2014 MINI Cooper Problems

The fuse box JBE module has a Quality Assurance problem with a solder connection to the NEC low pressure fuel relay. This is a known issue with BMW/Mini. The car suddenly stalls without warning. If the driver is not keen or if traffic patterns do not allow, the car can be left in very dangerous situations on the highway or in the middle of intersection. The repair for this problem is widely distributed online via blogs and YouTube, but replacement modules are $1500 (part only) and these modules are not available until at least October 2023. There are no warning lights or other warnings prior to the incident. While I am not aware of any serious injuries, it is only a matter of time before someone is t-boned at an intersections. This part MUST be immediately recalled due to the safety risk. The images below show the JBE fuse box housing as well as the PCB where the cold solder joint can be seen. I have circled the cold solder joint in the close up picture.

The contact owns a 2014 Mini Cooper. The contact stated that while driving approximately 25 mph, there was smoke detected from the vehicle. The vehicle caught fire without warning. There were no reported injuries, air bag deployment, or crash. The fire department distinguished the fire. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was towed to a lot. The manufacturer was not notified of the failure. The failure mileage was approximately 84,700.

The contact owns a 2014 Mini Cooper. The contact stated that the front driver's side and passenger’s side doors and windows failed to properly close. The vehicle was taken to the local mechanic who diagnosed the vehicle and determined that the failure was caused by a faulty foot well module which caused the electrical power windows to malfunction and the doors to not properly close. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 23V337000 (ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 80,000.

The fuse box JBE module has a Quality Assurance problem with a solder connection to the NEC low pressure fuel relay. This is a known issue with BMW/Mini. The car suddenly stalls without warning. If the driver is not keen or if traffic patterns do not allow, the car can be left in very dangerous situations on the highway or in the middle of intersection. The repair for this problem is widely distributed online via blogs and YouTube, but replacement modules are $1500 (part only) and these modules are not available until at least October 2023. There are no warning lights or other warnings prior to the incident. While I am not aware of any serious injuries, it is only a matter of time before someone is t-boned at an intersections. This part MUST be immediately recalled due to the safety risk. The images below show the JBE fuse box housing as well as the PCB where the cold solder joint can be seen. I have circled the cold solder joint in the close up picture.

Engine motor mount sheared, allowing motor to interact with and bounce directly on the frame, and stressing the other connections and components. Dealer indicated this is a very common problem for this car model and is likely a design issue, and even had another example of a sheared mount on display in order to show others with the same issue.

HELLO, I AM THE ORIGINAL OWNER OF A 2014 MINI COOPER COUNTRYMAN PURCHASED NEW FROM IRVINE MINI, IRVINE CALIFORNIA, ON MY WAY HOME TO SAN DIEGO FROM THE PURCHASE THE REAR PASSENGER WINDOW STOPPED WORKING, I PULLED OVER CALLED THE DEALERSHIP AND WAS TOLD TO GO IN THE NEXT DAY FOR REPAIR, IT WAS REPAIRED THE NEXT DAY, ELECTRICAL FAILURE. 2014, NEXT WAS THE ENGINE WOULD STAY ON WHEN THE KEY WAS REMOVED, DEALERSHIP X 3 BUT THEY COULD FIND NOTHING, 2ND YEAR WAS DRIVING UPHILL CITY STREETS AND CAR LOST POWER, STARTING SMOKING, PULLED OVER AFTER RESTING CAR WAS DRIVABLE, DEALERSHIPS COULD FIND NOTHING WRONG, WE NEVER RECEIVED ANY NOTICE FROM OUR DEALERSHIP INFORMING US OF FAULTY TRANSMISSION. MY CHECK ENGINE LIGHT NEVER CAME ON BUT CAR STARTED LOSING POWER A FEW WEEKS AGO. I RECENTLY TOOK IT TO DEALER WHO TOLD ME THE TRANSMISSION HAS TO BE REPLACED, IT WASN'T A COMPUTER GLITCH AND THESE TRANSMISSIONS CANNOT BE SERVICED. WHAT DO I DO NOW?

DRIVER'S DOOR HANDLE LOCK COVER (PLASTIC) FELT UNEXPECTEDLY WHILE DRIVING.

TL* THE CONTACT OWNS A 2014 MINI COOPER. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V815000 (STRUCTURE) WAS RECEIVED IN FEBRUARY OF 2015. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

The "Passenger Airbag Off" light is illuminated, meaning the primary safety restraint system is disabled. The failed component is the "Occupancy Classification System (OCS) / OC3 Sensor Mat." I purchased a very well-maintained 2014 MINI in March 2026 and the failure occurred shortly after the 10-year warranty window expired. BMW Group has similar BMW models using the very same technology, and they received 15-year extensions, not 10. BMW Coverage: Has extended the warranty for the OC3 mat to 15 years/Unlimited miles for specific "eligible US-specification" models like the 3 Series, 5 Series, and Z4. MINI Coverage: Currently caps the warranty extension at 10 years/120,000 miles for its eligible vehicles.

MY INSURANCE HAS ASKED ME TO FILE THIS COMPLAINT AS MY VEHICLE'SAIRBAGS DEPLOYED AT AN IMPACT UNDER 5 MPH LEADING TO THE CONCLUSION THAT THE AIRBAG SENSOR IN MY CAR IS FAULTY.ON FRIDAY, JULY 6TH AT 10:15 AM I WAS DRIVING ON THE 405 N IN BUMPER TO BUMPER FREEWAY TRAFFIC, IT WAS A CLEAR DAY WITH GOOD VISIBILITY AND ROAD CONDITIONS. THE TWO VEHICLE'S INVOLVED IN THE MINOR COLLISIONWERE MY 2014 MINI COUNTRYMAN AND A 2017 INFINITY. MANYCARS WERE CUTTING OVER TO THE RIGHT TO GET ONTO THE UPCOMING 55 NORTH AND SOUTHBOUND INTERCHANGE HIGHWAY. ASI WAS MERGING TO THE LEFT A GREY CAR SPED BY TO MERGE RIGHT CAUSING ME TO MERGE BACK INTO MY LANE. HOWEVER, THE WHITE INFINITY AHEADHAD HIT THE BRAKES CAUSING ME TOTAP HER REAR BUMPER AT AN IMPACT UNDER 5 MPH. THEN THE THREE DRIVER'S SIDE AIRBAGS DEPLOYED. I IMMEDIATELY CALLED 911 AND THEY TRANSFERRED ME TO THE CHP. AFTER HANGING UP, I GOT OUT OF MY CAR AND THE OTHER DRIVER AND IEXCHANGED INFORMATION. THE OTHER DRIVER LEFT WITHIN 5 MINUTES AS HERBUMPER WAS LEFT WITH ONLY A MINOR SCRATCH, AND NO DENTS OR BUMPS.I GOT BACK IN MY VEHICLE AND WAITED FOR THE CHP. WHEN THE OFFICER ARRIVED, HE PUSHED MY CAR TO THE RIGHT SIDE OF THE ROAD. WE WAITED FOR THE AAA TOW TRUCK. NO ACCIDENT REPORT WAS TAKEN AS THERE WAS NO ACCUSATIONS OR INJURY. THE TOW TRUCK DROVE MY VEHICLE TO THE NEAREST MINI DEALERSHIP.MY INSURANCE COMPANY WANTS TO MOVE FORWARD AND FIX BOTH CARS' MINOR DAMAGE AND REPAIR MY VEHICLE'S AIRBAGS. THECOST PER AIRBAG RANGES FROM $1000 TO $2000.HOW VERY UNFORTUNATE GIVEN THE EXTREMELY MINOR DAMAGE INVOLVED.FROM WHAT I HAVE GATHERED, I'VE FOUND THAT AIRBAGSARE TO DEPLOY AT AN ABSOLUTE MINIMUM SPEED OF 10 MPH. GIVEN THE FACT THAT THE AFOREMENTIONED COLLISION OCCURRED BELOW 10 MPH, IT IS THEREFORE TO BE ASSUMED THAT SOME SORT OF ERROR OCCURRED CAUSING THE DEPLOYMENT OF MY VEHICLE'S AIRBAGS.

Engine motor mount sheared, allowing motor to interact with and bounce directly on the frame, and stressing the other connections and components. Dealer indicated this is a very common problem for this car model and is likely a design issue, and even had another example of a sheared mount on display in order to show others with the same issue.

MY CAR WOULD MAKE A NOISE AT THE REAR OF THE CAR WHEN I DROVE ON A BUMPY STREET, I TOOK THE CAR TO THE DEALER AND AFTER THERE INSPECTION , THEY SAID THE REAR SWAY BAR LINKS HAD TO BE REPLACED. I AM CONCERNED THAT IF THE ORIGINAL PARTS WERE DEFECTIVE, MAYBE THE NEW PARTS WILL ALSO BE DEFECTIVE... THE CAR IS UNDER WARRANTY, THE DEALER IS MAKING THE REPAIRS...UPDATED 10/15/15 *BF THE DEALER STATED THE REAR SWAY BAR LINK WAS NOT THE PROBLEM CAUSING THE NOISE. UPDATED 10/20/15 *JB

The fuse box JBE module has a Quality Assurance problem with a solder connection to the NEC low pressure fuel relay. This is a known issue with BMW/Mini. The car suddenly stalls without warning. If the driver is not keen or if traffic patterns do not allow, the car can be left in very dangerous situations on the highway or in the middle of intersection. The repair for this problem is widely distributed online via blogs and YouTube, but replacement modules are $1500 (part only) and these modules are not available until at least October 2023. There are no warning lights or other warnings prior to the incident. While I am not aware of any serious injuries, it is only a matter of time before someone is t-boned at an intersections. This part MUST be immediately recalled due to the safety risk. The images below show the JBE fuse box housing as well as the PCB where the cold solder joint can be seen. I have circled the cold solder joint in the close up picture.

NEARLY RAN OUT OF GASOLINE BECAUSE THE GAS GAUGE IS NOT ACCURATE. AT AN INDICATED 1/2 FULL, THE CAR IS DOWN OVER 9 GALLONS AND THE TANK HOLD ABOUT 12.5 GALLONS. USING THE GAS GAUGE THERE IS NO WAY TO TELL HOW MUCH FUEL REMAINS IN THE TANK. *TR

DRIVING TO SHOPPING CENTER, I HAD MY HEATED SEAT TURNED TO THE HIGHEST SETTING. IT SEEMED AS THOUGH THE SEAT WAS UNUSUALLY WARM SO I TURNED THE SEAT DOWN TO THE MEDIUM SETTING AND CONTINUED DRIVING. THE SEAT CONTINUED TO FEEL UNCOMFORTABLE AS I DROVE, SO I TURNED IT DOWN TO LOW, BUT IT STILL DID NOT COOL DOWN. IT BECAME ALARMINGLY HOT SO I TURNED IT OFF COMPLETELY BUT IT DID NOT COOL DOWN. AT THIS POINT I WOULD HAVE EXITED THE CAR, BUT I WAS IN HEAVY TRAFFIC IN FRONT OF THE MALL. AFTER PARKING I DID MY SHOPPING AND DID NOT TURN THE SEAT ON FOR THE DRIVE HOME. THE NEXT MORNING I DISCOVERED A 13 INCH BURN IN THE CONFIGURATION OF A WIRE ON MY LEFT BUTTOCK AND THIGH. (PICTURE TAKEN) BMW REPORT STATED THAT THEY FOUND NOTHING WRONG WITH THE SEAT AND THAT IT "PERFORMED AS IT WAS DESIGNED." THEY ACCEPTED NO RESPONSIBILITY FOR MY BODILY INJURY. *TR

THERE WAS NO ONE SITTING IN THE FRONT PASSENGER SEAT, BUT MY IPOD WAS ON THE SEAT. A "FASTEN SEAT BELT" WARNING WENT OFF WHILE I WAS DRIVING AT HIGHWAY SPEEDS. I HAD BEEN DRIVING FOR OVER 30 MINUTES WHEN THIS HAPPENED. WHILE DRIVING, I REMOVED THE IPOD FROM THE SEAT, BUT THE WARNING DID NOT STOP. BECAUSE IT WAS NOT IMMEDIATELY POSSIBLE TO PULL OVER, I HAD TO IGNORE SAFETY LIGHTS AND CHIMES UNTIL I COULD PULL OVER. ALTHOUGH THIS FALSE WARNING HAS HAPPENED SEVERAL TIMES WITH LIGHT OBJECTS IN THE PASSENGER SEAT, IT DOES NOT HAPPEN CONSISTENTLY. THE DEALER INSISTS THE CAR IS FUNCTIONING PROPERLY, AND SUGGESTED I LEAVE THE PASSENGER SEAT BELT FASTENED. I THINK THIS BEHAVIOR IS A SAFETY CONCERN BECAUSE (1) IT IS A SOURCE OF UNPREDICTABLE DRIVER DISTRACTION; (2) IT ENCOURAGES DRIVERS TO DEFEAT A SAFETY WARNING BY LEAVING THE PASSENGER SEAT BELT FASTENED; AND (3) IF THE SEAT SENSOR CAN'T DISTINGUISH BETWEEN AN IPOD AND A PERSON, HOW CAN IT GIVE THE PROPER READINGS TO THE AIR BAG SYSTEM IN THE EVENT OF A CRASH. *TR

AFTER UNLATCHING THE DRIVER SIDE SEATBELT, THE BELT FOLD INTO THE RETRACTION MECHANISM SUCH THAT IT GOT STUCK AND COULD NOT BE USED UNTIL IT WAS MANUALLY UNSPOOLED, WHICH IS EXTREMELY DIFFICULT TO DO. THIS HAS HAPPENED MANY TIMES IN THIS CAR AND PRESENTS AND SERIOUS SAFETY ISSUE SINCE IT RENDERS THE SEATBELT POTENTIALLY UNUSABLE. *TR

THERE WAS NO ONE SITTING IN THE FRONT PASSENGER SEAT, BUT MY IPOD WAS ON THE SEAT. A "FASTEN SEAT BELT" WARNING WENT OFF WHILE I WAS DRIVING AT HIGHWAY SPEEDS. I HAD BEEN DRIVING FOR OVER 30 MINUTES WHEN THIS HAPPENED. WHILE DRIVING, I REMOVED THE IPOD FROM THE SEAT, BUT THE WARNING DID NOT STOP. BECAUSE IT WAS NOT IMMEDIATELY POSSIBLE TO PULL OVER, I HAD TO IGNORE SAFETY LIGHTS AND CHIMES UNTIL I COULD PULL OVER. ALTHOUGH THIS FALSE WARNING HAS HAPPENED SEVERAL TIMES WITH LIGHT OBJECTS IN THE PASSENGER SEAT, IT DOES NOT HAPPEN CONSISTENTLY. THE DEALER INSISTS THE CAR IS FUNCTIONING PROPERLY, AND SUGGESTED I LEAVE THE PASSENGER SEAT BELT FASTENED. I THINK THIS BEHAVIOR IS A SAFETY CONCERN BECAUSE (1) IT IS A SOURCE OF UNPREDICTABLE DRIVER DISTRACTION; (2) IT ENCOURAGES DRIVERS TO DEFEAT A SAFETY WARNING BY LEAVING THE PASSENGER SEAT BELT FASTENED; AND (3) IF THE SEAT SENSOR CAN'T DISTINGUISH BETWEEN AN IPOD AND A PERSON, HOW CAN IT GIVE THE PROPER READINGS TO THE AIR BAG SYSTEM IN THE EVENT OF A CRASH. *TR

TL* THE CONTACT OWNS A 2014 MINI COOPER. WHILE DRIVING AT 80 MPH, THE VEHICLE STARTED TO SHAKE VIOLENTLY. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V815000 (STRUCTURE) AND 14V154000, (EQUIPMENT); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 7,600.

ON TWO OCCASIONS (7/19/14 AND 7/29/14), THE ENGINE CUT-OFF, PUTTING THE CAR IN "ACCESSORY MODE." ON BOTH OCCASIONS, I WAS DRIVING ON A FLAT ROAD, AT LOW SPEED. THERE WAS NO ABILITY TO DRIVE THE VEHICLE WITHOUT COMPLETELY STOPPING, PUTTING THE CAR IN PARK, AND RESTARTING THE CAR. AS A RESULT OF BEING IN ACCESSORY MODE, I HAD NO POWER STEERING AND WAS ONLY ABLE TO GLIDE OVER TO THE SIDE OF THE ROAD. A MESSAGE APPEARED ON THE CAR'S SCREEN: "TRANSMISSION NOT IN PARK, VEHICLE MAY ROLL." I PURCHASED THIS VEHICLE 3 MONTHS AGO. I AM VERY CONCERNED, AND I DON'T FEEL SAFE DRIVING THIS CAR. IF THIS WERE TO HAPPEN ON A HIGHWAY, THERE WOULD CERTAINLY BE A SERIOUS ACCIDENT, AS I WOULD NOT BE ABLE TO GET THE CAR TO THE SHOULDER. AS EVIDENCED IN THE GM IGNITION SWITCH CASES, WHEN A CAR IS SWITCHED INTO ACCESSORY MODE WHILE DRIVING, THE AIRBAGS ARE DEACTIVATED AS WELL. SHOULD THIS HAPPEN ON A BUSY ROADWAY/HIGHWAY, AND THERE IS AN ACCIDENT, THERE IS THE POTENTIAL THAT IT COULD BE FATAL. *TR