2011 MINI Cooper S Electrical Problems

Failure of the Footwell Module failed due to corrosion by water intrusion as diagnosed by Mini Dealership. Windows, Turn signals and lights were inoperable as a result of failure. This matched the situation outlined in your recall notice Part 573 Safety Recall Report 23V-337. Car matched the model/years affected/listed in recall. However, Mini Dealer informed me my VIN was not listed in their recall. Subsequent research indicated that NHTSA/Mini limited the recall to cars purchased cars sold or registered in specific states (not part of the Safety recall report). Ref NEF-107DM dated 5/19/2023. I drove car in those states but did not buy or register the vehicle in them. I encourage you to have Mini extend it's recall/warranty to all vehicles which exhibit the safety failure.

NHTSA ID

11675944

Incident

Jul 7, 2025

The contact owns a 2011 Mini Cooper S. The contact recently replaced the 12-Volt battery; however, while attempting to roll down the windows, the windows failed to respond as needed. The contact stated that the running lights and fog lights were inoperable. The contact stated that the battery was replaced at a tire and battery shop. The contact drove the vehicle back to the shop and was informed that the vehicle could not be repaired. The contact had researched online and related the vehicle failure to NHTSA Campaign Number: 23V337000 (Electrical System). The contact called the manufacturer and was informed that the VIN was not included in the recall. The contact was referred by the manufacturer to contact the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 77,800.

NHTSA ID

11649526

Incident

Mar 10, 2025

Mileage

77,800 mi

My mini after the shop installed a new battery, the power windows don't work( can not roll up or down) as well as the lightning. I saw there is a recall for the footwell module for model 2007-2014 but when I call Mini, the agent told me that my car is not covered. This is a very expensive and important part to replace so please help me the best that you can. Thanks

NHTSA ID

11649399

Incident

Mar 19, 2025

Car stalls while driving and will not start again. No codes thrown. Found relay K96 on Junction Box Electronics module to have cracked through-hole solder joints resulting in bad continuity. Relay K96 supplies power to the low pressure fuel pump in the tank, thus with bad continuity, the pump gets no power. Relay K96 P/N is NEC Philippines P/N EP2F-B3G1ST. This issue has happened to many other people with the same car that I know. I suspect heat cycles over time stressed and fatigued the solder joints, causing the joint to crack. Overall the circuit board layout needs a heat sink for the relay to alleviate the heat produced from operation. I am IPC certified and work with aircraft engine electronics regularly and have seen similar issues.

NHTSA ID

11634691

Incident

Jan 1, 2025

The car was on BMW-MINI recall list and after I made a complaint of non-compliance with the recall, BMW removed my particular vehicle from the recall list without remedying the problem.

NHTSA ID

11627182

Incident

Nov 22, 2024

The contact owns a 2011 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that several warning lights were illuminated erroneously. Additionally, the door locks were locking and unlocking independently. The contact also stated that the sunroof was opening or closing without driver and passenger input. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was approximately 96,000. Parts distribution disconnect.

NHTSA ID

11610220

Incident

Jan 22, 2024

Mileage

96,000 mi

The contact owns a 2011 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contacts daughter called the dealer but could not identify which dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11563595

Incident

Jan 4, 2024

The contact owns a 2011 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electric System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11552922

Incident

Oct 15, 2023

The contact owns a 2011 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. An undisclosed dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11541690

Incident

May 13, 2023

The contact owns a 2011 Mini Cooper S. The contact stated that while driving at an undisclosed speed, the contact was informed that the left turn signal light was inoperable. The vehicle was taken to a local Pep Boys, where the left turn signal light bulb was replaced twice; however, the failure recurred 30 minutes later each time. Additionally, the contact stated that the brake lights were inoperable. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) which the contact related to the failure; however, the part to do the recall repair was not yet available. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 135,000. VIN tool confirms parts not available.

NHTSA ID

11535499

Incident

Jul 24, 2023

Mileage

135,000 mi

ON 05/06/2021, I PURCHASED A USED 2011 MINI COOPER S TURBO. TWO DAYS LATER, I WENT TO START THE CAR, AND IMMEDIATELY SMELLED SOMETHING ELECTRICAL BURNING. WHEN I LIFTED UP HOOD, I COULD SEE SMOKE COMING FROM INSIDE THE ENGINE. I IMMEDIATELY UNHOOKED THE TWO BATTERY CABLES. I CALLED THE CAR LOT THAT I PURCHASED THE VEHICLE, AND WAS TOLD THAT THAT YEAR MINI HAD ISSUES WITH A COMPUTER BOARD OVERHEATING PAND SOMETIMES EVEN STARTING FIRES EVEN WHEN THE CAR ISN'T RUNNING. I HAVE A MEHANIC SCHEDULED FOR MONDAY TO REPAIR THE CAR.

NHTSA ID

11416640

Incident

May 11, 2021

Mileage

100,472 mi

I OWNED A 2011 MINI COOPER S ("MINI") VEHICLE THAT CAUSED A FIRE AND INJURIES AT OUR HOME. THE FIRE WAS DISCOVERED WHILE THE MINI WAS PARKED IN OUR GARAGE WITH THE IGNITION OFF. THE FIRE DESTROYED OUR RESIDENCE, PERSONAL PROPERTY AND TWO VEHICLES, INCLUDING THE AFOREMENTIONED MINI. FIRE AUTHORITIES DETERMINED THAT THE FIRE ORIGINATED IN THE MINI'S ENGINE COMPARTMENT AND A SUBSEQUENT INVESTIGATION YIELDED THAT THE CAUSE OF THE FIRE WAS AN ELECTRICAL FAILURE TO AN ELECTRICAL CONNECTION FOR THE CIRCUIT BOARD ON THE AUXILIARY WATER PUMP. THE FAILURE IGNITED NEARBY COMBUSTIBLES IN THE ENGINE COMPARTMENT. THE FAILURE WAS DETERMINED TO BE CONSISTENT WITH THAT DESCRIBED IN NHTSA SAFETY RECALL CAMPAIGN 12V-008, WHICH AFFECTED 88,911 BMW VEHICLES. IT IS UNKNOWN WHY OUR MINI WAS NOT RECALLED AND OR INCLUDED IN THAT CAMPAIGN. BMW MANUFACTURES MINIS, AS WELL AS OTHER VEHICLES, AND IT HAS BEEN THE SUBJECT OF SEVERAL RECENT NATIONAL MEDIA REPORTS INVOLVING NUMEROUS "UNEXPLAINED" VEHICLE FIRES FOR WHICH THEY HAVE NOT ACCEPTED RESPONSIBILITY OR PROVIDED PLAUSIBLE EXPLANATIONS FOR. TO DATE, BMW HAS FAILED TO DO EITHER OF THE LATTER WITH REGARDS TO OUR FIRE. THIS COMPLAINT IS BEING FILED FOR THE PURPOSE OF ENABLING THE NHTSA TO THOROUGHLY INVESTIGATE THIS MATTER IN THE INTEREST OF PUBLIC SAFETY AND IN SUPPORT OF ITS MISSION OF SAVING LIVES AND PREVENTING ADDITIONAL INJURIES.

NHTSA ID

11120962

Incident

May 1, 2016

Mileage

60,000 mi

MY MINI COOPER WAS PARKED IN MY GARAGE FOR OVER TWO WEEKS. ON AUGUST 10, 2017 I MOVED IT OUT OF THE GARAGE TO GET TO SOME THINGS IN MY GARAGE. WHEN I BACKED IT BACK IN, I HEARD A POP AND WITHIN MINUTES I SAW SMOKE COMING FROM THE HOOD. WHEN WE WERE ABLE TO OPEN THE HOOD THE ENGINE WAS ON FIRE. WE HAD TO CALL 911 AND THEY TOLD US WE COULD NOT LEAVE THE CAR IN THE GARAGE BECAUSE OF THE FIRE INCIDENT. WE HAD TO FIGURE OUT HOW TO GET THE CAR INTO NEUTRAL SO THAT WE COULD MOVE IT OUT OF THE GARAGE WITHOUT STARTING THE CAR. ONCE PARKED ON THE DRIVE WAY, MY CAR PROCEEDED TO SMOLDER TWO MORE TIMES. WE DISCONNECTED THE BATTERY AND FINALLY ALL THE SMOKING STOPPED. MY CAR HAS BEEN AT THE BMW MOMENTUM DEALERSHIP SINCE AUGUST 12, 2017 WITH NO RESOLUTION ON WHAT CAUSED THE FIRE. ACCORDING TO MINI, THEY WERE SENDING A FIRE SPECIALIST TO SEE MY CAR WHICH THEY SAID WOULD TAKE SOME TIME. MY CAR WAS FINALLY LOOKED AT THE FIRST WEEK OF OCTOBER AND AS OF THIS EMAIL, BMW HAS NOT INFORMED ME AS TO WHAT CAUSED THE FIRE. THIS INCIDENT IS VERY CONCERNING TO ME. MY THREE KIDS WERE UPSTAIRS DOING HOMEWORK WHEN MY CAR CAUGHT ON FIRE. HAD I NOT PAID ATTENTION TO THE POP I HEARD AND CLOSED THE GARAGE DOOR, THE CAR WOULD HAVE BEEN ON FIRE IN OUR ATTACHED GARAGE WITH ALL OF US IN THE HOUSE. THIS ALL TOOK PLACE ABOUT 8 PM AS WE WERE WINDING DOWN FOR THE DAY. THE OUTCOME OF THIS COULD HAVE BEEN CATASTROPHIC FOR ME AND MY FAMILY. I WANT RESOLUTION TO THIS WHOLE INCIDENT WHICH AS OF TODAY BMW HAS NOT GIVEN ME ANY INDICATION AS TO WHAT CAUSED THE FIRE.

NHTSA ID

11044039

Incident

Aug 10, 2017

Mileage

41,000 mi

KNOWN ISSUE WITH THERMOSTAT HOUSING & SENSOR - MINI HAS ACKNOWLEDGED A KNOWN DESIGN ISSUE THAT CAUSES COOLANT TO LEAK ONTO THE THERMOSTAT SENSOR. FULL REPLACEMENT IS RECOMMENDED WITH UPDATED DESIGN AT CUSTOMER'S COST. MANUFACTURER SHOULD COVER THIS COST SINCE THIS IS AN ENGINEERING DESIGN DEFECT AND MAY LEAD TO POTENTIAL ELECTRICAL FIRES. AFFECTED PARTS ARE THE THERMOSTAT HOUSING, THERMOSTAT, THERMOSTAT SENSOR, UPPER RADIATOR HOSE & CROSSOVER TUBE. PLEASE REFER TO MANUFACTURER'S COMMUNICATION POST: 10049421, 10046779, & 10045301.

NHTSA ID

10954576

Incident

Feb 14, 2017

Mileage

53,000 mi

AIRBAG SEAT SENSORS ARE FAULTY. THEY ARE TURNING OFF THE AIRBAGS EVEN THOUGHT THE DRIVER AND PASSENGER ARE SEATED. *TR

NHTSA ID

10557200

Incident

Dec 1, 2013

Mileage

29,898 mi

AS I WAS ACCELERATING WHILE MERGING ONTO A HIGHWAY, AT APPROXIMATELY 55-60 MPH, IT FELT AS IF THE CAR LOST ALL POWER FROM THE DRIVE TRAIN. THE POWER REENGAGED ABOUT A SECOND LATER, AND OVER THE NEXT 5-10 SECONDS THE CAR LOST POWER/REENGAGED TWO MORE TIMES. NO WARNING LIGHTS WERE TRIGGERED ON THE DASH. I'VE TAKEN THE CAR INTO DEALERSHIP AND REFERENCED SERVICE BULLETIN NUMBER SIM12-02-11/NHTSA ITEM NUMBER 10040855. DEALER REPORTS THAT BECAUSE IT CANNOT REPLICATE THE ISSUE AND THERE ARE NO REPORTED FAULT CODES, IT APPEARS THAT THERE IS NOTHING WRONG WITH MY CAR, THEREFORE IT CANNOT CONFIRM IF I'M ON MOST RECENT SOFTWARE OR PERFORM SOFTWARE UPDATE TO FIX ERROR REFERENCED IN THE SERVICE BULLETIN. *TR

NHTSA ID

10454891

Incident

Apr 4, 2012

Mileage

6,500 mi