2003 MINI Cooper Problems

The contact owns a 2003 Mini Cooper. The contact stated that while operating the vehicle, the steering wheel was difficult to turn in either direction. The contact stated that the steering wheel malfunctioned, making the steering wheel easy to turn, causing severe oversteer while making a turn in either direction. The contact stated that the failure was due to a faulty power steering pump, and installed as part of the NHTSA Campaign Number: 15V660000 (STEERING). The vehicle was not repaired. The contact stated that after turning off the vehicle, the power steering pump remained running, causing the battery to drain. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 230,000.

68k miles on a 2003 mini cooper s and the power steering pump is whining. I feel as if this may be really early for it to be needing to be replaced.

TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT STATED THAT THE TRANSMISSION WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENTIRE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000.

WE PURCHASED A 2003 MINI COOPER JUST WEEKS AGO FROM A PRIVATE PARTY. ALMOST INSTANTLY THE POWER STEERING WENT OUT WHILE MY DAUGHTER WAS DRIVING. LUCKILY SHE WASN'T IN HEAVY TRAFFIC ON THE LA FREEWAY. WE WERE TOLD BY THE SERVICE CENTER THAT WE NEEDED A NEW POWER STEERING PUMP. WE PURCHASED THIS AND HAD IT INSTALLED FOR APPROX.$1200.00. HOWEVER THE ELECTRIC POWER STEERING PUMP FAN STILL WOULD NOT SHUT OFF WHEN THE ENGINE WAS TURNED OFF, SO THIS ISSUE WAS STILL NOT RESOLVED. IMMEDIATELY FOLLOWING THIS REPAIR MY DAUGHTER WAS DRIVING ON THE FREEWAY AT 60 MPH WHEN THE CAR SUDDENLY JERKED AND SLOWED TO A STOP. LUCKILY MY DAUGHTER WAS IN THE RIGHT HAND LANE AND COULD PULL OVER ON TO THE SIDE OF THE BUSY FREEWAY.(STILL NO POWER STEERING WORKING)THE CAR WAS TOWED TO THE MINI DEALER. THEY DIAGNOSED THAT THE CVT TRANSMISSION NEEDS TO BE REPLACED, AT A COST OF $7150 APPROX. AND THIS IS BEFORE THEY CAN EVEN DIAGNOSE THE STEERING FAN ELECTRICAL PROBLEM. FROM ALL THE COMPLAINTS ON THIS WEBSITE ABOUT BOTH OF THESE PROBLEMS, MINI NEEDS TO TAKE RESPONSIBILITY! WE DON'T KNOW WHAT TO DO, AS THE REPAIRS ARE MUCH MORE THAN THE CARS VALUE AND THE MINI SERVICE MANAGER STATES THAT THE NEW CVT TRANSMISSION ONLY HAS A 2 YEAR WARRANTY. IF THIS IS A DEFECTIVE TRANSMISSION, WHY SHOULD WE PAY FOR ANOTHER ONE. AS OF TODAY MY DAUGHTER HAS TO WALK/BUS TO SCHOOL AND THE MINI SITS.WE ARE INTERESTED IN THE CLASS ACTION SUIT. *TR

WHILE IN MOTION, CAR BEGAN TO BECOME JERKY WHILE EXCELERATING, THAN THE TRANSMISSION DISINGAGED. NO GEAR WOULD WORK THEREAFTER.

WINDSHIELD CRACKED FROM THE BOTTOM WHERE IT MEETS THE HOOD OF THE CAR. DRIVER'S SIDE WINDOW DOES NOT GO DOWN. I ONLY HEAR A CLICKING SOUND. WATER PUMP, OIL PAN AND VALVE COVER GASKETS FAILED PREMATURELY. I CAN'T SHIFT THE CAR INTO FIRST GEAR WITHOUT MULTIPLE ATTEMPTS.

TL* THE CONTACT OWNED A 2003 MINI COOPER. WHILE THE VEHICLE WAS PARKED IN THE PARKING LOT, THE NEIGHBORS NOTICED THAT IT CAUGHT FIRE AND CALLED THE FIRE DEPARTMENT. THE POLICE ARRIVED AND FILED A REPORT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE POLICE INFORMED THE CONTACT THAT THE FIRE ORIGINATED FROM THE ENGINE. THE VEHICLE WAS DESTROYED AND TOWED TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

WINDSHIELD CRACKED FROM THE BOTTOM WHERE IT MEETS THE HOOD OF THE CAR. DRIVER'S SIDE WINDOW DOES NOT GO DOWN. I ONLY HEAR A CLICKING SOUND. WATER PUMP, OIL PAN AND VALVE COVER GASKETS FAILED PREMATURELY. I CAN'T SHIFT THE CAR INTO FIRST GEAR WITHOUT MULTIPLE ATTEMPTS.

No air or blower or heat to defog windshield. Water in driver-side foot well. Power steering intermittent fault. Engine continues running and panel gauge lights remain on with ignition off and key removed.

i Purchased the car in Dover Pa . INspection sticker had same milage as on car so i shoulda knew he slapped a sticker on . drove 150 miles dash lit ip like chrismas tree. 1st thing left window wont work , then left lock wont work had to lock from passenfger dide. then door wont open at all . have to get ou t passenger door . know that wont open have to put down passenger window pull handel to get out . car is possessed light work whren they want does all kinda crazt stuff . batter has problems . charge and still cant start it . and hatch locks so i cant get to battery. power steering leaking going bad . timing belt making noise . no power on hills .cracking noise in right front pulls to right had . hazard to me ive been locked inside three times could get out of car i coulda sat in heat and died or cold and froze . cant get out of car when it ts electric doors dont work . car sucks . this has been gradual thing these events from feb to may . now i just hate the car

No air or blower or heat to defog windshield. Water in driver-side foot well. Power steering intermittent fault. Engine continues running and panel gauge lights remain on with ignition off and key removed.

NIGHT DRIVING IN COLORADO MTNS. LIGHTS BEGAN TO FLICKER AND POWER STEERING FAILED. FOUND SAFE PLACE TO PULL OVER AND TURNED OFF LIGHTS AND ENGINE. RESTARTED AND TURNED LIGHTS BACK ON TO RESUME DRIVING WITHIN A FEW MINUETS LIGHTS FLICKERED AND POWER STEERING FAILED AGAIN. HAD TO CONTINUE FOR SEVERAL MILES UNTIL IT WAS SAFE TO PULL OVER AGAIN. ATTEMPTED TO TURN OFF HEAD LIGHTS AND USE FOG LIGHTS ON COUNTY DIRT ROAD, STILL LIGHTS FLICKERED/DIMMED AND POWER STEERING FAILED. CURRENTLY VEHICLE IS PARKED AND WE ARE ATTEMPTING TO RESEARCH RECALL MATTERS WITH THIS MALFUNCTION. SUPERIOR DRIVING SKILL IS REQUIRED TO OPERATE THIS VEHICLE WITH NONFUNCTIONAL POWER STEERING. AVERAGE OPERATORS WILL HAVE GREAT DIFFICULTY MAINTAINING SAFE OPERATION OF THE AUTOMOBILE. THIS ISSUE WILL LEAD TO LOSS OF LIFE IF NOT ADDRESSED. NEAREST DEALER FOR MINI IS 130 MILES DISTANT. *TR

THE WARNING FOR TH EPASSENGER AIRBAG COMES ON, THOUGH APPARENTLY NOTHING IS WROMG WITH IT. IT SEEMS TO BE A COMMMON PROBLEM THAT MINI IS AWARE OFF, PUTS PEOPLE IN DANGER, BUT DOESNT DO ANYTHING TO FIX THE HARNESS UNDERNEATH THE PASSENGER SEAT, WHICH THEY QUOTE AT 1200 TO 1400 TO REPAIR THEIR ILL DESIGN AND FINAL PRODUCT

THE DASHBOARD AIRBAG WARNING LAMP IS ALWAYS ILLUMINATED. THE DEALER WANTS THOUSANDS TO FIX THIS PROBLEM EVEN THOUGH OTHER MODEL YEARS HAVE BEEN RECALLED. WE DON'T KNOW IF THE AIRBAG WILL OPERATE CORRECTLY IN AN EMERGENCY. *TR

i Purchased the car in Dover Pa . INspection sticker had same milage as on car so i shoulda knew he slapped a sticker on . drove 150 miles dash lit ip like chrismas tree. 1st thing left window wont work , then left lock wont work had to lock from passenfger dide. then door wont open at all . have to get ou t passenger door . know that wont open have to put down passenger window pull handel to get out . car is possessed light work whren they want does all kinda crazt stuff . batter has problems . charge and still cant start it . and hatch locks so i cant get to battery. power steering leaking going bad . timing belt making noise . no power on hills .cracking noise in right front pulls to right had . hazard to me ive been locked inside three times could get out of car i coulda sat in heat and died or cold and froze . cant get out of car when it ts electric doors dont work . car sucks . this has been gradual thing these events from feb to may . now i just hate the car

DRAIN HOSE FROM SUNROOF DRAIN RUNNING DOWN A-PILLAR CAME DISLODGED THROUGH "NORMAL WEAR AND TEAR" CAUSING MASSIVE FLOODING TO THE INTERIOR OF MY CAR. IT WAS RENDERED UNSERVICEABLE AND TOTALED, ON JUNE 16, 2014, BUT UNCOVERED BY INSURANCE. THIS WAS NOTHING THAT I WAS AWARE OF THAT WAS AN ISSUE, NOR WERE ANY RECALLS EVER ISSUED ON THIS ISSUE. I HAD IT IN TO THE DEALERSHIP IN 2012, 2 YEARS AGO, FOR ELECTRICAL FAILURE, AND THEY THOUGHT IT WAS MERELY THE BATTERY, SO THEY REPLACED IT AND IT SEEMED TO BE FINE, BUT THEY SAID TO KEEP THE BATTERY AS A BACK UP "JUST IN CASE" BECAUSE IT STILL APPEARED TO BE A GOOD BATTERY. THEN LATER IN 2013, I TOOK IT BACK TO THE MINI DEALER FOR GENERAL SERVICE AND I SAID I NOTICED WATER IN THE BOOT (TRUNK) AND FOR THEM TO CHECK THE HATCHBACK SEAL TO SEE IF THERE WAS ANY LEAKS, THEY SAID NO, AND NO FURTHER INVESTIGATION WAS DONE FOR EITHER EVENT. I BELIEVE THAT BOTH THESE EVENTS WERE RESULTS OF THE FAULTY DRAIN HOSE FROM THE A-PILLAR BEING DISLODGED FOR SO LONG. TODAY, THE AUTOMOBILE LEFT MY POSSESSION, TO AN AUCTION HOUSE. I WANTED TO FILE THIS COMPLAINT SO THAT YOU, THE NHTSA CAN PERHAPS HAVE MINI ISSUE A RECALL TO FIX THIS ISSUE AND HAVE THEM CHANGE THEIR VEHICLE'S SUNROOF DRAINAGE SYSTEM SO THAT SOMEONE ELSE DOESN'T HAVE A CAR TOTALLY RUINED BY FLOODING DUE TO THIS DEFECT IN ENGINEERING AND DESIGN. AFTER VIEWING SOME MINI FORUMS, I AM NOT THE ONLY PERSON WHO HAS HAD THIS ISSUE HAS HAPPENED TO THEIR MINI COOPER. I'M VERY SAD, BECAUSE I HAPPENED TO REALLY ENJOY THIS CAR, AND IT WAS TOTALLY FUN TO DRIVE. I WAS ADVISED BY A FRIEND WHO IS A MOTORCYCLE MECHANIC AND MY INSURANCE AGENT TO FILE THIS REPORT WITH YOUR ORGANIZATION, IN HOPES THAT SOMETHING WILL BE DONE ABOUT THIS. TOO MANY PEOPLE DON'T SPEAK UP, AND I AM NOT ONE TO LET SOMETHING DONE WRONG TO ME GO WITHOUT A FIGHT! DO ALL YOU CAN TO RECTIFY THIS ISSUE WITH MINI! *TR

THE LEFT REAR CONTROL ARM BROKE IN HALF. I NOTICED MY CAR WAS NOT REVERSING CORRECTLY AS IF THE REAR WHEEL WAS DRAGGING. I EXITED THE CAR AND ELEVATED IT WITH A FLOOR JACK TO FIND THE REAR CONTROL ARM ON THE DRIVER'S SIDE BROKEN IN HALF. *TR

THIS MINI COOPER A 2003 W/130K MILES DRIVEN BY A YOUNG FEMALE. SHE HAD NO IDEA HER WHEEL WAS GOING TO FALL OFF THE DRIVER SIDE FRONT. SHE HAD CALLED FOR A CHECK ENGINE LIGHT ON AND INTERMITTENT BATTERY FAILURE. IT WAS ASK THAT I DRIVE THE CAR AND LISTEN TO A POP COMING FROM THE WHEEL SECTION. THE POP WAS THE ENTIRE WHEEL ASSEMBLY MOVING FORWARDS AND BACK BUMPING THE WHEEL WELLS AS THE CAR WENT FORWARD. NEEDLESS TO SAY I DIDN'T DRIVE FAR NOR DID I ACCELERATE FASTER THAN 10 MPH. I TOLD THE PARENT OF THE DRIVER THAT THE CAR WAS NOT DRIVABLE UNDER ANY CONDITION AND THAT IT NEEDED IMMEDIATE ATTENTION. THE LOWER CONTROL ARM BUSHING RUBBER WAS COMPLETELY GONE. I DO NOT KNOW IF THIS IS A DEFECT. THIS PART IS A MOUNT AND IT'S HOLDING MANY COMPONENTS OF THIS CAR TOGETHER. IT IS NOTHING LIKE I HAVE SEEN BEFORE USED AS A MOUNT. I HAVE SEEN THE RUBBER WORN FROM THIS TYPE PART BUT THEY WERE NOT BEING USED AS A MOUNT. WHEN THE RUBBER ON THIS PART DETERIORATES IT CAUSES THE MOUNT TO BE UNSTABLE RESULTING IN THE WHOLE WHEEL ASSEMBLY MOVING LIKE A SWING FORWARDS AND BACKWARDS WHILE DRIVING. IN A TRAFFIC SITUATION THIS COULD BE DEVASTATING TO MORE THAN JUST THE DRIVER OF THIS CAR BUT ALSO TO THE CARS DRIVING NEAR IF THE WHEEL WERE TO COME OFF IN THEIR TRAFFIC. NEEDLESS TO SAY THE MINI COOPER WOULD IMMEDIATELY FAIL IN TRAFFIC WITH THE BRAKE CYLINDERS HITTING THE ROAD CAUSING FLYING SPARKS, IF REAR ENDED IT WOULD MORE THAN LIKELY FLIP. THIS IS A DANGEROUS SCENARIO. THIS CAR WAS PURCHASED SECOND HAND AS ARE A LOT OF CARS. THIS IS NOT A PART ON ANYONE'S CHECK LIST AND NOT ONE YOU CONSIDER TO BE ONE OF THIS TYPE OF FAILURE. I AM FILING THIS COMPLAINT BUT I AM NOT THE OWNER OF THIS CAR. I AM MERELY CONCERNED AT THE IMPLICATIONS OF THE DETERIORATION OF THE RUBBER AND WHAT THOSE IMPLICATIONS MEAN TO THE OTHER PURPOSE THIS PART IS SUPPOSE TO PERFORM AND CAN'T WHEN THE RUBBER IS GONE. *TR

THE SPARKPLUG HAS BLOWN COMPLETELY OUT THE HEAD OF MY 2003 MINI COOPER, I WENT ON LINE AND FOUND OUT THAT THIS IS BECOMING A COMMON PROBLEM. *TR

MY TRANSMISSION FAILED ON MY MINI-COOPER ONCE WHEN IT WAS IN WARRANTY AND I HAD TO PAY TO HAVE IT FIXED, ONCE AGAIN, AND IT WAS JUST OUT OF WARRANTY AND I PAID 3000$ TO HAVE IT FIXED AND ONCE AGAIN WHEN THE 2ND TRANSMISSION WAS IN WARRANTY AND MINICOOPER FIXED IT. THIS CAR WAS A LEMON AND MINI NEVER ACCEPTED RESPONSIBILITY FOR THE DEFECTIVE TRANSMISSION PROBLEMS. *TR

THE CAR STALLS(REDUCES SPEED 0-10MPH) IT MAY SHUT COMPLETELY DOWN AT TIMES THIS HAS BEEN THE SAME CONSISTENT PROBLEM SINCE DATE OF PURCHASE THE USED CAR DEALERSHIP HAS BEEN INFORMED OF THIS PROBLEM SINCE DOP AND FOR A MOMENT I THOUGHT THE PROBLEM HAD BEEN SOLVED BUT IT TURNED OUT TO BE A RECALL ON THE POWER STEERING PUMP WHICH WAS REPLACED BACK IN JULY-AUG 2013. THE MINI DEALER ALSO, THOUGHT THEY FOUND THE SOURCE OF THE PROBLEM BUT CONSISTENTLY JUST CHARGED ME MONIES FOR PROBLEM THAT NEVER TURNED OUT TO BE THE SOURCE SO I STOPPED GOING TO THEM. I TRIED TO FILE A LEMON LAW SUIT BUT WAS TOLD I COULDN'T PURSUE BECAUSE STATUTE OF LIMITATIONS. SO LAWYER REF ME TO CONTACT THIS OFFICE AND FILE A CLAIM BECAUSE I'VE SPENT NUMEROUS AMOUNTS OF MONEY AND NOTHING HAS BEEN FIXED I STILL FEEL UNSAFE AND SCARED FOR MY LIFE WHEN I DRIVE BUT I'M LIMITED IN MONEY TO KEEP TRYING TO FIND THE SOURCE THAT'S CAUSING THE PROBLEM. ONE THING NOTED THAT THE CAR ENGINE HAS BEEN REBUILT. ALSO, I'M PAYING A CAR NOTE . PLEASE IF THERE IS ANYWAY YOU CAN'T HELP I FEEL I WAS PREYED UPON AND TAKE. ADVANTAGE OF BECAUSE THE DEALER KNEW THERE WAS A PROBLEM AT THE TIME OF PURCHASE AND WITHHELD IT.

ACCELERATING AFTER BEING STOPPED AT A RED LIGHT, LOST POWER STEERING, SMOKE CAME OUT OF HOOD, ENGINE TEMPERATURE REDLINED, AND BATTERY LIGHT CAME ON. *TR

While driving on I-81 to NY state, I experienced serious tire vibration followed by tire loss of air. All tires were checked for proper tire inflation before trip. After pulling off to the side of the road, I witnessed a large hole with metal fiber sticking through the tire tread. I believe the tread separation was the cause.

While driving on I-81 to NY state, I experienced serious tire vibration followed by tire loss of air. All tires were checked for proper tire inflation before trip. The service center in which I ended up in said that the tire belts had separated and caused the rapid tire deflation.

i Purchased the car in Dover Pa . INspection sticker had same milage as on car so i shoulda knew he slapped a sticker on . drove 150 miles dash lit ip like chrismas tree. 1st thing left window wont work , then left lock wont work had to lock from passenfger dide. then door wont open at all . have to get ou t passenger door . know that wont open have to put down passenger window pull handel to get out . car is possessed light work whren they want does all kinda crazt stuff . batter has problems . charge and still cant start it . and hatch locks so i cant get to battery. power steering leaking going bad . timing belt making noise . no power on hills .cracking noise in right front pulls to right had . hazard to me ive been locked inside three times could get out of car i coulda sat in heat and died or cold and froze . cant get out of car when it ts electric doors dont work . car sucks . this has been gradual thing these events from feb to may . now i just hate the car

THE POWER STEERING PUMP, FAN, HYDRAULIC FLUID PUMP CHF 1 CORE CHARGE) AND HOSE CLAMP WERE REPLACED BY THE DEALER 5 DAYS EARLIER. MINI COOPER/BMW SENT ME A LETTER FOR VOLUNTARY REPLACEMENT BECAUSE MY MINI COPPER 2003 HAD TOO MANY COMPLAINTS WITH THIS ISSUE. THE CAR WAS RUNNING OK EXCEPT FOR THE POWER STEERING AFTER THE REPLACEMENT I ONLY DROVE ABOUT 70 MILES BECAUSE I WAS OFF FROM MY SCHOOL. THE INCIDENT HAPPENED ON JULY 15, 2013 APPROXIMATELY AT 3:45 PM. I DROVE ABOUT 30 MILES BACK FROM WORK. PARKED THE CAR IN FRONT OF RITE AID IN RANCHO PALOS VERDES. WHEN I RETURNED TO THE CAR IT WOULDN'T START. USED JUMP CABLES FOR SEVERAL MINUTES WITHOUT SUCCESS. WENT TO MY MECHANIC CLOSE BY. MY MECHANIC CAME TO LOOK AT THE CAR, HE WAS ABLE TO START THE CAR. I DROVE BACK HOME ABOUT 6 MILES. WHEN I PARKED THE CAR THE CAR WAS VERY HOT AND MOST OF THE LIGHTS IN THE PANEL WERE LIGHTEN. I MUST MENTION THAT MY CAR HAS A NEW BATTERY AND NEW STARTER (BOTH WERE REPLACED 9 MONTHS AGO). IT SEEMS THAT THE PROBLEM IS DIRECTLY RELATED TO THE ELECTRICAL SYSTEM AND TO THE REPLACEMENT OF THE PART ON 7/17/2013. *TR

DRAIN HOSE FROM SUNROOF DRAIN RUNNING DOWN A-PILLAR CAME DISLODGED THROUGH "NORMAL WEAR AND TEAR" CAUSING MASSIVE FLOODING TO THE INTERIOR OF MY CAR. IT WAS RENDERED UNSERVICEABLE AND TOTALED, ON JUNE 16, 2014, BUT UNCOVERED BY INSURANCE. THIS WAS NOTHING THAT I WAS AWARE OF THAT WAS AN ISSUE, NOR WERE ANY RECALLS EVER ISSUED ON THIS ISSUE. I HAD IT IN TO THE DEALERSHIP IN 2012, 2 YEARS AGO, FOR ELECTRICAL FAILURE, AND THEY THOUGHT IT WAS MERELY THE BATTERY, SO THEY REPLACED IT AND IT SEEMED TO BE FINE, BUT THEY SAID TO KEEP THE BATTERY AS A BACK UP "JUST IN CASE" BECAUSE IT STILL APPEARED TO BE A GOOD BATTERY. THEN LATER IN 2013, I TOOK IT BACK TO THE MINI DEALER FOR GENERAL SERVICE AND I SAID I NOTICED WATER IN THE BOOT (TRUNK) AND FOR THEM TO CHECK THE HATCHBACK SEAL TO SEE IF THERE WAS ANY LEAKS, THEY SAID NO, AND NO FURTHER INVESTIGATION WAS DONE FOR EITHER EVENT. I BELIEVE THAT BOTH THESE EVENTS WERE RESULTS OF THE FAULTY DRAIN HOSE FROM THE A-PILLAR BEING DISLODGED FOR SO LONG. TODAY, THE AUTOMOBILE LEFT MY POSSESSION, TO AN AUCTION HOUSE. I WANTED TO FILE THIS COMPLAINT SO THAT YOU, THE NHTSA CAN PERHAPS HAVE MINI ISSUE A RECALL TO FIX THIS ISSUE AND HAVE THEM CHANGE THEIR VEHICLE'S SUNROOF DRAINAGE SYSTEM SO THAT SOMEONE ELSE DOESN'T HAVE A CAR TOTALLY RUINED BY FLOODING DUE TO THIS DEFECT IN ENGINEERING AND DESIGN. AFTER VIEWING SOME MINI FORUMS, I AM NOT THE ONLY PERSON WHO HAS HAD THIS ISSUE HAS HAPPENED TO THEIR MINI COOPER. I'M VERY SAD, BECAUSE I HAPPENED TO REALLY ENJOY THIS CAR, AND IT WAS TOTALLY FUN TO DRIVE. I WAS ADVISED BY A FRIEND WHO IS A MOTORCYCLE MECHANIC AND MY INSURANCE AGENT TO FILE THIS REPORT WITH YOUR ORGANIZATION, IN HOPES THAT SOMETHING WILL BE DONE ABOUT THIS. TOO MANY PEOPLE DON'T SPEAK UP, AND I AM NOT ONE TO LET SOMETHING DONE WRONG TO ME GO WITHOUT A FIGHT! DO ALL YOU CAN TO RECTIFY THIS ISSUE WITH MINI! *TR

THE UPPER RIGHT HINGE ON THE REAR HATCHDOOR OF MY 2003 MINI SHEARED IN HALF CAUSING THE DOOR TO SPRING OFF AND ALMOST HIT ME ON THE HEAD. IT ALSO POSES THE RISK OF THE REAR HATCH DOOR FLYING OFF WHILE THE CAR IS IN MOTION POSING A HAZARD TO OTHER DRIVERS AND PEDESTRIANS. BMW CHARGED ME $700 DOLLARS TO REPLACE THE HINGE AND REFUSED TO ADMIT RESPONSIBILITY FOR THIS DEFECTIVE DESIGN. WHEN I CHECKED ON THE INTERNET IT APPEARS THAT THIS IS A KNOW HAZARDOUS DEFECT. THE FOLLOWING ARE EMAILS EXCHANGED BY ME WITH BMW WHICH QUOTE SOME OF THE INTERNET THREADS ON THIS ISSUE. SEE E.G. HTTP://WWW.NORTHAMERICANMOTORING.COM/FORUMS/STOCK-PROBLEMS-ISSUES/86679-PLEASE-LUBE-REAR-HATCH-HINGES-2.HTML AND HTTP://WWW.MINICOOPERFORUMS.COM/FORUM/SHOWTHREAD.PHP?T=2245. MOREOVER, THE SERVICE MANAGER FOR MINI AT THE DEALERSHIP ADMITTED TO ME THAT THIS IS A COMMON PROBLEM. EMAIL: THE ISSUE IS NOT THE LIFE OF A VEHICLE PART BUT OF A DESIGN DEFECT AND SAFETY FLAW. HINGES ON THE HATCH LID SHOULD NOT BREAK OFF ENDANGERING OWNERS UNDER NORMAL CONDITIONS. THE LID ALMOST FELL ON MY HEAD. THIS SEEMS TO BE A COMMON PROBLEM AND MY DEALER CONFIRMED IT. ARE YOU GOING TO WAIT FOR A LAWSUIT. MOREOVER, A $700 PRICE TAG TO REPLACE A $30 DOLLAR HINGE IS OUTRAGEOUS. THESE HINGES SHOULD NOT FAIL WITH NORMAL USE AND THAT IS ALL IT HAS BEEN SUBJECTED TOO. IF YOU LOOK ON THE INTERNET YOU WILL SEE NUMEROUS COMPLAINTS ABOUT THIS PROBLEM AND MY GUESS IS THAT YOU HAVE RECEIVED THEM AS WELL. THIS HAS COMPLETELY RUINED THE MINI EXPERIENCE FOR ME AND I WILL NOT BE A REPEAT OWNER WITH THAT ATTITUDE. PLEASE READ THEM. AS YOU CAN SEE YOU HAVE A SERIOUS DESIGN FLAW THAT YOU ARE IGNORING AND PASSING ON TO THE CUSTOMERS. IF I DO NOT RECEIVE SOME SATISFACTION WITH THIS I WILL FILE A COMPLAINT WITH THE NHTSA. ON AUGUST 28, 2010. THE REAR HATCH DOOR OF MY MINI FELL OFF WHEN BEING OPENED BECAUSE THE HINGE BROKE IN HALF. THIS COULD HAVE BEEN SERIOUS BUT FORTUNATELY NO ONE WAS HURT. *TR

TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT STATED THAT THE FUEL CAP WOULD NOT PROPERLY SEAL AND WAS CAUSING THE CHECK ENGINE WARNING LIGHT TO ILLUMINATE. THE VEHICLE WAS INSPECTED BY THE DEALER AND THEY ADVISED HER THAT THE FUEL CAP, FUEL TANK NOZZLE, HOSE AND CONNECTOR WOULD NEED REPLACING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 270,000. THE VIN WAS UNAVAILABLE. UPDATED 08/08/11*LJ UPDATED 3/02/2012 *LN

DRIVING HOME THE CAR STALLED AND CAUGHT FIRE. *BF MINI USA EXPERTS WERE UNABLE TO DIAGNOSE THE ROOT OF THE FIRE. *SC THE CONSUMER SPOKE TO 2 OTHER DIFFERENT CAR EXPERTS WHO WERE POSITIVE THAT THE PROBLEM WAS A DEFECTIVE FUEL LINE THAT CONTINUED TO PUMP FUEL ALL OVER THE ENGINE PARTS. *JB

NIGHT DRIVING IN COLORADO MTNS. LIGHTS BEGAN TO FLICKER AND POWER STEERING FAILED. FOUND SAFE PLACE TO PULL OVER AND TURNED OFF LIGHTS AND ENGINE. RESTARTED AND TURNED LIGHTS BACK ON TO RESUME DRIVING WITHIN A FEW MINUETS LIGHTS FLICKERED AND POWER STEERING FAILED AGAIN. HAD TO CONTINUE FOR SEVERAL MILES UNTIL IT WAS SAFE TO PULL OVER AGAIN. ATTEMPTED TO TURN OFF HEAD LIGHTS AND USE FOG LIGHTS ON COUNTY DIRT ROAD, STILL LIGHTS FLICKERED/DIMMED AND POWER STEERING FAILED. CURRENTLY VEHICLE IS PARKED AND WE ARE ATTEMPTING TO RESEARCH RECALL MATTERS WITH THIS MALFUNCTION. SUPERIOR DRIVING SKILL IS REQUIRED TO OPERATE THIS VEHICLE WITH NONFUNCTIONAL POWER STEERING. AVERAGE OPERATORS WILL HAVE GREAT DIFFICULTY MAINTAINING SAFE OPERATION OF THE AUTOMOBILE. THIS ISSUE WILL LEAD TO LOSS OF LIFE IF NOT ADDRESSED. NEAREST DEALER FOR MINI IS 130 MILES DISTANT. *TR

THE XENON IGNITER COMPONENT IN THE LEFT HEADLAMP HAS INTERMITTENT FUNCTION, FREQUENTLY CAUSING THE BULB NOT TO LIGHT. THE QUOTED REPAIR COST BY THE DEALER IS IN EXCESS OF $800 BECAUSE THE IGNITER PART IS NOT A REPLACEABLE COMPONENT (THE ENTIRE HEADLIGHT ASSY IS REPLACED). THE ORIGINAL OEM BULB IN THE AFFECTED LEFT HEADLAMP WAS REPLACED BY MINI DURING ITS WARRANTY PERIOD AND THIS WAS NOT REPORTED TO ME (THE LEFT AND RIGHT BULBS DID NOT MATCH UPON MY EXAMINATION OF THEM WHEN FIRST OBSERVING THIS PROBLEM). $800 TO FIX A LIGHT BULB IS RIDICULOUS, AND I'VE BEEN LIVING WITH THIS SAFETY HAZARD SINCE I OBSERVED IT IN SEPTEMBER 2010. BMW USA SHOULD BE COMPELLED TO RECALL THIS DEFECTIVE COMPONENT. *TR