2004 Mercury Mountaineer Recalls

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

THIS INVESTIGATION WAS OPENED ON JUNE 23, 2008, BASED ON 34 COMPLAINTS INVOLVING EIGHT INJURIES IN WHICH THE REAR LIFTGATE GLASS HATCH ON MODEL YEAR 2004 FORD EXPLORERS OR MERCURY MOUNTAINEERS BROKE OFF AND FELL, USUALLY WHILE INDIVIDUALS WERE OPERATING THE GLASS HATCH OR LOADING OR UNLOADING ITEMS FROM THE REAR OF THE VEHICLE.FORD CONDUCTED RECALL 04V-442 IN 2004 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 2002 AND CERTAIN MODEL YEAR 2003 FORD EXPLORERS AND MERCURY MOUNTAINEERS.THE INFORMATION FORD PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT FAILURES WITH 2004 VEHICLES WERE PRIMARILY LIFTGATE GLASS HATCH HINGE FAILURES RELATED TO CORROSION AT THE HINGE PIN, WHEREAS THE FAILURES THAT PROMPTED THE RECALL WITH THE EARLIER MODELS WERE PRIMARILY RELATED TO PROBLEMS WITH THE GLASS HATCH'S STRUTS OR FRACTURE OF A PRIOR HINGE DESIGN AT THE BOSS/BOLT CONNECTION AT THE GLASS.ODI'S REVIEW OF FORD'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2004 VEHICLES INDICATES THAT THESE RATES ARE SIGNIFICANTLY LOWER THAN THOSE FOR THE RECALLED POPULATION.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ODI WILL CONTINUE TO MONITOR COMPLAINTS AND TAKE APPROPRIATE ACTION AS NECESSARY.THIS INVESTIGATION IS CLOSED.

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.