2002 MINI Cooper S Problems

The contact owns a 2002 Mini Cooper S. The contact stated that while driving approximately 45-55 MPH, the steering wheel seized. There was no warning light illuminated. The vehicle was coasted to the side of the road. The contact restarted the vehicle and continued driving normally. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 15V660000 (STEERING). The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 43,000.

THE VIN # OF MY 2002 MINI COOPER S WAS NOT INCLUDED IN THE RECALL FOR THE ELECTROHYDRAULIC STEERING FAILURE OF 2002 - 2005 MINI COOPER S BUT I AM EXPERIENCING THE EXACT ISSUE OUTLINED IN THIS RECALL. THE STEERING IS INCREDIBLY HARD TO TURN WHEN PARKED, AS WELL AS WHILE DRIVING. I NOTICED THAT THE RECALL HAD ABOUT 339 COMPLAINTS AND ROUGHLY 85,000 VEHICLES WERE RECALLED, SO MAYBE AT THE TIME NO ONE WITH A SIMILAR VIN AS ME COMPLAINED.

TL* THE CONTACT OWNS A 2002 MINI COOPER S. WHILE DRIVING AT 60 MPH AND ATTEMPTING TO AVOID HITTING AN ANIMAL, THE STEERING WHEEL SEIZED WITHOUT WARNING AND THE VEHICLE STRUCK THE ANIMAL. THE AIR BAGS DID NOT DEPLOY; HOWEVER, THE AIR BAG WARNING LIGHT ILLUMINATED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 103,000. THE VIN WAS UNAVAILABLE.

THE AIRBAG SENSOR IN THE SEAT CUSHION HAS FAILED AND A WARNING LIGHT NOW PERMANENTLY SHOWS ON THE INSTRUMENT PANEL. THE PASSENGER AIRBAG MAY NOT FUNCTION AS DESIGNED. UPDATED 11/25/15*LJ UPDATED 2/5/2016 *JS UPDATED 11/07/2017*CN

POWER STEERING PUMP FAILURE AND DRAINED BATTERY (RECENTLY REPLACED). CAR WILL NOT START, AND CAN NOT ACCESS PASSENGER OR TRUNK DOOR DUE TO ELECTRICAL FAILURE. *TR

LOSS OF POWER WHEN GOING 60 MPH IN THE HIGH SPEED LEFT LANE OF FOUR LANE HIGHWAY. CAR WENT INTO "LIMP MODE" AND UNABLE TO ACCELERATE. CAR WOULD ONLY GO 5 TO 10 MPH WITH LARGE TRUCK BEHIND AND BEARING DOWN ON ME. EML AND SERVICE ENGINE LIGHTS ON DASH. WAS ABLE TO PULL INTO A CONSTRUCTION LANE THAT HAPPENED TO BE RIGHT THERE. OTHERWISE WOULD HAVE BEEN UNABLE TO GET CAR OUT OF THE WAY. CAR NEEDED TO BE TOWED. FAULT CODES LIST THROTTLE BODY AND WIRING HARNESS AS PROBLEMS AND RECOMMENDATION IS TO REPLACE BOTH. FROM MY RESEARCH, THE PROBLEM IS WELL KNOWN AND RELATES TO POOR CONNECTOR BETWEEN THROTTLE BODY AND WIRING HARNESS. MINI HAS SINCE REDESIGNED THE ANGLE OF THIS CONNECTOR TO FIX THIS PROBLEM. SUCH A LOSS OF POWER WHILE DRIVING IS EXTREMELY DANGEROUS. SHOULD BE RECALL ITEM. *TR

PURCHASED THIS CAR USED WITH LOW MILES. SHORTLY AFTER PURCHASE I NOTICED THE STEERING ON MY VEHICLE GOT A LITTLE HARDER TO STEER, DIDN'T THINK TO MUCH ABOUT IT. THEN THE RADIATOR FAN WOULD NOT TURN OFF WHEN THE VEHICLE WAS OFF. TOOK THE CAR IN TO TWO DIFFERENT MECHANICS TO FIND THE PROBLEM. FOUND OUT IT WAS THE POWER STEERING PUMP WENT OUT CAUSING THE COOLANT RESERVOIR TO GO OUT. THIS COULD CAUSE EXTREME SAFETY HAZARDS WHEN DRIVING ON THE FREEWAY AND THE STEERING FREEZES!! I CONTACTED BMW AFTER HEARING THERE WAS A RECALL FOR THIS SAME PROBLEM. I WAS TOLD WE MISSED THE RECALL TIME FRAME. I HAVE LOW MILES, 60,000. THE RECALL EXPIRED IN 2017. WELL, MY CARE WAS NOT HAVING THE ISSUES. I DON'T FEEL COMFORTABLE SELLING THE CAR AND HANDING THE PROBLEM TO ANOTHER CONSUMER. THIS RECALL SHOULD BE EXTENDED AS IT COULD BE AN UNPLEASANT RESULT.

ON 13 JUNE 2011 A POWER STEERING FAN SHORTED ON MY DAUHTERS 2002 MINI COOPER S CAUSING THE RADIATOR FAN TO STOP. THIS CAUSED THE CAR TO OVERHEAT. ON 14 JUNE 2011 CAR WAS REPAIRED BY A MINI COOPER DEALER AFTER BEING TOWED. PARTS REPLACED ARE FAN HOUSING WITH FAN, FAN WITH PROTECTING GRILLE, WIRING SET FOR POWER SUPPLY, CABLE STRAP. POWER STEERING FAN SEIZED CAUSING COOLING FANS NOT TO WORK. DEALER REPLACED WIRING HARNESS (UPDATED) TO KEEP POWER STEERING FAN AND COOLING FANS SEPERATE (AS TOLD BY SERVICE REP). OLD PARTS WHERE NOT KEPT. THIS HAPPENED ONCE. *TT

THE AIRBAG SENSOR IN THE SEAT CUSHION HAS FAILED AND A WARNING LIGHT NOW PERMANENTLY SHOWS ON THE INSTRUMENT PANEL. THE PASSENGER AIRBAG MAY NOT FUNCTION AS DESIGNED. UPDATED 11/25/15*LJ UPDATED 2/5/2016 *JS UPDATED 11/07/2017*CN

THE PASSENGER SIDE HEATED SEAT MALFUNCTIONED AND BURNED A HOLE INTO THE LEATHERETTE UPHOLSTERY AND MY WIFES SWEATER. SHE WAS SITTING ON THE PASSENGER SIDE WHEN IT OCCURRED. THIS COULD HAVE CAUSED A MAJOR FIRE A DEFINITE SAFETY HAZARD. *TR

AFTER AN APPARENT SHORT OUT OF THE ANTI-LOCK BRAKING SYSTEM A FIRE OCCURRED SHORTLY AFTER TWO TO FIVE MINUTE LATER THE CAR WAS COMPLETELY ENGULFED IN FLAMES. FIFTEEN MINUTES LATER THE CAR WAS COMPLETELY GONE, CALIFORNIA HIGHWAY PATROL AS WELL AS KEYS CITY FIRE DEPARTMENT BOTH GAVE THEIR CONCLUSION OF THE CAR BEING ABSOLUTELY TOTALED. LUCKILY I WAS ABLE TO GET THE CAR STOPPED AND OFF TO THE SIDE OF THE HIGHWAY AND WAS ABLE TO EVACUATE THE VEHICLE. *TR

WITH ONLY 24000 TOTAL MILES ON THE 2002 MINI COOPER-S ALL 4 BRAKES AND ROTORS WERE FAILING, WORN BEYOND LIMITS AND REQUIRED REPLACING. NOT COVERED BY WARRANTY DUE TO VEHICLE BEING OLDER THAN 3 YEARS AT THE TIME. *TR

METAL TABS CONNECTING GLASS SUNROOF TO SUNROOF GUIDES BROKE. THE METAL SPLIT POSSIBLY DUE TO METAL FATIGUE INDUCED BY VIBRATION. POTENTIAL FOR A VEHICLE TO LOSE SUNROOF IF IT WAS TO LOSE THE OTHER MOUNT. *TR

REAR HATCH HAS NO INSIDE RELEASE, ALTHOUGH SHOWN IN OWNER'S MANUAL. *TR

SEVERAL, THE AIR BAG WARNING LIGHT HAS ILLUMINATED MORE THEN TEN DIFFERENT TIMES, EACH TIME IT WAS REPAIRED BY THE DEALER (WESTCHESTER BMW/WESTCHESTER MINI) THE LAST FIX WAS AFTER THE NORMAL WARRANTY HAD EXPIRED AND REQUIRED MUCH FUSS TO GET IT REPAIRED FOR FREE. THE POWER STEERING PUMP SUDDENLY STOPPED WORKING WHILE DRIVING ON THE HIGHWAY. THE RADIATOR FAN WAS REPLACED TWO TIMES BY ME (CAR OUT OF WARRANTY) EVEN THOUGH I COMPLAINED TO THE DEALER WHEN THE CAR WAS STILL QUITE NEW ABOUT THE FREQUENCY OF THE FAN MOTOR'S STARTING AND STOPPING WHICH WILL SEVERELY SHORTEN THE LIFE OF ANY ELECTRIC MOTOR. THE WINDSHIELD STRESS CRACKED WHILE UNDER WARRANTY AND WAS REPAIRED. THE WINDSHIELD WIPED MOTOR HAS JUST FAILED DURING AN INCREDIBLE RAINSTORM. *JB

THE FRONT WINDSHIELD ON MY 2002 MINI COOPER S AUTO CRACKED SUDDENLY (WITH A POP) WHILE I WAS DRIVING ALONG THE FREEWAY, WITH NO APPARENT CAUSE--NO IMPACT SITE ON THE CRACK. THE CRACK ORIGINATES IN THE LOW/MIDDLE AREA OF THE WINDSHIELD, GOES UP ABOUT 2 INCHES, THEN SNEAKS TO THE PASSENGER SIDE ABOUT 5 INCHES. *JB

TL* THE CONTACT OWNS A 2002 MINI COOPER S. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE FAILED TO SHIFT GEARS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE SHIFT LINKAGE HAD FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 02V201000 (POWER TRAIN). THE FAILURE MILEAGE WAS APPROXIMATELY 34,000. THE VIN WAS UNAVAILABLE.

LOSS OF POWER WHEN GOING 60 MPH IN THE HIGH SPEED LEFT LANE OF FOUR LANE HIGHWAY. CAR WENT INTO "LIMP MODE" AND UNABLE TO ACCELERATE. CAR WOULD ONLY GO 5 TO 10 MPH WITH LARGE TRUCK BEHIND AND BEARING DOWN ON ME. EML AND SERVICE ENGINE LIGHTS ON DASH. WAS ABLE TO PULL INTO A CONSTRUCTION LANE THAT HAPPENED TO BE RIGHT THERE. OTHERWISE WOULD HAVE BEEN UNABLE TO GET CAR OUT OF THE WAY. CAR NEEDED TO BE TOWED. FAULT CODES LIST THROTTLE BODY AND WIRING HARNESS AS PROBLEMS AND RECOMMENDATION IS TO REPLACE BOTH. FROM MY RESEARCH, THE PROBLEM IS WELL KNOWN AND RELATES TO POOR CONNECTOR BETWEEN THROTTLE BODY AND WIRING HARNESS. MINI HAS SINCE REDESIGNED THE ANGLE OF THIS CONNECTOR TO FIX THIS PROBLEM. SUCH A LOSS OF POWER WHILE DRIVING IS EXTREMELY DANGEROUS. SHOULD BE RECALL ITEM. *TR

THE AIRBAG SENSOR IN THE SEAT CUSHION HAS FAILED AND A WARNING LIGHT NOW PERMANENTLY SHOWS ON THE INSTRUMENT PANEL. THE PASSENGER AIRBAG MAY NOT FUNCTION AS DESIGNED. UPDATED 11/25/15*LJ UPDATED 2/5/2016 *JS UPDATED 11/07/2017*CN