2012 MINI Cooper Countryman Problems

The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at undisclosed speeds, the vehicle stalled. The fuel tank was a third of the way full. The trunk was locking and unlocking continuously while driving or while the vehicle was parked. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical system). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who determined that there was a short in the footwell module due to water intrusion. The drain was also clogged in the sunroof. The manufacturer was contacted and opened a case. The failure mileage was approximately 161,818.

When the vehicle computer detects low voltage all turn signals, lights and instrument cluster immediately fail and do not turn back on. The Foot Well Module (FWM) or Foot Rest Module (FRM) computer becomes corrupt and deletes data from the module. This becomes a major safety hazard as a nighttime failure occurred causing several near accidents due to inability to signal to other vehicles. This is a known issue with Mini and they released an extended service bulletin knowing the factory footrest modules were manufactured incorrectly. Vehicles falling outside the initial warranty period are prone to safety risks when this occurs.

My 2012 MINI Countryman (R60) experienced a complete electrical shutdown and engine failure while operating due to a severe manufacturing defect. Authorized dealership Jackie Cooper MINI of Edmond diagnosed the vehicle under RO# [XXX] and confirmed in writing that the "JBE electronic connectors are heavily corroded" and "The FRM has water/corrosion damage," providing a repair estimate of $4,700 (including a specific $1,055.84 charge to replace the FRM and clean the sunroof drains). Water entering the footwell area through defective, shrinking sunroof drainage structures is the exact identical failure mechanism, component (FRM3 Module), and extreme safety/fire hazard covered under mandatory safety recall NHTSA Campaign 23V-337. However, MINI has improperly excluded the R60 Countryman model from active coverage despite it utilizing the identical electrical infrastructure and drainage engineering layout. Releasing this vehicle into traffic presents a catastrophic risk of a highway vehicle fire or sudden total loss of vehicle control and lighting at high speeds. NHTSA must expand Recall 23V-337 to include the 2012 MINI Countryman to protect consumers from these documented structural water-ingress fires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at undisclosed speeds, the vehicle stalled. The fuel tank was a third of the way full. The trunk was locking and unlocking continuously while driving or while the vehicle was parked. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical system). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who determined that there was a short in the footwell module due to water intrusion. The drain was also clogged in the sunroof. The manufacturer was contacted and opened a case. The failure mileage was approximately 161,818.

timing chain failure which caused engine shut down. this is a known problem with other models. It was not recalled but BMW lost a class action lawsuit for the same problem in the same car, different years. They have not updated or repaired the issue. very expensive repair.

UPON ENTERING AN EXIT ONLY LINE ON THE HIGHWAY AT THE END OF A 400 MILE JOURNEY, TRAFFIC BACKED UP AND CAME TO A STOP IN THE EXIT ONLY LANE. WHEN TRAFFIC STARTED MOVING AGAIN, MY CAR WHICH HAS A MANUAL TRANSMISSION WOULD NOT SHIFT FROM NEUTRAL INTO 1ST GEAR (OR ANY GEAR). I WAS STOPPED AND UNABLE TO MOVE WITH TRAFFIC MOVING 50-60 MPH BEHIND ME AND NEXT TO ME. CARS SLAMMED ON BRAKES TO AVOID HITTING ME AND ONE ALMOST HIT ME AFTER SLAMMING ON ITS BREAKS AND TURNING SIDEWAYS. IT WAS ONE OF THE MOST TERRIFYING EXPERIENCES I HAVE EVER ENCOUNTERED. A STATE POLICE OFFICE PULLED UP BEHIND ME AFTER ABOUT 5-10 MINUTES AND WAS ABLE TO PUSH ME TO THE BREAKDOWN LANE. THERE WAS A TERRIBLE BURNING SMELL AND CONSIDERABLE SMOKE FROM UNDER THE CAR WHICH INDICATED A CATASTROPHIC FAILURE OF THE CLUTCH. THE CAR WAS TOWED TO AN AUTO REPAIR SHOP WHERE I LATER LEARNED THE CLUTCH MATERIAL HAD DISINTEGRATED ENTIRELY AND THE FLYWHEEL WAS CRAZED AND BURNED FROM THE EXTREME HEAT. BOTH THE CLUTCH AND FLYWHEEL HAD TO BE REPLACED. THE COST TO REPAIR THE CAR WAS OVER $4000. THE CAR HAD 78,067 MILES ON IT AND PRIOR TO THE CATASTROPHIC FAILURE OF THE CLUTCH THERE WERE ONLY 2 INDICATIONS OF A POTENTIAL CLUTCH PROBLEM WHEN THE TACHOMETER FLUTTERED WHEN SHIFTING INTO HEAR AT ABOUT 300 MILES PRIOR TO THE INCIDENT AND THEN ABOUT 25 MILES PRIOR TO THE INCIDENT, INDICATING TO ME THAT THE CLUTCH WAS STARTING TO SLIP. OTHER THAN THAT, THERE WERE NO WARNING LIGHTS OR OTHER INDICATIONS OF A PROBLEM. THE CAR IS ROUTINELY SERVICED BY THE DEALER AND WHENEVER THERE IS ANY INDICATION OF A PROBLEM. I DO NOT DRIVE CARS HARD. THIS CAR IS STILL ON ITS FIRST SET OF BRAKES AND ONLY ITS SECOND SET OF TIRES. I HAVE DRIVEN MANUAL SHIFT CARS FOR MANY YEARS AND KNOW THE SYMPTOMS OF A FAILING CLUTCH. I CONSIDER THE NEAR CATASTROPHE THAT I EXPERIENCED THE RESULT OF A MAJOR DEFECT IN EITHER THE CLUTCH OR THE WARNING MECHANISM.

Passenger side airbag light on with no one in seat. The repair shop stated that there is a seat sensor fault code is 93c3(passenger seat occupancy detector). If there is an accident the airbag may not deploy. I was told to by the BMW of Hawaii in Kona that it will cost $2030 for parts and labor.

The front passenger occupancy detector (or OC3) failed, making the passenger airbags inoperable. This is a common problem with minis and many other models have had the mat warranty extended. The dealer confirmed that the OC3 is bad but wanted $800 just to order the part which is embedded in the seat cushion. Consumers shouldn't have to bear the cost of a defective vital safety component that should last the life of the car.

My 2012 MINI Countryman (R60) experienced a complete electrical shutdown and engine failure while operating due to a severe manufacturing defect. Authorized dealership Jackie Cooper MINI of Edmond diagnosed the vehicle under RO# [XXX] and confirmed in writing that the "JBE electronic connectors are heavily corroded" and "The FRM has water/corrosion damage," providing a repair estimate of $4,700 (including a specific $1,055.84 charge to replace the FRM and clean the sunroof drains). Water entering the footwell area through defective, shrinking sunroof drainage structures is the exact identical failure mechanism, component (FRM3 Module), and extreme safety/fire hazard covered under mandatory safety recall NHTSA Campaign 23V-337. However, MINI has improperly excluded the R60 Countryman model from active coverage despite it utilizing the identical electrical infrastructure and drainage engineering layout. Releasing this vehicle into traffic presents a catastrophic risk of a highway vehicle fire or sudden total loss of vehicle control and lighting at high speeds. NHTSA must expand Recall 23V-337 to include the 2012 MINI Countryman to protect consumers from these documented structural water-ingress fires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There is a recall existing for my car, by VIN mine is not included, however I have the exact same problem. Water in the driver side foot well electrical panel which has caused a fault in the lighting, hazard lights, and battery issue. The car cannot be driven because the hazard lights and daytime running lights will not turn off even with the key out. Running out the battery in the process. The mechanic found water and corrosion inside the electrical housing.

While traveling on the highway at speed, the forward (retractable) sunroof exploded with no apparent provocation or warning. When the failure occurred there was a loud bang followed by glass forcefully raining down into the front and back seat area of the vehicle. There were no vehicles immediately ahead, and no overpasses or trees from which something could have fallen. The driver immediately slowed but did not swerve and there were no other vehicles close by so there was no secondary incident. The glass from the roof continued to fall on subsequent bumps in the road until all of the loose glass had fallen. The size of the glass pieces varied in size and sharpness greatly, with some pieces being very small clear slivers (causing mild cut to hand when exiting the vehicle). In addition when exiting the vehicle a piece of glass from the sunroof found its way into the driver's seatbelt fastener and as a result can no longer be buckled. The vehicle has not yet been inspected by anyone and is available for inspection on request.

I was driving down the road when a light popped onto my dash, it was the airbag/seatbelt light after some research. From what I've read, this will prevent the airbags from activating in case of a crash, and after talking to other MINI owners it is extremely common.

HIGH PRESSURE FUEL RAIL DEVELOPED A CRACK AT A BRAZEN JOINT. HIGH PRESSURE FUEL WAS THEN BEEN RELEASED IN THE VICINITY OF THE EXHAUST SYSTEM. STRONG FUEL SMELL IN CABIN AND NEAR VEHICLE. NO FIRE OR DAMAGE RESULTED. VEHICLE REPAIRED AT OWNERS EXPENSE.

WHILE TRAVELING AT HIGHWAY SPEEDS THE CAR LOST THE ABILITY TO ACCELERATE AND INSTEAD LURCHED AND CHOKED. THE MECHANIC DETERMINED THAT THE THROTTLE BODY BROKE FREE OF ITS HOUSING. LUCKILY I WAS ABLE TO MOVE THE CAR TO AN OFF-RAMP THAT SLOPED DOWNHILL TO GET TO SAFETY.

My front windshield wipers stopped working suddenly while driving in the rain

While traveling on the highway at speed, the forward (retractable) sunroof exploded with no apparent provocation or warning. When the failure occurred there was a loud bang followed by glass forcefully raining down into the front and back seat area of the vehicle. There were no vehicles immediately ahead, and no overpasses or trees from which something could have fallen. The driver immediately slowed but did not swerve and there were no other vehicles close by so there was no secondary incident. The glass from the roof continued to fall on subsequent bumps in the road until all of the loose glass had fallen. The size of the glass pieces varied in size and sharpness greatly, with some pieces being very small clear slivers (causing mild cut to hand when exiting the vehicle). In addition when exiting the vehicle a piece of glass from the sunroof found its way into the driver's seatbelt fastener and as a result can no longer be buckled. The vehicle has not yet been inspected by anyone and is available for inspection on request.

THIS VEHICLE WAS PURCHASED IN 2011 AND HAS REQUIRED A MULTITUDE OF MAINTENANCE /REPAIRS DUE TO MANUFACTURER ISSUES. THE DEALERSHIP OF ORIGINAL PURCHASE WAS INCREDIBLY RESPONSIBLE AND TOOK RESPONSIBILITY OF THESE REPAIRS. I MOVED TO ANOTHER AREA TWO YEARS AGO AND RIGHT ABOUT THIS TIME, THE FRONT PASSENGER AIR BAG LIGHT BEGAN TO RANDOMLY GO ON AND OFF INDICATING THAT THE AIR BAG WOULD NOT BE ENGAGED. THE LIGHT WILL GO ON AND OFF WHEN IN MOTION OR JUST IDLING. THIS HAS CONTINUED TO GO UNRESOLVED AS I TEND TO MOST OFTEN RIDE ALONE AND DON'T HAVE ADDITIONAL $$$ FOR THE REPAIR AT THIS TIME. I DID JUST FINISH REPLACING THE CLUTCH IN THIS VEHICLE WHICH CURRENTLY ONLY HAS 51K MILES ON IT.

TAKATA RECALL. I LIVE IN NEWPORT, WA. I AM APPROXIMATELY 6 - 7 HOURS FROM A MINI DEALER IN SEATTLE/TACOMA. MY CLOSEST CITY IS SPOKANE, WA. I HAVE A GREAT CERTIFIED MECHANIC WHO DOES ALL OF MY REPAIR WORK BRANDON MARTIN OF MARTIN'S AUTO SERVICE, SPOKANE, WA, WHO IS COMPETENT AT WORKING ON MINI-COOPERS. IT IS UNREASONABLE TO REQUIRE THAT I MAKE A TRIP TO SEATTLE FOR THIS REPAIR. I AM WILLING TO HAVE THE REPAIR DONE HERE AND BE REIMBURSED, BUT MINI WILL NOT ALLOW THAT. THEY ARE REQUIRING EXTREME TRAVEL AND EVEN AN OVERNIGHT STAY TO ABIDE BY THEIR OWN RECALL REGULATIONS. THEY DO SEEM TO MAKE THE RULES TO SUIT THEMSELVES; BECAUSE IF I HAD MADE THIS REPAIR PRIOR TO THE RECALL, THEY WOULD HAVE REIMBURSED ME, BUT NOW I CANNOT HAVE THE REPAIR DONE WITHOUT EXTREME ADDED EXPENSES INCURRED. DUE TO THE CIRCUMSTANCES OF EXCESS TRAVEL, I RESPECTFULLY REQUEST THAT I AM ABLE TO MAKE THE RECALL REPAIR AND BE REIMBURSED FOR THE COST. THIS IS NECESSARY FOR MY SAFETY. DUE TO THE COMPANY'S UNREASONABLE RULE, I AM AT RISK.

OUR 2012 MINI COOPER COUNTRYMAN WAS PARKED IN PARKING GARAGE. WITHIN MINUTES OF SHUTTING IT OFF THE ENGINE CAUGHT ON FIRE WHICH SPREAD QUICKLY. THE CAR WAS COMPLETELY DESTROYED. OTHER CARS NEXT TO IT WERE AFFECTED AND THE FLOOR OF THE PARKING GARAGE WAS CLOSED DUE TO DAMAGES. THIS IS VERY SERIOUS AND DANGEROUS. *TR

Passenger side airbag light on with no one in seat. The repair shop stated that there is a seat sensor fault code is 93c3(passenger seat occupancy detector). If there is an accident the airbag may not deploy. I was told to by the BMW of Hawaii in Kona that it will cost $2030 for parts and labor.

I PURCHASED THE 2012 MINI NEW AND TOOK DELIVERY 12/20/2013. THE FIRST ISSUE INVOLVED THE SEAT BELT WARNING LIGHT AND ALARM. AFTER DRIVING THE CAR FOR ABOUT 10 MINUTES THE FASTEN SEAT BELT WARNING LIGHT CAME ON ALONG WITH THE AUDIBLE ALARM. THE SEAT BELT WAS SECURELY FASTENED, I HAD NO PASSENGERS AND THERE WAS NOTHING ON THE PASSENGER SEAT. I PULLED OVER AGAIN, TURNED THE ENGINE OFF, TOOK THE KEY OUT OF THE IGNITION, AND UNFASTENED THE SEAT BELT. AFTER 5 MINUTES I FASTENED THE SEAT BELT AND RESTARTED THE CAR. THE WARNING RESUMED IMMEDIATELY AND CONTINUED FOR THE ENTIRE 1 HOUR DRIVE HOME. I CALLED THE SERVICE DEPARTMENT. THE SERVICE MANAGER DISMISSED MY CONCERN AND INSISTED THERE MUST BE A HEAVY PURSE OR GROCERY BAG ON THE SEAT. THIS ISSUE CONTINUES. THE 2ND PROBLEM WAS STEERING FAILURE. ONE MORNING I WAS UNABLE TO TURN THE WHEELS TO LEAVE MY DRIVEWAY. THE CAR WAS RUNNING. I TURNED THE ENGINE OFF, WAITED A FEW MINUTES AND TRIED AGAIN.I CALLED THE SERVICE DEPARTMENT AND REPORTED THE PROBLEM. THE SERVICE MANAGER SAID HE HAD SPOKEN TO HIS "TOP MECHANICS" AND NONE OF THEM COULD THINK OF A SINGLE THING THAT WOULD CAUSE THE PROBLEM. HE INSISTED IT WAS DRIVER ERROR: I HAD STALLED THE CAR, THE PARKING BRAKE WAS ON, OR THERE WAS SOMETHING UNDER THE CAR PREVENTING THE WHEELS FROM TURNING. NO, NO AND NO. THE ISSUE APPARENTLY FIXED ITSELF LATER THAT DAY. I BROUGHT THE CAR IN FOR A CHECK OF THESE PROBLEMS. THE SCAN INDICATED A FAULTY POWER STEERING MODULE. THE FOREMAN OF THE SERVICE DEPT TOLD ME THIS WAS A FREQUENT PROBLEM IN THE 2011 MODELS. THEY SAID THERE WAS NOTHING WRONG WITH THE SEAT BELT SYSTEM. THE PROBLEM PERSISTS TO THIS DAY INTERMITTENTLY. THE LAST TIME I SPOKE TO THE SERVICE MANAGER HE TOLD ME TO TAKE A PHOTO OF THE INFORMATION DISPLAY THE NEXT TIME IT HAPPENED TO "PROVE THAT THE CAR IS RUNNING WHEN THE WARNING LIGHT COMES ON" - HE WANTS TO SEE THE SPEEDOMETER. *TR

I KEEP HAVING PROBLEMS ELECTRIC PROBLEMS ENGINE LIGHTS COME ON COIL BROKE BROKE DOWN WON'T START

OUR 2012 MINI COOPER COUNTRYMAN WAS PARKED IN PARKING GARAGE. WITHIN MINUTES OF SHUTTING IT OFF THE ENGINE CAUGHT ON FIRE WHICH SPREAD QUICKLY. THE CAR WAS COMPLETELY DESTROYED. OTHER CARS NEXT TO IT WERE AFFECTED AND THE FLOOR OF THE PARKING GARAGE WAS CLOSED DUE TO DAMAGES. THIS IS VERY SERIOUS AND DANGEROUS. *TR

No warning lights have come on and the car is braking on its own. I try to push the gas and it doesn't want to go. The car has around 42k miles on it. I took it to tom bush mini last week, the said the front axle was leaking some fluid, they ordererd the axle, changed all brake pads, changed the brake fluid and said it was good to go, cost about $2300. Got the car back, doing the same thing. Now they said all calipers need to be replaced and the hydro unit dsc needs to be replaced which will cost around $6400 and they can't get the hyro unit dsc or 2 months. If this was the problem why didn't they know last week? It doesn't seem like the car has enough miles to have such a big issues and no part for 2 months. I don't know what to do.