2009 MINI Cooper Clubman Problems

REPLACED THERMOSTAT, HEATER STOPPED WORKING, VEHICLE OVERHEATED WHAT SEEMS TO BE A FAULTY WATER PUMP OR THERMOSTAT, CAR SMOKED INTENSELY DROVE SHORT DISTANCE- THERMOSTAT MELTED- MOTOR BLEW. THIS VEHICLE WAS WELL MAINTAINED***

TAMARA RECALL

I recently purchased a 2009 mini cooper clubman. Within three weeks of taking possession of the car, the airbag warning light activated. Upon a diagnostic test, it was determined that the passenger occupancy sensor was malfunctioning. After discussing this with the mini cooper dealer in my area and mini USA, it was acknowledged that this was a well known and documented issue. First generation mini coopers were afforded a safety recall to rectify this safety issue while second generation cars were given an extended warranty. Unfortunately, I am now driving a car outside of the extended warranty that was only offered to the original owner with a faulty airbag system for any passenger in my car. A recall MUST be issued for the second generation mini cooper to hold the company responsible for this faulty design. Owners of these cars are avoiding the $2500 repair bill by installing sensor bypass modules in order to clear the malfunctioning light warning. NHSTA is well aware of this problem as I have read hundreds of issues and concerns in mini cooper forums. Please address this problem as force the recall on the occupancy airbag sensor before a passenger is seriously injured or killed.

The passenger-side airbag is not recognized when a passenger is in the vehicle. Mechanic says this is a known recall for Mini's and has repaired several but my model is not covered under the recall. There has not been an incident or accident to report at this time. I have reached out to Mini and asked them about the recall and they originally said they would fix it bc it was under recall. When I brought the car in they said they couldn't because the recall doesn't cover the R55 model. After months of going back and forth with them, they have concluded that they will only repair at their service cost of $1500.

The contact owned a 2009 Min Cooper Clubman. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while the vehicle was parked, turned on, and unoccupied, there was black smoke coming from the interior of the vehicle. The contact stated the footwell control module located on the driver's side had caught on fire. The vehicle was extinguished by the Fire Department. The vehicle was destroyed as it was consumed by the fire. A fire report was filed, and a fire report number was provided; however, the cause for the failure was not yet determined. A police report was not filed due to the incident occurring on private property. No injuries were sustained. The dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was not towed and remained at the incident location. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 95,000. Parts distribution disconnect.

The driver's side footwell is continuously full of water for the past several years. During rain water runs inside the car, from somewhere behind the dash, into the driver's footwell. The Footwell Control Module (FRM) is in water and is actively corroding. The Footwell Control Module is an electronic control unit located behind an interior trim panel in the driver's footwell area. Mini/BMW has already found that this corrosion could potentially result in a short circuit, resulting in a potential thermal event which could increase the risk of fire or injury. For some reason this vehicle is not included in Recall Campaign No. 23V-337 for the very same issue. This vehicle has been erroneously excluded from all appropriate MINI recalls. This vehicle was not included in 09V-143 despite the fact that it has factory 15" wheels. This vehicle had an auxiliary water pump fail, 200 miles after the warranty expired, but was not included in 18V-248. It would seem as though it has been erroneously excluded from all recalls because it was custom ordered and imported by the dealer. I am the sole owner of this vehicle, I purchased it new, custom made and imported for me at a dealership in Las Vegas. This vehicle has never been included in any of the recalls despite being affected by all of them.

THE CAR ENGINE STOPPED DEAD IN THE MIDDLE OF A STATE HIGHWAY WHILE GOING AT CRUISING SPEED OF 35MPH ON THE RIGHT MOST LATE, AND WITH ENGINE DEAD POWER STEERING BECAME UNRESPONSIVE AND BECAME IMPOSSIBLE TO STEER THE CAR TO THE SIDE. THE CAR WAS LITERALLY DEAD IN THE MIDDLE OF THE HIGHWAY, WE HAD KIDS ON BOARD AND FOR A SMALL CAR, WE WERE REALLY THAT LUCKY PASSING CARS WERE ABLE TO SPOT US AND AVOID HITTING US. WHEN WE TOOK TOWED IT TO THE SHOP, THE ISSUE WAS THAT THE TIMING CHAIN HAD SNAPPED AND ALSO CRACKED THE ENGINE TOP COVER ON THE LEFT SIDE. ON SEARCHING THE INTERNET IT LOOKS LIKE THIS IS THE "TIMING CHAIN, TENSIONER ISSUES" THAT BMW/MINI IS ALREADY AWARE OF HOWEVER THEY HAVE NOT YET DONE A RECALL. THERE WAS ALMOST NO WAY OF TELLING THERE WAS THIS PROBLEM BREWING WITH THE VEHICLE. ALTHOUGH NOW IN RETROSPECT THERE WERE A FEW TELL-TALE SIGNS, WHEN IT WAS COLD, WE HAD HEARD A RATTLE SOUND, WHICH WENT AWAY IMMEDIATELY. ALSO THE SAME DAY THE CAR ENGINE STOPPED WHEN STANDING AT A SIGNAL, BUT STARTED UP AGAIN. NOW WE REALIZE THAT THESE SIGNS WERE RELATED TO THE PROBLEM THAT OTHER USERS HAD COMPLAINED TOO BEFORE THE TIMING CHAIN BROKE.

CAR STARTED MAKING RATTLING NOISE ON START UP, DROVE IT TO MINI, THEY SAY MY TIMING CHAIN IS STRETCHED AND HOUSING BROKEN, AROUND $2500, TO REPAIR. READING ONLINE THIS IS A COMMON PROBLEM, EVEN THE BASIS OF A LAWSUIT AND I FEEL IT SHOULD BE LOOKED INTO. *TR

THE REAR SPLIT DOORS WON'T OPEN WHEN UNLOCKING USING THE KEY FOB. THERE IS NO MANUAL LATCH TO OPEN REAR DOORS FROM THE INSIDE OF THE VEHICLE. THIS IS MY WIFE'S ONLY VEHICLE AND MY CONCERNS ARE AS FOLLOW. 1- WE CAN'T ACCESS THE SPARE TIRE AND EMERGENCY TOOLS SINCE THE DOORS DOESN'T OPEN. AND MY MAIN CONCERN IS 2- WHAT WILL HAPPEN IF THERE IS AN ACCIDENT/FIRE IN FRONT OF THE VEHICLE AND THE ONLY EMERGENCY EXIT IS THROUGH THE REAR OF THE VEHICLE UTILIZING THE REAR DOORS? DIFFERENT SCENARIO WHAT IF THE VEHICLE FALLS IN WATER AND THE ONLY WAY OUT IS TO OPEN THE REAR DOORS BUT THERE IS NO MANUAL LATCH TO EGRESS? I BELIEVE THAT MINI COOPER FAILED OR DIDN'T THINK ABOUT THIS MATTER. I CAN'T INCLUDE PICTURES BECAUSE I'LL BE SHOWING A SHUT DOOR.

THE MANUFACTURER'S PROVIDED DRIVERS SIDE FLOOR MAT SLIDES UP OVER BOTH THE BRAKE PEDAL AND ACCELERATOR CAUSING UNINTENTIONAL BRAKING AND/OR ACCELERATION. I EMAILED THE MANUFACTURER REGARDING THIS PROBLEM, BUT SO FAR NO RESPONSE. *TR

LOW OIL INDICATOR DOESN'T LIGHT UP UNTIL THE OIL LEVELS ARE CRITICALLY LOW. DEALER STATES THAT THEY'VE SEEN THIS HAPPEN A LOT AND IT'S "NORMAL." COST ME OVER $4,000 TO FIX IT AT THE DEALER. 3RD DOOR (SUICIDE DOOR) LOCK MECHANISM STICKS/BREAKS DOWN. AFTER GETTING IT FIXED, THE LATCH ITSELF BROKE DOWN.

IVE PERSONALLY DRIVEN MY 2009 MINI COOPER CLUBMAN 11K MILES OF THE 34K IT HAS ON IT WITHOUT ANY ISSUE UNTIL ON JUNE 5TH, 2016 I PARKED IT NEAR MY WORK AND RETURNED TO IT THE NEXT MORNING.IT STARTED UP JUST FINE AND I JUST LET THE FIRST GEAR TAKE ME OUT OF THE PARKING GARAGE. THEN I TRIED TO ACCELERATE ONCE ON THE ROAD AND NOTHING... NO POWER. I PUT THE PEDAL TO THE FLOOR AND NOTHING. I PULLED OVER AND IT SOUNDED LIKE A LABORED, CLANKY, ROUGH IDLE. GOT IT TOWED TO A SHOP, DIAGNOSTIC TEST SHOWED MAIN RELAY FAILURE AND SOMETHING ABOUT VALVETRONIC SERVOMOTOR AND LIMITATION AND PLAUSIBLE AIR MASS SENSOR ISSUE. MAIN RELAY PART REPLACED FOR $20.WORKED FINE AFTER THAT. EIGHTEEN DAYS LATER IT HAPPENED AGAIN. WENT HOME AND AFTER SOME RESEARCH, I FOUND SCARY POSSIBILITIES COULD HAPPEN WITH MY MINI RELATED TO THE ENGINE COOLING SYSTEMS, AIR INTAKE, WATER PUMP AND TIMING CHAIN SENSOR WORST OF ALL. THINGS THAT COULD CAUSE DAMAGE IF FAILED WHILE ON THE HIGHWAY AT 70MPH OR IN AN INTERSECTION OR IN TRAFFIC! TO DATE, ILL BE RETURNING TO THE SHOP THAT HELPED MEET BAND AID THE PROBLEM, THEN TO MY REAL PROFESSIONAL TO HELP ME DIAGNOSE AND TREAT FURTHER POSSIBLE ISSUES.

Following approximately 12 months of slow deterioration, the passenger-side airbag deployment system in this vehicle appears to have become continuously inoperative (red airbag failure annunciator continuously illuminated on instrument cluster in conjunction with continuous illumination of the amber "Passenger Airbag OFF" informational annunciator in the overhead console). Failure now occurs whether passenger seat is empty or occupied, although it previously only occurred when the seat was unoccupied and ambient temperatures were colder (below approximately 40 degrees F). I suspect that the passenger seat occupancy sensor mat is the failed system component due to the slow onset of the problem (continuous illumination of aforementioned annunciators was spurious at first, then intermittent, now continuous). Vehicle has not been submitted to a MINI dealer for diagnosis. However, MINI/BMW has already issued a recall on the passenger seat occupancy sensor mats in 2005-2008 model MINIs, setting the precedent that other model years could be similarly affected as well. Vehicle will not pass Texas state inspection with the airbag failure annunciator illuminated, and therefore cannot be registered. Recommend that MINI/BMW expand the sensor mat recall to include at least their 2009 model year vehicles as well.

THE PASSENGER SIDE AIRBAG SENSOR HAS BEEN GOING OFF INDICATING THAT THE AIRBAG WILL NOT DEPLOY EVEN WHEN SOMEONE OF NORMAL ADULT SIZE (160LBS) IS IN THE FRONT PASSENGER SEAT. I HAVE CONTACTED MINI AND THEY REFUSE TO FIX IT UNLESS I PAY FOR THE COSTLY REPAIR, EVEN THOUGH THEY HAVE BEEN SLOWLY RECALLING OTHER MODELS FOR THE SAME PROBLEM. THE IMPROPERLY FUNCTIONING MAT IN MY MINI COOPER CLUBMAN MAY CAUSE THE PASSENGER FRONTAL AIR BAG TO BE INACTIVE WHEN THE SEAT IS OCCUPIED, AND IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT DEPLOY, INCREASING THE PASSENGER'S RISK OF INJURY. THIS IS CLEARLY DUE TO A DESIGN, MANUFACTURING, INSTALLATION, AND/OR EXPOSURE ISSUES, THAT CAUSES THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT NOT TO FUNCTION PROPERLY AND, AS A RESULT, THE FRONT PASSENGER AIR BAG MAY NOT DEPLOY IN A CRASH. THIS NEEDS TO BE RESOLVED AND NOT WAIT UNTIL MORE PEOPLE ARE HURT BY BMW'S REFUSAL TO ADDRESS THE PROBLEM IN ALL VEHICLES THAT HAVE THIS PROBLEM. THEY ARE WAITING FOR MORE DEATHS, INJURIES AND/OR COMPLAINTS BEFORE THEY FINALLY RESOLVE THEIR PROBLEM AT THEIR COST IN ALL CARS. WHAT CHANGE HAVE THEY EMPLOYED AFTER 2008 TO THIS DESIGN, MANUFACTURING AND INSTALLATION PROCESS IN THEIR PASSENGER SIDE AIRBAG SENSORS THAT MAKES THEM ISOLATE ONLY SOME REPAIRS ON SOME MINIS? NONE! AT LEAST NONE THAT HAVE WORKED AS I HAVE A 2009 MINI COPPER CLUBMAN WITH THE IDENTICAL PROBLEM, SO CLEARLY THEY HAVEN'T RESOLVED IT AND SHOULD NOT LIMIT THEIR RECALL TO 2005-2006 MINI COOPERS AND COOPER S, NOR JUST CONVERTIBLE MINI COOPERS BETWEEN 2005-2008 MODELS. 2009 MINI COOPER CLUBMANS HAVE THIS SAME PROBLEM, YET BMW TELLS ITS CUTOMERS WITH WARRANTIES TO PAY FOR IT THEMSELVES! BAD BUSINESS. HOPE SOMEONE SUES THEM, BUT PROBABLY NOT UNTIL SOMEONE DIES. AT LEAST THIS PUTS THEM ON NOTICE SO THEY CAN BE SUED MORE EASILY. I HAVE CHILDREN...SHAME ON YOU BMW!

INTERMITTENT STEERING LOSS WHILE DRIVING. MINI IS AWARE OF ISSUE... OFFERS NO FIX. LOW MILEAGE. FAILURE HAPPENED WHILE DRIVING TURNING AND NOT TURNING. NO WARNING LIGHTS OR DASHBOARD WARNING OR MESSAGE. AFTER SOME RESEARCH, IT APPEARS MINI IS AWARE AND VERY HIGH PETE STAGE OF OWNERS HAVE EXPERIENCED THE SAME .... DEATHS HAVE BEEN REPORTED .

ON MY 2009 MINI COOPER CLUBMAN WITH AUTOMATIC TRANSMISSION, THE POWER STEERING FAILED. OUR TEENAGER WAS PRIACTICING PARALLEL PARKING FOR ABOUT 15 MINUTES ON A HOT DAY. AFTER IT FAILED, WE TURNED OFF THE CAR. TWO HOURS LATER WHEN WE RESTARTED THE CAR IT WAS FUNCTIONING AGAIN. THE DEALER, SAYS THEY CANNOT DO ANYTHING UNLESS THEY CAN REPRODUCE THE PROBLEM, WHICH THEY HAVE NOT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) T

THE SOCKET THAT GOES IN THE BULB FOR THE HEADLIGHTS ARE BURNED ON BOTH HEADLIGHTS. THE BULBS HAVE BEEN REPLACED AND BECAUSE OF THE BURNED SOCKET THAT CONNECTS TO THE HEADLIGHT APPARENTLY IS UNABLE TO SEND A SIGNAL TO THE BULB AND NO ONE SEEMS TO KNOW HOW TO FIX THE PROBLEM.

THE MANUFACTURER'S PROVIDED DRIVERS SIDE FLOOR MAT SLIDES UP OVER BOTH THE BRAKE PEDAL AND ACCELERATOR CAUSING UNINTENTIONAL BRAKING AND/OR ACCELERATION. I EMAILED THE MANUFACTURER REGARDING THIS PROBLEM, BUT SO FAR NO RESPONSE. *TR

TL* THE CONTACT OWNS A 2009 MINI COOPER CLUBMAN. THE CONTACT STATED THAT WHEN SHE CLOSED THE DOOR, THE SEAT BELT DID NOT RETRACT QUICKLY ENOUGH AND CAUSED THE DOOR TO SEIZE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 68,000....UPDATED 07-10-13 *BF

THE MANUFACTURER'S PROVIDED DRIVERS SIDE FLOOR MAT SLIDES UP OVER BOTH THE BRAKE PEDAL AND ACCELERATOR CAUSING UNINTENTIONAL BRAKING AND/OR ACCELERATION. I EMAILED THE MANUFACTURER REGARDING THIS PROBLEM, BUT SO FAR NO RESPONSE. *TR