1996 Mitsubishi Montero Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Mitsubishi Montero, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine1032.3%
- Brakes412.9%
- Transmission412.9%
- Steering412.9%
- Body & structure26.5%
- Interior & seats26.5%
- Visibility13.2%
- Seat belts13.2%
- Driver assistance13.2%
- Heating & air conditioning13.2%
- Electrical13.2%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL*THE CONTACT OWNS A 1996 MITSUBISHI MONTERO. THE CONTACT STATED THAT THE BOLTS OF THE CRANK SHAFT PULLEY HAVE FALLEN. SHE HEARD A STRANGE NOISE WHILE DRIVING AND ALL OF THE INSTRUMENT PANEL LIGHTS ILLUMINATED. SHE ALSO STATED THAT THE STEERING WHEEL LOCKED UP. THE MANUFACTURER ADVISED HER TO CALL AN AUTHORIZED DEALER. THE DEALER STATED THAT NO RECALLS FOR THESE FAILURES WERE AVAILABLE FOR HER VEHICLE. THE CONTACT RESEARCHED THE NHTSA WEBSITE AND FOUND A RECALL THAT RELATES TO THESE FAILURES. THE FAILURE AND CURRENT MILEAGES WERE 146,000. UPDATED 01/02/08. *LJ RECALL#00V311001. UPDATED 12/12/07 , REMAILED COMPLAINT EVOQ 2/07/08. *LJ
WHILE DRIVING STEERING FAILED. THE CRANKSHAFT BOLT THAT HELD IT DISENGAGED. RECALL 00V311001 WAS ISSUED. *AK
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
ABS BRAKING SYSTEM WAS NOT OPERABLE AND BRAKE LIGHT CAME ON DASHBOARD. BRAKES MADE GRINDING AND STREAKING NOISES. ALSO, VEHICLE WAS TAKEN TO THE DEALERSHIP TWICE AND ROTORS WERE REPLACED.*AK
1996 MITSUBISHI MONTERO SEEMS PRONE TO PREMATURE BRAKE WEAR, IN NORMAL DRIVING CONDITIONS. I'VE HAD TO REPLACE PADS AT 17,000 MILES, 30,000, AND IT APPEARS REPLACEMENT WILL AGAIN BE NECESSARY AT 40,000 MILES.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
WHILE DRIVING ENGINE CHECK LIGHT ILLUMINATED, INDICATING A MALFUNCTION. DEALER STATED THAT THIS OCCURRED BECAUSE OF INTERFERENCE IN THE TRANSMISSION CONTROL MODULE CAUSED BY CELL PHONE USE. PLEASE GIVE ANY FURTHER DETAILS. *AK
TRANSMISSION WILL NOT SHIFT WHEN VEHICLE IS COLD. MANUFACTURER SAID IT'S AN EMISSION PROBLEM. INFORMED IT'S NORMAL. TAKES TOO LONG TO WARM UP BEFORE SHIFTING. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
WHILE DRIVING STEERING FAILED. THE CRANKSHAFT BOLT THAT HELD IT DISENGAGED. RECALL 00V311001 WAS ISSUED. *AK
NAR 03/05/2003 THE CONSUMER REAR DOOR HINGES HAD TO BE REPLACED , THE TIE ROD BROKE ON THE TRUCK, AND THE WATER PUMP FROZE SEIZING POWER TO THE TIMING BELT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
NAR 03/05/2003 THE CONSUMER REAR DOOR HINGES HAD TO BE REPLACED , THE TIE ROD BROKE ON THE TRUCK, AND THE WATER PUMP FROZE SEIZING POWER TO THE TIMING BELT.
BACK DOOR HINGES HAVE RUSTED. DEALER HAS INSPECTED VEHICLE, AND WILL REPLACE HINGES. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
WHILE DRIVING BETWEEN 40-45 MPH METAL THAT KEPT THE DRIVER SIDE SEAT BACK UP RIGHT BROKE ON THE RIGHT SIDE. WHEN THIS OCCURRED DRIVER'S SIDE SEAT BACK DECLINED BACKWARDS ON THE RIGHT SIDE. THIS REDUCED THE DRIVER'S VISIBILITY. DRIVER HAD TO PULL OFF THE ROAD. THE ENTIRE SEAT NEEDED TO BE REPLACED. *AK
ENGINE CHECK LIGHT APPEARS TO BE MALFUNCTIONING. AUTO HAS BEEN SERVICED FOR THE CHECK ENGINE LIGHT/SRS LIGHT REPEATEDLY. THE COMPUTER READING STATES TO REPLACE VARIOUS SENSORS. SENSORS HAVE BEEN REPLACED AND THE CHECK ENGINE LIGHT CONTINUES TO COME ON. PROBLEM IS PERPLEXING SERVICE MECHANICS -VEHICLE OWNER FEARFUL SRS MAY NOT FUNCTION PROPERLY. VEHICLE IN SERVICE OVER 7 WEEKS.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
REAR VIEW MIRRORS DEFECTIVE, CAUSING POOR VISIBILITY.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
OUR CENTURY "SMART MOVE" INFANT/TODDLER CARSEAT DID NOT INSTALL SECURELY. IT WOBBLED & DID NOT FIT IN THE MIDDLE BACK SEAT CORRECTLY - IT BLOCKED OUR VIEW OUT OF THE BACK WINDOW. WE ENDED UP EXCHANGING IT FOR THE FISHER PRICE CARSEAT, AND LIKE IT MUCH BETTER. A FRIEND OF MINE ALSO RETURNED HER "SMARTMOVE" FOR THE SAME REASON.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WHEN DRIVING AT HIGHWAY SPEED TRAVELING ABOUT 55 MPH, AND UPON DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE LOSES POWER WITHOUT WARNING. ALSO THE CHECK ENGINE LIGHT COMES ON THE DASHBOARD. CONSUMER HAS CONTACTED THE DEALER, PARTS HAVE BEEN REPLACED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Heating & air conditioning
Reports naming the heating, ventilation and air-conditioning system.
From owner reports, verbatim
NAR 03/05/2003 THE CONSUMER REAR DOOR HINGES HAD TO BE REPLACED , THE TIE ROD BROKE ON THE TRUCK, AND THE WATER PUMP FROZE SEIZING POWER TO THE TIMING BELT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
CD PLAYER/STEREO SPEAKER FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .