2007 MINI Cooper US Engine Problems

VEHICLE WAS DRIVEN 1.2 MILES FOR FIRST RUN OF THE DAY. TEMP WAS 48 F. CAR WAS IN DRIVE AT STOPLIGHT WHEN ENGINE ACCELERATED BEYOND MAX RPM. CAR LUNGED FORWARD INTO INTERSECTION AND A LOT OF EFFORT HAD TO BE APPLIED TO BRAKE TO KEED CAR FROM GOING ANY FURTHER. DRIVER GRABBED GEAR SHIFTER AND SHIFTED TO NEUTRAL AND HAVING SLIPPED INTO REVERSE. ENGINE RPM THEN SUBSIDED AND VEHICLE WAS THEN DRIVEN 14 MILES WITH NO FURTHER INCIDENCE. *TR

NHTSA ID

10559163

Incident

Jan 9, 2014

Mileage

74,000 mi

AFTER NUMEROUS TRIPS TO GARAGE TO DETERMINE WHY THE ENGINE LIGHT WAS COMING ON AND CAR SIGNALING BY WAY OF ALARM FOR ME TO SEE SERVICE DEPT IMMEDIATELY AND AT LEAST TWICE HAVING BEEN TRAVELING ON THE INTERSTATE AND FOUND MYSELF STRANDED WITH EXTREMELY LOW LEVEL OF ANTIFREEZE, BMW SERVICE DEPT RECOMMENDED A CHANGE OF HEATING THERMOSTAT. SAID THEY HAD SEEN THIS NUMEROUS TIMES. I TRUSTED THEM AND SPENT $550.00 ONLY TO START HAVING THE PROBLEM AGAIN 3 WEEKS LATER. NOW I'M TOLD BY MINI DEALERSHIP I NEED A RADIATOR, BUT GUESS WHAT, IT'S OUT OF WARRANTY. THIS CAR LIVES AT THE GARAGE AND I CANNOT TAKE IT ON A TRIP WITHOUT FEAR OF BEING STRANDED ON THE HIGHWAY. BMW REFUSES TO COMPENSATE FOR WHAT I BELIEVE IS AN ERROR IS DIAGNOSIS. *TR

NHTSA ID

10445141

Incident

Jan 24, 2012

Mileage

33,240 mi

MT CLIENT WAS REACHING INTO THE REAR OF A 2007 MINI COOPER BMW WHEN HER LEG MADE CONTACT WITH THE PROTRUDING MUFFLER THAT CAUSED A SEVERE BURN ON HER LEG. *TR

NHTSA ID

10217342

Incident

Sep 9, 2007

MINI COOPER S 07 MAKES A HORRIBLE RATTLE ON COLD START UP. ENGINE LIGHT COMES ON. CAR DIES. SOUNDS LIKE THERE IS NO OIL IN ENGINE. AFTER CAR IS WARMED UP NOISE GOES AWAY. DEALER HAS REPLACED NON RETURN OIL VALVE. DIDN'T WORK. CAR HAS BEEN AT THE DEALER AT LEAST 6 TIMES FOR THIS PROBLEM. THIS MUST BE DAMAGING THE ENGINE. ONLY 13,300 MILES ON THE CAR. *TR

NHTSA ID

10216298

Incident

Sep 1, 2007

Mileage

9,000 mi

(1) A DEISE-LIKE RATTLING NOISE, NOT IN TIME WITH THE ENGINE, COMING FROM UNDER THE HOOD ON START-UP. THE NOISE WOULD EVENTUALLY GO AWAY AS THE ENGINE WARMED UP. AS TIME PROGRESSED, THE NOISE GREW LOUDER AND TOOK LONGER TO SUBSIDE. VEHICLE WAS EVENTUALLY TURNED OVER TO THE DEALER FOR EVALUATION. (2) THE NOISE WAS DETERMINED TO BE A FAILURE OF THE OIL-FED CAM CHAIN TENSIONER. THE PISTON WAS DETERMINED TO BE STARVED OF OIL, CAUSING THE CAM CHAIN TO CREATE A RATTLING NOISE INCREASING IN VOLUME AND DURATION. (3) PARTS WERE ORDERED TO FIX THE CAM CHAIN TENSIONER AND THE PISTON AND TENSIONER WERE REPLACED. THERE IS STILL SOME RATTLING ON START-UP, BUT THE NOISE HAS SIGNIFICANTLY DIMINISHED. SEVERAL OTHER OWNERS ONLINE HAVE REPORTED SIMILAR ISSUES AND IT APPEARS THE REPLACEMENT OF THE CAM CHAIN TENSIONER IS A TEMPORARY FIX (WITH THE NOISE RETURNING SOME WEEKS LATER). FAILURE OF THE CAM CHAIN TENSIONER WILL LEAD TO ADDITIONAL WEAR ON THE CAM CHAIN EVENTUALLY DAMAGE TO THE ENGINE CASE, CAMS AND VALVES THEMSELVES. A CATASTROPHIC ENGINE FAILURE WILL OCCUR IF THIS ISSUE IS NOT ADDRESSED. *TR

NHTSA ID

10206727

Incident

Sep 27, 2007

Mileage

8,800 mi

THE HOOD (RIGHT ABOVE THE HOOD SCOOP) ON MY R56 07 MINI COOPER S IS EXTREMELY HOT AFTER ANY DRIVING AT ALL. IT'S LITERALLY HOT ENOUGH TO MELT THE PLASTIC ON THE HOOD. THIS IS WELL OVER 200 DEGREES F AND IS A HUGE SAFETY HAZARD TO NOT ONLY MYSELF BUT ANY INDIVIDUAL PASSING BY THE CAR. I'M DEATHLY AFRAID THAT THIS WILL EITHER START A FIRE IN MY GARAGE OR CAUSE AN INDIVIDUAL TO ACCIDENTALLY BURN THEMSELVES ON THE HOOD OF MY CAR. I HAVE ALREADY BEEN BURNED FROM THIS ONCE BY PLACING MY HAND ON THE HOOD. *TR

NHTSA ID

10205391

Incident

Sep 21, 2007

Mileage

7,500 mi

1. I WAS UNLOADING A FEW THINGS FROM THE BACK OF CAR. 2. THE FAILURE IS THAT THE STOCK MINI COOPER S TAILPIPE EXTEND BEYOND THE REAR BUMPER WHICH IS RIGHT WHERE YOU HAVE TO STAND TO ACCESS THE TRUNK. THE CONSEQUENCES ARE THAT I GOT A BIG CIRCULAR BURN ON MY CALF WHEN I LEANED IN TO GRAB SOMETHING. 3. WHAT CAN I DO TO CORRECT THIS? IT'S A STOCK PART / DESIGN THAT'S NEVER BEEN RECALLED AND IS STILL FOR SALE. *JB

NHTSA ID

10204480

Incident

Sep 29, 2007

Mileage

4,000 mi

EXTREME HOOD TEMPERATURE DUE TO TURBO IN EXCESS OF 225 DEGREES F DUE TO EXTREME TEMPERATURES BURNS TO BODY PARTS UP TO 2ND DEGREE CAN OCCUR IF HOOD OF CAR IS TOUCHED. DAMAGE TO PLASTIC HOODSCOOP ON CAR...BASICALLY IT IS MELTING AND DEFORMING I REPLACED THE HOOD SCOOPE AND REFRAIN FROM TOUCHING THE HOOD FOR ABOUT AN HOUR AFTER THE CAR IS SHUT OFF. THIS IS A PROBLEM IF I AM GOING TO HAVE WORK DONE ON THE CAR. *JB

NHTSA ID

10204475

Incident

May 9, 2007

Mileage

1 mi

MY 10 YEAR OLD DAUGHTER RECEIVED A SERIOUS BURN ON HER LEG FROM THE EXHAUST OF MY MINI COOPER S. THE DOUBLE EXHAUST IS LOCATED IN THE CENTER BACK OF THE CAR AND EXTENDS PAST THE EDGE OF THE VEHICLE. IT IS VERY DIFFICULT TO GET ITEMS OUT OF THE TRUNK AREA WITHOUT TOUCHING THE EXHAUST. THE EXHAUST IN LOCATED IN THE EXACT LOCATION WHERE ONE STANDS TO RETRIEVE CARGO. I HAVE BURNED MY LEG TWICE UNLOADING GROCERIES. IT TAKES A CONSTANT EFFORT TO REMEMBER TO AVOID THE EXHAUST. THIS IS A SERIOUS DESIGN FLAW THAT NEEDS TO BE ADDRESSED. *JB ADD PICTURE *121108 CW UPDATED 12/11/08

NHTSA ID

10203038

Incident

Aug 10, 2007

Mileage

2,500 mi

I PARKED MY CAR AFTER ARRIVING AT MY FRIENDS HOUSE, WHICH WAS APPROX. A TWO HOUR DRIVE. AFTER REACHING INSIDE OF THE HATCHBACK TO GRAB LUGGAGE OUT OF MY 2007 MINI COOPER 'S' I WAS BURNED ON MY LEG BY THE TAILPIPE. AFTER STEPPING AWAY FROM THE VEHICLE MY LEG WAS RED IN TWO SPOTS (TWIN-PIPE) AND THEN BUBBLED IN THE NEXT SEVERAL HOURS AND SCABBED. I NOTICED THAT THE TAIL PIPE EXTENDS BEYOND THE BODY OF THE CAR WHICH ALLOWS FOR EASY SKIN CONTACT WITH THE HOT PIPE. UPDATED 04-15-08 *BF UPDATED

NHTSA ID

10201929

Incident

Aug 24, 2007