENS WHILE IN MOTION ON THE 110 FREEWAY IN DOWNTOWN LOS ANGLELES, CA. COULD BE THE ELECTRIC THROTTLE BODY OR REAR ACTUATOR. OR ANY OTHER COMPONENT THAT WORKS WITH THE ELECTRIC MOTOR AND BATTERY.

WE BOUGHT VEHICLE IN JAN, 2018 FROM A PRIVATE PARTY, AS A WORK VEHICLE FOR MY HUSBAND, WHO IS A USPS RURAL ROUTE CARRIER. TWO WEEKS AFTER PURCHASE, THE ANTI-LOCK BRAKE LIGHT WENT ON, AND THE CAR WOULD NOT STOP WHEN IT WAS SUPPOSED TO, WHICH WAS VERY DANGEROUS IN WINTER. WE BELIEVE THE PRIOR OWNER KNEW ABOUT THIS. THE LIGHT WOULD JUST GO ON & OFF WITH NO PATTERN. ABOUT 1 1/2 MONTHS LATER, HE WAS DRIVING ON A 2 LANE HGWY (55 MPH) DELIVERING MAIL. HE WENT TO PULL FORWARD BUT THE CAR MADE A BRIEF NOISE AND THEN EVERYTHING JUST STOPPED WORKING. THE CAR WOULDN'T START, NO ELECTRICAL OR LIGHTS, HE COULD NOT EVEN ROLL THE VEHICLE BY HIMSELF TO A SAFE PLACE W/OUT HELP. THE ELECTRICAL AND PROPULSION SIMPLY STOPPED WORKING; PERIOD. WE ENDED UP DRAGGING IT HOME. DEALERSHIP GAVE EST. AMT OF REPAIRS AROUND $18K. I FOUND THE RECALL IN 2014 (14S19) FOR THE SAME THING. THE MEC PUMP WAS REPLACED IN 2014, WITH A "SUPPLEMENTAL" FIX IN 2015 SAME ISSUE. THIS IS THE EXACT SAME ISSUE AS THE PREVIOUS RECALL, WHICH NEITHER MERCURY OR ANY DEALERSHIP WANTS TO HONOR. I'M GUESSING THERE ARE MORE HYBRID MARINERS W/ SIMILAR ISSUES, BUT NOT ENOUGH TO ISSUE A FOLLOW-UP RECALL. SO HERE WE ARE STUCK IN CAR REPAIR PURGATORY. I DO BELIEVE THEY SHOULD HONOR THE RECALL NOW AND FIX THE PUMP AND REPLACE THE HYBRID BATTERY. NOT SURE ABOUT THE BRAKES, BUT I HAVE SEEN A LOT OF COMPLAINTS ABOUT THEM AS WELL - AGAIN, NOT ENOUGH FOR A RECALL, WHICH AGAIN. PURGATORY. MY HUSBAND WAS VERY LUCKY. HAD IT BEEN A DIFF TIME OF DAY THERE WOULD HAVE BEEN MUCH MORE CAR & SEMI-TRUCK TRAFFIC ON THE HWY (SPEED LIMIT IS 55) AND WITH HIM LITERALLY JUST STOPPED DEAD IN HIS TRACKS, THERE SURELY WOULD HAVE AN IMMINENT RISK OF A SERIOUS REAR-END COLLISON, WITH POTENTIALLY DEADLY INJURIES. I AM LOOKING FOR HELP, ASSISTANCE, GUIDANCE AND ANYTHING ELSE FROM ANY SOURCE POSSIBLE TO RESOLVE THIS ISSUE. WE ARE AT OUR WITTS END!!

TL* THE CONTACT OWNS A 2008 MERCURY MARINER HYBRID. WHEN THE CONTACT PLACED THE VEHICLE IN PARK, IT BEGAN TO ROLL. THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 15V606000 (POWER TRAIN). THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000. *TT UPDATED 11/30/18*JB

TL* THE CONTACT OWNS A 2008 MERCURY MARINER HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOSS MOTIVE POWER AND STALLED WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO ANDY MOHR FORD LOCATED AT 2713 E. MAIN ST, PLAINFIELD, IN 46168 HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 87,000.

I HAVE ABS, BRAKE WARNING AND REGEN BRAKES DISABLED MESSAGES ON DASH. FORD MECHANIC ESTIMATED COST OVER 5K.

TL* THE CONTACT OWNS A 2008 MERCURY MARINER HYBRID. THE CONTACT STATED THAT WHILE PARKED, THE IGNITION SWITCH DID NOT MOVE FROM THE OFF TO ON POSITION WITHOUT WARNING. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE COOLANT PUMP NEEDED TO BE UPDATED AND REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 199,000. THE VIN WAS NOT AVAILABLE.

WHILE DRIVING ON THE FREEWAY THE GAS ENGINE TO MY 2008 MERCURY MARINER HYBRID UNEXPECTEDLY SHUT DOWN AT LEAST 4 TIMES LAST EVENING. THE CONTROL PANEL DISPLAYED A RED TRIANGLE ALTER AND THE PHRASE "STOP SAFELY NOW". THIS WAS A VERY DANGEROUS SITUATION ON A CROWDED DETROIT FREEWAY WHERE I HAD TO MANEUVER OVER MULTIPLE LANES AT A SLOW SPEED TO STOP THE VEHICLE ON THE RIGHT SHOULDER (THE ONLY AVAILABLE SPACE). THE VEHICLE RESTARTED EACH TIME AND THE PROBLEM RECURRED AFTER LESS THAN A MILE 4 OR 5 TIMES AND THEN HAS NOT OCCURRED SINCE. I HAD A SIMILAR PROBLEM ABOUT SIX MONTHS AGO WHERE I PAID FORD TO FIX THE PROBLEM, BUT APPARENTLY THAT DIDN'T HAPPEN. THIS IS A VERY DANGEROUS PROBLEM AND SHOULD BE FIXED BEFORE PEOPLE END UP DEAD IF IT HASN'T ALREADY HAPPENED. *TR

I WAS DRIVING MY 2008 MERCURY MARINER HYBRID WHEN THE STOP SAFELY LIGHT CAME ON AND THE CAR DIED INSTANTLY. I WAS ON THE HIGHWAY DRIVING 55 MPH AND IT WAS EXTREMELY DANGEROUS TO HAVE RAPID DECELERATION AT THAT TIME. I WAS BARELY ABLE TO PULL MY CAR OVER TO THE SIDE IN A SAFE MANNER. I TURNED OFF THE CAR, RESTARTED AND PROCEED TO GET ON THE HIGHWAY AGAIN. IT HAPPENED THREE TIMES. NEEDLESS TO SAY, I DO NOT FEEL SAFE DRIVING MY VEHICLE ANYWHERE AT THIS POINT IN TIME. *TR

THE ABS TONE RINGS ON THE 2008 MODEL MERCURY MARINER AND FORD ESCAPE ARE DEFECTIVE IN DESIGN - THEY ARE THIN METAL, BUT PUT UNDER STRESS BY BEING FORCED ONTO THE HALF-SHAFT (DIFFERENT METAL, DIFFERENT EXPANSION RATE), AND THEREFORE PRONE TO CRACKING/BREAKING. WHEN CRACKED/BROKEN, THEY CAUSE THE ABS BRAKE SYSTEM AND REGENERATIVE BRAKING TO FAULT OUT, SOMETIMES INTERMITTENTLY AND WITH NO WARNING. THE PART ITSELF IS CHEAP (~$10 EACH), AND APPARENTLY SHOULD BE, BUT THE DEALER WILL NOT SELL THEM SEPARATELY, AND INSTEAD REQUIRES THE OWNER TO REPLACE THE HALF-SHAFT, WITH ESTIMATES FROM THE DEALERSHIP AND INDEPENDENT MECHANICS OF BETWEEN $400 AND $1000 TO REPLACE BOTH FRONT HALF-SHAFTS. SIMPLY MAKING THE PART THICKER, OR OF THE SAME METAL AS THE HALF-SHAFT, WOULD FIX THE PROBLEM - INSTEAD, FORD FORCES OWNERS TO CHOOSE BETWEEN AN UNSAFE VEHICLE AND ROBBERY, WITH NO GUARANTEE THAT THE PROBLEM WOULDN'T RECUR WITHIN A MONTH OF DRIVING (THE CRACKING SEEMS TO BE MORE RELATED TO TEMPERATURE THAN MILEAGE). THIS SHOULD BE RECALLED AND FORD SHOULD BE FORCED TO REPLACE THESE AT THEIR OWN COST - I BET THEY'D THEN "DISCOVER" A WAY TO PREVENT RECURRENCE IF THEY WERE PAYING OUT OF THEIR OWN POCKET FOR ANY THAT FAILED BEFORE 100,000 MILES. A CURSORY SEARCH ON THE INTERNET WILL TURN UP THOUSANDS OF RESULTS FOR THIS PROBLEM. *TR