1992 Mitsubishi Mighty Max Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1992 Mitsubishi Mighty Max, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Transmission444.4%
- Brakes111.1%
- Electrical111.1%
- Engine111.1%
- Seat belts111.1%
- Tires & wheels111.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
SHAFT AND FORK PIECE BROKE IN HALF. THIS HAS OCCURED 3 TIMES, 1998,1999 AND CURRENT. ONCE WITH THE ORIGINAL PART AND TWICE WITH THE REPLACEMENT PARTS. IT IS A HAZARD WHEN DRIVING IN MOTION. YOU'RE JOLTED WITH TREMENDOUS FORCE WHEN IT BREAKS WITHOUT NOTICE AND SUDDEN LOSS OF SPEED. MAY CAUSE CAR FOLLOWING IN REAR TO BACK END VEHICLE AND CREATE AN ACCIDENT.*AK
CLUTCH DISC (OEM AND OTHER) FAILS AT 16-18 MONTHS/30K MILES. POOR DESIGN. DANGEROUS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
WHILE DRIVING 30 MPH, THE CONSUMER DEPRESSED THE PEDAL AND IT TRAVELED TO FLOOR. THE CONSUMER DOWN SHIFTED FOR THE VEHICLE TO COME TO A STOP. THE CONSUMER INSPECTED THE VEHICLE, AND NOTICED THAT THE BRAKE LINE HAD RUSTED, CAUSING BRAKE FLUID TO LEAK. *AK THE ABS HAD RUSTED IN THE AREA WHERE THE LINES RAN BETWEEN THE FRAME OF THE VEHICLE AND THE EXHAUST PIPE/MUFFLER. *SC *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
THE ENGINE WOULD SHUT DOWN WITH NO PRIOR WARNING, THE COIL ASSEMBLY WAS REPLACED (35000) AND LAST MONTH IT FAILED AGAIN, AFTER THE VEHICLE HAD BEEN AT THE DEALER FOR 3 DAYS THEY DETERMINED THAT THE ELECTRICAL SYSTEM WAS NOT WORKING PROPERLY. NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
THIS PART HAS BROKEN PROBABLY MORE THAN SIX TIMES. THE FIRST COUPLE OF TIMES, THE TRUCK WAS TOWED TO A MECHANIC RATHER THAN THE DEALER, THINKING THAT THIS WAS JUST A SMALL PROBLEM. AFTER TWO VISITS TO THE SAME MECHANIC, THE TRUCK WAS THEN TOWED TO THE DEALER. THE FIRST TIME AT THE DEALER (DOBBS BROS. MITSUBISHI-MEMPHIS), I WAS TOLD THAT THE BALANCE SHAFT WAS OUT OF BALANCE. $715.78 LATER (THIS PART IS NOW UNDER A ONE YEAR/12,000 MILE WARRANTY), THE SHAFT FORK BREAKS AGAIN. THIS TIME, I WAS TOLD THAT IT WAS A PART FAILURE. 4000 MILES LATER, IT BREAKS AGAIN. THE TRUCK WAS AT THE SERVICE SHOP FOR MORE THAN A WEEK WHILE THEY WERE 'CHECKING OUT WHAT COULD MAKE THIS PIECE KEEP BREAKING'. AFTER A THOROUGH CHECK (INCL. THE MANUAL TRANSMISSION) AND STILL WARRANTEED, IT IS FIXED. ABOUT 4000 MILES LATER, IT BREAKS AGAIN. THIS TIME, I'M TOLD BY THE SERVICE MANAGER THAT 'BECAUSE OF THE MULTIPLE BREAKS THAT SHE COULD NOT WARRANTY THIS PART ANYMORE.' I TOLD HER THAT THE PART CONTINUES TO BREAK WHILE I'M DRIVING. SHE STATED" YOU MUST BE TOWING SOMETHING TOO HEAVY OR SOMETHING." (THE TRUCK HAS NO BUMPER ACCESSORY). SHE DID OFFER TO PERFORM ANOTHER THOROUGH CHECK OF THE VEHICLE (FOR ABOUT $1100) STATING THAT "I JUST CAN'T KEEP FIXING A PART THAT'S BREAKING LIKE THIS" I WOULD LIKE AN INVESTIGATION INTO THIS BECAUSE THIS PART IS FAULTY AND CAN CAUSE SERIOUS INJURY WHEN IT BREAKS WHILE DRIVING. A PERSON COULD LOSE CONTROL OF THE VEHICLE.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
THE PLASTIC PORTION OF THE BUCKLE (WHERE THE LAP/SHOULDER BELT LOOPS THROUGH) HAS BECOME BRITTLE, AND CRACKED ON ALL THREE BELTS IN THE VEHICLE. SAFETY HAZARD. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TL* THE CONTACT OWNS A 1992 MITSUBISHI MIGHTY MAX EQUIPPED WITH NEPTUNE UN101 (NA) TIRES, SIZE: 195/75/R14 (NA). WHILE DRIVING VARIOUS SPEEDS, THE CONTACT LOST CONTROL OF THE VEHICLE. THE CONTACT PULLED THE VEHICLE OVER AND NOTICED THAT THE TIRE BELT HAD SHIFTED ON THE TIRES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VIN WAS UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 83,500 AND THE TIRE FAILURE MILEAGE WAS 5,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .