2011 MINI Cooper Electrical Problems

I am filing this complaint against Keeler MINI in Latham, NY, and MINI USA regarding their refusal to provide a working recall remedy or alternative transportation under federal NHTSA Safety Recall 23V-337 (Footwell Control Module Moisture Intrusion). My 2011 MINI Cooper suffered an active, total failure of the Footwell Control Module—the precise component identified in Recall 23V-337. The module short-circuited, creating a constant parasitic power drain that disables the battery and renders the vehicle completely un-drivable. I have been without a functioning car for over three weeks. Keeler MINI claims the recall repair will take four weeks due to parts delays, yet they explicitly refuse to provide a dealer loaner or authorize a rental vehicle while holding my disabled car. Representatives from MINI USA Corporate explicitly confirmed to us that under official Service Bulletin SI B61 05 23, this recall qualifies for Alternative Mobility Solutions (AMS) rental reimbursement, and a MINI Regional Director confirmed I should receive a loaner. However, Keeler MINI's service staff refuses to issue a vehicle, screening our calls, ignoring repeated messages, and refusing to let us speak with service management. I am an elderly consumer with significant medical needs. Being left completely stranded without transportation for nearly a month has forced me to miss multiple critical specialist medical appointments (including follow-ups for a TIA/stroke, ophthalmology, physical therapy, and nephrology). This unreasonable barrier to a safety recall remedy poses a severe risk to my health and safety. Addendum: Keeler said parts are available for repair-will still take 4 weeks. I originally called Keeler 9-12 mos ago,every 2-4 wks for an appt that did not take 4 weeks. None available. Footwell Control Module currently totally broken

NHTSA ID

11755957

Incident

Jul 22, 2026

The contact owns a 2011 Mini Cooper. The contact stated that while driving at approximately 45 MPH in the rain with the windows rolled down, the driver's side and passenger's side windows failed to roll up. No warning light illuminated. Additionally, the headlights, windows, and daytime running lights became inoperable. The contact was unsure if the taillights were affected. The contact stated that the vehicle had been garage-kept. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System). The vehicle was towed to the local dealer, where it was diagnosed that the footwell control module had failed. The vehicle was not repaired because there was no extended warranty coverage. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 198,000.

NHTSA ID

11742747

Incident

May 31, 2026

Mileage

198,000 mi

My Mini Cooper has been showing repeated warnings stating “Start-off assistance inactive. Caution: vehicle may roll back!” for some time. This issue appears to relate to an existing recall involving potential electrical and starter/rollaway defects. The vehicle also has a persistent front parking light malfunction and intermittent electrical issues with the windows, which stop mid-way and roll back down automatically when the car shifts gears or moves slightly. In addition, the battery repeatedly dies, even though it was replaced with a brand-new one a few months ago. This suggests an underlying electrical drain or short, which could increase the risk of electrical fire or vehicle failure while driving. These malfunctions create significant safety concerns, as the vehicle may roll backward when stopped on an incline and could pose a fire risk due to the known recall. The car has not been safe to drive. The closest Mini dealership (Flow Mini of Raleigh - about 2 hours away) confirmed that the recall is open but refused to provide or authorize a tow, even after I explained that the vehicle could not be safely driven to their location about 2 hours away. The problem has been ongoing for several years, worsening over time. Warning messages appear intermittently but frequently, especially during start-up or when stopped on slopes. Mini USA has not inspected or repaired the vehicle, and their representatives have stated they will not assist with transport to the dealership despite the known recall risk. I called MINI USA directly, and recorded the whole ordeal. I was forwarded to 5 different departments, and the last person stated that because my car is out of warranty that there’s nothing they can do to help me - that any tow I opt for would have to be out-of-pocket. I was in the middle of explaining to her that my car has these very specific warnings and issues associated with this recall that is solely the fault of Mini, and she hung up on me.

NHTSA ID

11692411

Incident

Oct 9, 2025

After receiving your notice regarding my MiniCooper (VIN [XXX] ), I contacted my local dealer, Motor City Mini (where I purchased the vehicle) to schedule the inspection, and repairs if necessary. I was informed that the earliest inspection would be in September and they would need to keep the vehicle for several weeks to do the inspection. If repairs are required, they would need to keep 'the vehicle 'for additional weeks or months to complete the work. Loaner vehicles would not be available. In your letter, you state, "If your MINI dealer is unable to remedy the defect ...within a reasonable period of time, you may notify the Administrator. .." . I consider weeks to inspect and month(s) to repair unreasonable. Please advise on how I should proceed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11666386

Incident

May 15, 2025

The contact owns a 2011 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11651122

Incident

Apr 15, 2023

See attached document for complaint.

NHTSA ID

11637404

Incident

Feb 16, 2022

I bought a used 2011 MINI Cooper S (R56) and it had a recall for the footwell module (FRM). I took it to the local MINI dealership and they said that MINI would not honor the recall because the FRM was replaced with a used FRM that was not properly programmed. They want to charge me over $1000 new FRM. I believe that the previous owner of the vehicle replaced the FRM before the recall. I believe that the corrosion that has lead to the recall affected the car before MINI announced the recall and the previous owner, to save money, replaced the FRM using a used part.

NHTSA ID

11622040

Incident

Oct 25, 2024

There has been a recall on my mini Cooper for sometime now. Over a year and a half at least. We have been patiently waiting for the remedy and still, do not have one. Our car, at times has become inoperable due to this recall. We took it to an auto shop, they ran a test and confirmed that the issues we are receiving are from the recall. I feel like this issue is taking a very long time for mini to fix and it is putting us out of money and causing lots of stress to us. I am filing this complaint in hopes this can provide a solution to us and mini.

NHTSA ID

11613242

Incident

Aug 15, 2024

The contact owns a 2011 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11591029

Incident

May 28, 2024

The contact owns a 2011 Mini Cooper. The contact stated that the rear taillights had stopped illuminating, the windows were not rolling up or down, and the driver's and passenger's side door buttons were not opening the door. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 120,000. VIN tool confirms parts not available.

NHTSA ID

11586350

Incident

Mar 1, 2023

Mileage

120,000 mi

found fault code:2BDL4 MONITORING POWER SUPPLY 3 SENSOR CY320 CONTROL UNIT LOGGING ECCENTRIC SHAFT SENSOR VOLTAGES OUTSIDE OF THRESHOLDS FOUND ENGINE CONTROL UNIT FAULTY

NHTSA ID

11571185

Incident

Feb 10, 2024

The contact owns a 2011 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the vehicle was shuddering while starting. Additionally, the contact stated while driving 15-20 MPH, the vehicle was shuddering and turning off intermittently. The check engine warning light was illuminated. The contact stated that he was able to pull to the side of the road each time the failure occurred. The contact stated that upon restarting the vehicle, the vehicle shuddered. The contact was able to drive to a nearby independent mechanic. The mechanic informed the contact that the vehicle was overheating while starting, and that the vehicle was still running even after being turned off. The vehicle was being diagnosed but was not yet repaired. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000. VIN tool confirms parts not available.

NHTSA ID

11563316

Incident

Dec 9, 2023

Mileage

95,000 mi

The contact owns a 2011 Mini Cooper. The contact stated that the turn signal, interior lights, hazard lights, fog lights, brake lights, windows, and exterior lights were inoperable. The Service Now warning light was illuminated. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 56,000. VIN tool confirms parts not available.

NHTSA ID

11560094

Incident

Jun 1, 2023

Mileage

56,000 mi

The contact owns a 2011 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle failed to start. The vehicle was towed to an independent mechanic who diagnosed the vehicle and determined that the footwell control module had failed. The failure mileage was approximately 111,000. The manufacturer was made aware of the issue. VIN tool confirms parts not available.

NHTSA ID

11558696

Incident

Dec 1, 2023

Mileage

111,000 mi

The contact owns a 2011 Mini Cooper. The contact stated that while driving at an undisclosed speed, the electrical system became inoperable. The contact stated the turn signals and the lights were not functioning as intended. The contact also stated that the doors and the window power switches were inoperable. The contact stated that due to the electrical failure, the turn signals could not be used while driving which presented a safety hazard. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but did not assist. The failure mileage was approximately 163,000.

NHTSA ID

11558301

Incident

Nov 27, 2023

Mileage

163,000 mi

What component or system failed or malfunctioned, and is it available for inspection upon request? THE AIRBAG LIGHT KEEPS COMING ON AND OFF, AS WELL AS THE SEATBELT LIGHTS. IT CAN BE INSPECTED IF REQUESTED. How was your safety or the safety of others put at risk? IF THE AIRBAGS OR SEAT BELTS ARE NOT FUNCTIONING PROPERLY THIS COULD RESULT IN INJURY UP TO AND INCLUDING DEATH. Has the problem been reproduced or confirmed by a dealer or independent service center? IT KEEPS HAPPENING, NOT BEEN TO A DEALER YET THOUGH. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO INPSECTION HAS BEEN DONE. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? IT APPEARS THAT THE SUNROOF HAS BEEN LEAKING DOWN THE DASH ON THE PASSENEGER SIDE. THAT LEAKS RIGHT ONTO THE FUSE BOX WHICH COULD BE CAUSING SOME OF THE ISSUES. IF THE FUSE BOX IS BEING LEAKED ONTO THIS COULD BE A POTENTIAL FIRE HAZARD.

NHTSA ID

11555327

Incident

May 1, 2023

Footwell Control Module - (FRM) was dead after battery dead. It had a safety recall repot 23V-337 on the same model and year of my vehicle BUT mine is not on the list? A extended warranty was found till 2021 and mine had problem since 2014, and I paid dealership for inspection for at least 6 times, and it was still not got replaced till it was dead completely currently.

NHTSA ID

11551454

Incident

Oct 7, 2023

The contact owns a 2011 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11549832

Incident

Oct 11, 2023

The contact owns a 2011 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000(Electrical System) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

NHTSA ID

11549654

Incident

Oct 1, 2023

The contact owns a 2011 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11545167

Incident

Sep 18, 2023

While driving, my turn signals, power windows and lights stopped working. I believe this is due to the Footwell Module recall, but the dealer will not replace the module because there isn't a remedy for the recall. It's been 5 months now.

NHTSA ID

11544647

Incident

Apr 1, 2023

trouble code: 93C3 ACSM/MRS: Seat-occupancy detector, passenger

NHTSA ID

11544198

Incident

Sep 12, 2023

Changed out the battery and now my windows and lights and locks are not working

NHTSA ID

11543324

Incident

Sep 8, 2023

The contact owns a 2011 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted, and the contact was informed that the part for the recall repair was not yet available. The contact stated that the manufacturer was made aware of the issue. The contact was informed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11541123

Incident

Aug 28, 2023

the car just started to smoke it looked like it was going to catch fire now the car won't start and I can't use it

NHTSA ID

11539052

Incident

Jul 17, 2023